Search

To simulate food contact surfaces with pits or cracks, stainless steel plates with grooves (depths between 0.2 and 5 mm) were constructed. These plates were artificially contaminated with Listeria monocytogenes in clean conditions, with organic soiling, or after 14 days of biofilm formation after which inactivation of the pathogen by Suma Tab D4 (sodium dichloroisocyanurate, 240 and 300 mg/liter), Suma Bac D10 (quaternary ammonium compound, 740 mg/liter), and bacteriophage suspension (Listex P100) was determined. Both chemical disinfectants performed well in suspension tests and in clean carrier tests according to the European standard with a reduction of more than 5 and 4 log units, respectively, of Listeria cells after 5 min of contact time. However, for the plates with grooves, the reduction could not meet the standard requirement, although a higher reduction of L. monocytogenes was observed in the shallow grooves compared with the deeper grooves. Furthermore, presence of food residues and biofilm reduced the effect of the disinfectants especially in the deep grooves, which was dependent on type of food substrate. Bacteriophages showed the best antimicrobial effect compared with the chemical disinfectants (sodium dichloroisocyanurate and quaternary ammonium compound) in most cases in the shallow grooves, but not in the deep grooves. The chlorine based disinfectants were usually less effective than quaternary ammonium compound. The results clearly demonstrate that surfaces with grooves influenced the antimicrobial effect of the chemical disinfectants and bacteriophages because the pathogen is protected in the deep grooves. The use of bacteriophages to inactivate pathogens on surfaces could be helpful in limited cases; however, use of large quantities in practice may be costly and phage-resistant strains may develop. [ABSTRACT FROM AUTHOR]

The essential oil of the resin of Pistacia lentiscus var. Chia (mastic oil) was studied in vitro against a wide range of foodborne pathogenic and spoilage microorganisms with a diffusion and a dilution method. Furthermore its chemical composition was analyzed by means of Gas Chromatography-Mass Spectrometry (GC-MS) and the possibility of using the essential oil in food preservation was discussed. The Minimal Inhibitory Concentrations (MICs) of mastic oil were estimated for 6 species of bacteria (Bacillus cereus, Campylobacter jejuni, Clostridium perfringens, Escherichia coli, Salmonella Typhimurium, Staphylococcus aureus), 2 species of yeasts (Saccharomyces cerevisiae and Zygosaccharomyces bailii) and 3 species of fungi (Penicillium roquefortii, Aspergillus flavus and Eurotium amstelodami). GC-MS analysis revealed a chemotype dominated by monoterpenes, principally a-pinene and β-myrcene comprising more than 90% of the mastic oil. Both methods showed Cl. perfringens as the most susceptible microorganism followed by S. cerevisiae and Z. bailii. With the exception of C. jejuni, Gram-positive were found to be more susceptible to the essential oil than Gram-negative microorganisms and all fungi appeared very resistant to mastic oil. Based on the observed MICs, the contribution of mastic oil to the preservation of bakery/confectionary products at the amounts currently used for flavoring purposes is likely to be negligible. [ABSTRACT FROM AUTHOR]

Using artificially contaminated chicken, the quantitative overall effect of Campylobacter jejuni cross-contamination, either via cutlery, cutting board, or hands, on the microbiological quality of a chicken salad was tested to identify the most critical transfer route. The end contamination level of salads prepared according to different scenarios, with or without cross-contamination, was compared. It was shown that the mean transfer rate calculated for all salads prepared allowing cross-contamination was 0.12% of the initial number of C. jejuni on the chicken fillet (8.8 ± 0.2 log CFU). The difference in calculated transfer rates for the tested cross-contamination routes was not significantly different (P > 0.05). The prevention of cross-contamination by replacing cutlery and cutting board after handling raw chicken and the prevention of hand contact resulted in considerably reduced end contamination levels (<2.4 log CFU) or noncontaminated end products. The results of this study emphasize the importance of preventing cross-contamination during food handling in reducing the risks of foodborne infections, and they provide useful data for quantitative microbiological risk assessment. [ABSTRACT FROM AUTHOR]

Epidemiological data indicate that cross-contamination during food preparation in the home contributes noticeably to the occurrence of foodborne diseases. To help prevent such occurrences, the inclusion of a cross-contamination model in exposure assessments would aid in the development and evaluation of interventions used to control the spread of pathogenic bacteria. A quantitative analysis was carried out to estimate the probability of contamination and the levels of Salmonella and Campylobacter spp. on salads as a result of cross-contamination from contaminated chicken carcasses via kitchen surfaces. Data on the prevalence and numbers of these bacteria on retail chicken carcasses and the use of unwashed surfaces to prepare foods were collected from scientific literature. The rates of bacterial transfer were collected from laboratory experiments and literature. A deterministic approach and Monte Carlo simulations that incorporated input parameter distributions were used to estimate the contamination of the product. The results have shown that the probability of Campylobacter spp. contamination on salads is higher than that of Salmonella spp., since both the prevalence and levels of Campylobacter spp. on chicken carcasses are higher than those of Salmonella spp. It is realistic to expect that a fraction of the human exposure to Campylobacter spp., in particular, originates from cross-contamination in private kitchens during food handling. The number of human campylobacteriosis cases could be reduced either by reducing the degree of Campylobacter spp. contamination on chicken carcasses or by improving the hygiene in private kitchens. To eliminate the cross-contamination route, it is important to use separate surfaces or to properly wash the surfaces during the preparation of raw and cooked foods or ready-to-eat foods. [ABSTRACT FROM AUTHOR]

Experiments were carried out to assess the reduction rate of two salmonella strains (S. eastbourne and S. typhimurium) in chocolate bars. After artificial contamination of chocolate, after ‘conching’, with about 106S. eastbourne/g. this organism was still recovered after 9 months storage. The strain of S. typhimurium was less resistant. Both serotypes died off more rapidly in bitter chocolate than in milk chocolate.After contamination with a smaller dose (about 103/g.) with these two serotypes, similar differences were observed. [ABSTRACT FROM PUBLISHER]

Background: Hand hygiene is important for interrupting transmission of viruses through hands. Effectiveness of alcohol-based hand disinfectant has been shown for bacteria but their effectiveness in reducing transmission of viruses is ambiguous., Aim: To test efficacy of alcohol hand disinfectant against human enteric and respiratory viruses and to compare efficacy of an alcohol-based hand disinfectant and handwashing with soap and water against norovirus., Methods: Efficacies of a propanol and an ethanol-based hand disinfectant against human enteric and respiratory viruses were tested in carrier tests. Efficacy of an alcohol-based hand disinfectant and handwashing with soap and water against noroviruses GI.4, GII.4, and MNV1 were tested using finger pad tests., Findings: The alcohol-based hand disinfectant reduced the infectivity of rotavirus and influenza A virus completely within 30s whereas poliovirus Sabin 1, adenovirus type 5, parechovirus 1, and MNV1 infectivity were reduced <3 log10 within 3 min. MNV1 infectivity reduction by washing hands with soap and water for 30s (>3.0 ± 0.4 log10) was significantly higher than treating hands with alcohol (2.8 ± 1.5 log10). Washing with soap and water for 30s removed genomic copies of MNV1 (>5 log10), noroviruses GI.4 (>6 log10), and GII.4 (4 log10) completely from all finger pads. Treating hands with propanol-based hand disinfectant showed little or no reduction to complete reduction with mean genomic copy reduction of noroviruses GI.4, GII.4, and MNV1 being >2.6, >3.3, and >1.2 log10 polymerase chain reaction units respectively., Conclusions: Washing hands with soap and water is better than using alcohol-based hand disinfectants in removing noroviruses from hands., (Copyright © 2015 The Healthcare Infection Society. Published by Elsevier Ltd. All rights reserved.)

Steam meals are ready-to-eat meals composed of raw and semi-cooked ingredients, which get cooked while microwave heating. In this study, an Indian style meal was selected, Chicken Tandoori, from two different producers. These meals were first evaluated with the Risk Ranger® to identify the main foodborne pathogens risks, which were Listeria monocytogenes, Salmonella Typhimurium and Bacillus cereus. Thereafter, quantitative microbiology was applied using different models and verified with growth and inactivation challenge tests. It was observed that the gamma model and the ComBase program® showed very similar results. However, in some cases the results obtained with the challenge tests showed different results. The information gathered was used to create different scenarios which indicate how to manage the risks by setting Performance Objectives during the different stages of the food chain of this product and hence reaching a suggested Food Safety Objective., (Copyright © 2010 Elsevier Ltd. All rights reserved.)

The purpose of this study was to determine the prevalence of Campylobacter in fresh vegetables and fruits at retail level in the Netherlands, and to estimate its implications on the importance of vegetables and fruits as risk factor for campylobacteriosis. Thirteen of the 5640 vegetable and fruit samples were Campylobacter positive, resulting in a prevalence of 0.23% (95% confidence interval (Cl): 0.12-0.39%). The prevalence of packaged products (0.36%, 95% Cl: 0.17-0.66) was significantly higher than of unpackaged products (0.07; 95% Cl: 0.01-0.27). No statistical differences were found between seasons. Combining the mean prevalence found in this study with data on the consumption of vegetables and fruits, an exposure of 0.0048 campylobacters ingested per person per day in the Netherlands by transmission via vegetables and fruits, was calculated. This exposure, as input in a Beta-Poisson dose-response model, resulted in an estimated number of 5.3×10⁵ cases of infection with Campylobacter per year for the whole Dutch population. This constitutes the consumption of raw vegetables and fruits, especially when packaged, to be a risk factor for Campylobacter infections., (Copyright © 2010 Elsevier B.V. All rights reserved.)

Survival of Listeria monocytogenes on a conveyor belt material with or without antimicrobial additives, in the absence or presence of food debris from meat, fish and vegetables and at temperatures of 10, 25 and 37 degrees C was investigated. The pathogen survived best at 10 degrees C, and better at 25 degrees C than at 37 degrees C on both conveyor belt materials. The reduction in the numbers of the pathogen on belt material with antimicrobial additives in the first 6h at 10 degrees C was 0.6 log unit, which was significantly higher (P<0.05) than the reduction of 0.2 log unit on belt material without additives. Reductions were significantly less (P<0.05) in the presence of food residue. At 37 degrees C and 20% relative humidity, large decreases in the numbers of the pathogen on both conveyor belt materials during the first 6h were observed. Under these conditions, there was no obvious effect of the antimicrobial substances. However, at 25 degrees C and 10 degrees C and high humidity (60-75% rh), a rapid decrease in bacterial numbers on the belt material with antimicrobial substances was observed. Apparently the reduction in numbers of L. monocytogenes on belt material with antimicrobial additives was greater than on belt material without additives only when the surfaces were wet. Moreover, the presence of food debris neutralized the effect of the antimicrobials. The results suggest that the antimicrobial additives in conveyor belt material could help to reduce numbers of microorganisms on belts at low temperatures when food residues are absent and belts are not rapidly dried., (Copyright 2010 Elsevier B.V. All rights reserved.)

This study aimed to characterize the number of Salmonella on chicken breast filet at the retail level and to evaluate if this number affects the risk of salmonellosis. From October to December 2005, 220 chilled raw filets (without skin) were collected from five local retail outlets in The Netherlands. Filet rinses that were positive after enrichment were enumerated with a three-tube most-probable-number (MPN) assay. Nineteen filets (8.6%) were contaminated above the detection limit of the MPN method (10 Salmonella per filet). The number of Salmonella on positive filets varied from 1 to 3.81 log MPN per filet. The obtained enumeration data were applied in a risk assessment model. The model considered possible growth during domestic storage, cross-contamination from filet via a cutting board to lettuce, and possible illness due to consumption of the prepared lettuce. A screening analysis with expected-case and worst-case estimates for the input values of the model showed that variability in the inputs was of relevance. Therefore, a Monte Carlo simulation with probability distributions for the inputs was carried out to predict the annual number of illnesses. Remarkably, over two-thirds of annual predicted illnesses were caused by the small fraction of filets containing more than 3 log Salmonella at retail (0.8% of all filets). The enumeration results can be used to confirm this hypothesis in a more elaborate risk assessment. Modeling of the supply chain can provide insight for possible intervention strategies to reduce the incidence of rare, but extreme levels. Reduction seems feasible within current practices, because the retail market study indicated a significant difference between suppliers.

Refrigerated storage is an important step in the preparation of foods and inadequate storage is one of the main causes of food poisoning outbreaks of Clostridium perfringens. Therefore, growth and germination characteristics of C. perfringens in a temperature range of 3-42 degrees C were determined in fluid thioglycollate broth (FTG) and Dutch pea soup. To study the effect of adaptation, cells were either inoculated from a 37 degrees C pre-culture or from a temperature-adapted pre-culture. Membrane fatty acid patterns were determined at all temperatures to examine the effect of temperature on membrane composition. Spores were either inoculated with and without heat treatment. Adaptation of cells did not influence growth rate nor lag phase. Growth in pea soup, however, was slower and lag phases tended to be more extended compared to FTG. No growth was observed at temperatures < or =10 degrees C and death rates in pea soup were higher than those in FTG at these low temperatures. Cells preserved the membrane fluidity by reducing the arachidic acid content and increasing the lauric acid content when the temperature dropped. This resulted in a net reduction in chain length. Microscopic analysis of cells grown at 15 degrees C revealed a morphological change: cells were elongated compared to those grown at 37 degrees C. These data demonstrate the ability of C. perfringens to adapt to lower temperatures. However, this did not influence growth characteristics compared to non-adapted cells. Spores of C. perfringens did germinate at all temperatures with and without heat-activation. Combining this fact with the extended survival at low temperatures emphasizes the need for adequate heating of refrigerated foods before consumption to eliminate health risks due to C. perfringens.

Enterobacter sakazakii is a motile, peritrichous, gram-negative rod that was previously known as a yellow pigmented Enterobacter cloacae. It is documented as a rare cause of outbreaks and sporadic cases of life-threatening neonatal meningitis, necrotizing enterocolitis, and sepsis. E. sakazakii has been isolated from milk powder-based formulas, and there is thus a need to investigate whether and where E. sakazakii occurs in these manufacturing environments. For this purpose, a simple detection method was developed based on two features of E. sakazakii: its yellow pigmented colonies when grown on tryptone soy agar and its constitutive alpha-glucosidase, which is detected in a 4-h colorimetric assay. Using this screening method, E. sakazakii strains were isolated from three individual factories from 18 of 152 environmental samples, such as scrapings from dust, vacuum cleaner bags, and spilled product near equipment. The method is useful for routine screening of environmental samples for the presence of E. sakazakii.

Foods associated with Clostridium perfringens outbreaks are usually abused after cooking. Because of their short generation times, C. perfringens spores and cells can grow out to high levels during improper cooling. Therefore, the potential of C. perfringens to multiply in Dutch pea soup during different cooling times was investigated. Tubes of preheated pea soup (50 degrees C) were inoculated with cocktails of cells or heat-activated spores of this pathogen. The tubes were linearly cooled to 15 degrees C in time spans of 3, 5, 7.5, and 10 h and were subsequently stored in a refrigerator at 3 or 7 degrees C for up to 84 h. Cell numbers increased by 1-log cycle during the 3-h cooling period and reached their maximum after 10 h of cooling. Subsequent refrigeration hardly reduced cell numbers. Cooling of 3.75 liters of pea soup in an open pan showed that this amount of pea soup cooled from 50 to 15 degrees C in 5 h, which will allow a more than 10-fold increase in cell numbers. These findings emphasize the need of good hygienic practices and quick cooling of heated foods after preparation.