Search

Simple Summary: A-band ultraviolet (UVA) in solar radiation plays an important role in the natural decay of airborne bacteria. In this study, laboratory simulation experiments were conducted to investigate the impact of varied UVA intensities on the decay of airborne bacteria and to analyze the potential use of UVA to reduce indoor airborne bacteria in cattle houses. Decay and inactive rates of airborne bacteria from cattle sources increased with the UVA radiation intensities when the radiation was over 1500 μW cm−2, and it was affected by the initial concentration and radiation durations. Results of this study provide the foundation for further applying UVA as an alternative way to reduce indoor airborne bacteria in animal houses. Inspired by the effects of solar or UV radiation on the decay of airborne bacteria during their transport, this study investigated the effect of UVA on the decay of airborne bacteria from cattle houses and analyzed the potential use of UVA to reduce indoor airborne bacteria under laboratory conditions. Airborne bacteria from the cattle source were generated and released into a small-scale test chamber (1.5 m3) with different strategies according to the different objectives in decay tests and simulated sterilization tests. Increasing with the UVA radiation gradients (0, 500, 1000, 1500 μW cm−2), the average decay rate of total curable airborne bacteria ranged from 2.7% to 61.6% in decay tests. Under the combination of different UVA radiation intensities (2000 μW cm−2 in maximum) and radiation durations (60 min in maximum), simulated sterilization tests were conducted to examine the potential use of UVA radiation for air sterilization in animal houses. With the dynamic inactive rate (DIR) ranging from 17.2% to 62.4%, we proved that UVA may be an alternative way to reduce the indoor airborne bacteria in cattle houses if applied properly. Similar effects would be achieved using either a high radiation intensity with a short radiation duration or a low radiation intensity with a long radiation duration. [ABSTRACT FROM AUTHOR]

Low-profile, cross-ventilated (LPCV) dairy barns represent a modern trend in farm buildings but are associated with notable air quality challenges. To evaluate the annual variations in the pollutants in an LPCV dairy barn, an Internet-of-Things (IoT)-based environmental monitoring system was installed to continuously measure the total suspended particle (TSP), particle with aerodynamic diameters of ≤2.5 μm (PM2.5), and NH3 concentrations year round at multiple points. Spatiotemporal distributions and main factors were analyzed. The results showed that the annual average concentrations of indoor TSP, PM2.5, and NH3 were 86.4, 28.5, and 875.0 μg/m3, respectively. Corresponding emission rates were 140.6, 28.5, and 3461.1 mg/(h·cow). TSP concentrations were significantly higher during winter and spring (p < 0.05) and were elevated during daily operational hours, particularly in feeding alleys and downwind areas. Emissions were significantly higher in winter and summer (p < 0.05). Indoor PM2.5 concentrations in winter exceeded China's standards for 24.9% of the time, which were 2.2 times higher than those in other seasons (p < 0.05), peaking in the morning hours. NH3 concentrations and emissions were consistently high throughout the year, with peak levels in manure and downwind areas. The building's structure, ventilations, and daily operations were key factors affecting air pollutant levels, which need to be considered when implementing mitigation measures. [ABSTRACT FROM AUTHOR]

Long-term exposure to a relatively high concentration of airborne bacteria emitted from intensive livestock houses could potentially threaten the health and welfare of animals and workers. There is a dual effect of air sterilization and promotion of vitamin D synthesis for the specific bands of ultraviolet light. This study investigated the potential use of A-band ultraviolet (UVA) tubes as a clean and safe way of reducing airborne bacteria and improving calf health. The composition and emission characteristics of airborne bacteria were investigated and used to determine the correct operating regime of UVA tubes in calf houses. Intermittent exceedances of indoor airborne bacteria were observed in closed calf houses. The measured emission intensity of airborne bacteria was 1.13 ± 0.09 × 107 CFU h−1 per calf. Proteobacteria were the dominant microbial species in the air inside and outside calf houses. After UVA radiation, the indoor culturable airborne bacteria decreased in all particle size ranges of the Anderson sampler, and it showed the highest reduction rate in the size range of 3.3–4.7 μm. The results of this study would enrich the knowledge of the source characteristics of the airborne bacteria in intensive livestock farming and contribute to the environmental control of cattle in intensive livestock production. [ABSTRACT FROM AUTHOR]

The emission factor method (Tier 1) recommended by the Intergovernmental Panel on Climate Change (IPCC) is commonly used to estimate greenhouse gas (GHG) emissions from livestock and poultry farms. However, the estimation accuracy may vary due to practical differences in manure management across China. The objectives of this study were to estimate the direct and indirect nitrous oxide (N2O) emissions from dairy manure management between 1990 and 2021 in China and characterize its spatial and temporal variations following IPCC guideline Tier 2. The N2O emission factor (EF) of dairy cow manure management systems was determined at the national level and regional level as well. The results showed that the national cumulative N2O emission of manure management from 1990 to 2021 was 113.1million tons of CO2 equivalent, ranging from 90.3 to 135.9 million tons with an uncertainty of ±20.2%. The annual EF was 0.021 kg N2O-N (kg N)−1 for total emissions, while it was 0.014 kg N2O-N (kg N)−1 for direct emissions. The proportions of N2O emissions in North China, Northeast China, East China, Central and Southern China, Southwest China and Northwest China were 32.3%, 18.6%, 11.4%, 5.8%, 6.1% and 25.8%, respectively. In addition, N2O emissions varied among farms in different scales. The respective proportions of total N2O emissions from small-scale and large-scale farms were 64.8% and 35.2% in the past three decades. With the improvement in farm management and milk production efficiency, the N2O emissions per unit mass of milk decreased from 0.77 × 10−3 kg to 0.48 × 10−3 kg in 1990–2021. This study may provide important insights into compiling a GHG emission inventory and developing GHG emission reduction strategies for the dairy farming system in China. [ABSTRACT FROM AUTHOR]

Based on the experiments of isothermal forging wedge-shaped samples, Deform-3D numerical simulation software was used to confirm the strain distribution in the wedge-shaped samples. The effect of deforming temperature and strain on abnormal grain growth(AGG) in extruded FGH96 superalloy was examined. It is found that when the forging speed is 0.04 mm/s,the critical AGG occurring temperature is 1100℃,and the critical strain is 2%.AGG does not occur within 1000-1070℃,but still shows the feature of ‘critical strain’,and the region with strain of 5%-10% has the largest average grain size.AGG can be avoided and the uniform fine grains can be gained when the strain is not less than 15%.