Search

Deep-fried (DF) foods are considered nutritionally-inferior due to increased fat content, although they are popular with consumers due to desirable sensory characteristics. This study attempted to reduce fat of DF surimi, DF fish-protein-isolate (FPI), and DF chicken-protein-isolate (CPI) by pre-baking or pre-roasting. Surimi, FPI, and CPI were also nutrified with ω-3-rich oil, fiber, and KCl-based salt substitute. Pre-baking decreased (p < 0.05) fat content, while pre-roasting increased (p < 0.05) it. Pre-baking resulted in less (p < 0.05) changes to cook loss, moisture loss, expressible moisture, water-holding-capacity, whiteness, and texture when compared to pre-roasting. Pre-baking also better maintained ω-3 PUFAs concentration than pre-roasting, resulting in higher (p < 0.05) concentration of α-linolenic (ALA, 18:3ω3), eicosapentaenoic (EPA, 20:5ω3), and docosahexaenoic (DHA, 22:6ω3) FAs as well as unsaturated FAs and total ω-3 FAs in DF surimi, DF FPI, and DF CPI. Pre-baking in combination with nutrification using ω-3 PUFAs improved nutritional value of DF foods, while causing minimal quality changes., Competing Interests: Declaration of Competing Interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2023 Elsevier Ltd. All rights reserved.)

Isoelectric solubilization/precipitation (ISP) was used to extract krill protein isolate (KPI). Due to krill endogenous proteases ISP-KPI barely forms gel which is a major hurdle in wide application of this tremendous protein source for direct human consumption. The objective was to improve gelation and elucidate interaction mechanism between κ-carrageenan and KPI. κ-Carrageenan was added to KPI at 0.00, 0.75, 1.50, 2.25, and 3.00 g/150 g and heated at 90 °C for 15 min. Added κ-carrageenan improved texture of KPI gels. However, the level of addition had minimal effect. SDS-PAGE revealed severe proteolysis of KPI even during heating. Total and free sulfhydryl were not different, while surface hydrophobicity and water-holding-capacity slightly decreased and increased, respectively with added κ-carrageenan. Fourier-transform-infrared-spectroscopy showed none-to-minimal shift of β-sheet and α-helical protein structure; while CC and CO stretching as well as CH bending of κ-carrageenan showed the greatest shift, indicating that κ-carrageenan was mainly responsible for gel formation., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

The objective of this study was to evaluate the nutritional quality and physical characteristics of soluble proteins separated from silver carp at 4, 20, and 40 °C. Ground silver carp was diluted, and soluble proteins were separated by centrifugation and dried. The proximate composition (dry wt) of the protein powders averaged 82.42% protein, 3.25% lipid, and 14.50% ash. Average protein recovery yield was 11.78% with the better yields occurring at 20 °C (P < 0.05). Mineral profile revealed greater concentrations of Fe, Mg, P, and Na when compared to the initial homogenate. More saturated and monounsaturated fatty acids were recovered in the 4 °C powder and the least in the 40 °C powder (P < 0.05). Polyunsaturated fatty acids displayed a reverse trend, with the greatest concentration in the 40 °C powder and the least in the 4 °C powder (P < 0.05). The amino acid profile revealed that the protein powder met all FAO/WHO/UNO amino acid requirements for adults. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) revealed high amounts of low and medium molecular weight (MW) proteins (10-15 and 25-50 kDa, respectively). Two-dimensional (2-D) electrophoresis indicated that the low MW proteins possessed a neutral isoelectric point relative to that of the medium MW proteins. The protein powder was significantly less soluble (P < 0.05) than whey protein concentrate 80 at every pH tested (pH 3.0 to 11.0). Similar tendencies were seen when ionic strength was shifted (0.0 to 1.1 I; P < 0.05). Soluble protein powders derived from silver carp are nutrient rich and have physical characteristics resembling whey protein concentrate. Changes in process temperature had limited effects on protein powder composition., Practical Application: Soluble proteins contribute to 20 to 40% of fish protein and are soluble in neutral salt solutions. Much of the sarcoplasmic proteins are lost when they solubilize in processing water and are discarded similarly to how whey protein was once discarded during dairy processing. When government regulations on whey disposal were implemented, the dairy industry responded by repurposing the high-quality protein for human use and it is now a billion dollar industry. The aim of this research project was to verify the composition of an otherwise overlooked protein source., (© 2018 Institute of Food Technologists®.)

Background: Egg sticks fortified with omega-3 polyunsaturated fatty acids (ω-3 PUFAs) were developed by replacing egg yolk with salmon, algae, and flax oils. Egg sticks were cooked before analysis. Quality indicators for storage stability under different packaging and temperature were determined throughout a 28-day storage. Egg sticks were vacuum and non-vacuum packed. Further, both packaging treatments were divided into two storage temperatures of 4 and 10 °C. Quality indicators were determined every 7 days, including pH, syneresis, texture, color, microbial growth, proximate composition, fatty acid profile, and lipid oxidation., Results: Vacuum-packed egg sticks stored at 4 °C had slower degradation over time than all other treatments; however, they also had higher syneresis, harder texture, and higher anaerobic growth. Although vacuum packaging slowed lipid oxidation, it had limited effect on prevention of ω-3 PUFAs degradation; whereas refrigeration (4 °C) seemed to prevent degradation of ω-3 PUFAs better than it could slow lipid oxidation., Conclusion: Based on the results, it can be concluded that both vacuum packaging and refrigeration at 4 °C decrease degradation of egg sticks developed in the present study during storage. Under these conditions, egg sticks may maintain stability for at least 21 days of storage. © 2017 Society of Chemical Industry., (© 2017 Society of Chemical Industry.)

Background: Protein may be recovered by using pH shifts to solubilize and precipitate protein. Typically, sodium hydroxide is used as the processing base; however, this has been shown to significantly increase sodium in the final recovered protein., Results: Protein was extracted from black bullhead catfish (Ameiurus melas) using a pH-shift method. Protein was solubilized using either sodium hydroxide (NaOH) or calcium hydroxide (Ca(OH) 2 ) and precipitated at pH 5.5 using hydrochloric acid (HCl). Protein solubility was greater when Ca(OH) 2 was used compared to NaOH during this process. Using Ca(OH) 2 as the processing base yielded the greatest lipid recovery (P < 0.05) at 77 g 100 g -1 , whereas the greatest (P < 0.05) protein recovery yield was recorded as 53 g 100 g -1 protein using NaOH. Protein solubilized with Ca(OH) 2 had more (P < 0.05) calcium in the protein fraction, whereas using NaOH increased (P < 0.05) sodium content., Conclusion: Results of our study showed that protein solubility was increased and the recovered protein had significantly more calcium when Ca(OH) 2 was used as the processing base. Results showed both NaOH and Ca(OH) 2 to be an effective processing base for pH-shift protein recovery processes. © 2016 Society of Chemical Industry., (© 2016 Society of Chemical Industry.)

Calcium-enhanced protein recovered from black bullhead catfish was used to develop gels containing increasing amounts of potato starch (0-20 g/kg protein paste) and the effects of starch on functional, textural, and color properties were tested. Energy required to unfold protein groups was greater with the addition of 5 g starch/kg protein paste. Gels containing starch were harder, chewier, and less springy ( p  < .05) than gels without starch. For most measurements, regression analysis showed that increasing the starch concentration beyond 5 g/kg did not contribute to further significant textural changes. Torsional shear stress and strain along with Kramer shear force increased as the concentration of starch increased ( R 2  = .79, .79, and .53, respectively). The addition of ≥10 g starch/kg protein paste resulted in darker gels and gels got darker as more starch was added ( R 2  = .71). Results showed no benefit to increasing starch concentration in gels beyond 5 g starch/kg protein paste.

Background: Gelation conditions affect the setting of myofibrillar fish protein gels. Therefore the impact of widely applied pre-cooking gelation time/temperature strategies and post-cooking period on the texture and color of final protein gels was determined. Four pre-cooking gelation strategies (no setting time, 30 min at 25 °C, 1 h at 40 °C or 24 h at 4 °C) were applied to protein pastes (fish protein concentrate and standard functional additives). After cooking, texture and color were analyzed either directly or after 24 h at 4 °C on gels adjusted to 25 °C., Results: No-set gels were harder, gummier and chewier (P < 0.05) when analyzed immediately after cooling; however, gel chewiness, cohesiveness and firmness indicated by Kramer force benefited from 24 h at 4 °C gel setting when stored post-cooking. Gel-setting conditions had a greater (P < 0.05) effect on texture when directly analyzed and most changes occurred in no-set gels. There were significant (P < 0.05) changes between directly analyzed and post-cooking stored gels in texture and color, depending on the pre-cooking gelation strategy., Conclusion: Pre-cooking gelation conditions will affect final protein gel texture and color, with gel stability benefiting from a gel-setting period. However, post-cooking storage may have a greater impact on final gels, with textural attributes becoming more consistent between all samples., (© 2015 Society of Chemical Industry.)

Background: Isoelectric solubilization and precipitation (ISP) processing uses pH shifts to separate protein from fish frames, which may increase commercial interest for silver carp. Texture and color properties of gels made from silver carp protein recovered at different pH strategies and organic acid types were compared. ISP was applied to headed gutted silver carp using 10 mol L(-1) sodium hydroxide (NaOH) and either glacial acetic acid (AA) or a (1:1) formic and lactic acid combination (F&L). Protein gels were made with recovered protein and standard functional additives., Results: Texture profile analysis and the Kramer shear test showed that protein gels made from protein solubilized at basic pH values were firmer, harder, more cohesive, gummier and chewier (P < 0.05) than proteins solubilized under acidic conditions. Acidic solubilization led to whiter (P < 0.05) gels, and using F&L during ISP yielded whiter gels under all treatments (P < 0.05)., Conclusion: Gels made from ISP-recovered silver carp protein using organic acids show potential for use as a functional ingredient in restructured foods., (© 2014 Society of Chemical Industry.)

Infant milk formula has recently been implicated as a transmission vehicle for an emerging foodborne pathogen, Enterobacter sakazakii, resulting in high mortality rates. Electron beam (e-beam) efficiently and non-thermally inactivates foodborne pathogens, including E. sakazakii, in infant milk formula. However, the effects of e-beam on chemical changes of nutrients in infant formula have not been determined. Therefore, the objective of this study was to fulfill this gap. Dehydrated infant milk formula was processed with e-beam at 0 (control) to 25 kGy. Amino acid, fatty acid, and mineral profiles (AAP, FAP, and MP, respectively), as well as protein degradation and lipid oxidation, were determined. There were no differences (P>0.05) in FAP, AAP, and MP. SDS-PAGE electrophoresis qualitatively detected three major protein bands in all samples up to 25 kGy. Densitometry analysis of SDS-PAGE gels confirmed no size degradation (P>0.05) as a function of increased e-beam dose. Totol-volatile-basic-nitrogen (TVBN) excluded (P>0.05) protein degradation due to microbial activity. There was no increase (P>0.05) in lipid oxidation, as assessed with thiobarbituric-reactive-substances (TBARS), except in samples processed at 25 kGy. Dehydrated formula has low water activity, which likely protected nutrients from e-beam-induced chemical changes. This study demonstrates that proteins, lipids, and minerals in infant milk formula are stable when processed with e-beam up to 25 kGy at low temperature and under anaerobic conditions., (Copyright © 2013 Elsevier Ltd. All rights reserved.)

Although dietary fiber provides health benefits, most Western populations have insufficient intake. Surimi seafood is not currently fortified with dietary fiber, nor have the effects of fiber fortification on physicochemical properties of surimi been thoroughly studied. In the present study, Alaska pollock surimi was fortified with 0-8 g/100 g of long-chain powdered cellulose as a source of dietary fiber. The protein/water concentrations in surimi were kept constant by adding an inert filler, silicon dioxide in inverse concentrations to the fiber fortification. Fiber-fortified surimi gels were set at 90 °C. The objectives were to determine (1) textural and colour properties; (2) heat-induced gelation (dynamic rheology); and (3) protein endothermic transitions (differential scanning calorimetry) of surimi formulated with constant protein/water, but variable fiber content. Fiber fortification up to 6 g/100 g improved (P<0.05) texture and colour although some decline occurred with 8 g/100g of fiber. Dynamic rheology correlated with texture and showed large increase in gel elasticity, indicating enhanced thermal gelation of surimi. Differential scanning calorimetry showed that fiber fortification did not interfere with thermal transitions of surimi myosin and actin. Long-chain fiber probably traps water physically, which is stabilized by chemical bonding with protein within surimi gel matrix. Based on the present study, it is suggested that the fiber-protein interaction is mediated by water and is physicochemical in nature., (Copyright © 2013 Elsevier Ltd. All rights reserved.)

Protein isolate was recovered from whole gutted fish using isoelectric solubilisation/precipitation (ISP). The objective was to determine chemical properties of heat-set gels made of the ISP protein isolate fortified with ω-3 polyunsaturated fatty acids (PUFAs)-rich oils (flaxseed, fish, algae, krill, and blend). The extent of the PUFAs increase, ω-6/ω-3 FAs and unsaturated/saturated FAs ratios, and the indices of thrombogenicity and atherogenicity depended on specific ω-3 PUFAs-rich oil used to fortify protein isolate gels. Lipid oxidation in ω-3 PUFAs fortified gels was minimal, although greater (P<0.05) than control gels (without ω-3 PUFAs fortification). However, all gels were in the slightly rancid, but acceptable range. The commonly used thiobarbituric-acid-reactive-substances (TBARS) assay to determine lipid oxidation in seafood may be inaccurate for samples containing krill oil due to its red pigment, astaxanthin. Protein degradation (total-volatile-basic-nitrogen) was greater (P<0.05) in ω-3 PUFAs fortified gels than control gels. However, all gels were considerably below the acceptability threshold for protein degradation. The shear stress of ω-3 PUFAs fortified gels was generally greater than the control gels and the shear strain was generally unchanged. This study demonstrates that ω-3 PUFAs fortification of protein isolates recovered with ISP from fish processing by-products or whole fish has potential application in the development of functional foods., (Copyright © 2013 Elsevier Ltd. All rights reserved.)

Unlabelled: Protein was recovered from headed gutted silver carp by isoelectric solubilization at pH 2.5, 3.0, 11.5, or 12.0 and precipitation (ISP) at pH 5.5 using acetic (AA) or a 30% formic and lactic acid combination (F&L) and 10 N sodium hydroxide. Total protein and fat recovery yields, proximate composition and mineral analyses of fractions were determined. Protein and lipid recovery yields when solubilized under basic conditions were comparable to yields reported from other studies using hydrochloric acid; however, the recovered fractions were less pure. Processing at basic pH using AA was more effective than F&L at removing impurities (P < 0.05) from the recovered protein fraction and impurities were effectively removed from recovered lipids regardless of processing pH or acid type (P > 0.05). For the most part, sodium was greater (P < 0.05) and there was less calcium, phosphorus, magnesium, and iron (P < 0.05) in the recovered protein regardless of acid used when compared to the initial paste. This research shows that organic acids have the potential to recover protein and lipid by ISP processing., Practical Application: This research presents a reliable method for extracting nutritionally valuable fish protein and oils from otherwise hard to process fish and its byproducts. Replacing the traditionally used strong acids with organic acids might further accomplish bacterial load reduction while resulting in similar to or improved protein recovery yields. Therefore, this technology may increase the commercial viability of hard to process fish., (© 2013 Institute of Food Technologists®)

Background: Skin-on bone-in chicken drumsticks were processed with isoelectric solubilization/precipitation to recover muscle proteins. The drumsticks were used as a model for dark chicken meat processing by-products. The main objective of this study was conversion of dark chicken meat processing by-products to restructured functional food product. An attempt was made to develop functional food product that would resemble respective product made from boneless skinless chicken breast meat. A three-prong strategy to address diet-driven cardiovascular disease (CVD)with a functional food was used in this study. The strategy included addition of three ingredients with well-documented cardiovascular benefits: (i) ω-3 polyunsaturated fatty acid-rich oil (flaxseed-algae, 9:1); (ii) soluble fiber; and (iii) salt substitute. Titanium dioxide, potato starch, polyphosphate, and transglutaminase were also added. The batters were formulated and cooked resulting in heat-set gels., Results: Color (L*a*b*), texture (torsion test, Kramer shear test, and texture profile analysis), thermal denaturation (differential scanning calorimetry), and gelation (dynamic rheology) of chicken drumstick gels and chicken breast gels were determined and compared. Chicken drumstick gels generally had comparable color and texture properties to the gels made from chicken breast meat. The endothermic transition (thermal denaturation) of myosin was more pronounced and gelation properties were better for the drumstick gels., Conclusion: This study demonstrated a feasibility to develop functional food made of muscle proteins recovered with isoelectric solubilization/precipitation from low-value dark chicken meat processing by-products. The functional food developed in this study was enriched with CVD-beneficial nutrients and had comparable instrumental quality attributes to respective products made of chicken breast meat. Although the results of this study point towards the potential for a novel, marketable functional food product, sensory tests and storage stability study are recommended., (Copyright © 2012 Society of Chemical Industry.)

Excessive dietary intake of Na (i.e., NaCl) contributes to hypertension, which is a major risk factor for cardiovascular disease. Normally, NaOH and HCl are used to dissolve and precipitate, respectively, fish muscle proteins in isoelectric solubilization/precipitation (ISP), therefore contributing to increased Na content in the recovered fish protein isolates (FPI). Substitution of NaOH with KOH may decrease the Na content in FPI and, thus, allow development of reduced-Na seafood products. In this study, FPI was recovered with ISP using NaOH or KOH. In order to develop a nutraceutical seafood product, the FPI was extracted with NaCl or KCl-based salt substitute and subjected to cold- or heat-gelation. In addition, standard nutraceutical additives (ω-3 fatty acids-rich oil and dietary fiber) along with titanium dioxide (TiO2) were added to FPI. Color, texture, dynamic rheology, Na and K content, and lipid oxidation of the FPI gels were compared to commercial Alaska pollock surimi gels. FPI gels had greater (p < 0.05) whiteness, good color properties (L*a*b*), and generally better textural properties when compared to surimi gels. Although the ISP-recovered FPI and surimi developed similar final gel elasticity, the proteins in FPI and surimi had different gelation pattern. A reduction (p < 0.05) of Na content and simultaneous increase (p < 0.05) in K content of FPI gels was achieved by the substitution of NaOH with KOH during ISP and NaCl with the KCl-based salt substitute during formulation of the FPI paste. Although cooking and addition of NaCl during formulation of the FPI paste increased (p < 0.05) lipid oxidation in FPI gels, TBARS values were much below rancidity levels. These results indicate that KOH can replace NaOH to recover FPI from whole gutted fish for subsequent development of nutraceutical seafood products tailored for reduction of diet-driven cardiovascular disease.

Surimi-based seafood products are widely accepted and enjoyed worldwide. The US consumption increased in 1980s; however, it leveled thereafter. Food products nutrified with ω-3 polyunsaturated fatty acids (PUFAs) are in increasing demand due to demonstrated health benefits. Currently, surimi seafood is not nutrified with ω-3 PUFAs. In the present study, surimi seafood was nutritionally-enhanced with ω-3 PUFAs-rich oils (flaxseed, algae, menhaden, krill, and blend). The objectives were (1) chemical characterization of FA composition and oxidation, and (2) determination of physicochemical properties (colour and texture) of the nutritionally-enhanced surimi seafood. Oil addition resulted in increased (P<0.05) concentration of total ω-3 FAs in surimi seafood; however, the concentration of α-linolenic (ALA, 18:3ω-3), eicosapentaenoic (EPA, 20:5ω-3) and docosahexaenoic (DHA, 22:6ω-3) acids depended on which oil was added. Although the ω-3 PUFAs nutrification resulted in increased (P<0.05) susceptibility of surimi seafood to lipid oxidation, it was within ranges acceptable to consumers. Texture analysis (texture profile analysis, Kramer shear and torsion test) showed that ω-3 PUFAs nutrification did not affect texture. Colour properties of ω-3 PUFAs nutrified surimi seafood were generally improved except when krill oil or blend was added. This study demonstrates that nutritional value of surimi seafood can be enhanced with concurrent improvement of colour and without affecting texture., (Copyright © 2011 Elsevier Ltd. All rights reserved.)

Isoelectric solubilization and precipitation (ISP) is a protein recovery process effective at reducing Listeria innocua, a nonpathogenic bacterium typically used as a surrogate for L. monocytogenes in recovered trout protein. The response of L. monocytogenes to ISP processing was determined and compared to the response of L. innocua. Headed and gutted rainbow trout were inoculated with L. monocytogenes (10.16 log CFU/g), homogenized, and pH-adjusted with granular citric acid (pH 2.0 and 2.5) or glacial acetic acid (pH 3.0 and 3.5). Proteins were solubilized and centrifugation was used to remove insoluble components (skin, insoluble protein, so on). The supernatant was returned to the protein isoelectric point (pH 5.5) with NaOH and centrifuged to remove precipitated protein. Microbial load was enumerated on both growth and selective media; recovery was not significantly different (P > 0.05). Surviving cells from each component (protein, insoluble, and water) were compared to initial inoculum numbers. Significant reductions were detected at all pH (P < 0.05). The greatest reductions were at pH 3.0 with acetic acid, with a mean log reduction of 3.03 in the combined components, and a 3.53 log reduction in the protein portion. Data were compared to results from a previous study using L. innocua. Significant differences (P < 0.05) in recovery were found between the 2 species at pH 2.0 and 3.0 with greater recovery of L. monocytogenes, regardless of processing pH or acid type. These results demonstrate the variability in resistance between species and indicate that L. innocua is not an appropriate surrogate for L. monocytogenes for ISP processing with organic acids., (© 2011 Institute of Food Technologists®)

During mechanical fish processing, a substantial amount of protein is discarded as by-products. Isoelectric solubilization and precipitation (ISP) is a process that uses extreme pH shifts to solubilize and precipitate protein from by-products to recover previously discarded protein. Typically, strong acids are used for pH reduction, but these acids do not have a pasteurization effect (6 log reduction) on bacterial load; therefore, organic acids were used during ISP processing to test the impact on Listeria innocua concentrations. Headed and gutted rainbow trout (Oncorhynchus mykiss) were inoculated with L. innocua, homogenized, and brought to the target pH with granular citric acid (pH 2.0 and 2.5) or glacial acetic acid (pH 3.0 and 3.5). Proteins were solubilized for 10 min at 4°C, and insoluble components (e.g., skin and insoluble protein) were removed by centrifugation. The remaining solution was pH shifted to the protein isoelectric point (pH 5.5) with sodium hydroxide, and precipitated protein was separated from the water. Microbial cells for each component (proteins, insolubles, and water) were enumerated on modified Oxford agar (MOX) and tryptic soy agar with 6% yeast extract (TSAYE). The sums of the surviving cells from each component were compared with the initial inoculum levels. No significant differences were observed between results obtained from TSAYE and from MOX (P > 0.05). Significant reductions in microbial populations were detected, regardless of pH or acid type (P < 0.05). The greatest reduction was at pH 3.0 with glacial acetic acid, resulting in a mean reduction of 6.41 log CFU/g in the recovered protein and 5.88 log CFU/g in the combined components. These results demonstrate the antimicrobial potential of organic acids in ISP processing.

Purpose: Electron beam (e-beam) efficiently and non-thermally inactivates microorganisms in food by lethal DNA changes (direct effects) and free radicals from water radiolysis (in-direct effects). Non-pathogenic Escherichia coli DH5α (α substrain of DH5 described by Hanahan 1985 , 'DH' stands for Douglas Hanahan) is a microorganism that lacks DNA repair capability, resulting in high radiosensitivity. Studying microbial inactivation of E. coli DH5α repeatedly subjected to sub-lethal e-beam in ground beef may enhance understanding of microbial radioresistance. The objective of this study was to determine if repetitive processing with e-beam at sub-lethal doses increases D-value (e-beam dose required to inactivate one log of microbial population) of E. coli DH5α in ground beef., Materials and Methods: Survivors from the highest e-beam dose were isolated and incubated in ground beef for the next cycle of e-beam processing. Five cycles were conducted. To acclimatise E. coli DH5α, first two cycles used low doses. D-values were determined following the third cycle., Results: D-values increased (p < 0.05) significantly with each cycle. Thus, E. coli DH5α has a capability to develop greater radioresistance under these experimental conditions. Following the third cycle D-values were 0.32 ± 0.006 and 0.32 ± 0.002 kGy for survivors enumerated on non-selective and selective media, respectively; the fourth cycle 0.39 ± 0.007 and 0.40 ± 0.019 kGy; and the fifth cycle 0.46 ± 0.006 and 0.46 ± 0.020 kGy. D-values on non-selective and selective media were similar (p > 0.05) indicating absence of cell recovery in E. coli DH5α., Conclusions: E. coli DH5α increases radioresistance to e-beam as a result of repetitive exposure to sub-lethal doses despite its DNA repair deficiency.

The effects of dietary modification with flaxseed oil-enhanced (Flax) feed on the product quality of brook trout fillets were examined. Trout were fed a commercial feed supplemented with fish oil (CD) or flaxseed oil (Flax) for 165 d before harvesting. Proximate composition and fatty acid profile were determined on fillets. Quality parameters of the raw fillets were examined over the storage period by measuring color (L*, a*, b*), muscle pH, and thiobarbituric acid reactive substances test. Evaluations on the cooked fillets included sensory evaluation with triangle tests and a paired preference test. There were no differences in proximate composition between the groups; however, the total omega-3 fatty acids were greater in Flax fillets (P<0.05). Diet and day were shown to interact in their effect on whiteness, pH, and lipid oxidation (P<0.05); however, linear regression did not determine that malondialdehyde concentration was associated with time in either diet type implying that lipid oxidation in the vacuum-packed fish was controlled at storage temperatures (4°C). Sensory panelists were able to choose the odd sample in a replicated triangle test analyzed using the β-binomial model, and there was preference for Flax fillets (P<0.05). Results indicate that a Flax-enhanced diet would have favorable effects on product quality of farmed brook trout.

Unlabelled: The effect of electron beam (e-beam) radiation on the recovery of Salmonella serotypes Tennessee (ATCC 10722) and Typhimurium (ATCC 14028) in creamy peanut butter over a 14-d storage period at 22 °C was studied. Each Salmonella type was independently inoculated into peanut butter and subjected to e-beam doses that ranged from 0 to 3.1 kGy, confirmed by film dosimetry. After 2-, 4-, 6-, 8-, and 14-d of storage, microbial analyses were conducted. Survivors were recovered on growth and selective media using standard spread-plating methods. Microbial counts (CFU/g) were log-converted and differences were determined by ANOVA and Tukey's Honestly Significant Differences test. When samples were not e-beam-treated, there were no significant changes (P > 0.05) in microbial numbers over time. In e-beamed samples, microbial numbers decreased over time; however, reductions were not always significant. Initial recovery rates (R-rates) 2 d after e-beam treatment were significantly different for the 2 strains of Salmonella and between recovery media (P < 0.05); however, these differences did not persist for the remainder of the storage period (P > 0.05) indicating that injured cells were not able to survive in the high-fat, low-water activity peanut butter environment. R-rates for both strains of Salmonella were maintained until day 14 when there were significant reductions in Salmonella Typhimurium (P < 0.05). These results indicate that Salmonella Tennessee and Salmonella Typhimurium will survive in peanut butter when exposed to nonlethal doses of e-beam irradiation., Practical Application: Electron beam (e-beam) irradiation is an alternative to thermal processing; this technique inactivates microorganisms and insects that might be present in a food by generating radiation by accelerated electrons that inactivate organisms directly because of interaction with cell components and indirectly by producing free radicals that disrupt integrity of the cell membrane. E-beam radiation will reduce the number of probable microbiological hazards that could be present while the food remains generally unaffected in texture, taste, and nutritional value. A recent study showed e-beam irradiation to be effective at reducing both Salmonella Tennessee and Typhimurium in peanut butter by one log after exposure to less than 1 kGy, highlighting the need to explore this process further.

Peanut butter and peanut paste products were implicated as the vehicle of contamination in an outbreak of Salmonella Typhimurium, which began in September 2008, and in the November 2006 outbreak of Salmonella Tennessee. Therefore, this study evaluated the effectiveness of electron beam (e-beam) radiation for the reduction of Salmonella serovars Tennessee (ATCC 10722) and Typhimurium (ATCC 14028) in creamy peanut butter. Each strain was studied independently. Peanut butter samples were inoculated with approximately 8.0 log CFU/g of Salmonella, and exposed to e-beam doses ranging from 0 to 3.1 kGy. Doses were confirmed with film dosimetry. Survivors were enumerated by standard spread plating on nonselective tryptic soy agar (TSA) and selective xylose-lysine-desoxycholate agar (XLD) media. Salmonella Tennessee was more susceptible to e-beam radiation, with 5.00- and 6.75-log reduction of cells on TSA and XLD, respectively, at the approximate e-beam dose of 3.0 kGy. Salmonella Typhimurium was reduced by 4.19 and 4.85 log on TSA and XLD, respectively, at the approximate e-beam dose of 3.0 kGy. D(10)-values show that Salmonella Typhimurium was more resistant (0.82 +/- 0.02 and 0.73 +/- 0.01 kGy on TSA and XLD, respectively) than was Salmonella Tennessee (0.72 +/- 0.02 and 0.60 +/- 0.01 kGy on TSA and XLD, respectively) to e-beam radiation (P < 0.05). The recovery on growth and selective media were different (P < 0.05), indicating cell injury. The results of this study demonstrate that e-beam radiation may be an effective processing step for the nonthermal inactivation of Salmonella in peanut butter.

Protein recovery for fish processing by-products utilizes extreme pH shifts for isoelectric solubilization and precipitation. The purpose of this study was to determine if Escherichia coli would survive exposure to the extreme pH shifts during the protein recovery process. Fresh rainbow trout were beheaded, gutted, and minced and then inoculated with approximately 10(9) CFU of E. coli ATCC 25922 per g, homogenized, and brought to the target pH of 2.0, 3.0, 11.5, or 12.5 by the addition of concentrated hydrochloric acid or sodium hydroxide to solubilize muscle proteins. The homogenate was blended and centrifuged to separate the lipid and insoluble components (bones, skin, insoluble protein, etc.) from the protein solution. The protein solution was subjected to a second pH shift (pH 5.5) resulting in protein precipitation that was recovered with centrifugation. Microbial analysis was conducted on each fraction (i.e., lipid, insoluble components, protein, and water) with selective and nonselective media. The sums of the surviving E. coli in these fractions were compared with the initial inoculum. The greatest total microbial reduction occurred when the pH was shifted to 12.5 (P < 0.05), i.e., a 4.4-log reduction of cells on nonselective media and a 6.0-log reduction of cells on selective media. The use of selective and nonselective media showed that there was significant (P < 0.05) injury sustained by cells exposed to alkaline treatment (pH 11.5 and 12.5) in all fractions except the insoluble fraction at pH 11.5. Increasing the exposure time or the pH may result in greater bacterial reductions in the recovered protein.

Protein wasted by the disposal of fish processing by-products may be recovered using isoelectric solubilization and precipitation. Extreme pH shifts are used to solubilize the protein and then it is recovered by precipitation and centrifugation. Microbial survival after this process is unknown; therefore, the purpose was to see if Listeria innocua would survive extreme pH shifts during the protein recovery process. Fresh rainbow trout fillets were inoculated with L. innocua, homogenized, and brought to the target pH of 2, 3, 11.5, or 12.5 by the addition of concentrated hydrochloric acid or sodium hydroxide. The proteins were allowed to solubilize at 4 degrees C for 10 min, centrifuged, and the lipid and insoluble components (bones, skin, insoluble protein, and so on) were removed. A 2nd pH shift (pH 5.5) and centrifugation was used to separate the precipitating protein and water fractions. Each constituent (lipid, protein, water, insoluble components) was analyzed for bacterial content using growth and selective media. The sums of the surviving L. innocua in these constituents were compared to the initial inoculum. There were no significant differences in recovery on growth or selective media (P > 0.05). The greatest loss occurred when the pH was shifted to 2, with a 3.1-log reduction in the combined fractions of the trout fillets and a 3.8-log reduction in the protein fraction. There were no significant losses when the pH was adjusted to 11.5 (P > 0.05). Future studies will continue to look at the effects of using organic acid, rather than inorganic, for protein solubilization.

Ready-to-eat meat products have been implicated in several foodborne listeriosis outbreaks. Microbial contamination of these products can occur after thermal processing when products are chilled in salt brines. The objective of this study was to evaluate UV radiation on the inactivation of Listeria monocytogenes and lactic acid bacteria in a model brine chiller system. Two concentrations of brine (7.9% [wt/wt] or 13.2% [wt/wt]) were inoculated with a approximately 6.0 log CFU/ml cocktail of L. monocytogenes or lactic acid bacteria and passed through a UV treatment system for 60 min. Three replications of each bacteria-and-brine combination were performed and resulted in at least a 4.5-log reduction in microbial numbers in all treated brines after exposure to UV light. Bacterial populations were significantly reduced after 5 min of exposure to UV light in the model brine chiller compared with the control, which received no UV light exposure (P < 0.05). The maximum rate of inactivation for both microorganisms in treated brines occurred between minutes 1 and 15 of UV exposure. Results indicate that in-line treatment of chill brines with UV light reduces the number of L. monocytogenes and lactic acid bacteria.

A novel and compact low-energy (keV) high-power pulsed electron beam (e-beam) that utilizes a secondary emission electron gun (SEEG) was designed and constructed. Escherichia coli JM 109 at a concentration of 10(6) CFU/mL was spread-plated on Luria-Bertani (LB) medium and subjected to the SEEG e-beam. The e-beam was administered as 1 or 5 pulses. The duration of a single pulse was constant at 5 micros, e-beam current density was constant at 25 mA/cm2, and e-beam energy varied between 60 and 82.5 keV. Following treatment with the SEEG e-beam, survivors of the irradiated E. coli samples were enumerated by a standard 10-fold dilution and spread-plated. The survivor curves were plotted on logarithmic scale as a function of e-beam dose. The D10-values were calculated as a negative reciprocal of the slope of the survivor curves. The D10-values for E. coli inactivated with 1- and 5-pulse SEEG e-beam were 0.0026 and 0.0217 Gy, respectively. These D10-values were considerably lower than published D10-values for E. coli inactivated with conventional high-energy continuous e-beam, likely due to shorter exposure time (t), greater current density (J), and a pulse mode of the SEEG e-beam. The SEEG e-beam showed promising results for microbial inactivation in a nonthermal manner; however, due to low energy of the SEEG e-beam, current applications are limited to surface decontamination. The SEEG e-beam may be an efficient processing step for surface inactivation of food-borne pathogens on ready-to-eat products, including fresh and leafy vegetables.

Sensory and chemical consequences of treating goat milk using an UV fluid processor were assessed. Milk was exposed to UV for a cumulative exposure time of 18 s and targeted UV dose of 15.8 +/- 1.6 mJ/cm2. A triangle test revealed differences between the odor of raw milk and UV irradiated milk. Oxidation and hydrolytic rancidity was measured by thiobarbituric acid reactive substances and acid degree values (ADV). As UV dose increased, there was an increase in thiobarbituric acid reactive substance values and ADV of the milk samples. A separate set of samples were processed using the fluid processor but with no UV exposure to see if lipase activity and agitation from pumping contributed to the differences in odor. The ADV increased at the same rate as samples exposed to UV; however, sensory studies indicated that the increase of free fatty acids was not enough to cause detectable differences in the odor of milk. Solid phase microextraction and gas chromatography were utilized for the analysis of volatile compounds as a result of UV exposure. There was an increase in the concentration of pentanal, hexanal, and heptanal (relative to raw goat milk) after as little as 1.3 mJ/cm2 UV dose. Ultraviolet irradiation at the wavelength 254 nm produced changes in the sensory and chemical properties of fluid goat milk.

Certain types of goat's cheeses are produced using unpasteurized milk, which increases the food safety concerns for these types of products. Popularity and consumption of goat's milk products have increased, and the niche market includes gourmet goat's cheeses. The U.S. Code of Federal Regulations and the Pasteurized Milk Ordinance both address the possibility for processing alternatives to heat treatment, and the use of UV light treatment may be a viable alternative that still ensures the safety of the product. Fresh goat's milk was inoculated with Listeria monocytogenes (L-2289) at 10(7) CFU/ml and exposed to UV light using the CiderSure 3500 apparatus (FPE Inc., Macedon, NY). Inoculated milk was exposed to a UV dose range between 0 and 20 mJ/cm2 to determine the optimal UV dose. A greater than 5-log reduction was achieved (P < 0.0001) when the milk received a cumulative UV dose of 15.8 +/- 1.6 mJ/cm2. The results of this study indicate that UV irradiation could be used for the reduction of L. monocytogenes in goat's milk.