Pharmacokinetics of epimeric budesonide and fluticasone propionate after repeat dose inhalation - intersubject variability in systemic absorption from the lung

Aims Pharmacokinetic variability is likely to be a significant factor contributing to the interindividual differences in dose requirements, anti-inflammatory response and side-effects with inhaled corticosteroids (ICS), but there is limited information about the disposition of ICS during regular dosing with a pressurized metered dose inhaler (pMDI). This study uses a mixed effects modelling approach to quantify and compare the interindividual variability in pharmacokinetics of epimeric budesonide (BUD) and fluticasone propionate (FP) after repeat-dose inhalation. Methods This pharmacokinetic substudy was part of a previously published open-label, randomised, placebo-controlled, 7-period crossover study to evaluate the short-term effects on plasma cortisol levels of inhaled BUD (400, 800, 1600 µg twice daily) and FP (375, 750, 1000 µg twice daily) via pMDI in a group of healthy male volunteers. On the fifth day of each high-dose treatment period (BUD 1600 µg twice daily and FP 1000 µg twice daily), venous blood samples were collected in nine subjects prior to the last dose and at 15 min, 30 min, 1, 2, 4, 6 and 8 h postdose for measurement of plasma drug concentrations to determine the pharmacokinetics of epimeric BUD and FP following inhalation. Non-compartmental analysis and a mixed effects model were used to characterize the disposition profiles. Results Both drugs had a rapid absorption half-life (BUD 10 min vs FP 11.3 min), but quite different elimination half-lives (BUD 2.4 h vs FP 7.8 h). Although there were intraindividual differences in the handling of the 22R-and 22S-epimers of BUD, there were no consistent pharmacokinetic differences between the two enantiomers in the group as a whole. Consistent with previous reports of FP’s higher volume of distribution (V) and lower systemic bioavailability (F), the V/F ratio was lower for BUD than FP (498 l vs 8100 l). The parameter with the greatest interindividual variability for both BUD and FP was the rate of systemic absorption from the lung. Conclusions This is the first report describing the pharmacokinetics of epimeric BUD and FP after repeat dose inhalation via pMDI. Three observations may be of clinical relevance: (1) there is considerable intersubject variability in the rate of absorption of both drugs from the lung; (2) in some individuals there was a long t½,z for BUD, resulting in higher and more sustained plasma drug levels in the 4–12 h postdose period than would be predicted from single-dose pharmacokinetic data; and (3) there is evidence of diurnal variation in FP pharmacokinetics, with higher-than-expected plasma drug concentrations in the morning compared with the evening.