Search

Lipid oxidation is a major contributor to the deterioration of the sensory quality of fat-containing dairy powders. Hydroperoxides are the primary oxidation products from unsaturated fatty-acids that readily yield a complex mixture of volatile organic compounds that can adversely impact product quality and shelf life. Headspace solid-phase microextraction gas-chromatography mass-spectrometry was chosen to quantify thirteen lipid oxidation compounds in whole milk powder encompassing a range of volatilities and chemical classes. A central composite rotatable design (CCD, α = 1.1) based on a 2 3 factorial table was used with response surface methodology to optimize the HS-SPME parameters; determined at; 45 min extraction time and 43 °C extraction temperature. The significant model terms were found to be extraction temperature (p < 0.05) and the interaction between time and temperature (p < 0.05). Precision, accuracy, LOD and LOQ were determined and the method was validated for whole milk powder., (Copyright © 2019 Elsevier Ltd. All rights reserved.)

The study objectives were to determine assessors' (n = 256) preference for corned beef, produced with sequential reductions in NaCl concentrations and to determine if preference was affected by assessor age. The use of a salt replacer such as potassium lactate was also assessed. The youngest age cohort disliked samples containing the highest level of NaCl, whereas the oldest age cohort did not detect differences between samples. The most negatively perceived sample was the control, suggesting that NaCl levels added to commercial corned beef are currently too high for consumer acceptance. All age cohorts, with the exception of the 65-74 age cohort, accepted corned beef samples possessing NaCl levels closest to the FSAI target (1.63 g/100 g). No major sensory differences were noted between samples with and without potassium lactate by the ≥65 age cohort. Potassium lactate may be added to corned beef without affecting sensory attributes, whilst enhancing nutritional content. Assessors of varying age groups have differing preferences for certain NaCl levels and salt replacers., (Copyright © 2019. Published by Elsevier Ltd.)

This study was commissioned to assess if there are regional differences in the acceptability of beef between consumers from Northern Ireland (NI), Republic of Ireland (ROI) and Great Britain (GB). Palatability traits were affected by socioeconomic and behavioural factors such as preferred cooking endpoint, animal welfare, value, health aspects of beef product, ease of preparation as well as consumption frequency for specific cuts. "Willingness to pay" (WTP) was influenced by income, preferred cooking endpoint, value of beef product, ease of preparation and consumption frequency for frying steak. Results showed that GB consumers scored higher for the same striploin steak compared to NI and ROI consumers. This may be due to differences in the motivation for beef choice and/or consumption habits. GB consumers were less concerned about the healthiness of beef product and beef origin. In addition, a higher consumption frequency for rump was reported in GB, which may explain the higher sensory scores observed among GB consumers for striploins., (Copyright © 2019. Published by Elsevier Ltd.)

Reformulation of bread in terms of salt content remains an important measure to help achieve a reduction in salt intake in the population and for the prevention of hypertension and elevated blood pressure (BP). Our fundamental studies on the reduction of salt on dough and bread characteristics showed that wheat breads produced with 0.3 g salt/100 g ("low-salt") were found to be comparable quality to that produced with the typical level of salt (1.2%). This food-based intervention trial examined, using a 5 week cross-over design, the potential for inclusion of "low-salt" bread as part of a pragmatic reduced-salt diet on BP, markers of bone metabolism, and plasma lipids in 97 adults with slightly to moderately elevated BP. Assuming all sodium from dietary intake was excreted through the urine, the intake of salt decreased by 1.7 g/day, on average, during the reduced-salt dietary period. Systolic BP was significantly lower (by 3.3 mmHg on average; p < 0.0001) during the reduced-salt dietary period compared to the usual-salt dietary period, but there was no significant difference ( p = 0.81) in diastolic BP. There were no significant differences ( p > 0.12, in all cases) in any of the urinary- or serum-based biochemical indices of calcium or bone metabolism or in plasma lipids between the two periods. In conclusion, a modest reduction in dietary salt intake, in which the use of "low-salt" (i.e., 0.3 g/100g) bread played a key role along with dietary advice, and led to a significant, and clinically meaningful, decrease in systolic, but not diastolic, BP in adults with mildly to moderately elevated BP.

The objective was to compare the quality of beef from bulls reared in typical Irish indoor systems or in novel grass-based systems. Bulls were assigned to one of the following systems: (a) grass silage plus barley-based concentrate ad libitum (CON); (b) grass silage ad libitum plus 5 kg of concentrate (SC); (c) grazed grass without supplementation (G0); (d) grazed grass plus 0.5 kg of the dietary dry matter intake as concentrate (GC) for (100 days) until slaughter (14.99 months). Carcass characteristics and pH decline were recorded. Longissimus thoracis was collected for analytical and sensory analysis. Lower carcass weight, conformation and fatness scores were found for grazing compared to CON and SC groups. CON bulls had highest intramuscular fat and lighter meat colour compared with grazing bulls. The SC meat (14 days aged) was rated higher for tenderness, texture, flavour and acceptability compared with grazing groups. CON saturated and monounsaturated fatty acid (FA) concentration was highest, conversely, omega-3 FA concentration was higher for GC compared with CON, while no differences were found in polyunsaturated FA. In conclusion, while market fatness specification was not reached by grazed grass treatments, beef eating quality was not detrimentally affected and nutritional quality was improved.

Fatty acids and oxidative stability were determined in meat from lambs fed a diet containing 15% dehydrated alfalfa (CON, n = 8) or cardoon meal (CMD, n = 7). Furthermore, the antioxidant activity of a phenolic-rich cardoon meal extract (1.32 GAE mg/ml) was examined in muscle homogenates (0, 0.5, 1, 5% v/w) subjected to iron/ascorbate-induced oxidation. Feeding CMD did not affect lamb performances and carcass traits but reduced (P < 0.05) the vaccenic and rumenic acids and increased stearic acid in muscle. Lipid oxidation was higher in raw meat from the CMD-fed lambs after 7 days of storage (P < 0.05). Feeding CMD did not affect the colour stability of raw meat and the oxidative stability of cooked meat and of muscle homogenates incubated with pro-oxidant catalysts. Adding 5% cardoon extract in muscle homogenates increased (+114.3%; P = 0.03) the total phenolic content and reduced (-77.6%; P < 0.01) lipid oxidation, demonstrating the antioxidant potential of compounds present in cardoon meal., (Copyright © 2019 Elsevier Ltd. All rights reserved.)

Antimicrobial coated films were produced by an innovative method that allowed surface modification of commercial low-density polyethylene films so that well-defined antimicrobial surfaces could be prepared. A Pluronic™ surfactant and a polystyrene-polyethylene oxide block copolymer were employed to develop modified materials. The Pluronic™ surfactant provided a more readily functionalised film surface, while block copolymer provided a reactive interface which was important in providing a route to silver nanoparticles that were well adhered to the surface. Antimicrobial films containing silver were manufactured using a spray coater and the amount of silver used for coating purposes varied by the concentration of the silver precursor (silver nitrate) or the number of silver coatings applied. Potential antimicrobial activity of manufactured silver-coated low-density polyethylene films was tested against Pseudomonas fluorescens, Staphylococcus aureus and microflora isolated from raw chicken. The microbiological and physicochemical quality of chicken breast fillets wrapped with silver-coated low-density polyethylene films followed by vacuum skin packaging was also assessed during storage. Antimicrobial activity of developed silver-coated low-density polyethylene films was dependent ( p < 0.05) upon the concentrations of silver precursor and the number of silver coatings used. Better antimicrobial activity against P. fluorescens, S. aureus and chicken microflora was observed when the concentration of silver precursor was 3% and the spray coating deposition of silver was repeated four times. Use of silver-coated low-density polyethylene films extended ( p < 0.05) shelf life of chicken breast fillets and enhanced ( p < 0.05) oxidative stability compared to control films. Results indicated that silver-coated low-density polyethylene films could potentially be used as antimicrobial packaging for food applications.

This study investigated the efficacy of power ultrasound (US) for the inactivation of Escherichia coli and Listeria innocua in the presence of sodium salt and salt replacers. Inoculated bacteria suspensions were treated at ultrasonic frequencies of 33 or 20 kHz alone or in combination, and in the presence of 5% NaCl, 5% KCl or 5% NaCl/KCl. Inactivation curves were fitted to the Weibull and the Biphasic models. The goodness of the fit for each model was evaluated based on R 2 and RMSE, while AIC and BIC values were used to choose the best model predictor. The Weibull and the biphasic models showed high regression coefficient (R 2  > 0.99) and low RMSE (<0.03) values. According to the results, inactivation up to 6 log for E. coli K12 and to 4 log for L. innocua could be achieved within one hour of ultrasound treatment. However, the presence of NaCl, or its substitution with KCl did not affect the degree of inhibition for both microorganisms. The results of this study suggest that power ultrasound treatment may be employed for the inactivation of microorganisms when low salt or salt substitutes are employed., (Copyright © 2018 Elsevier B.V. All rights reserved.)

Many advances have occurred in the field of smart meat packaging, and the potential for these to be used as tools that respond to challenges faced by industry is exciting. Here, we review packaging solutions to several immediate concerns, encompassing dark cutting, purge and yield losses, product traceability and provenance, packaging durability, microbial spoilage and safety, colour stability, environmental impacts, and the preservation of eating quality. Different active and intelligent packaging approaches to each of these were identified and are discussed in terms of their usefulness - to processors, retailers and/or consumers. From this, it became apparent that prior to selecting a packaging solution, industry should first define their criteria for success (e.g. How much purge is too much? What is a reasonable shelf-life to facilitate product turnover? Is the customer willing to pay for this?), and understand that packaging is not the sole solution, but acts as part of a holistic response to these issues., (Crown Copyright © 2018. Published by Elsevier Ltd. All rights reserved.)

The properties of varying salt and fat levels in traditional breakfast sausages were investigated. Sausages were produced with fat levels of: 30%, 20% and 15%. Fat was replaced with pea extract. Salt levels employed were: 2.5%, 1.1% and 0.0%. A reduced sodium salt which contains 45% less sodium than standard salt was used. Sensory analysis was conducted on consumers (n = 228): 18-40 yrs., 41-64 yrs. and 65-85 yrs. The 18-40 yr. olds preferred sausages containing 20% fat, 41-64 yr. olds preferred sausages with 15% fat, 65+ age group preferred sausages containing 30% fat. The 18-40 yr. olds preferred high salt samples, 41-64 yr. olds displayed no salt preference, while the 65+ age group preferred high salt sausages. Sausage formulation choice was found to be driven by texture for the younger age cohort, flavour for the middle age cohort and visual aspects from the oldest age cohort. There is a need to understand how meat products might be reformulated different age palates., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

Background: The use of bulls rather than steers for beef production offers some considerable advantages; however, the eating quality of bull beef is an issue of marketing concern. This study assessed the physicochemical characteristics of young Holstein-Friesian (HF) bull and steer beef. Steer carcasses were suspended by the Achilles tendon (AS) and by pelvic suspension (PS)., Results: HF steer beef had higher redness, yellowness and chroma values, whereas bulls had higher ultimate pH and darker muscle. Warner-Bratzler shear force, cook loss at different ageing times, moisture, and insoluble and total collagen were higher for HF bull beef, whereas intramuscular fat, soluble collagen and collagen solubility were higher for steer beef. HF steer beef had a higher proportion of saturated fatty acids (SFA) and monounsaturated fatty acids (MUFA), whereas bull beef had higher proportions of polyunsaturated fatty acids (PUFA), PUFA/SFA and n-6/n-3 PUFA ratios. In comparison to AS, PS increased redness and chroma after 24 h blooming; PS improved tenderness up to 7 days of ageing and accelerated the ageing process., Conclusion: For young dairy cattle, steer beef would likely have superior eating quality but a relatively less favourable nutritional fatty acid profile to bull beef. Suspension method affected the tenderness and colour intensity of dairy steer beef at different ageing times. © 2018 Society of Chemical Industry., (© 2018 Society of Chemical Industry.)

This study investigates dietary fortification of heifer feeds with cholecalciferol and ergocalciferol sources and effects on beef total vitamin D activity, vitamer, respective 25-hydroxymetabolite contents, and meat quality. Thirty heifers were allocated to one of three dietary treatments [(1) basal diet + 4000 IU of vitamin D 3 (Vit D 3 ); (2) basal diet + 4000 IU of vitamin D 2 (Vit D 2 ); and (3) basal diet + 4000 IU of vitamin D 2 -enriched mushrooms (Mushroom D 2 )] for a 30 day pre-slaughter period. Supplementation of heifer diets with Vit D 3 yielded higher (p < 0.001) Longissimus thoracis (LT) total vitamin D activity (by 38-56%; p < 0.05) and serum 25-OH-D concentration (by 20-36%; p < 0.05), compared to that from Vit D 2 and Mushroom D 2 supplemented animals. Irrespective of vitamin D source, carcass characteristics, sensory and meat quality parameter were unaffected (p > 0.05) by the dietary treatments. In conclusion, vitamin D 3 biofortification of cattle diets is the most efficacious way to enhance total beef vitamin D activity., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

With the goal of optimising a protein-enriched restructured beef steak targeted at the nutritional and chemosensory requirements of older adults, technological performance of thirty formulations, containing plant-based ingredients, pea protein isolate (PPI), rice protein (RP) and lentil flour (LF) with transglutaminase (TG) to enhance binding of meat pieces, were analysed. Maximal protein content of 28% in cooked product was achieved with PPI, RP and LF. Binding strength was primarily affected by TG, while textural parameters were improved with LF inclusion. Optimal formulation (F) to obtain a protein-enriched steak with lowest hardness values was achieved with TG (2%), PPI (8%), RP (9.35%) and LF (4%). F, F1S (optimal formulation 1 with added seasoning) and control restructured products (not containing plant proteins or seasonings) were scored by 120 consumers' aged over-65 years. Controls were most preferred (P < .05), while F1S were least liked by the older consumers. Consumer testing suggests further refinement and optimisation of restructured products with plant proteins should be undertaken., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

Meat intakes in the older population are commonly reduced because the relatively tough texture of meat can impair mastication. Fruit-derived proteolytic enzymes have been reported to have beneficial effects on tenderness, by causing significant degradation of myofibrillar proteins and collagen. Three treatments including: papain, bromelain, and a 50:50 mixture of papain/bromelain, alongside one control were applied to beef M. semitendinosus steaks. Effects on Warner-Bratzler shear force, texture parameters, color, and cook loss were determined. Both enzymatic treatments that included papain significantly reduced Warner-Bratzler shear force values (p < .05) and increased cook loss. Beef steaks tenderized with papain and papain/bromelain offer potential for inclusion in older consumers' diets, but improvement in tenderization may be associated with a reduction in processing yield., Practical Applications: Meat processors have a role to play in enhancing the availability of appropriate foodstuffs for older people, through developing targeted products that will meet the specialized nutritional and chemosensory needs of this cohort. Meat intakes in the older population are commonly reduced because the relatively tough texture of meat can impair mastication. In this study, beef steaks tenderized with papain and papain: bromelain (50:50) were demonstrated to produce more tender meat products, with a lower cook loss compared with tenderization with bromelain alone, which has relevance to the development of texture-optimized meat products that appeal to older adults with difficulty in mastication. This information could help meat processors to develop strategies for optimization of texture-modified beef products within their own businesses., (© 2017 Wiley Periodicals, Inc.)

The commercially-available optical oxygen-sensing system Optech-O₂ Platinum was applied to nondestructively assess the in situ performance of bulk, vacuum-packaged raw beef in three ~300 kg containers. Twenty sensors were attached to the inner surface of the standard bin-contained laminate bag (10 on the front and back sides), such that after filling with meat and sealing under vacuum, the sensors were accessible for optical interrogation with the external reader device. After filling and sealing each bag, the sensors were measured repetitively and nondestructively over a 15-day storage period at 1 &deg;C, thus tracking residual oxygen distribution in the bag and changes during storage. The sensors revealed a number of unidentified meat quality and processing issues, and helped to improve the packaging process by pouring flakes of dry ice into the bag. Sensor utility in mapping the distribution of residual O₂ in sealed bulk containers and optimising and improving the packaging process, including handling and storage of bulk vacuum-packaged meat bins, was evident.

This study characterised the response of ruminal fermentation and the rumen microbiome in lambs fed commercial vegetal sources of hydrolysable tannins (HT) and condensed tannins (CT). Forty-four lambs (19.56 ± 2.06 kg) were randomly assigned to either a concentrate diet (CON, n = 8) or CON supplemented with 4% of two HT [chestnut (Castanea sativa, HT-c) and tara (Caesalpinia spinosa, HT-t)] and CT [mimosa (Acacia negra, CT-m) and gambier (Uncaria gambir, CT-g)] extracts (all, n = 9) for 75 days pre-slaughter. Tannin supplementation did not influence ruminal fermentation traits. Quantitative PCR demonstrated that tannins did not affect the absolute abundance of ruminal bacteria or fungi. However, CT-m (-12.8%) and CT-g (-11.5%) significantly reduced the abundance of methanogens, while HT-t (-20.7%) and CT-g (-20.8%) inhibited protozoal abundance. Ribosomal amplicon sequencing revealed that tannins caused changes in the phylogenetic structure of the bacterial and methanogen communities. Tannins inhibited the fibrolytic bacterium, Fibrobacter and tended to suppress the methanogen genus, Methanosphaera. Results demonstrated that both HT and CT sources could impact the ruminal microbiome when supplemented at 4% inclusion level. HT-t, CT-m and CT-g extracts displayed specific antimicrobial activity against methanogens and protozoa without compromising ruminal fermentation in a long-term feeding trial.

This work aims to develop a rapid analytical technique to predict beef sensory attributes using Raman spectroscopy (RS) and to investigate correlations between sensory attributes using chemometric analysis. Beef samples (n = 72) were obtained from young dairy bulls (Holstein-Friesian and Jersey×Holstein-Friesian) slaughtered at 15 and 19 months old. Trained sensory panel evaluation and Raman spectral data acquisition were both carried out on the same longissimus thoracis muscles after ageing for 21 days. The best prediction results were obtained using a Raman frequency range of 1300-2800 cm -1 . Prediction performance of partial least squares regression (PLSR) models developed using all samples were moderate to high for all sensory attributes (R 2 CV values of 0.50-0.84 and RMSECV values of 1.31-9.07) and were particularly high for desirable flavour attributes (R 2 CVs of 0.80-0.84, RMSECVs of 4.21-4.65). For PLSR models developed on subsets of beef samples i.e. beef of an identical age or breed type, significant improvements on prediction performances were achieved for overall sensory attributes (R 2 CVs of 0.63-0.89 and RMSECVs of 0.38-6.88 for each breed type; R 2 CVs of 0.52-0.89 and RMSECVs of 0.96-6.36 for each age group). Chemometric analysis revealed strong correlations between sensory attributes. Raman spectroscopy combined with chemometric analysis was demonstrated to have high potential as a rapid and non-destructive technique to predict the sensory quality traits of young dairy bull beef., (Copyright © 2018. Published by Elsevier Ltd.)

Reported salt levels in whole-muscle cured meat products differ substantially within and among European countries, providing substantial scope for salt reduction across this sector. The objective of this study was to identify the minimum acceptable salt levels in typical whole-muscle cured products in terms of physicochemical, microbial and sensorial properties. Salt levels in a small selection of commercial Irish meat products were determined to establish a baseline for reduction. Subsequently, eight different back bacon rasher and cooked ham products were produced with varying levels of salt: 2.9%, 2.5%, 2% and 1.5% for bacon, and 2%, 1.6%, 1.0% and 0.8% for ham. Salt reduction produced products with significantly harder texture and higher microbial counts, with no difference in the colour and affecting the sensory properties. Nonetheless, salt reduction proved to be feasible to levels of 34% and 19% in bacon and ham products, respectively, compared to baseline., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

The data presented in this article are related to the research article entitled "Application of Raman spectroscopy and chemometric techniques to assess sensory characteristics of young dairy bull beef" [1]. Partial least squares regression (PLSR) models were developed on Raman spectral data pre-treated using Savitzky Golay (S.G.) derivation (with 2nd or 5th order polynomial baseline correction) and results of sensory analysis on bull beef samples ( n  = 72). Models developed using selected Raman shift ranges (i.e. 250-3380 cm -1 , 900-1800 cm -1 and 1300-2800 cm -1 ) were explored. The best model performance for each sensory attributes prediction was obtained using models developed on Raman spectral data of 1300-2800 cm -1 .

There has been a surge in interest in relation to differentiating dairy products derived from pasture versus confined systems. The impact of different forage types on the sensory properties of milk and cheese is complex due to the wide range of on farm and production factors that are potentially involved. The main effect of pasture diet on the sensory properties of bovine milk and cheese is increased yellow intensity correlated to β-carotene content, which is a possible biomarker for pasture derived dairy products. Pasture grazing also influences fat and fatty acid content which has been implicated with texture perception changes in milk and cheese and increased omega-3 fatty acids. Changes in polyunsaturated fatty acids in milk and cheese due to pasture diets has been suggested may increase susceptibility to lipid oxidation but does not seem to be an issue to due increased antioxidants and the reducing environment of cheese. It appears that pasture derived milk and cheese are easier to discern by trained panellists and consumers than milk derived from conserved or concentrate diets. However, milk pasteurization, inclusion of concentrate in pasture diets, cheese ripening time, have all been linked to reducing pasture dietary effects on sensory perception. Sensory evaluation studies of milk and cheese have, in general, found that untrained assessors who best represent consumers appear less able to discriminate sensory differences than trained assessors and that differences in visual and textural attributes are more likely to be realized than flavour attributes. This suggests that sensory differences due to diet are often subtle. Evidence supports the direct transfer of some volatiles via inhalation or ingestion but more so with indirect transfer post rumen metabolism dietary components. The impact of dietary volatiles on sensory perception of milk and dairy products obviously depends upon their concentration and odour activity, however very little quantitative studies have been carried out to date. Some studies have highlighted potential correlation of pasture with enhanced "barny" or "cowy" sensory attributes and subsequently linked these to accumulation of p -cresol from the metabolism of β-carotene and aromatic amino acids or possibly isoflavones in the rumen. p -Cresol has also been suggested as a potential biomarker for pasture derived dairy products. Other studies have linked terpenes to specific sensory properties in milk and cheese but this only appears to be relevant in milk and cheese derived from unseeded wild pasture where high concentrations accumulate, as their odour threshold is quite high. Toluene also a product of β-carotene metabolism has been identified as a potential biomarker for pasture derived dairy products but it has little impact on sensory perception due to its high odour threshold. Dimethyl sulfone has been linked to pasture diets and could influence sensory perception as its odour threshold is low. Other studies have linked the presence of maize and legumes (clover) in silage with adverse sensory impacts in milk and cheese. Considerably more research is required to define key dietary related impacts on the flavour of milk and cheese., Competing Interests: The authors declare no conflict of interest. The funding agency had no role in the writing of this manuscript or in the decision to publish.

Background: The present study aimed to assess the physico-chemical and sensory characteristics of Longissimus thoracis muscle from young dairy bulls: Holstein-Friesian (HF) and Jersey × Holstein-Friesian (JEX). Bulls slaughtered at 15 months of age differed with respect to the finishing system, whereas 19-month-old bulls differed in energy consumption during a second grazing season and finishing period. All bulls were offered different diets during the first grazing season., Results: Insoluble and total collagen contents increased with slaughter age, whereas collagen solubility and hue angle reduced with age. Bulls fed a higher concentrate finishing diet held a longer beef flavour. Intramuscular fat (IMF) content and beef flavour score were enhanced by higher concentrate intake during the second season and finishing period. Beef from a higher forage diet displayed a more intense red colour and higher thawing loss. There was limited effect of silage finishing or first and second grazing season on quality traits. Beef from JEX breed had a higher IMF content, higher flavour, juiciness and texture-related scores while lower moisture content compared to HF beef., Conclusion: The eating quality of beef from young dairy bulls was generally good. Slaughter age and the energy level of diet had obvious effects on quality characteristics. Cross-breeding Jersey with the HF breed can improve the beef quality of young dairy bulls. © 2017 Society of Chemical Industry., (© 2017 Society of Chemical Industry.)

Background: This study investigated the effect of blanching (60, 70 and 80 °C for 1, 3, 5 and 10 min) combined with oven drying at 60 °C on the phenolic compounds, antioxidant activity, colour and drying characteristics (drying time, drying rate constant, effective moisture diffusivity and activation energy) of onion slices., Results: Blanching of onion slices at 60 °C for 3 min and at 70 °C for 1 min prior to drying increased their bioactive compounds and antioxidant activity compared to the control samples and other treatments. Eighteen drying models were evaluated. The Modified Page and two-term exponential models best represented the drying data. The effective diffusivity ranged from 3.32 × 10 -11 m 2 s -1 (control) to 5.27 × 10 -11 m 2 s -1 , 5.01 × 10 -11 m 2 s -1 , and 4.74 × 10 -11 m 2 s -1 for onions blanched at 60 °C, 70 °C and 80 °C, respectively. The higher activation energy was observed for the control (unblanched) sample and slightly lower values were found for 1 min- and 3 min-blanched samples, confirming the higher drying efficiency as a result of the blanching pre-treatment., Conclusion: The use of blanching as a pre-treatment before drying of onions resulted in enhanced phytochemical content and drying efficiency. © 2017 Society of Chemical Industry., (© 2017 Society of Chemical Industry.)

The present study investigated the effect of geometric parameters of the ultrasound instrument during meat salting in order to enhance salt diffusion and salt distribution in pork meat on a lab scale. The effects of probe size (∅2.5 and 1.3cm) and of different distances between the transducer and the meat sample (0.3, 0.5, and 0.8cm) on NaCl diffusion were investigated. Changes in the moisture content and NaCl gain were used to evaluate salt distribution and diffusion in the samples, parallel and perpendicular to ultrasound propagation direction. Results showed that 0.3cm was the most efficient distance between the probe and the sample to ensure a higher salt diffusion rate. A distance of 0.5cm was however considered as a trade-off distance to ensure salt diffusion and maintenance of meat quality parameters. The enhancement of salt diffusion by ultrasound was observed to decrease with increased horizontal distance from the probe. This study is of valuable importance for meat processing industries willing to apply new technologies on a larger scale and with defined operational standards. The data suggest that the geometric parameters of ultrasound systems can have strong influence on the efficiency of ultrasonic enhancement of NaCl uptake in meat and can be a crucial element in determining salt uptake during meat processing., (Copyright © 2017 Elsevier B.V. All rights reserved.)

The effect of 3 diets (grass, grass/clover, and total mixed ration) on the volatile and sensory properties of bovine milk was assessed over an entire lactation season. Little evidence was found of direct transfer of terpenes into raw milk from the different diets, and it is likely that the monocultures of ryegrass used with and without white clover were factors as these contained very few terpenes. Evidence of direct transfer of nonterpene volatiles from forage to the subsequent raw milks was probable; however, differences in the protein carbohydrate availability and digestion in the rumen appeared to have a greater contribution to volatile profiles. Pasteurization significantly altered the volatile profiles of all milks. A direct link between the milk fatty acid content, forage, and volatile products of lipid oxidation was also evident and differences in fatty acid content of milk due to forage may also have influenced the viscosity perception of milk. Irish sensory assessors preferred pasteurized milk produced from grass-fed cows, with least preference from milk produced from total mixed ration diets. β-Carotene content was significantly higher in milks derived from grass or grass/clover and appears to have directly influenced color perception. Toluene and p-cresol are both degradation products of β-carotene and along with β-carotene were identified as potential biomarkers for milk derived from pasture. The only correlation that appeared to influence the flavor of milk as determined using ranked descriptive analysis was p-cresol. P-Cresol appears to be responsible for the barnyard aroma of milk and is also likely derived from the deamination and decarboxylation of tryptophan and tyrosine due to the higher levels of available protein in the grass and grass/clover diets. The highest levels of p-cresol were in the grass/clover diets and are likely due to the degradation of the isoflavone formononetin in the rumen, which is present in white clover swards., (Copyright © 2018 American Dairy Science Association. Published by Elsevier Inc. All rights reserved.)

The lethal effects of soundwaves on a range of microorganisms have been known for almost a century whereas, the use of ultrasound to promote or control their activity is much more recent. Moreover, the fundamental molecular mechanism influencing the behaviour of microorganisms subjected to ultrasonic waves is not well established. In this study, we investigated the influence of ultrasonic frequencies of 20, 45, 130 and 950 kHz on growth kinetics of Lactobacillus sakei. A significant increase in the growth rate of L. sakei was observed following ultrasound treatment at 20 kHz despite the treatment yielding a significant reduction of ca. 3 log cfu/mL in cells count. Scanning electron microscopy showed that ultrasound caused significant changes on the cell surface of L. sakei culture with the formation of pores "sonoporation". Phenotypic microarrays showed that all ultrasound treated L. sakei after exposure to various carbon, nitrogen, phosphorus and sulphur sources had significant variations in nutrient utilisation. Integration of this phenotypic data with the genome of L. sakei revealed that various metabolic pathways were being influenced by the ultrasound treatments. Results presented in this study showed that the physiological response of L. sakei in response to US is frequency dependent and that it can influence metabolic pathways. Hence, ultrasound treatments can be employed to modulate microbial activity for specialised applications.

The effects of ultrasound (US) frequency, addition of Lactobacillus sakei culture and drying time on key nutritional (protein, amino acids, and organic acids) and physicochemical properties (texture and colour) of cultured and uncultured beef jerky were evaluated. Cultured and uncultured jerky samples were subjected to US frequencies of 25kHz, 33kHz and 45kHz for 30min prior to marination and drying. Principal component analysis demonstrated a significant effect of beef jerky processing conditions on physicochemical properties. Taurine content of jerky samples was found to increase with an increase in ultrasonic frequencies for cultured samples. No significant changes in colour values were observed for ultrasound pre-treated and control samples. Interactive effects of culture treatment, drying and ultrasonic frequency were observed. This study demonstrates that the nutritional profile of beef jerky can be improved through the incorporation of L. sakei., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

Background: Meat packaging once acted primarily as an inert barrier to protect its contents against contamination and this function has shifted., Discussion: Packaging now includes complementary functions that improve product quality, longevity and customer/retail appeal. The devices and methods applied to achieve these functions may be categorised as smart packaging, which includes intelligent packaging, devised to monitor and communicate packaged content status, and active packaging, to provide passive adjustment of inpack conditions from its interactions with the packaged meat., Conclusion: Smart packaging examples already available from recent patents include antimicrobial and antioxidant packaging coatings and inserts; sensors or indicators that identify spoilage and freshness; functional engineering customisations; improvements to packaging integrity; leak or tamper detectors; and, environmentally sustainable options. Together, these inventions respond to industry and customer demands for meat packaging and are therefore the focus of this review, in which we discuss their applications and limitations in meat packaging., (Copyright© Bentham Science Publishers; For any queries, please email at epub@benthamscience.org.)

This study investigated the effects of cholecalciferol (vitamin D₃) supplementation on beef vitamin D activity, beef tenderness and sensory attributes. Thirty heifers were randomly allocated to one of three finishing dietary treatments [(T1) basal diet+0IU vitamin D₃; (T2) basal diet+2000IU vitamin D₃; and (T3) basal diet+4000IU vitamin D₃] for a 30day period pre-slaughter. Vitamin D₃ supplementation linearly increased serum 25-hydroxyvitamin D₃ (25-OH-D 3 ) concentrations (R 2 =0.48), Longissimus thoracis (LT) total vitamin D activity (R 2 =0.78) as well as individually vitamin D₃ (R 2 =0.84) and 25-OH-D₃ (R 2 =0.75). The highest vitamin D₃ inclusion diet (T3) had a 42% increase (P<0.001) in LT vitamin D activity compared to the intermediate diet (T2) and a 145% increase over the lowest level diet (T1). Vitamin D₃ supplementation decreased LT shear (P<0.05) force values after 14days chilling. Sensory parameters were not affected (P>0.05). In conclusion, through short-term vitamin D₃ supplementation of cattle diets, beef vitamin D activity can successfully be enhanced., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

Mixture design was used to technologically optimise inclusions of protein ingredients [rice protein (RP) 0-10%, and lentil flour (LF) 0-10%] in fortified beef patties [meat (M) 90-100%] to ensure acceptable technological and sensorial properties. 17 formulations were generated. Composition, texture parameters, colour, lipid oxidation, microbiological and sensorial parameters were assessed. Maximal predicted protein content was 28.7% (P<0.01) which positively correlated with RP, but not LF. Models showed that LF inclusion correlated with improved texture and also reduced cook loss. Two optimised formulations (OF1 and OF2), for protein content and technological performance, were experimentally validated. Sensory panellists scored the optimised formulations higher than controls for tenderness and beef aroma (P<0.05). This presents an opportunity to produce protein fortified beef patties with softer texture and acceptable technological characteristics. The consumption of such protein fortified beef patties could assist older adults reach their targeted protein requirements., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

Fresh and processed muscle-based foods are highly perishable food products and packaging plays a crucial role in providing containment so that the full effect of preservation can be achieved through the provision of shelf-life extension. Conventional packaging materials and systems have served the industry well, however, greater demands are being placed upon industrial packaging formats owing to the movement of muscle-based products to increasingly distant markets, as well as increased customer demands for longer product shelf-life and storage capability. Consequently, conventional packaging materials and systems will have to evolve to meet these challenges. This review presents some of the new strategies that have been developed by employing novel nanotechnological concepts which have demonstrated some promise in significantly extending the shelf-life of muscle-based foods by providing commercially-applicable, antimicrobially-active, smart packaging solutions. The primary focus of this paper is applied to subject aspects, such as; material chemistries employed, forming methods utilised, interactions of the packaging functionalities including nanomaterials employed with polymer substrates and how such materials ultimately affect microbes. In order that such materials become industrially feasible, it is important that safe, stable and commercially-viable packaging materials are shown to be producible and effective in order to gain public acceptance, legislative approval and industrial adoption., (Copyright © 2017. Published by Elsevier Ltd.)

In this study, ultrasound was employed to enhance the diffusion of microencapsulated fatty acids into pork meat. Nanovesicles of fish oil composed of 42% EPA (eicosapentanoic acid) and 16% DHA (docosahexanoic acid) were prepared using two different commercial Pronanosome preparations (Lipo-N and Lipo-CAT; which yield cationic and non-cationic nanovesicles, respectively). The thin film hydration (TFH) methodology was employed for encapsulation. Pork meat (Musculus semitendinosus) was submerged in the nanovesicles suspension and subjected to ultrasound (US) treatment at 25kHz for either 30 or 60min. Samples were analysed for fatty acid composition using gas chromatography-flame ionisation (GC-FID). The content of long-chain PUFAs, especially omega-3, was found to increase following the US treatment which was higher for Lipo-CAT compared to Lipo-N nanovesicles. Samples subjected to Lipo-N had higher atherogenic and thrombogenic indices, indicating higher levels of saturated fatty acids compared to the Lipo-CAT. The omega-6/omega-3 ratio in pork meat was significantly reduced following the US treatment, thus indicating an improved fatty acid profile of pork., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

This study assessed the capability of various Irish assessor age cohorts to identify beef steaks of varying texture. Varying steak textures Moderately Tough (M TH ), Moderately Tender (M TR ) and Tender (T R ) were achieved by aging beef longissimus thoracis et lumborum (LTL) muscle for 2, 7 and 21days respectively. Warner Bratzler Shear Force (WBSF) was measured to standardise the samples. Sensory evaluation was carried using 428 participants; 18-30yrs (years) (n=143), 31-60yrs (n=80), 61-75yrs (n=99) and 76-85yrs old (n=106). Within 6 age cohort categories (18-70), significant positive and negative correlations were observed for T R and M TH tenderness categories respectively. Poor identification of tenderness classification was found in the 71-85 age cohort groupings. Consequently more research is required in this area so that guidelines could be presented for industrial uptake. This study supports the hypothesis that changes in textural perception occur with age in humans., (Copyright © 2017. Published by Elsevier Ltd.)

Raman spectroscopy and chemometrics were investigated for the prediction of eating quality related physico-chemical traits of Holstein-Friesian bull beef. Raman spectra were collected on the 3rd, 7th and 14th days post-mortem. A frequency range of 1300-2800cm -1 was used for partial least squares (PLS) modelling. PLS regression (PLSR) models for the prediction of WBSF and cook loss achieved an R 2 CV of 0.75 with RMSECV of 6.82 N and an R 2 CV of 0.77 with RMSECV of 0.97%w/w respectively. For the prediction of intramuscular fat, moisture and crude protein content, R 2 CV values were 0.85, 0.91 and 0.70 with RMSECV of 0.52%w/w, 0.39%w/w and 0.38%w/w respectively. An R 2 CV of 0.79 was achieved for the prediction of both total collagen and hydroxyproline content, while for collagen solubility the R 2 CV was 0.88. All samples (100%) from 15- and 19-month old bulls were correctly classified using PLS discriminant analysis (PLS-DA), while 86.7% of samples from different muscles (longissimus thoracis, semitendinosus and gluteus medius) were correctly classified. In general, PLSR models using Raman spectra on the 3rd day post-mortem had better prediction performance than those on the 7th and 14th days. Raman spectroscopy and chemometrics have potential to assess several beef physical and chemical quality traits., (Copyright © 2017 Elsevier Ltd. All rights reserved.)

Active (anti-microbial) packaging was prepared using three different formulations; Auranta FV; Inbac-MDA and sodium octanoate at two concentrations (2.5 and 3.5 times their minimum inhibitory concentration (MIC, the lowest concentration that will inhibit the visible growth of the organisms) against Clostridium estertheticum , DSMZ 8809). Inoculated beef samples were packaged using the active packaging and monitored for 100 days storage at 2 °C for blown pack spoilage. The time to the onset of blown pack spoilage was significantly ( p < 0.01) increased using Auranta FV and sodium octanoate (caprylic acid sodium salt) at both concentrations. Moreover, sodium octanoate packs had significantly ( p < 0.01) delayed blown pack spoilage as compared to Auranta FV. It was therefore concluded that Auranta FV or sodium octanoate, incorporated into the packaging materials used for vacuum packaged beef, would inhibit blown pack spoilage and in the case of the latter, well beyond the 42 days storage period currently required for beef primals., Competing Interests: The authors declare no conflict of interest.

Background: Onions contain a number of bioactive compounds, in particular polyphenols. They are rich sources of such compounds in the human diet and offer significant health benefits to the consumer. Demand for organic crops is steadily increasing partly based on the expected health benefits of organic food consumption. The current study examines the influence of organic and conventional crop management practices on bioactive polyphenolic content of onion., Results: We examined the effect of conventional, organic, and mixed cultivation practices on the content of total phenolics, total flavonoids and antioxidant activity in two varieties of onion grown over 4 years in a split-plot factorial systems comparison trial. Levels of total phenolics and total flavonoids showed a significant year-on-year variation and were significantly different between organic and conventional production systems. The levels of total phenolics, total flavonoids and antioxidant activity in general were significantly higher (P < 0.05) under fully organic compared to fully conventional management., Conclusion: Organic cultivation practices resulted in significantly higher levels of potential bioactive compounds in onion. © 2016 Society of Chemical Industry., (© 2016 Society of Chemical Industry.)

We carried out a 6-year study to assess the effect of conventional, organic, and mixed cultivation practices on bioactive compounds (flavonoids, anthocyanins) and antioxidant capacity in onion. Total flavonoids, total anthocyanins, individual flavonols, individual anthocyanins, and antioxidant activity were measured in two varieties ('Hyskin' and 'Red Baron') grown in a long-term split-plot factorial systems comparison trial. This is the first report of repeated measurements of bioactive content over an extensive time period in a single crop type within the same trial. Antioxidant activity (DPPH and FRAP), total flavonol content, and levels of Q 3,4' D and Q 3 G were higher in both varieties under fully organic compared to fully conventional management. Total flavonoids were higher in 'Red Baron' and when onions were grown under organic soil treatment. Differences were primarily due to different soil management practices used in organic agriculture rather than pesticide/ herbicide application.

It is well known that sensitivity of quenched-phosphorescence O 2 sensors can be tuned by changing the nature of indicator dye and host polymer acting as encapsulation and quenching mediums. Here, we describe a new type of sensor materials based on nanostructured hard elastic polymeric substrates. With the example of hard elastic polypropylene films impregnated with Pt-benzoporphyrin dye, we show that such substrates enable simple one-step fabrication of O 2 sensors by standard and scalable polymer processing technologies. In addition, the resulting sensor materials show prominent response to tensile drawing via changes in phosphorescence intensity and lifetime and O 2 quenching constant, K q . The mechanosensitive response shows reversibility and hysteresis, which are related to macroscopic changes in the nanoporous structure of the polymer. Such multifunctional materials can find use as mechanically tunable O 2 sensors, as well as strain/deformation sensors operating in a phosphorescence-lifetime-based detection mode.

Two antimicrobial coatings, namely Sodium octanoate and Auranta FV (a commercial antimicrobial composed of bioflavonoids, citric, malic, lactic, and caprylic acids) were used. These two antimicrobials were surface coated onto the inner polyethylene layer of cold plasma treated polyamide films using beef gelatin as a carrier and coating polymer. This packaging material was then used to vacuum pack beef sub-primal cuts and stored at 4 °C. A control was prepared using the non-coated commercial laminate and the same vacuum packaged sub-primal beef cuts. During storage, microbial and quality assessments were carried out. Sodium octanoate treated packages significantly (p < 0.05) reduced microbial counts for all bacteria tested with an increase of 7 and 14 days, respectively compared to control samples. No significant effect on pH was observed with any treatment. The results suggested that these food grade antimicrobials have the potential to be used in antimicrobial active packaging applications for beef products., (Copyright © 2016 Elsevier Ltd. All rights reserved.)

The aim of this review is to describe the factors contributing to diminished food intake, resulting in nutritional deficiencies and associated health conditions in older adults and proposes food innovation strategies to mitigate these. Research has provided convincing evidence of a link between healthy eating patterns and healthy aging. There is a need to target new food product development (NPD) with functional health benefits specifically designed to address the particular food-related needs of older consumers. When developing foods for older adults, consideration should be given to the increased requirements for specific macro- and micronutrients, especially protein, calcium, vitamin D, and vitamin B. Changes in chemosensory acuity, chewing difficulties, and reduced or poor swallowing ability should also be considered. To compensate for the diminished appetite and reduced intake, foods should be energy dense, nutritionally adequate, and, most importantly, palatable, when targeting this cohort. This paper describes the potential of new food product development to facilitate dietary modification and address health deficiencies in older adults., (© 2017 Institute of Food Technologists®.)

Bulls and steers (n=60) were assigned to a pre-finishing grazing period and subsequently finished on concentrates or offered concentrates without grazing until slaughter (19months). Colour and pH of longissimus thoracis were measured (48h post-slaughter), and samples collected for proximate composition, collagen, sarcomere length, muscle fibre and enzymatic profile analysis. Steaks for texture, cook loss and sensory were aged (14days). Castration increased intramuscular fat content, cook loss and myosin isoforms IIa and I proportions, and decreased IIx proportion (P<0.05). Steer meat was positively correlated to overall tenderness, texture and acceptability (P<0.05). The presence of a pre-finishing grazing period decreased intramuscular fat and increased the proportion of IIa compared with animals on concentrates, while no differences were found in sensory. Muscle colour, collagen, sarcomere length and instrumental texture were not modified by diet or castration. In conclusion, beef sensory characteristics were unaffected by diet, whereas castration resulted in a small improvement; however all the treatments produced an acceptable product., (Copyright © 2016 Elsevier Ltd. All rights reserved.)

Fermentation processes involve the participation of enzymes and organic catalysts, generated by range of microorganisms to produce chemical transformations. Ultrasound can be used in such processes to either monitor the progress of fermentation or to influence its progress. High frequency ultrasound (>2MHz) has been extensively reported as a tool for the measurement of the changes in chemical composition during fermentation providing real time information on reaction progress. Low frequency ultrasound (20-50kHz) can influence the course of fermentation by improving mass transfer and cell permeability leading to improved process efficiency and production rates. It can also be used to eliminate micro-organisms which might otherwise hinder the process. This review summarises key applications of high and low frequency ultrasound in food fermentation applications., (Copyright © 2016 Elsevier B.V. All rights reserved.)

The effects of clean label functional protein ingredients; pea protein isolate (PPI), rice protein (RP) and lentil flour (LF), at 3% and 7% inclusion levels on technological and shelf life parameters of beef patties were evaluated over 12days. Protein content in the RP7 treatment was higher (P<0.05) than controls, but did not differ significantly from PPI7 and RP3. No effects on moisture, fat or ash content were detected. LF addition reduced product hardness, cohesiveness, gumminess and chewiness compared with controls. RP-enriched and control patties were associated with lower lipid oxidation over storage than PPI- and LF-enriched patties. RP had a differential effect on (L*), (a*) and (b*) when compared with controls. Microbiological characteristics for all treatments were acceptable after 12days. Protein fortified beef patties with a softer texture and acceptable technological properties targeted for ease of consumption by older adults were produced in an attempt to reach dietary targeted protein requirements for this segment., (Copyright © 2016. Published by Elsevier Ltd.)

The effects of sodium tripolyphosphate (STPP), two sources of starch (potato starch: PS and rice starch: RS) and comminution degree (CD) on the technological, instrumental and sensory characteristics of reformed hams were studied using response surface methodology. Both starches reduced cook loss and decreased ham flavour intensity, but RS had stronger effects on instrumental measures of texture, while PS was associated with improved juiciness when low/no added STPP was included. Coarsely ground meat, processed 100% with the kidney plate was associated with slightly increased cook loss, reduced texture profile analysis parameters and a more intense ham flavour compared to the other treatment (80% ground with a kidney plate plus 20% with a 9mm plate). STPP was the sole factor affecting overall liking. If starch is included in the formulation, the standard level of STPP (0.3%) can be reduced by half with no increase in cook losses, but some decline in sensory quality cannot be avoided., (Copyright © 2016 Elsevier Ltd. All rights reserved.)

New and emerging robust technologies can play an important role in ensuring a more resilient meat value chain and satisfying consumer demands and needs. This paper outlines various novel thermal and non-thermal technologies which have shown potential for meat processing applications. A number of process analytical techniques which have shown potential for rapid, real-time assessment of meat quality are also discussed. The commercial uptake and consumer acceptance of novel technologies in meat processing have been subjects of great interest over the past decade. Consumer focus group studies have shown that consumer expectations and liking for novel technologies, applicable to meat processing applications, vary significantly. This overview also highlights the necessity for meat processors to address consumer risk-benefit perceptions, knowledge and trust in order to be commercially successful in the application of novel technologies within the meat sector., (Copyright © 2016. Published by Elsevier Ltd.)

To examine the human exposure to a novel silver and copper nanoparticle (AgNP and CuNP)/polystyrene-polyethylene oxide block copolymer (PS-b-PEO) food packaging coating, the migration of Ag and Cu into 3% acetic acid (3% HAc) food simulant was assessed at 60 °C for 10 days. Significantly lower migration was observed for Ag (0.46 mg/kg food) compared to Cu (0.82 mg/kg food) measured by inductively coupled plasma - atomic emission spectrometry (ICP-AES). In addition, no distinct population of AgNPs or CuNPs were observed in 3% HAc by nanoparticle tracking analysis (NTA) and transmission electron microscopy (TEM). The predicted human exposure to Ag and Cu was used to calculate a margin of exposure (MOE) for ionic species of Ag and Cu, which indicated the safe use of the food packaging in a hypothetical scenario (e.g. as fruit juice packaging). While migration exceeded regulatory limits, the calculated MOE suggests current migration limits may be conservative for specific nano-packaging applications., (Copyright © 2016 Elsevier Ltd. All rights reserved.)

The objective of this study was to investigate the efficacy of high intensity ultrasound on the fermentation profile of Lactobacillus sakei in a meat model system. Ultrasound power level (0-68.5 W) and sonication time (0-9 min) at 20 °C were assessed against the growth of L. sakei using a Microplate reader over a period of 24h. The L. sakei growth data showed a good fit with the Gompertz model (R(2)>0.90; SE<0.042). Second order polynomial models demonstrated the effect of ultrasonic power and sonication time on the specific growth rate (SGR, μ, h(-1)) and lag phase (λ, h). A higher SGR and a shorter lag phase were observed at low power (2.99 W for 5 min) compared to control. Conversely, a decrease (p<0.05) in SGR with an increase in lag phase was observed with an increase in ultrasonic power level. Cell-free extracts obtained after 24h fermentation of ultrasound treated samples showed antimicrobial activity against Staphylococcus aureus, Listeria monocytogenes, Escherichia coli and Salmonella typhimurium at lower concentrations compared to control. No significant difference (p<0.05) among treatments was observed for lactic acid content after a 24h fermentation period. This study showed that both stimulation and retardation of L. sakei is possible, depending on the ultrasonic power and sonication time employed. Hence, fermentation process involving probiotics to develop functional food products can be tailored by selection of ultrasound processing parameters., (Copyright © 2016 Elsevier B.V. All rights reserved.)

The establishment and control of oxygen levels in packs of oxygen-sensitive food products such as cheese is imperative in order to maintain product quality over a determined shelf life. Oxygen sensors quantify oxygen concentrations within packaging using a reversible optical measurement process, and this non-destructive nature ensures the entire supply chain can be monitored and can assist in pinpointing negative issues pertaining to product packaging. This study was carried out in a commercial cheese packaging plant and involved the insertion of 768 sensors into 384 flow-wrapped cheese packs (two sensors per pack) that were flushed with 100% carbon dioxide prior to sealing. The cheese blocks were randomly assigned to two different storage groups to assess the effects of package quality, packaging process efficiency, and handling and distribution on package containment. Results demonstrated that oxygen levels increased in both experimental groups examined over the 30-day assessment period. The group subjected to a simulated industrial distribution route and handling procedures of commercial retailed cheese exhibited the highest level of oxygen detected on every day examined and experienced the highest rate of package failure. The study concluded that fluctuating storage conditions, product movement associated with distribution activities, and the possible presence of cheese-derived contaminants such as calcium lactate crystals were chief contributors to package failure.

Black pudding, also known as blood sausages or blood pudding, is a kind of meat product made by blood, popular in Asia, Europe, and America. Twenty-five black pudding formulations with varying fat contents of 2.5%, 5%, 10%, 15%, and 20% (w/w) and sodium contents of 0.2%, 0.4%, 0.6%, 0.8%, and 1.0% (w/w) were manufactured. Sensory acceptance and ranking descriptive analyses as well as compositional and physicochemical analyses were conducted. Samples high in sodium (0.6-1.0%) were scored higher in juiciness, toughness, saltiness, fatness, and spiciness. These samples were the most accepted, whereas samples containing 0.2% sodium were the least accepted. Black pudding samples containing 0.6% sodium and 10% fat displayed a positive ( P  < 0.05) correlation to liking of flavor and overall acceptability. This meets the sodium target level set by the Food Safety Authority of Ireland and shows additionally that a fat reduction in black pudding products is more than achievable.

Twenty-two black puddings possessing different fat (10%, 5%) and sodium (0.6%, 0.4%) levels were used as base formulations for 11 different salt and fat replacers. Compositional, physicochemical and sensory analyses were conducted. Black pudding samples with 5% fat and 0.6% sodium containing potassium chloride (KCl), potassium chloride and glycine mixture (KClG), and seaweed, respectively, and 10% fat and 0.4% sodium containing carrageen were rated higher (P<0.05) for spiciness and saltiness. Samples with 10% fat and 0.4% sodium containing KClG were rated positively (P<0.05) to fatness. Samples with 5% fat and 0.6% sodium containing pectin and a combination of potassium citrate, potassium phosphate and potassium chloride (KCPCl), as well as samples containing 10% fat and 0.4% sodium with waxy maize starch (WMS) were liked (P<0.05) for flavor and overall acceptance. The Food Safety Authority of Ireland (FSAI) recommends a sodium target level of 0.6% and an even lower sodium level (0.4%) was achieved., (Copyright © 2015 Elsevier Ltd. All rights reserved.)