Search

Sustainability and life-cycle concerns about the conventional activated sludge (CAS) process for wastewater treatment have been driving the development of energy-efficient, greener alternatives. Feasibility of an algal-based wastewater treatment (A-WWT) system has been demonstrated recently as a possible alternative, capable of simultaneous nutrient and energy recovery. This study compared capabilities of the A-WWT and CAS systems in removing organic micropollutants (OMP). Initial assessments based on surrogate organic measures and fluorescence excitation-emission matrix (FEEM) scans revealed that the A-WWT system achieved higher removals of organics than the CAS system. However, effluents of both systems contained residual organic matter, necessitating further OMP assessment for a rigorous comparison. A novel ultrahigh-performance liquid chromatography- Fourier transform mass spectrometry (UPLC-FTMS)-based non-targeted screening approach was adopted here for residual OMP analysis. This approach confirmed that the A-WWT system resulted in better OMP removal, eliminating 329 compounds and partially reducing 472 compounds, compared to 206 eliminations and 410 partial reductions by the CAS system. Mass spectra signal corresponding to some OMPs increased with treatment while some transformation products were observed following treatment. Higher OMP reduction in the A-WWT system with concurrent reductions of biodegradable carbon, nutrients, and pathogens in a single-step while producing energy and nutrient rich algal biomass underscore its potential as a greener alternative for wastewater treatment., Competing Interests: Declaration of competing interest The authors declare no competing financial interest., (Copyright © 2024 Elsevier Ltd. All rights reserved.)

Membrane distillation (MD) has received ample recognition for treating complex wastewater, including hypersaline oil and gas (O&G) produced water (PW). Rigorous water quality assessment is critical in evaluating PW treatment because PW consists of numerous contaminants beyond the targets listed in general discharge and reuse standards. This study evaluated a novel photocatalytic membrane distillation (PMD) process, with and without a UV light source, against a standard vacuum membrane distillation (VMD) process for treating PW, utilizing targeted analyses and a non-targeted chemical identification workflow coupled with toxicity predictions. PMD with UV light resulted in better removals of dissolved organic carbon, ammoniacal nitrogen, and conductivity. Targeted organic analyses identified only trace amounts of acetone and 2-butanone in distillates. According to non-targeted analysis, the number of suspects reduced from 65 in feed to 25-30 across all distillate samples. Certain physicochemical properties of compounds influenced contaminant rejection in different MD configurations. According to preliminary toxicity predictions, VMD, PMD with and without UV distillate samples, respectively contained 21, 22, and 23 suspects associated with critical toxicity concerns. Overall, non-targeted analysis together with toxicity prediction provides a competent supportive tool to assess treatment efficiency and potential impacts on public health and the environment during PW reuse., Competing Interests: Declaration of Competing Interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2024 Elsevier B.V. All rights reserved.)

Hydrothermal liquefaction (HTL) has emerged as a viable pathway for processing wet organic solid wastes (OSW) to yield biocrude oil which could be upgraded to transportation fuels and specialty chemicals. The HTL process results in two byproducts laden with high levels of carbon, nitrogen, and phosphorous. Recovery of phosphates in the byproducts as struvite and ammoniacal-nitrogen (NH 4 -N) as ammonium sulfate is proposed here as a promising pathway to utilize the HTL byproducts. A case study of this pathway using algal biomass as a model OSW yielded 8.2 g struvite/100 g OSW and 10.7 g ammonium sulfate/100 g OSW. Heavy metal levels in both struvite and ammonium sulfate crystals were below EPA regulations for land application. This biofertilizer recovery pathway could render OSW processing by HTL a greener alternative to anaerobic digestion, offering feedstock versatility, substantially smaller footprint, and a higher degree of OSW valorization., (Copyright © 2021 Elsevier Ltd. All rights reserved.)

Previous reports have documented the technical viability of an algal pathway for treating primary effluent and recovering its phosphorus-content (P) via hydrothermal liquefaction (HTL) of the resulting biomass. In this pathway, leaching P from HTL-derived biochar was found as the critical step impacting the economics of P-recovery. As such, a process model was developed in the current study to optimize P leaching from biochar as a function of five parameters. Model predictions under various conditions agreed well with measured data (r 2  = 0.93; n = 184). The validated process model was then integrated with a cost model to establish the following conditions as optimal for leaching P from biochar: batch leaching time of 72 h; eluent NaOH concentration of 0.5 M; eluent-to-biochar ratio of 20; temperature of 60 °C; and provision of mixing. Under these conditions, 73.5% of P from biochar could be recovered at $5.98/kg P., (Copyright © 2021 Elsevier Ltd. All rights reserved.)

Today's wastewater utilities are facing the dilemma of balancing pathological threats of bacteria and viruses in their effluent against health threats associated with the byproducts of disinfection. A possible solution to this dilemma is to adopt secondary treatment technologies capable of concurrent pathogen reduction, minimizing the demand for external disinfectants. Towards this end, bacterial and viral reductions possible in algal wastewater treatment (WWT) systems are highlighted here and compared with those in conventional activated sludge (AS) systems and membrane bioreactor (MBR) systems. High log reduction values (LRV) of E. coli [>5] and fecal coliform [>7] have been achieved without any external disinfectants in the classical photoautotrophic algal WWT systems and in an emerging mixotrophic algal WWT system. LRVs of E. coli, fecal coliform, and somatic coliphages in the mixotrophic system are higher than those in AS systems and, comparable to those in MBRs. But, LRVs of F-specific coliphages, Enterovirus and Norovirus GI are greater in MBRs than in the mixotrophic and AS systems. The low-energy algal WWT systems providing high inherent reductions of bacteria and viruses can serve as affordable alternatives to the capital- and energy-intensive AS and MBR systems for greener WWT, meeting several of the United Nation's Sustainable Development Goals., Competing Interests: Declaration of competing interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2020 Elsevier Ltd. All rights reserved.)

This paper presents a pilot scale study of an algal-based sewage treatment and resource recovery (STaRR) system capable of treating municipal sewage and recovering its nitrogen- and phosphorous-content as fertilizer. Core components of the STaRR system include i) mixotrophic cultivation of algal biomass in settled sewage; ii) hydrothermal liquefaction (HTL) of the resulting algal biomass, and iii) processing of the products of HTL to recover energy in the form of biocrude and nutrients in the form of struvite. Performance of a pilot-scale STaRR system in recovering nitrogen (N) and phosphorus (P) from settled sewage as struvite is documented and compared with that of existing and emerging technologies. Nutrient removal per unit energy input in the STaRR system is estimated as 257.1 g N/kWh and 36.6 g P/kWh while that in eight full-scale sewage treatment plants (STPs) averaged 74.3 g N/kWh and 135.1 g P/kWh. Energy required to treat primary effluent in the STaRR system (531.5 kWh/MG) is estimated to be lower than the average in the 8 STPs (1,037.9 ± 503.3 kWh/MG). While existing technologies had been originally designed for removal of nutrients rather than any recovery, a review of the literature revealed 12 emerging technologies for nutrient recovery. Nutrient recovery performance of the STaRR system (5.9% N and 71.6% P) is shown to be superior to that of those 12 emerging technologies. Recoveries recorded in the STaRR system translate to a yield of 2.4 kg struvite per 100 m 3 of primary effluent. Results of this study imply that the STaRR system deserves due consideration as a greener and sustainable pathway for nutrient removal and recovery from sewage., Competing Interests: Declaration of competing interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2020 Elsevier Ltd. All rights reserved.)

In this study, we compared removal of antibiotic resistant bacteria (ARB) and antibiotic resistant genes (ARGs) in two wastewater treatment systems fed with the same primary effluent: a conventional wastewater treatment system (consisting of a trickling filter followed by an activated sludge process) versus an algal-based system, employing an extremophilic alga, Galdieria sulphuraria. Our results demonstrated that the algal system can reduce concentrations of erythromycin- and sulfamethoxazole-resistant bacteria in the effluent more effectively than the conventional treatment system. A decreasing trend of total bacteria and ARGs was observed in both the treatment systems. However, the relative ratio of most ARGs (qnrA, qnrB, qnrS, sul1) and intI1 in the surviving bacteria increased in the conventional system; whereas, the algal system reduced more of the relative abundance of qnrA, qnrS, tetW and intⅠ1 in the surviving bacteria. The role of bacteriophages in horizontal gene transfer (HGT) of ARGs in the two systems was indicated by a positive correlation between ARG absolute abundance in bacteriophage and ARG relative abundance in the bacteria. Four of the five detectable genes (qnrS, tetW, sul1 and intI1) were significantly reduced in the algal system in bacteriophage phase which signified a decrease in phage-mediated ARG transfer in the algal system. Results of this study demonstrate the feasibility of the algal-based wastewater treatment system in decreasing ARGs and ARB and in minimizing the spread of antibiotic resistance to the environment., (Copyright © 2019 Elsevier B.V. All rights reserved.)