Search

Updating of the current Urban Waste Water Treatment Directive (91/271/EEC) will demand stricter regulations for nutrients removal. In this frame, wastewater treatment plants (WWTPs) of small-to-medium potential will face new challenges for achieving process intensification. Integrating intermittent aeration (IA) and integrated fixed-film activated sludge (IFAS) technologies could be a promising solution to meet such requirements. This study analyzed how IA cycles affected nutrients removal in IFAS reactors with different biofilm carriers (e.g., plastic and sponge media). The plants responses to different carbon/nitrogen/phosphorous (C/N/P) ratios were evaluated while operating under low sludge retention time (SRT) to simulate overloaded conditions. A short IA cycle (1 h) with an aeration/not aeration ratio of 2:1 enabled high organic carbon and nitrification performances when operating at high C/N/P (11.8/1/1), whereas low denitrification and phosphorous removal yields were obtained because of the short not-aerated phase. Decreasing C/N ratio (8.8/1/1) without changing the IA cycle resulted in nitrification worsening because of the reduced metabolic kinetics of biofilm. Under such load conditions, a higher IA cycle (2 h) was necessary to improve process performance. A longer not-aerated phase was also positive for denitrification and phosphorous removal because of the establishment of anoxic and anaerobic environments within the bulk and inner biofilm layers. Besides, results suggested that sponge carriers offered advantages over plastic ones, enabling a higher biofilm retention capacity, better nutrient removal, as well as robustness and resilience to operating condition changes. This would result in simpler management systems for implementing the IA process, thus reducing process complexity and costs., Competing Interests: Declaration of competing interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2024 Elsevier Ltd. All rights reserved.)

Minimization of excess sludge produced by wastewater treatment plants has become a topical theme nowadays. One of the most used approaches to achieve this aim is the anaerobic side-stream reactor (ASSR) process. This is considered affected by the hydraulic retention time (HRT) of the anaerobic reactor, the anaerobic sludge loading rate (ASLR) and the sludge interchange ratio (SIR), although, studies available in the literature did not reflect a clear relationship with the sludge minimization yields. To overcome this, a novel parameter namely anaerobic exposure time (AET) was defined and related to reduction of the observed yield coefficient (Y obs ) in a lab-scale plant implementing the ASSR process. Furthermore, the AET was validated by performing a detailed and thorough review of previous literature. Excess sludge production was successfully reduced (10-60 %) with the increase of the AET (7.9-13 h/d), although maintaining the same HRT in the ASSR and a constant sludge interchange ratio (SIR) (100 %). A strong correlation (Pearson = 0.763) was found between the AET, and the Y obs reduction reported in previous studies, also indicating a linear relationship (R 2 = 0.92) between these parameters. Contrarily, the correlation between the Y obs with the ASLR and the ASSR-HRT resulted moderate (Pearson = 0.186) or weak (Pearson=-0.346), respectively. Overall, while operating at low AET (< 6 h), maintenance and uncoupling metabolism were found the main sludge reduction mechanisms. Increasing the AET (>8 h) favoured the occurrence of extracellular polymeric substances (EPS) hydrolysis and endogenous decay mechanisms, which improved excess sludge reduction. To conclude, the AET could be considered a reliable parameter to be used for design or control purposes for the ASSR-based process., Competing Interests: Declaration of competing interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2024 Elsevier Ltd. All rights reserved.)

In the present research, insights about the mechanisms of excess sludge minimization occurring in an oxic-settling-anaerobic (OSA) were provided. The investigation involved two systems operating in parallel. In particular, a conventional activated sludge (CAS) system as control and a system implementing the OSA process both having a pre-denitrification scheme were considered. Five periods (P1-P5) were studied, during which several operating conditions and configurations were tested. Specifically, the hydraulic retention time (HRT) in the anaerobic reactor of the OSA system (P1 8 h, P2-P3 12 h, P4 8 h, P5 12 h) and the return sludge from the anaerobic to the anoxic (scheme A) (P1-P2) or aerobic (scheme B) mainstream reactors (P3-P5) were investigated. The results highlighted that the excess sludge production in the OSA was lower in all the configurations (12-41%). In more detail, the observed yield (Y obs ) was reduced from 0.50-0.89 gTSS gCOD -1 (control) to 0.22 -0.34 gTSS gCOD -1 in the OSA process. The highest excess sludge reduction (40%) was achieved when the OSA was operated according to scheme B and HRT of 12 h in the anaerobic reactor (P3). Generally, scheme A enabled the establishment of cell lysis and extracellular polymeric substances (EPS) destructuration, leading to a worsening of process performances when high anaerobic HRT (>8 h) was imposed. In contrast, scheme B enabled the establishment of maintenance metabolism in addition to the uncoupling metabolism, while cell lysis and EPS destruction were minimized. This allowed obtaining higher sludge reduction yield without compromising the effluent quality., Competing Interests: Declaration of competing interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2022 Elsevier Ltd. All rights reserved.)

This study investigated the chance to couple the conventional Oxic Settling Anaerobic (OSA) process with a thermic treatment at moderate temperature (35 °C). The maximum excess sludge reduction rate (80%) was achieved when the plant was operated under 3 h of hydraulic retention time (HRT). Compared with the conventional OSA system, the thermic treatment enabled a further improvement in excess sludge minimization of 35%. The observed yield coefficient decreased from 0.25 gTSS gCOD -1 to 0.10 gTSS gCOD -1 when the temperature in the anaerobic reactor was increased to 35 °C, despite the lower HRT (3 h vs 6 h). Moreover, the thermic treatment enabled the decrease of filamentous bacteria, thereby improving the sludge settling properties. The thermic treatment enhanced the destruction of extracellular polymeric substances and the increase of endogenous decay rate (from 0.64 d -1 to 1.16 d -1 ) that reduced the biomass active fraction (from 22% to 4%)., Competing Interests: Declaration of Competing Interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2019 Elsevier Ltd. All rights reserved.)

In the present paper, the feasibility of citrus wastewater treatment with aerobic granular sludge sequencing batch reactors (AGSBR) was investigated. Two AGSBRs (named R1 and R2, respectively) were operated for 90 days under different organic loading rates (OLR) and pH in two experimental periods. The OLR ranged approximately between 3.0 kg TCOD m -3 d -1 and 7 kg TCOD m -3 d -1 during Period I, whereas between 7 kg TCOD m -3 d -1 and 15 kg TCOD m -3 d -1 during Period II. pH was maintained at 7.0 and 5.5 in R1 and R2, respectively. The results revealed that under high OLR and unbalanced feast/famine regime (Period I), the development of fast-growing microorganisms (fungi and filamentous bacteria) was favoured in both reactors, resulting in granular sludge instability. An extended famine phase and a proper balancing between feast and famine periods (Period II) were favourable for the development of bacteria with low growth rates (0.05 d -1 ) thus enhancing the granules stability. To the benefit of granular sludge stability and effluent quality, the length of the feast period should not exceed 25% of cycle length. Moreover, under OLR lower than 7 kg TCOD m -3 d -1 the removal efficiency of total chemical oxygen demand (TCOD) was approximately 90% in R1 and R2 and no side effects on the organic carbon removal performance related to the pH were observed. In contrast, at higher OLR a significant decrease in the removal efficiency (from 90% to less than 75%) was observed in R2. Results revealed also that under low pH, hydrolysis of proteins occurred and a decrease in the biological kinetic rates proportionally to the applied OLR was observed., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

The modification of the physical properties of aerobic granular sludge treating fish-canning wastewater is discussed in this paper. The structure and composition of the Extracellular Polymeric Substances (EPSs) were analyzed at different salinity levels and related to granules stability. Results outlined that the total EPSs content increased with salinity, despite the EPSs increment was not proportional to the salt concentration. Moreover, the EPSs structure was significantly modified by salinity, leading to a gradual increase of the not-bound EPSs fraction, which was close to the 50% of the total EPSs content at 75gNaClL -1 . The increasing salt concentration modified also the EPSs composition, causing the gradual reduction of protein content resulting in a decrease of granule hydrophobicity. The results pointed out that the granules stability significantly reduced above 50gNaClL -1 , suggesting the existence of a salinity threshold above which granules stability is compromised., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

Results obtained from three aerobic granular sludge reactors treating brewery wastewater are presented. Reactors were operated for 60d days in each of the two periods under different cycle duration: (Period I) short 6h cycle, and (Period II) long 12h cycle. Organic loading rates (OLR) varying from 0.7kgCODm -3 d -1 to 4.1kgCODm -3 d -1 were tested. During Period I, granules successfully developed in all reactors, however, results revealed that the feast and famine periods were not balanced and the granular structure deteriorated and became irregular. During Period II at decreased 12h cycle time, granules were observed to develop again with superior structural stability compared to the short 6h cycle time, suggesting that a longer starvation phase enhanced production of proteinaceous EPS. Overall, the extended famine conditions encouraged granule stability, likely because long starvation period favours bacteria capable of storage of energy compounds., (Copyright © 2016 Elsevier Ltd. All rights reserved.)

Fish processing industries produce wastewater containing high amounts of salt, organic matter and nitrogen. Biological treatment of such wastewaters could be problematic due to inhibitory effects exerted by high salinity levels. In detail, high salt concentrations lead to the accumulation of nitrite due to the inhibition of nitrite-oxidizing bacteria. The feasibility of performing simultaneous nitritation and denitritation in the treatment of fish canning wastewater by aerobic granular sludge was evaluated, and simultaneous nitritation-denitritation was successfully sustained at salinities up to 50 gNaCl L(-1), with a yield of over 90%. The total nitrogen concentration in the effluent was less than 10 mg L(-1) at salinities up to 50 gNaCl L(-1). Nitritation collapsed above 50 gNaCl L(-1), and then, the only nitrogen removal mechanism was represented by heterotrophic synthesis. In contrast, organic matter removal was not affected by salinity but was instead affected by the organic loading rate (OLR). Both COD and BOD removal efficiencies were over 90%. The COD fractionation analysis indicated that aerobic granules were able to remove more than 95% of the particulate organic matter. Finally, results obtained in this work noted that aerobic granular sludge had an excellent ability to adapt under adverse environmental conditions., (Copyright © 2015 Elsevier Ltd. All rights reserved.)

A granular continuous-flow membrane bioreactor with a novel hydrodynamic configuration was developed to evaluate the stability of aerobic granular sludge (AGS). Under continuous-flow operation (Period I), AGS rapidly lost their structural integrity resulting in loose and fluffy microbial aggregates in which filamentous bacteria were dominant. The intermittent feeding (Period II) allowed obtaining the succession of feast and famine conditions that favored the increase in AGS stability. Although no further breakage occurred, the formation of new granules was very limited, owing to the absence of the hydraulic selection pressure. These results noted the necessity to ensure, on the one hand the succession of feast/famine conditions, and on the other, the hydraulic selection pressure that allows flocculent sludge washout. This preliminary study shows that the proposed configuration could meet the first aspect; in contrast, biomass selection needs to be improved., (Copyright © 2015 Elsevier Ltd. All rights reserved.)