Search

Zaire ebolavirus, Sudan ebolavirus, and Marburg marburgvirus are the filoviruses most commonly associated with human disease. Previously, we administered a three-dose regimen of trivalent vaccines comprising glycoprotein antigens from each virus in mice and non-human primates (NHPs). The vaccines, which contained a polysorbate 80-stabilized squalane-in-water emulsion adjuvant and were lyophilized from a solution containing trehalose, produced high antibody levels against all three filovirus antigens. Subsequently, single-vial formulations containing a higher concentration of adjuvant were generated for testing in NHPs, but these vaccines elicited lower neutralizing antibody titers in NHPs than previously tested formulations. In order to explain these results, in the current work we measured the size of adjuvant emulsion droplets and the peroxide levels present in the vaccines after lyophilization and reconstitution and tested the effects of these variables on the immune response in mice. Increases in squalane droplet sizes were observed when the ratio of adjuvant to trehalose was increased beyond a critical value, but antibody and neutralizing antibody titers in mice were independent of the droplet size. Higher levels of peroxides in the vaccines correlated with higher concentrations of adjuvant in the formulations, and higher peroxide levels were associated with increased levels of oxidative damage to glycoprotein antigens. Neutralizing titers in mice were inversely correlated with peroxide levels in the vaccines, but peroxide levels could be reduced by adding free methionine, resulting in retention of high neutralizing antibody titers. Overall, the results suggest that oxidation of glycoprotein antigens by peroxides in the polysorbate 80-stabilized squalane-in-water emulsion adjuvant, but not lyophilization-induced increases in adjuvant emulsion droplet size may have been responsible for the decreased neutralizing titers seen in formulations containing higher amounts of adjuvant.

Zaire ebolavirus (EBOV), Sudan ebolavirus (SUDV), and Marburg marburgvirus (MARV) are the most prevalent and pathogenic species of filovirus. Previously, we showed that glycoprotein antigens from each virus could be lyophilized to create thermostable monovalent subunit vaccines. However, cross-protection is not expected from the monovalent vaccines and therefore developing a trivalent filovirus vaccine would be desirable. Subunit protein vaccines often require the addition of an adjuvant to sufficiently boost the immunogenicity. Typically, liquid suspensions or emulsions of adjuvants and lyophilized antigens are stored in separate vials to avoid destabilizing interactions and are only mixed immediately before administration. Herein, we describe the development and characterization of monovalent and trivalent filovirus vaccines that are co-lyophilized with a squalane-in-water emulsion adjuvant. We found that the single-vial presentation retained adjuvant particle diameter and zeta potential after lyophilization and reconstitution. Furthermore, the trivalent vaccines elicited high antibody levels against all three antigens in mice and non-human primates. These results advance the prospect of developing a single-vial trivalent filovirus vaccine, which would enable easier distribution and administration of the vaccine to resource-poor areas.

The filoviruses Zaire ebolavirus (EBOV), Marburg marburgvirus (MARV), and Sudan ebolavirus (SUDV) are some of the most lethal infectious agents known. To date, the Zaire ebolavirus vaccine (ERVEBO®) is the only United States Food and Drug Administration (FDA) approved vaccine available for any species of filovirus. However, the ERVEBO® vaccine requires cold-chain storage not to exceed −60 °C. Such cold-chain requirements are difficult to maintain in low- and middle-income countries where filovirus outbreaks originate. To improve the thermostability of filovirus vaccines in order to potentially relax or eliminate these cold-chain requirements, monovalent subunit vaccines consisting of glycoproteins from EBOV, MARV, and SUDV were stabilized within amorphous disaccharide glasses through lyophilization. Lyophilized formulations and liquid controls were incubated for up to 12 weeks at 50 °C to accelerate degradation. To identify a stability-indicating assay appropriate for monitoring protein degradation and immunogenicity loss during these accelerated stability studies, filovirus glycoprotein secondary, tertiary, and quaternary structures and vaccine immunogenicity were measured. Size-exclusion chromatography was the most sensitive indicator of glycoprotein stability in the various formulations for all three filovirus immunogens. Degradation of the test vaccines during accelerated stability studies was reflected in changes in quaternary structure, which were discernible with size-exclusion chromatography. Filovirus glycoproteins in glassy lyophilized formulations retained secondary, tertiary, and quaternary protein structure over the incubation period, whereas the proteins within liquid controls both aggregated to form higher molecular weight species and dissociated from their native quaternary structure to form a variety of structurally-perturbed lower molecular weight species.