Search

Salmonella is capable of surviving dehydration within various foods, such as dried fruit. Dried fruit, including apple slices, have been the subject of product recalls due to contamination with Salmonella. A study was conducted to determine the fate of Salmonella on apple slices, following immersion in three antimicrobial solutions (viz., ε-polylysine [epsilon-polylysine or EP], sodium bisulfate [SBS], or peracetic acid [PAA]), and subsequent hot air dehydration. Gala apples were aseptically cored and sliced into 0.4 cm thick rings, bisected, and inoculated with a five-strain composite of desiccation-resistant Salmonella, to a population of 8.28 log CFU/slice. Slices were then immersed for 2 min in various concentrations of antimicrobial solutions, including EP (0.005, 0.02, 0.05, and 0.1%), SBS (0.05, 0.1, 0.2, and 0.3%), PAA (18 or 42 ppm), or varying concentrations of PAA + EP, and then dehydrated at 60°C for 5 h. Salmonella populations in positive control samples (inoculated apple slices washed in sterile water) declined by 2.64 log after drying. In the present study, the inactivation of Salmonella, following EP and SBS treatments, increased with increasing concentrations, with maximum reductions of 3.87 and 6.20 log (with 0.1 and 0.3% of the two compounds, respectively). Based on preliminary studies, EP concentrations greater than 0.1% did not result in lower populations of Salmonella. Pretreatment washes with either 18 or 42 ppm of PAA inactivated Salmonella populations by 4.62 and 5.63 log, respectively, following desiccation. Combining PAA with up to 0.1% EP induced no greater population reductions of Salmonella than washing with PAA alone. The addition of EP to PAA solutions appeared to destabilize PAA concentrations, reducing its biocidal efficacy. These results may provide antimicrobial predrying treatment alternatives to promote the reduction of Salmonella during commercial or consumer hot air drying of apple slices.

Chlorine is commonly used by the fresh produce industry to sanitize water and minimize pathogen cross-contamination during handling. The pH of chlorinated water is often reduced to values of pH 6–7, most commonly with citric acid to stabilize the active antimicrobial, hypochlorous acid (a form of free chlorine). Previous studies have demonstrated that citric acid reacts with chlorine to form trichloromethane, a major chlorine by−product in water and a potential human carcinogen. However, it is unclear if other pH control agents could be used in the place of citric acid to minimize the formation of trichloromethane. The objective of the present study was to determine the reactivity of organic and inorganic pH control agents, with chlorine, to generate trichloromethane. Free chlorine (∼100 mg/L) was mixed with 10 mM of each of twelve organic acids and two inorganic pH control agents (i.e., sodium acid sulfate and phosphoric acid) to effect a pH level of 6.5. Free chlorine and trichloromethane levels were measured over 3 h at 3 and 22°C. Results demonstrated that ascorbic acid, dehydroascorbic acid, citric acid, and malic acid rapidly depleted free chlorine concentrations at both 22°C and 3°C, while tartaric acid and lactic acid decreased chlorine concentrations more slowly. Other pH control agents did not significantly reduce free chlorine either at 22 or 3°C. Citric acid led to the generation of significantly higher concentrations of trichloromethane than did other acids. Chloroacetone was also found in chlorinated water in the presence of citric acid and ascorbic acid. Taking buffering capacity and pKa values into account, phosphoric acid and some organic acids may be used to replace citric acid as pH control agents in chlorinated water for washing fresh produce, to stabilize free chlorine level and reduce the generation of trichloromethane.

Antimicrobial properties of biochar have been attributed to its ability to inactivate foodborne pathogens in soil, to varying degrees. High concentrations of biochar have reduced E. coli O157:H7 in soil and dairy manure compost, based on alkaline pH. Preliminary studies evaluating 31 different biochars determined that two slow pyrolysis biochars (paper biochar and walnut hull cyclone biochar) were the most effective at inactivating E. coli in soil. A study was conducted to determine the lowest percentages of paper and walnut hull cyclone biochars needed to reduce E. coli O157:H7 in soil. A model soil was adjusted to 17.75% moisture, and the two types of biochar were added at concentrations of 1.0, 1.5, 2.0, 2.5, 3.5, 4.5, 5.5, and 6.5%. Nontoxigenic E. coli O157:H7 were inoculated into soil at 6.84 log CFU/g and stored for up to 6 weeks at 21°C. Mean E. coli O157:H7 counts were 6.01–6.86 log CFU/g at all weeks between 1 and 6 in soil-only positive control samples. Populations in all soil amended with 1.0 and 1.5% of either type of biochar (as well as 2.0% of the walnut hull biochar) resulted in ≤0.68 log reductions at week 6, when compared with positive controls. All other concentrations (i.e., ≥2.0% paper and ≥2.5% walnut hull) inactivated ≥2.7 log at all weeks between 1 and 6 (p

Fresh-cut apples, being rich in antioxidants and other nutrients, have emerged as popular snacks in restaurants, at home, and in school lunch programs, partially due to freshness, convenience, and portion size availability. Two major challenges in processing fresh-cut apples are the browning of cut surfaces and contamination with human pathogens. Regarding human pathogens, contamination by Listeria monocytogenes is a major concern, as evidenced by two outbreaks of whole apples and numerous recalls of fresh-cut apples. Antibrowning agents currently used by the industry have little to no antimicrobial properties. The present review discusses the possible origins of L. monocytogenes in fresh-cut apples, including contaminated whole apples, and contamination via the processing environment and the equipment in fresh-cut facilities. Treatment with antibrowning solutions could possibly be an opportunity for Listeria contamination and represents the last chance to inactivate pathogens. The discussion is focused on the antibrowning treatments where formulations and coatings with antibrowning and antimicrobial properties have been developed and evaluated against Listeria and other microorganisms. In addition, several research needs and considerations are discussed to further reduce the chance of pathogen contamination on fresh-cut apples.

A laboratory-acquired E. coli O157:H7 infection with associated severe sequelae including hemolytic uremic syndrome occurred in an individual working in the laboratory with a mixture of nalidixic acid-resistant (NalR) O157:H7 mutant strains in a soil-biochar blend. The patient was hospitalized and treated with an intravenous combination of metronidazole and levofloxacin. The present study investigated the source of this severe laboratory acquired infection and further examined the influence of the antibiotics used during treatment on the expression and production of Shiga toxin. Genomes of two Stx2a-and eae-positive O157:H7 strains isolated from the patient’s stool were sequenced along with two pairs of the wt strains and their derived NalR mutants used in the laboratory experiments. High-resolution SNP typing determined the strains’ individual genetic relatedness and unambiguously identified the two laboratory-derived NalR mutant strains as the source of the researcher’s life-threatening disease, rather than a conceivable ingestion of unrelated O157:H7 isolates circulating at the same time. It was further confirmed that in sublethal doses, the antibiotics increased toxin expression and production. Our results support a simultaneous co-infection with clinical strains in the laboratory, which were the causative agents of previous O157:H7 outbreaks, and further that the administration of antibiotics may have impacted the outcome of the infection.

The objective of the study was to evaluate the effect of trichome (fuzz) removal on the efficacy of ultraviolet-C in inactivating Escherichia coli O157:H7 on peach fruit, and quality of peach [Prunus persica (L.) Batsch, cv. PF25] fruit as affected by fuzz removal and ultraviolet-C. Peach (cultivar PF25) fruit, with and without fuzz removal, were inoculated with a five-strain cocktail of E. coli O157:H7 and treated with ultraviolet-C at doses of 0, 221, and 442 mJ/cm2. Fuzz was rubbed off using damped cloths. Survival of E. coli populations was determined at days 1, 4, and 7 at 20 °C. To study fruit quality, noninoculated fruit with and without fuzz removal were treated with ultraviolet-C at the same doses. Results demonstrated that ultraviolet-C at 442 mJ/cm2 reduced the population of E. coli by 1.2 to 1.4 log colony-forming units (CFU)/fruit on peach with fuzz, and 0.9 to 1.1 log CFU/fruit on fruit without fuzz 1 day after ultraviolet-C treatment. However, E. coli populations of all samples were similar with additional storage time, resulting in no significant difference among the treatments after 7 days of storage at 20 °C. Ultraviolet-C at doses up to 442 mJ/cm2 did not have any significant effect on the surface color of peaches during 7 days of storage, although fruit with fuzz removal increased L*, hue, and chroma values. In addition, fuzz removal promoted the loss of firmness during storage. Furthermore, ultraviolet-C at 442 mJ/cm2 increased antioxidant capacity of peach skin with fuzz. Overall, our results suggested that fuzz removal had marginal effects on the efficacy of ultraviolet-C, and ultraviolet-C did not negatively affect the quality of peaches.