Search

Multiple approaches utilizing viral and DNA vectors have shown promise in the development of an effective vaccine against HIV. In this study, an alternative replication-defective flavivirus vector, RepliVax (RV), was evaluated for the delivery of HIV-1 immunogens. Recombinant RV-HIV viruses were engineered to stably express clade C virus Gag and Env (gp120TM) proteins and propagated in Vero helper cells. RV-based vectors enabled efficient expression and correct maturation of Gag and gp120TM proteins, were apathogenic in a sensitive suckling mouse neurovirulence test, and were similar in immunogenicity to recombinant poxvirus NYVAC-HIV vectors in homologous or heterologous prime-boost combinations in mice. In a pilot NHP study, immunogenicity of RV-HIV viruses used as a prime or boost for DNA or NYVAC candidates was compared to a DNA prime/NYVAC boost benchmark scheme when administered together with adjuvanted gp120 protein. Similar neutralizing antibody titers, binding IgG titers measured against a broad panel of Env and Gag antigens, and ADCC responses were observed in the groups throughout the course of the study, and T cell responses were elicited. The entire data demonstrate that RV vectors have the potential as novel HIV-1 vaccine components for use in combination with other promising candidates to develop new effective vaccination strategies.

Zika virus (ZIKV) is an emerging mosquito-borne pathogen representing a global health concern. It has been linked to fetal microcephaly and other birth defects and neurological disorders in adults. Sanofi Pasteur has engaged in the development of an inactivated ZIKV vaccine, as well as a live chimeric vaccine candidate ChimeriVax-Zika (CYZ) that could become a preferred vaccine depending on future ZIKV epidemiology. This report focuses on the CYZ candidate that was constructed by replacing the pre-membrane and envelope (prM-E) genes in the genome of live attenuated yellow fever 17D vaccine virus (YF 17D) with those from ZIKV yielding a viable CYZ chimeric virus. The replication rate of CYZ in the Vero cell substrate was increased by using a hybrid YF 17D-ZIKV signal sequence for the prM protein. CYZ was highly attenuated both in mice and in human in vitro models (human neuroblastoma and neuronal progenitor cells), without the need for additional attenuating modifications. It exhibited significantly reduced viral loads in organs compared to a wild-type ZIKV and a complete lack of neuroinvasion following inoculation of immunodeficient A129 mice. A single dose of CYZ elicited high titers of ZIKV-specific neutralizing antibodies in both immunocompetent and A129 mice and protected animals from ZIKV challenge. The data indicate that CYZ is a promising vaccine candidate against ZIKV.

The RepliVax® vaccine (RV) platform is based on flavivirus genomes that are rationally attenuated by deletion. These single-cycle RV vaccine candidates targeting flavivirus pathogens have been demonstrated to be safe, highly immunogenic, and efficacious in animal models, including non-human primates. Here we show utility of the technology for delivery of a non-flavivirus immunogen by engineering several West Nile-based RV vectors to express full-length rabies virus G protein. The rabies virus G protein gene was incorporated in place of different West Nile structural protein gene deletions. The resulting RV-RabG constructs were demonstrated to replicate to high titers (8 log 10 infectious particles/ml) in complementing helper cells. Following infection of normal cells, they provided efficient rabies virus G protein expression, but did not spread to surrounding cells. Expression of rabies virus G protein was stable and maintained through multiple rounds of in vitro passaging. A sensitive neurovirulence test in 2-3 day old neonatal mice demonstrated that RV-RabG candidates were completely avirulent indicative of high safety. We evaluated the RV-RabG variants in several animal models (mice, dogs, and pigs) and demonstrated that a single dose elicited high titers of rabies virus-neutralizing antibodies and protected animals from live rabies virus challenge (mice and dogs). Importantly, dogs were protected at both one and two years post-immunization, demonstrating durable protective immunity. The data demonstrates the potential of the RepliVax® technology as a potent vector delivery platform for developing vaccine candidates against non-flavivirus targets., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

The RepliVax vaccine platform(RV) is based on flavivirus genomes that are rationally attenuated by deletion. The self-limiting infection provided by RV has been demonstrated to be safe, highly immunogenic and efficacious for several vaccine candidates against flaviviruses. Here respiratory syncytial virus (RSV) F, influenza virus HA, and simian immunodeficiency virus (SIV) Env proteins were expressed in place of either prM-E or C-prM-E gene deletions of the West Nile (WN) virus genome. The resulting RV-RSV, -influenza and -SIV vaccine prototypes replicated efficiently in complementing helper cells expressing the WN structural proteins in trans. Expressed antigens exhibited correct post-translational processing and the RV recombinants were shown to be highly attenuated and immunogenic in mice, eliciting strong antigen-specific antibodies as well as detectable T-cell responses. These data support the utility of RV vectors for development of vaccines against non-flavivirus targets including rabies and HIV.

Purification of enveloped viruses such as live flavivirus vaccine candidates poses a challenge as one must retain viral infectivity to preserve immunogenicity. Here we describe a laboratory-scale purification procedure for two replication defective (single-cycle) flavivirus variants for use in a pre-clinical setting. The two step purification scheme based on hollow fiber tangential flow filtration (TFF) followed by anion exchange chromatography using convective interaction media (CIM(®)) monoliths results in a ∼60% recovery of infectious virus titer and can be used to prepare nearly homogenous, highly purified vaccine viruses with titers as high as 1×10(9) focus forming units per mL. Flavivirus virions prepared by this method are 2 and 3 orders of magnitude more pure with respect to dsDNA and BHK host cell proteins, respectively, as compared to the raw feed stream., (Copyright © 2014 Elsevier Ltd. All rights reserved.)

Tick-borne encephalitis (TBE) virus is the most important human pathogen transmitted by ticks in Eurasia. Inactivated vaccines are available but require multiple doses and frequent boosters to induce and maintain immunity. Thus far, the goal of developing a safe, live attenuated vaccine effective after a single dose has remained elusive. Here we used a replication-defective (single-cycle) flavivirus platform, RepliVax, to generate a safe, single-dose TBE vaccine. Several RepliVax-TBE candidates attenuated by a deletion in the capsid gene were constructed using different flavivirus backbones containing the envelope genes of TBE virus. RepliVax-TBE based on a West Nile virus backbone (RV-WN/TBE) grew more efficiently in helper cells than candidates based on Langat E5, TBE, and yellow fever 17D backbones, and was found to be highly immunogenic and efficacious in mice. Live chimeric yellow fever 17D/TBE, Dengue 2/TBE, and Langat E5/TBE candidates were also constructed but were found to be underattenuated. RV-WN/TBE was demonstrated to be highly immunogenic in Rhesus macaques after a single dose, inducing a significantly more durable humoral immune response compared with three doses of a licensed, adjuvanted human inactivated vaccine. Its immunogenicity was not significantly affected by preexisting immunity against WN. Immunized monkeys were protected from a stringent surrogate challenge. These results support the identification of a single-cycle TBE vaccine with a superior product profile to existing inactivated vaccines, which could lead to improved vaccine coverage and control of the disease.

RepliVax, a novel replication-defective vaccine platform has recently been described as a suitable means of generating potent vaccines targeting flaviviruses. In this study, we directly compared attenuation, immunogenicity and efficacy of several prototype RepliVax constructs to available, well characterized live attenuated (LAV) and inactivated (INV) flavivirus vaccine controls in mice and hamsters. Other important aspects of general mechanisms and properties of RepliVax vaccines were also studied. The prototypes were found to be nonpathogenic in sensitive suckling mouse neurovirulence tests, and highly immunogenic and efficacious in mice and hamsters, with evidence that immunogenicity can be comparable to LAV controls in terms of both magnitude and durability of response. Our data also suggest that choice of inoculation route can be beneficial for maximizing RepliVax immunogenicity. Additionally, different vaccine constructs can be administered as cocktail formulations without compromising immunogenicity of individual components. RepliVax constructs were determined to induce a Th1 biased immune response, similar to LAVs, and different from INV inducing a Th2 type response. The results presented validate the utility of the RepliVax platform for development of novel flavivirus vaccines., (Copyright © 2011 Elsevier Ltd. All rights reserved.)

A live chimeric vaccine virus against Japanese encephalitis (JE), ChimeriVax-JE, was used to define methods for optimal, random insertion of foreign immunologic determinants into flavivirus glycoproteins. The conserved M2e peptide of influenza A virus was randomly inserted into the yellow fever-specific NS1 glycoprotein of ChimeriVax-JE. A technique combining plaque purification with immunostaining yielded a recombinant virus that stably expressed M2e at NS1-236 site. The site was found permissive for other inserts. The insertion inhibited NS1 dimerization in vitro, which had no significant effect on virus replication in vitro and immunogenicity in vivo. Two different NS1-specific monoclonal antibodies and a polyclonal antibody efficiently recognized only the NS1 protein dimer, but not monomer. Adaptation of the virus to Vero cells resulted in two amino acid changes upstream from the insert which restored NS1 dimerization. Immunized mice developed high-titer M2e-specific antibodies predominantly of the IgG2A isotype indicative of a Th1-biased response.

Although the theoretical concern of genetic recombination has been raised related to the use of live attenuated flavivirus vaccines [Seligman, Gould, Lancet 2004;363:2073-5], it has little foundation [e.g., Monath TP, Kanesa-Thasan N, Guirakhoo F, Pugachev K, Almond J, Lang J, et al. Vaccine 2005;23:2956-8]. To investigate biological effects of recombination between a chimeric yellow fever (YF) 17D/Japanese encephalitis (JE) vaccine virus (ChimeriVax-JE) and a wild-type flavivirus Kunjin (KUN-cDNA), the prM-E envelope protein genes were swapped between the two viruses, resulting in new YF 17D/KUN(prM-E) and KUN/JE(prM-E) chimeras. The prM-E genes are easily exchangeable between flavivirues, and thus the exchange was expected to yield the most replication-competent chimeras, while other rationally designed recombinants would be more likely to be crippled or non-viable. The new chimeras proved highly attenuated in comparison with the KUN-cDNA parent, as judged by plaque size and growth kinetics in cell culture, low viremia in hamsters, and reduced neurovirulence/neuroinvasiveness in mice. These data provide strong experimental evidence that the potential of recombinants, should they ever emerge, to cause disease or spread (compete in nature with wild-type flaviviruses) would be indeed extremely low.

Numerous viruses of the Flaviviridae family, including dengue, yellow fever, Japanese encephalitis, and West Nile, cause significant disease in humans and animals. The structure and function of the molecular components of the flavivirus envelope are therefore of significant interest. To our knowledge, a membrane (M) protein mutation which affects the pH at which flavivirus particles are inactivated in vitro has never been reported. Here we show that substitution of proline for glutamine at residue M5 (MQ5P) of a Japanese encephalitis-yellow fever chimera (ChimeriVax-JE) increases its acid sensitivity in vitro by 0.3 pH units (i.e., increases the pH at which virus titer is reduced by 50% from 6.08 to 6.38). In addition, growth kinetics of this mutant virus are accelerated in Vero cells, while neurovirulence and neuroinvasiveness measured in a mouse model are unaffected. A possible interpretation of these observations is that M can modulate the envelope (E) protein function during cell infection.

St. Louis encephalitis (SLE) and West Nile (WN) flaviviruses are genetically closely related and cocirculate in the United States. Virus neutralization tests provide the most specific means for serodiagnosis of infections with these viruses. However, use of wild-type SLE and WN viral strains for laboratory testing is constrained by the biocontainment requirements. We constructed two highly attenuated yellow fever (YF) virus chimeras that contain the premembrane-envelope (prM-E) protein genes from the virulent MSI-7 (isolated in the United States) or the naturally attenuated CorAn9124 (Argentina) SLE strains. The YF/SLE (CorAn version) virus and the previously constructed YF/WN chimera were shown to specifically distinguish between confirmed human SLE and WN cases in a virus neutralization test using patient sera. These chimeras have the potential for use as diagnostic reagents and vaccines against SLE and WN.

Three consecutive plaque purifications of four chimeric yellow fever virus-dengue virus (ChimeriVax-DEN) vaccine candidates against dengue virus types 1 to 4 were performed. The genome of each candidate was sequenced by the consensus approach after plaque purification and additional passages in cell culture. Our data suggest that the nucleotide sequence error rate for SP6 RNA polymerase used in the in vitro transcription step to initiate virus replication was as high as 1.34 x 10(-4) per copied nucleotide and that the error rate of the yellow fever virus RNA polymerase employed by the chimeras for genome replication in infected cells was as low as 1.9 x 10(-7) to 2.3 x 10(-7). Clustering of beneficial mutations that accumulated after multiple virus passages suggests that the N-terminal part of the prM protein, a specific site in the middle of the E protein, and the NS4B protein may be essential for nucleocapsid-envelope interaction during flavivirus assembly.

Although the smallpox virus was eradicated over 20 years ago, its potential release through bioterrorism has generated renewed interest in vaccination. To develop a modern smallpox vaccine, we have adapted vaccinia virus that was derived from the existing Dryvax vaccine for growth in a human diploid cell line. We characterized six cloned and one uncloned vaccine candidates. One clone, designated ACAM1000, was chosen for development based on its comparability to Dryvax when tested in mice, rabbits and monkeys for virulence and immunogenicity. By most measures, ACAM1000 was less virulent than Dryvax. We compared ACAM1000 and Dryvax in a randomized, double-blind human clinical study. The vaccines were equivalent in their ability to produce major cutaneous reactions ('takes') and to induce neutralizing antibody and cell-mediated immunity against vaccinia virus.

Yellow fever, dengue, Japanese encephalitis and tick-borne encephalitis viruses are the medically most important members of the Flavivirus genus composed primarily of arboviruses. In this paper, we review the commercially available traditional flavivirus vaccines against yellow fever, Japanese encephalitis, and tick-borne encephalitis, as well as modern approaches to flavivirus vaccines. Formalin inactivation technology has been employed to produce killed vaccines. Flaviviruses have been attenuated by multiple passages in animal tissues and cell cultures to produce empirical live attenuated vaccines. The use of traditional methods is being pursued to develop vaccines against other flavivirus diseases, such as dengue, and to improve existing vaccines, such as for Japanese encephalitis. With the recent development of infectious clones, rational approaches to attenuated flavivirus vaccines have employed the introduction of specific mutations into wild type viruses and chimerisation between different viruses. Novel methods for delivery of live vaccines, such as inoculation of infectious DNA or RNA, have been described. Other approaches, such as the construction of protein subunit, expression vector-based and naked DNA vaccines, have been proposed to create alternate vaccine candidates.

Consensus sequencing of the genome of the ARILVAX live attenuated yellow fever (YF) 17D vaccine was performed directly on reconstituted virus from a vial of the vaccine secondary seed (without plaque-purification or cloning of cDNA). The genome of ARILVAX was identical in organization and size (10,862 nucleotides (nt)) to other published YF 17D sequences. A total of 12 nt heterogeneities were detected indicating that the vaccine is a heterogeneous population. Some of these indicated the presence of quasispecies with residues not reported previously for other sequenced YF 17D strains. A number of nts clearly differed from some YF vaccine strain sequences but coincided with the others, which could be due to the use of consensus sequencing approach in this study. Most (but not all) of the heterogeneities and nt differences were silent (i.e. did not result in an amino acid change). The differences are inconsequential to safety and effectiveness of ARILVAX. Other YF 17D vaccines are undoubtedly also heterogeneous and need to be re-examined using the consensus approach.

The yellow fever (YF) 17D virus is one of the most successful vaccines developed to data. Its use has been estimated to be over 400 million doses with an excellent record of safety. In the past 3 years, yellow fever vaccination was intensified in Brazil in response to higher risk of urban outbreaks of the disease. Two fatal adverse events temporally associated with YF vaccination were reported. Both cases had features similar to yellow fever disease, including hepatitis and multiorgan failure. Two different lots of YF 17DD virus vaccine were administered to the affected patients and also to hundreds of thousands of other individuals without any other reported serious adverse events. The lots were prepared from the secondary seed, which has been in continuous use since 1984. Nucleotide sequencing revealed minor variations at some nucleotide positions between the secondary seed lot virus and the virus isolates from patients; these differences were not consistent across the isolates, represented differences in the relative amount of each nucleotide in a heterogeneous position, and did not result in amino acid substitutions. Inoculation of rhesus monkeys with the viruses isolated from the two patients by the intracerebral (ic) or intrahepatic (ih) route caused minimal viremia and no clinical signs of infection or alterations in laboratory markers. Central nervous system histological scores of rhesus monkeys inoculated ic were within the expected range, and there were no histopathological lesions in animals inoculated ih. Altogether, these results demonstrated the genetic stability and attenuated phenotype of the viruses that caused fatal illness in the two patients. Therefore, the fatal adverse events experienced by the vaccinees are related to individual, genetically determined host factors that regulate cellular susceptibility to yellow fever virus. Such increased susceptibility, resulting in clinically overt disease expression, appears to be extremely rare.

We previously reported construction of a chimeric yellow fever-dengue type 2 virus (YF/DEN2) and determined its safety and protective efficacy in rhesus monkeys (F. Guirakhoo et al., J. Virol. 74:5477-5485, 2000). In this paper, we describe construction of three additional YF/DEN chimeras using premembrane (prM) and envelope (E) genes of wild-type (WT) clinical isolates: DEN1 (strain PUO359, isolated in 1980 in Thailand), DEN3 (strain PaH881/88, isolated in 1988 in Thailand), and DEN4 (strain 1228, isolated in 1978 in Indonesia). These chimeric viruses (YF/DEN1, YF/DEN3, and YF/DEN4) replicated to ~7.5 log(10) PFU/ml in Vero cells, were not neurovirulent in 3- to 4-week-old ICR mice inoculated by the intracerebral route, and were immunogenic in monkeys. All rhesus monkeys inoculated subcutaneously with one dose of these chimeric viruses (as monovalent or tetravalent formulation) developed viremia with magnitudes similar to that of the YF 17D vaccine strain (YF-VAX) but significantly lower than those of their parent WT viruses. Eight of nine monkeys inoculated with monovalent YF/DEN1 -3, or -4 vaccine and six of six monkeys inoculated with tetravalent YF/DEN1-4 vaccine seroconverted after a single dose. When monkeys were boosted with a tetravalent YF/DEN1-4 dose 6 months later, four of nine monkeys in the monovalent YF/DEN groups developed low levels of viremia, whereas no viremia was detected in any animals previously inoculated with either YF/DEN1-4 vaccine or WT DEN virus. An anamnestic response was observed in all monkeys after the second dose. No statistically significant difference in levels of neutralizing antibodies was observed between YF virus-immune and nonimmune monkeys which received the tetravalent YF/DEN1-4 vaccine or between tetravalent YF/DEN1-4-immune and nonimmune monkeys which received the YF-VAX. However, preimmune monkeys developed either no detectable viremia or a level of viremia lower than that in nonimmune controls. This is the first recombinant tetravalent dengue vaccine successfully evaluated in nonhuman primates.

Rubella virus (RUB) is a small plus-strand RNA virus classified in the Rubivirus genus of the family Togaviridae. Live, attenuated RUB vaccines have been successfully used in vaccination programs for over 25 years, making RUB an attractive vaccine vector. In this study, such a vector was constructed using a recently developed RUB infectious cDNA clone (Robo). Using a standard strategy employed to produce expression and vaccine vectors with other togaviruses, the subgenomic promoter was duplicated to produce a recombinant construct (termed dsRobo) that expressed reporter genes such as chloramphenicol acetyltransferase and green fluorescent protein (GFP) under control of the second subgenomic promoter. However, expression of the reporter genes, as exemplified by GFP expression by dsRobo/GFP virus, was unstable during passaging, apparently due to homologous recombination between the subgenomic promoters leading to deletion of the GFP gene. To improve the stability of the vector, the internal ribosome entry site (IRES) of a picornavirus, encephalomyocarditis virus, was used instead of the second subgenomic promoter to eliminate homology. Construction was initiated by first replacing the subgenomic promoter in the parent Robo infectious clone with the IRES. Surprisingly, viable virus resulted; this virus did not synthesize a subgenomic RNA. The subgenomic promoter was then reintroduced in an orientation such that a single subgenomic RNA was produced, GFP was the initial gene on this RNA, while the RUB structural protein open reading frame was downstream and under control of the IRES element. GFP expression by this vector was significantly improved in comparison to dsRobo/GFP. This strategy should be applicable to increase the stability of other togavirus vectors.

Rubella virus (RUB), a small plus-strand RNA virus, is a significant human pathogen. The RA27/3 vaccine strain of RUB is one of the most successful live attenuated vaccines developed. In this article, we report the construction of an RA27/3 infectious clone, a complete cDNA copy of the RA27/3 genome that can be transcribed in vitro to generate infectious RNA molecules. Virus generated from such in vitro transcripts was phenotypically similar to RA27/3 virus. To investigate the attenuation of the RA27/3 strain, a series of chimeras was made by the insertion of different fragments of the RA27/3 genome into an infectious clone based on the Therien wild-type strain of RUB. Analysis of the resulting chimeric viruses revealed that the pattern of RA27/3 attenuation in cell culture is complex: attenuating elements in the RA27/3 genome were found in the 5' untranslated region (UTR), a region of the nonstructural proteins containing the protease motif and the capsid gene. Within the 5' UTR, the attenuation determinant was mapped to nt 7. Surprisingly, these analyses also revealed a potentiating mutation at nt 164 of the RA27/3 genome. Although this determinant was within the coding sequences of the nonstructural proteins, the encoded amino acid had no effect on cell culture phenotype and thus the determinant may operate at the level of RNA structure. In addition to investigation of the mechanisms of RA27/3 attenuation, the availability of the RA27/3 infectious clone offers the opportunity for strict genetic control over RUB vaccine manufacturing, for development of novel DNA-based vaccines against RUB, and for development of recombinant RUB vaccines that also target other diseases., (Copyright 2000 Academic Press.)

The replication of rubella virus (RUB) in Vero cells, an adherent cell line, results in apoptotic death of infected cells as detected by chromatin fragmentation assays. In infected cultures, virtually all of the cells that had become detached (a hallmark feature of RUB-induced cytopathology) were apoptotic; they were predominantly dead as shown by propidium iodide and trypan blue exclusion tests. In contrast, the majority of the cells in the infected monolayers that remained adherent were alive and contained intact chromatin. Thus simple counting of detached cells in the medium is a convenient way of measuring the extent of RUB-induced apoptosis. RUB-induced cytopathology was inhibited by z-VAD-fmk, an inhibitor of caspases that are involved in the execution stages of apoptosis, confirming the induction of apoptosis by RUB. The lack of apoptotic adherent cells (maximally 1% at any time point through 6 days postinfection) indicates that the induction of apoptosis is asynchronous since cells become uniformly virus antigen-positive by day 2 postinfection. To elucidate whether this asynchronicity and the ability of RUB to persistently infect Vero cells were due to a suppression of apoptosis, we examined whether RUB can suppress chemically induced apoptosis. Staurosporine (ST) was found to be an efficient inducer of apoptosis in Vero cells. ST treatment of RUB-infected and RUB persistently infected cells resulted in a much higher proportion of detached cells, higher even than in Vero cells treated with ST alone. This indicates that RUB does not suppress ST-induced apoptosis and, rather, that ST and RUB acted cumulatively in inducing apoptosis, possibly indicating that they use different induction pathways., (Copyright 1998 Academic Press.)

The 5' end of the genomic RNA of rubella virus (RUB) contains a 14-nucleotide (nt) single-stranded leader (ss-leader) followed by a stem-and-loop structure [5'(+)SL] (nt 15 to 65), the complement of which at the 3' end of the minus-strand RNA [3'(-)SL] has been proposed to function as a promoter for synthesis of genomic plus strands. A second intriguing feature of the 5' end of the RUB genomic RNA is the presence of a short (17 codons) open reading frame (ORF) located between nt 3 and 54; the ORF encoding the viral nonstructural proteins (NSPs) initiates at nt 41 in an alternate translational frame. To address the functional significance of these features, we compared the 5'-terminal sequences of six different strains of RUB, with the result that the short ORF is preserved (although the coding sequence is not conserved) as is the stem part of both the 5'(+)SL and 3'(-)SL, while the upper loop part of both structures varies. Next, using Robo302, an infectious cDNA clone of RUB, we introduced 31 different mutations into the 5'-terminal noncoding region, and their effects on virus replication and macromolecular synthesis were examined. This mutagenesis revealed that the short ORF is not essential for virus replication. The AA dinucleotide at nt 2 and 3 is of critical importance since point mutations and deletions that altered or removed both of these nucleotides were lethal. None of the other mutations within either the ss-leader or the 5'(+)SL [and accordingly within the 3'(-)SL], including deletions of up to 15 nt from the 5'(+)SL and three different multiple-point mutations that lead to destabilization of the 5'(+)SL, were lethal. Some of the mutations within both ss-leader and the 5'(+)SL resulted in viruses that grew to lower titers than the wild-type virus and formed opaque and/or small plaques; in general mutations within the stem had a more profound effect on viral phenotype than did mutations in either the ss-leader or upper loop. Mutations in the 5'(+)SL, but not in the ss-leader, resulted in a significant reduction in NSP synthesis, indicating that this structure is important for efficient translation of the NSP ORF. In contrast, viral plus-strand RNA synthesis was unaffected by the 5'(+)SL mutations as well as the ss-leader mutations, which argues against the proposed function of the 3'(-)SL as a promoter for initiation of the genomic plus-strand RNA.

The sequence of the genome of the RA27/3 vaccine strain of rubella virus (RUB) was determined. In the process, several discrepancies between the previously reported genomic sequences of two wild RUB strains (Therien and M33) were resolved. The genomes of all three strains contain 9762 nucleotides (nts), exclusive of the 3' poly A tract. In all three strains, the genome contains (5' to 3'), a 40 nt 5' untranslated region (UTR), an open reading frame (ORF) of 6348 nts that encodes nonstructural proteins, a 123 nt UTR between the two genomic ORFs, a 3189 nt ORF that encodes the structural proteins, and a 62 nt 3' UTR. The 5' end of the subgenomic RNA was found to correspond to a uridine residue at nt 6436 of the genomic RNA. At the nucleotide level, the sequence of the three strains varied by 1.0 to 2.8%, while at the amino acid level, the sequence varied by 1.1 to 2.4% over both ORFs. The RA27/3 sequence will be of use in identification of the determinants of its attenuation, in vaccine production control and in development of second generation RUB vaccines based on recombinant DNA technology.

A plasmid, Robo102, which contains a cDNA copy of the rubella virus (RUB) genomic RNA from which infectious transcripts can be synthesized in vitro, was recently developed (C. Y. Wang, G. Dominguez, and T. K. Frey, J. Virol. 68:3550-3557, 1994). To increase the specific infectivity of Robo102 transcripts (approximately 5 plaques/10 microg of transcripts), a modified reverse transcription-PCR method was used to amplify nearly 90% of the RUB genome in three fragments, which were then used to replace the corresponding fragments in Robo102. Replacement of a fragment covering nucleotides (nt) 5352 to 9759 of the RUB genome yielded a construct, Robo202, which produced highly infectious transcripts (10(4) plaques/microg), indicating the presence of an unrecognized deleterious mutation (or mutations) in this region of the Robo102 cDNA. Robo102 was based on the w-Therien strain of RUB, which forms opaque plaques in Vero cells, while the PCR replacement fragments were generated from a variant, f-Therien, which produces clear plaques in Vero cells. Although Robo202 contains over 4,000 nt from f-Therien, Robo202 virus produces opaque plaques. However, when the other two PCR fragments amplified from f-Therien (nt 1 to 1723 and nt 2800 to 5352) were introduced into Robo202, the resulting construct, Robo302, yielded transcripts that produced a virus that formed clear plaques. This indicates that the determinants of plaque morphology map to the regions of the genome covered by these two fragments, both of which are in the nonstructural open reading frame. Generation of Robo202/302 chimeras indicated that the most 5' terminal fragment (nt. 1 to 1723) had the greatest effect on plaque morphology. The plaque morphology was correlated with the ability of the viruses to kill infected cells. The only difference at the molecular level detected among the viruses was that the more cytopathic viruses produced more nonstructural proteins than did the less cytopathic viruses. This finding, as well as the mapping of the genetic determinants to the region of the genome encoding these proteins, indicates that the nonstructural proteins can mediate cell killing.

A series of double-subgenomic Sindbis virus (dsSIN) recombinants that express cassettes encoding the immunogenic proteins of Japanese encephalitis virus (JEV) [prM-E, prM-E-NS1, NS1-NS2A, 80%E (encodes the amino-terminal 80% part of E), and NS1] were constructed and analyzed for their ability to confer protective immunity in mice against lethal challenge with neurovirulent JEV. The cassettes were introduced into both 5' [second subgenomic promoter of the vector precedes the SIN structural open reading frame (SP-ORF)] and 3' (the promoter follows the SP-ORF) dsSIN vectors. The longest cassette (prM-E-NS1) was 3.2 kb in length, which is remarkable for such a small vector virus as SIN (SIN genome is roughly 11.8 kb in length). The level of expression of JEV proteins appeared similar for both 5' and 3' recombinants. In general, the stability of the recombinants obtained was found to be low (expression was lost following one to five passages at low multiplicity of infection, depending on the recombinant). However, 5' recombinants containing longer cassettes (prM-E-NS1, prM-E, NS1-NS2A) were more stable than the corresponding 3' recombinants. Intraperitoneal inoculation of mice with 10(7) PFU of dsSIN-JEV recombinants induced antibodies against JEV proteins and low titers of JEV-neutralizing antibodies were produced by mice inoculated with recombinants expressing 80%E, prM-E, and prM-E-NS1. A single immunization of mice with the dsSIN-prM-E or dsSIN-prM-E-NS1 recombinants provided 40-65% protection against peripheral lethal challenge with 10(4) LD50 of neurovirulent JEV. The results demonstrate that genetically engineered togaviruses can be successfully used as vaccine vectors.

Double-subgenomic Sindbis virus (dsSIN) recombinants that express cassettes encoding prM-E or a C-terminally truncated form of E of Japanese encephalitis virus (JEV) were constructed. The products were efficiently expressed in both mammalian and mosquito cell lines infected with the dsSIN recombinants. However, suppression of prM-E secretion from mammalian cells infected with dsSIN-prM-E recombinants was observed. This suppression was more pronounced late in infection (< 5% of total product was secreted during an 8-hr chase) than early in infection (15% secretion during a 6-hr chase). In comparison, a vaccinia virus-prM-E recombinant (vP829) described previously (E. Konishi et al. (1991) Virology 185, 401-410) was shown to secrete 35-50% of total product during a 6- to 8-hr chase both early and late in infection. In contrast, secretion of prM-E from dsSIN-prM-E-infected mosquito (C6/36) cells was found to be efficient (> 50% during an 8-hr chase). The prM-E secreted from both mammalian and mosquito cells was in the form of subviral particles as determined by velocity gradient centrifugation, sensitivity to nonionic detergent, and analysis of processing of N-linked glycans. The truncated E protein expressed by the dsSIN recombinants was secreted efficiently from both mammalian and mosquito cells. Coinfection experiments with the dsSIN-JEV recombinants + wild-type vaccinia virus and vP829 + SIN demonstrated that the reduced level of secretion of subviral particles exhibited by the dsSIN-JEV recombinants was due to an inhibitory effect of the dsSIN vectors. Furthermore, this inhibitory effect was accounted for by the SIN nonstructural proteins since SIN replicons that express prM-E cassette in place of the SIN structural protein open reading frame exhibited a low level of subviral particle secretion. No self-propagating infectious particles were produced in cells transfected with SIN replicons that encode the JEV prM-E cassette. The suppression of subviral particle secretion was apparently correlated with the inhibition of cell protein synthesis which is mediated in SIN-infected vertebrate cells by expression of the SIN nonstructural proteins.

By means of immunoaffinity chromatography and expression of the gene in Escherichia coli, non-structural glycoprotein NS1 of tick-borne encephalitis virus (TBEV) and its recombinant analog were prepared. Antisera against these proteins were obtained by hyperimmunisation of rabbits. The antisera were tested by means of complement fixation, agar diffusion, hemagglutination inhibition and virus neutralization. Although both antisera are reacted with natural antigen, the recombinant analog of NS1 did not bind antibodies against natural protein in complement fixation and immunoprecipitation. Nevertheless the NS1 analog was rather active in ELISA. Neither the natural nor the recombinant protein protected experimental animals from lethal virus infection. A contamination of natural NS1 antigen with small amounts of structural glycoprotein E may be responsible for both antibody formation and virus neutralization. This can be relevant for the design of a subunit vaccine.

Several mutations were introduced into the putative serine protease domain of the tick-borne encephalitis virus NS3 protein and into a possible internal cleavage site within the protein. The influence of these mutations on proteolytic activity of NS3 protein and NS3' protein formation was tested in vitro. It was found that NS3' formation was not dependent on the activity of the NS3 N-terminal serine protease. Mutations affecting the Ser-138 residue of the NS3 protein prohibited cleavage between NS2B and NS3 proteins when the NS2B-NS3 part of the viral genome was expressed in vitro, suggesting the key role of Ser-138 in viral serine protease functioning.

Using monoclonal antibodies to the tick-borne encephalitis virus (TBE) nonstructural protein NS3 two forms of this protein were revealed in TBE-infected mammalian cells: a full-length form (69 kDa) and a short form (49 kDa) which has not been observed before and was called NS3'. Recombinant plasmids were constructed and various fragments of the TBE NS3 gene were expressed in rabbit reticulocyte lysate. By analyzing immune precipitates of 35S-labeled translation products, we could monitor and localize internal cleavage of NS3, due to which the NS3' protein was generated.

On the base of two overlapping cDNA-clones of tick-borne encephalitis virus (TBEV) genome and synthetic DNA fragments full DNA-copy of the TBEV NS3 protein gene was constructed and expressed in the E. coli cells. It was demonstrated that the relatively low biosynthesis level of full-length NS3 protein in the bacteria was due to the toxicity of the N-terminal region of the protein, consisting of it's first 180 amino acid residues. A form of the gene with deletion of nucleotides coding for the toxic region (called NS3*) was constructed and effective bacterial product of NS3* protein was obtained. The panel of monoclonal antibodies to TBEV NS1 and NS3 proteins was generated. According to the results of experiments of the binding of the monoclonal antibodies 18B2 to the bacterial products of NS3 and NS3* genes it was concluded, that the antigenic determinant recognized by these antibodies was located between 174 and 236 amino acids of TBEV NS3 protein.

Two possible forms of tick-borne encephalitis virus (TBE) gene NS1 (called NS1' and NS1) were constructed using two overlapping cDNA-fragments of TBE genome and synthetic DNA fragments. This genes were expressed in E. coli cells in expression vector pUR290 as individual proteins or fusion with bacterial beta-galactosidase. The proteins NS1 (Mw. 39 kDa), beta-galactosidase-NS1' (Mw. 162 kDa) and beta-galactosidase-NS1 (Mw. 155 kDa) were effectively synthesized under the Plgc-promoter induction conditions. Expression of NS1' gene results in the formation of two virus-specific proteins (Mw. 46 and 44 kDa). All bacterial analogs of NS1 protein fixed monoclonal and polyclonal antibodies specific to viral NS1.