Search

A double mutant of tick anticoagulant peptide (TAP) was cloned as a chimeric fusion with the yeast alpha-mating factor pre-proleader peptide. Expression in yeast (Saccharomyces cerevisiae) resulted in the secretion of the TAP mutein into the culture medium. An HPLC-based assay was used to screen yeast strains to find those giving highest expression levels. Efficiency of cleavage at the junction of the leader-TAP mutein varied from strain to strain, and a rapid purification method followed by N-terminal sequence analysis was used to identify a host strain that minimized undesirable cleavage products. A purification scheme was developed which separated the TAP mutein from improperly processed peptides present in the medium. This scheme employed cation-exchange chromatography and reversed-phase HPLC. Scale-up of the process was successful and produced 100 mg of fully functional TAP mutein of >96% homogeneity from a 50-L yeast culture., (Copyright 1998 Academic Press.)

It has been shown previously that immunization of animals with recombinant virus-like particles (VLPs) consisting of the viral capsid proteins L1 or L1 plus L2 protected animals against experimental viral challenge. However, none of these experimental models addresses the issue of whether systemic immunization with VLPs elicits a neutralizing antibody response in the genital mucosa. Such a response may be necessary to protect the uterine cervix against infection with genital human papillomavirus (HPV) types. African green monkeys systemically immunized with HPV-11 VLPs expressed in Saccharomyces cerevisiae and formulated on aluminum adjuvant elicited high-titered HPV-11 VLP-specific serum antibody responses. Sera from these immunized monkeys neutralized HPV-11 in the athymic mouse xenograft system. Significant levels of HPV-11-neutralizing antibodies also were observed in cervicovaginal secretions. These findings suggest that protection against HPV infection of the uterine cervix may be possible through systemic immunization with HPV VLPs.

The major capsid protein L1 of human papillomaviruses (HPVs) has been identified as a promising candidate antigen for a prophylactic HPV vaccine. Since amino acid sequence heterogeneity has been demonstrated for the L1 genes within individual HPV types, nucleotide sequences of L1 were determined from six HPV-18 clinical isolates and the cervical carcinoma cell line SW756 and compared to the published HPV-18 prototype sequence. The sequences were almost identical between the clinical isolates and SW756 but differed markedly from the published prototype sequence. Resequencing the prototype HPV-18 revealed that these differences were due to sequencing artifacts of the prototype HPV-18 sequence archived in GenBank. Thus, the HPV-18 L1 genes seem to display a very high level of sequence conservation. The HPV-18 L1 gene derived from SW756 was expressed in Saccharomyces cerevisiae and self-assembly of the L1 protein into virus-like particles was demonstrated.

Papillomaviruses infect epithelia of the skin and mucous membranes and cause benign or malignant tumours in animals and in humans. The viruses are highly species-specific, and cell culture systems for propagating human papillomaviruses (HPVs) do not exist. However, there are several animal papillomavirus models. In the cottontail rabbit papillomavirus (CRPV) system, we demonstrated that recombinant CRPV virus-like particles (VLPs) consisting of the capsid proteins L1 or L1+L2 can be produced in the yeast Saccharomyces cerevisiae. Three immunizations with L1 VLPs formulated on aluminum adjuvant at 1-100 micrograms dose-1 efficiently protected rabbits from challenge with CRPV. Sera of immunized rabbits were shown to contain high-titered serum antibodies to CRPV L1 VLPs and to neutralize CRPV in vitro. Our results suggest that recombinant yeast-derived VLPs could be the basis for a candidate HPV vaccine.

Hirudin (HIR), derived from leeches, and tick anticoagulant peptide (TAP) are polypeptide protease inhibitors of thrombin and coagulation factor Xa (fXa), respectively, and they have both shown utility in vitro and in vivo as potent antithrombotic agents. A thorough side-by-side comparison of the in vivo efficacy of factor Xa inhibition compared to thrombin inhibition by TAP and HIR, respectively, required purification and characterization of multigram amounts of hirudin. Therefore, a recombinant Saccharomyces cerevisiae strain was developed using a plasmid containing the gene encoding the MF alpha 1 preproleader, a synthetic hybrid HV1-HV2 HIR gene, and a galactose-inducible promoter which directed the secretion of 44 mg/liter of recombinant HIR (rHIR) after induction. rHIR was purified by a process that consisted of two chromatographic steps and decolorization. Total yield for the purification process was 3.6 g, or 41%. This process gave 59-fold purification of rHIR that was judged to be > 96% pure with regard to polypeptide content by capillary zonal electrophoresis and reversed-phase high-performance liquid chromatography. Single, unique N- and C-termini were obtained by sequencing and were identical to those predicted from the deduced sequence of the cDNA. Determination of the dissociation constant, by thrombin:hirudin inhibition reaction, and anticoagulant activity, by the activated partial thromboplastin time, demonstrated that the hybrid rHIR HV1-HV2 protein discussed in this report was essentially equipotent with rHIR preparations HV1 and HV2 reported by others.

Secretion from recombinant yeast was used as a potential source of large quantities of the leech protein antistasin (ATS), a potent and highly specific inhibitor of the serine protease coagulation factor Xa. Mature recombinant ATS (r-ATS) is obtained after intracellular cleavage by the yscF protease of the mating factor alpha-1 pre-proleader from the fusion protein at the Lys-Arg sequence junction. Production levels are relatively low (ca. 1 mg/liter). Purification of the secreted product from a complex growth medium involved cell removal by microfiltration and diafiltration, cation-exchange capture and concentration on S-Sepharose Fast Flow, C-4 reverse-phase high-performance liquid chromatography (RP-HPLC), and HPLC cation-exchange chromatography step, and RP-HPLC concentration and desalting. The process was scaled up from the 16- to the 250-liter level with a corresponding increase in amount of r-ATS. From the 250-liter fermentation two major forms, r-ATS-I and r-ATS-II, distributed approximately 60:40, and a minor form, r-ATS-minor (ca. 1% of the purified r-ATS), were characterized. Limited N-terminal sequence analysis by Edman degradation indicated that r-ATS-I has the predicted mature N-terminus starting with Gln, that r-ATS-II is N-terminally blocked with pyroglutamate, and that r-ATS-minor is an incompletely processed form. RP-HPLC, hydrophilic-interaction HPLC, cation-exchange HPLC analysis, and electrophoresis results are consistent with the differences observed by sequencing. Preliminary in vitro characterization by intrinsic Ki determination for factor Xa inhibition indicated that the yeast r-ATS forms are indistinguishable from each other as well as from r-ATS expressed by the insect baculovirus host-vector system. Nevertheless, r-ATS-I and r-ATS-II appear less potent than insect-derived r-ATS in the activated partial thromboplastin time clotting assay. Further characterization indicated that C-terminal cleavage at Pro-116 had occurred in r-ATS-I and r-ATS-II as well as oxidation of methionine residues to methionine sulfoxide. The possible role of the C-terminus in inhibition of the prothrombinase complex is discussed.

The rapidly acting inhibitor of plasminogen activators, PAI-1, was produced intracellularly in Saccharomyces cerevisiae by using the ADH2 promoter to drive the expression of the human PAI-1 cDNA. Approximately 8 mg of human PAI-1 was produced per liter of confluent yeast culture. A purification scheme which resulted in 20% recovery of isolated PAI-1 from the broken yeast cell homogenate was devised. Yeast-derived human PAI-1 differs from endothelial-type PAI-1 isolated from HT1080 fibrosarcoma cells in that the recombinant inhibitor does not contain carbohydrate side chains. Nevertheless, the activity and other functional attributes of yeast-derived PAI-1 are similar to those exhibited by HT1080 fibrosarcoma cell-derived PAI-1. Hence, this study demonstrates that expression of human PAI-1 in yeast is a viable strategy for the production of ample quantities of this key modulator of plasminogen activator-mediated proteolysis.

An artificial capillary system was devised for growth of hepatoma cells that yields very high titers of hepatitis B surface antigen (HBsAg). High yield of antigen was facilitated by slowing cellular metabolism through reduction of incubation temperature and addition of 0.1 mM caffeine. Deletion of serum from the medium did not reduce the yield of antigen. HBsAg prepared from the culture fluid by affinity chromatography and additional chemical and enzymatic steps was essentially pure and was indistinguishable from HBsAg prepared from infected human plasma. Preparation of HBsAg from the cell culture source presents advantages over that of human plasma and might be a source of HBsAg for vaccine preparation.

Vaccine against human hepatitis B was prepared using antigen derived from hepatitis B carrier hepatoma cells grown in the interstices of a Diaflo hollow filter unit. Hepatitis B surface antigen (HBsAg) produced by these cells was purified by immune affinity chromatography, digestion with DNase and pepsin, and Sephadex G-150 separation. The Formalin-treated antigen was formulated in 20-micrograms dose on alum adjuvant with thimerosal added as a preservative. This cell culture vaccine was as potent as human plasma-derived vaccine as measured in a mouse potency assay. The vaccine proved safe in tests in chimpanzees and in human subjects who were in late stages of cancer of the central nervous system and who were receiving therapy for their condition. None of five subjects who received the vaccine developed untoward clinical reactions. Two of the subjects who received all three doses of vaccine developed antibody against HBsAg. Three persons, two given only the primary doses and one who was given all three doses but was lost to follow-up, demonstrated no response. The slow and relatively low antibody responses to the vaccine were similar to those in other immunosuppressed persons who were given vaccine of human plasma origin.