Search

The aim of this work was to evaluate the effect of exposure of grass pea seeds to IR (infrared) radiation applied at varying time intervals on their mechanical properties, trypsin inhibitor activity, and reactive lysine content. Grass pea seeds cv. Derek were exposed to IR radiation at 180°C for 30, 60, 90, 120, and 180 s, respectively. Compared with that of raw seeds, IR heating of grass pea seeds reduced trypsin inhibitor activity. Reactive lysine proved to be relatively stable in the applied heating conditions. In addition, the process led to the reduction in the value of breaking load required for the destruction of a single seed, which may facilitate further processing, for example, flaking. Therefore, IR heating can be used in processing grass pea seeds. [ABSTRACT FROM AUTHOR]

The aim of the study was to determine the effect of thermal infrared treatment of Indian sesame seeds (Sesamum indicum L.) on the yield and quality of extracted oil. The infrared radiation treatment of the seeds was applied for 30 s, 60 s, 90 s, 120 s, and 150 s at a temperature of 180ºC. The mean moisture and fat content in the seeds was 7,46 and 45,61%, respectively. The extracted oil was assessed in terms of the hydrolysis degree (AV), primary oxidation degree (PV), oxidative stability in the Rancimat test, and content of carotenoid and chlorophyll pigments. The study has shown that the infrared thermal treatment of sesame seeds contributed to an increase in the oil extraction efficiency, compared to the control sample. The highest increase in the oil yield was found in the case of seeds heated for 120 s. Simultaneously, there was a reduction of the quality of these oils accompanied by increased oxidative stability. The induction time in oils extracted from infrared-treated seeds increased gradually together with the increase in the length of the heating process. The longest induction time (9,53 h) was noted in sesame oil obtained from seeds heated for 150 s. [ABSTRACT FROM AUTHOR]

Samples of butternut squash were heated in a convection steam oven at the temperature of 80°C and 100°C without any/or with addition of steam. The most significant changes of texture properties in the pulp were registered regarding its hardness and chewiness, while the alterations of its springiness and cohesiveness occurred within a smaller range. The decisive influence on changing the hardness and chewiness of butternut pulp was observed for the addition of steam, and, to a lower extent, for the time and temperature of treatment; in case of springiness the vital factor was the temperature of the process. [ABSTRACT FROM AUTHOR]

An increase in the demand for cold-pressed vegetable oils can be observed, e.g. from sunflower. The press cake formed during sunflower oil production can also be an important source of protein, carbohydrates, and phenolic compounds. The aim of the study was to examine the quality of gluten-free breads fortified with sunflower seed cake. The fortified products were characterized by lower moisture content (49.35-48.87%). The bake loss parameter decreased after the use of the highest 15% dose of the sunflower cake. The addition of the sunflower cake caused an increase in the content of nutrients, compared to the control sample: protein (7.44-9.69% d.b. ), fat (3.41-10.72% d.b. ), crude fiber (1.23-2.34% d.b. ), polyphenols (89.3-222.3 mg·100 g d.b. -1 ), and soluble sugars (2.42-2.73% d.b. ). The gluten-free breads with the sunflower seed cake exhibited lower hardness, springiness, and chewiness but higher cohesiveness. The use of the additive contributed to the darkening of the gluten-free bread crumb. The appearance, consistency, aroma, and palatability of the sunflower cake-fortified gluten-free bread were found to be much more attractive than the parameters of the unmodified bread. The conducted research has shown that, thanks to sunflower cake addition, it is possible to obtain a highly nutritious product with desirable sensory quality., (© 2023. The Author(s).)

Due to their different properties compared to other materials, nanoparticles of iron and iron oxides are increasingly used in the food industry. Food technologists have especially paid attention to their ease of separation by magnetic fields and biocompatibility. Unfortunately, the consumption of increasing amounts of nanoparticles has raised concerns about their biotoxicity. Hence, knowledge about the applicability of iron nanoparticle-based materials in the food industry is needed not only among scientists, but also among all individuals who are involved in food production. The first part of this article describes typical methods of obtaining iron nanoparticles using chemical synthesis and so-called green chemistry. The second part of this article describes the use of iron nanoparticles and iron nanoparticle-based materials for active packaging, including the ability to eliminate oxygen and antimicrobial activity. Then, the possibilities of using the magnetic properties of iron nano-oxides for enzyme immobilization, food analysis, protein purification and mycotoxin and histamine removal from food are described. Other described applications of materials based on iron nanoparticles are the production of artificial enzymes, process control, food fortification and preserving food in a supercooled state. The third part of the article analyzes the biocompatibility of iron nanoparticles, their impact on the human body and the safety of their use.

In this study, we included 15% doses of infrared-irradiated camelina, flax, and sunflower seeds in the diets of broiler chickens (grower and finisher) and focused on assessing the effects on the production traits, selected slaughter analysis parameters, nutrients, and minerals in breast and drumstick meat and some organs, i.e., liver, proventriculus, and heart. In total, 200 one-day-old broiler chickens were assigned randomly to four treatments with five replicate cages of 10 broiler chickens per cage (five females and five males). The experiment lasted 6 weeks. In the group of broiler chickens in which diets were supplemented with micronised camelina and flax seeds, there was an increase in (p < 0.05) breast, thigh, and drumstick weight and a decrease (p < 0.05) in the abdominal fat of the carcasses. The oilseed treatments reduced the ether extract content and the calorific value in the breast and drumstick muscles and organs. The flax seeds contributed to an increase in the contents of Ca (breast muscle and liver), Cu (breast muscle and proventriculus), and Fe (drumstick muscle and heart). Likewise, some blood parameters were influenced by supplementation with infrared-irradiated camelina and flax seeds, for example, there was a decrease in the haemoglobin level and the mean corpuscular haemoglobin concentration (p < 0.05). The oilseed treatments also modified the contents of Fe and Ca in the blood plasma of broiler chickens (p < 0.05). It may be concluded that infrared-irradiated camelina, flax, and sunflower seeds can be regarded as good diet components exerting positive effects on the dietary value of poultry meat and organs used in dietetics.

Background: Fortification of rolls, one of the most popular snacks for children and adults, with coconut by-products can be interesting in terms of both nutritional enrichment and reduction of food waste. Coconut by-products, such as residues from coconut milk (RCM) and coconut oil (RCO) extraction, are a valuable source of dietary fiber. In the study, coconut flours obtained from RCM and RCO were used (FCM and FCO, respectively) for supplementation of rolls; white wheat flour was replaced with FCM or FCO at levels of 6, 12, and 18 g per 100 g., Results: The effect of the addition of the coconut by-products on the nutritional value, sensory evaluation, physical properties, and texture of rolls was determined after 24 and 72 h of storage. The research showed a positive effect of FCM and FCO on the roll yield, crumb moisture, and baking loss. The sensory evaluation revealed that the 12% addition of coconut residues yielded products with high overall acceptability (8 points on a 9-point scale). Compared with the control, a 12% addition of FCO or FCM contributed to an increase in proteins of 7.9% and 3.9% respectively and an increase in dietary fiber of 76% and 57% respectively. Despite the increase in the fat and protein contents, the energy value of the coconut rolls was significantly lower (244.6 kcal and 245.3 kcal for FCO and FCM respectively) than in the control wheat rolls (266.0 kcal)., Conclusion: White rolls with coconut flours obtained after grinding residues from oil or coconut milk extraction significantly increased the nutritional value of the rolls. © 2021 Society of Chemical Industry., (© 2021 Society of Chemical Industry.)

The aim of the study was to evaluate the effect of inclusion of micronized full-fat camelina, flax, or sunflower seeds in the diet for broiler chickens on the performance productivity, nutrient utilization, and composition of intestinal microbial populations and to assess the possibility of modification of the resistance of isolated bacteria to chemotherapeutic agents with different mechanisms of action. The use of micronized oilseeds improved the broiler chicken body weight (P = 0.035) and the FCR value (P = 0.045) in the final rearing stage by enhancement of the utilization of total protein and organic matter. Lactobacillus-Enterococcus spp., Bifidobacterium spp., Escherichia coli, and Salmonella spp. were isolated from small intestinal contents, and Enterobacteriaceae taxa were detected in the cecum and cloaca of the broiler chickens. The addition of micronized camelina seeds (CAM.IR) contributed to an increase in the Bifidobacterium counts in the small intestine, compared with the control treatment (P < 0.050). Escherichia coli bacteria were not isolated only in the CAM.IR treatment. Nitrofurantoin and chloramphenicol were the most effective agents against the isolates from the cecum and cloaca in all oilseed treatments, whereas streptomycin exhibited the lowest efficacy. In the CAM.IR and micronized sunflower seed (SUN.IR) treatments, there were higher counts of trimethoprim/sulfamethoxazole-resistant Enterobacteriaceae strains than in the control and micronized flax seed (FLA.IR) treatments (P < 0.05). There was a difference between strains isolated from the cecum and cloaca only in the FLA.IR treatment, i.e., increased tetracycline sensitivity was exhibited by strains isolated from the cloaca (13% vs. 50%), also in comparison with the control treatments (P = 0.054). In comparison with the CAM.IR and control treatments, reduced numbers of multi-resistant strains were found in the cloaca isolates from the for FLA.IR and SUN.IR variants. Micronized camelina, flax, and sunflower seeds can be used as part of an effective nutritional strategy focused on optimization of the efficiency of rearing broiler chickens, as they positively modify intestinal microbial populations and increase bacterial sensitivity to the analyzed chemotherapeutic agents., (Copyright © 2021 The Authors. Published by Elsevier Inc. All rights reserved.)

The paper presents the possibility of applying ultrasonic technology for inactivation of mesophilic aerobic microorganisms, lactic acid bacteria, coliform bacteria, and yeast with the maintenance of the chemical and structural properties of tomato juice. The research was conducted on fresh tomato juice obtained from the Apis F 1 variety. Pressed juice was exposed to high power ultrasound and frequency 20 kHz with three operational parameters: ultrasound intensity (28 and 40 W cm -2 ), treatment time (2, 5, and 10 min), and product storage time (1, 4, 7 and 10 days). The temperature of the juice during the sonication ranged from 37 to 52 °C depending on the intensity of ultrasound and time of treatment. Effectiveness of the tested microorganisms eradication in the juice depended on the amplitude and duration of the ultrasound treatment. It was shown that the juice exposed to an ultrasonic field with an intensity of 40 W cm -2 for 10 min was microbiologically pure and free from spoilage microorganism even after 10 storage days. No statistically significant differences in pH were found between the untreated juice and the sonicated samples. The ultrasonic treatment was found to change the content of lycopene in small degree (both an increase and a decrease, depending on the processing time) and to induce a small decrease in the vitamin C content. The study suggests that the ultrasonic treatment can be successfully implemented on an industrial scale for the production of not-from-concentrate (NFC) tomato juice.

Cold Atmospheric pressure Plasma (CAP) is a non-thermal method used in food processing. CAP generated with the use of nitrogen in a Glide-arc device for 300 to 600 s exhibited high potential for microbial decontamination and did not induce substantial changes in the physicochemical properties of NFC tomato juice. Samples exposed to cold atmospheric plasma had mostly an intact structure, as revealed by digital microscopy. The investigations indicate that CAP can be applied for biological and chemical waste-free decontamination of food and extension of its shelf life.

Pasta production is a good opportunity for product innovation in different forms. The aim of this work was to assess the use of flaxseed components for pasta production. We examined the chemical composition and cooking quality, at different contents of flaxseed flour (FF) and flaxseed cake (FC), added for pasta processing. The analysis showed that the addition of flaxseed components to the dough caused a substantial difference in the International Commission on Illumination color model (CIE) parameter, compared to control samples. The samples of pasta with FF and FC were darker, redder, and less yellow than the control. The minimum cooking time for the enriched pasta was longer than that for the control pasta, although cooking losses were lower. The increasing content of flaxseed components did not significantly change the weight and volume increase index. The enrichment of pasta with 23% FF and 17% FC yielded good quality pasta. The results of the chemical composition of the flaxseed-enriched pasta indicate considerably enhanced nutritional quality, particularly the levels of protein, fat, and dietary fiber of the pasta, without affecting its quality. Moreover, flaxseed cake can be an important source of nutritional ingredients for pasta production, although it is a by-product of the oil cold pressing technology.

The aim of study was to determine the content of basic nutrients, the level of fatty acids, tocopherols, xanthophyll, and lycopene, and the total phenolic content in camelina ( Camelina sativa L. Crantz) (Cs), sunflower ( Helianthus L.) (Ha), and flax ( Linum L.) (Lu) seeds. The seeds were either raw or subjected to processing, i.e. boiling, micronization, or microwave roasting. The basic chemical composition was established and the fatty acid composition as well as the content of tocopherol (α, β, γ, δ, total), β-carotenoids, xanthophyll, lycopene, and total phenolics were determined in the analyzed oil seeds. The analyzed oil seeds are a rich source of protein and PUFAs as well as α-tocopherols (Ha) and γ-tocopherols (Cs, Lu), xanthophyll, and phenolics One portion of seeds covered from 746/513 (Cs) to as much as 1209/813% (Lu) (female/male) of the ALA daily intake. The AI value in the processed seeds increased ( P  < 0.05) and the values of H/H and HC declined ( P  < 0.05). The oil seed processing resulted in loss of most nutrients and bioactive constituents and appearance of some amounts of trans isomers, especially in the microwave roasted seeds (0.99-1.79 g/100 g crude lipid). The phenolic content decreased in the boiled seeds (Ha: 1301; Cs: 578.3, and Lu: 62.75 mg/100 g)., Competing Interests: Conflict of interestThe authors declare no conflicts of interest.

The Cold Atmospheric pressure Plasma (CAP) technology is an emerging technology used for conditioning and microbiological decontamination of biomaterials including food. A novel tool for inactivation of juice background spoilage microorganisms, as well as high count of inoculated yeast while maintaining physicochemical properties in tomato juice - CAP technology was utilized in this study. Dry matter content and pH were not significantly influenced by CAP generated in GlidArc reactor. Small increase of lycopene, and slight loss of vitamin C content were observed.

The paper presents the results of an experiment on the effect of pre-sowing stimulation of seeds with atmospheric pressure plasma jet operating with dielectric barrier discharge (DBD plasma jet) on the process of germination of Thuringian Mallow (Lavatera thuringiaca L.). Five groups of seeds characterized by a different exposure times (1, 2, 5, 10 and 15 minutes) as well as untreated seeds-control were used. Pre-sowing plasma stimulation of seeds improved germination parameters such as: germination capacity and germination energy for all tested groups relative to control. The highest germination parameters were obtained for seeds stimulated with plasma for the exposure times of 2 and 5 min. The analysis of the contact surface angle indicated the decrease of its' mean values upon seed stimulation while no statistical effects were observed. Analysis of the SEM scans revealed the increase in seed pattern intensity which could be attributed to removing of the surface parts of cuticle possibly covered with wax upon short time-2 and 5 min plasma treatment. Such a phenomenon can act similarly to mechanical scarification of seeds. Longer exposure of seeds to plasma resulted in affecting the deeper zone of cuticle and damage or fracture of some parts of the cuticle. Lower germination parameters of seeds upon longer exposure times to plasma may indicate mechanical damage of the seeds.

This study aimed to evaluate the effect of micronized pea seeds introduced into feed mixes for broilers on the slaughter yield, blood lipid parameters, content of fatty acids in selected tissues, and meat quality. The studies involved 150 1-day-old Ross 308 chicks split into three groups (for 42 days). The feed rations differed in terms of the source of proteins: in the control group (C), it was post-extraction soybean meal (SBM) 100%; in group I, SBM 50% and micronized peas 50%; and in group II, micronized peas only, 100%. Irradiated pea seeds added to the feed ration for chicks reduced the fattening grade of carcasses (P < 0.05). Additionally, significant improvement of blood lipid indices was recorded. The share of the irradiated pea seeds in feed mixes decreased the share of saturated fatty acids in the muscles and abdominal fat and had a positive effect on the n-6/n-3 ratio, hypocholesterolemic / hypercholesterolemic ratio, as well as the atherogenic and thrombogenic indices (P < 0.05)., (© 2016 Japanese Society of Animal Science.)

Introduction: A food allergy is a group of symptoms occurring in the organism and resulting from consuming some food, where the problems are conditioned by immunological mechanisms. The symptoms may become apparent first in adulthood and they may be an initial manifestation of a latent allergy. Typical symptoms of a food allergy occur in different organs, thus not only in the digestive system, but also in the skin, respiratory system and circulatory system., Aim: To assess the frequency of food allergy onset in rural areas of the Lublin region as well as to determine which factors induce such allergies., Material and Methods: A survey was conducted, involving the participation of 340 inhabitants of rural areas. The study monitored the knowledge and situation of the disease, concerning allergens, allergy symptoms, methods of treatment and opinions regarding such treatment., Results: The analysis focused on 124 people with diagnosed allergies., Conclusions: Introducing a diet did not result in a statistically significant difference regarding elimination of the symptoms, as compared to the patients who did not follow any diet. On the other hand, pharmacological treatment causes statistically worse results than using other methods or not being treated at all. The patients in whom allergy symptoms disappeared were more convinced about the positive character of their diet than those in whom the symptoms were not eliminated. The age when the allergy becomes evident does not affect its duration, yet it matters as to the time of its later elimination. The more symptoms were experienced by a patient, the longer the duration of the allergy was.