Search

This experiment used indirect calorimetry to determine the net energy ( NE) content of five corn distillers dried grains with solubles (corn DDGS) containing different oil levels and to compare the NE obtained using indirect calorimetry with that calculated using previously published prediction equations. There were two samples of high-oil DDGS, one sample of medium-oil DDGS and two samples of low-oil DDGS. Twelve barrows (initial BW of 32.8 ± 2.0 kg) were used in a repeated 3 × 6 Youden square design with three periods and six diets. The diets were comprised of a corn-soybean meal basal diet and five diets containing 29.25% of one of the corn DDGS added at the expense of corn and soybean meal. During each period, the pigs were individually housed in metabolism crates for 16 days which included 7 days for adaption to feed and environmental conditions. On day 8, the pigs were transferred to respiration chambers and fed one of the six diets at 2300 kJ ME/kg BW0.6/day. Faeces and urine were collected from day 9 to 13 and heat production (HP) was also measured. From day 14 to 15, the pigs were fed 893 kJ ME/kg BW0.6/day to allow them to adapt from the fed to the fasted state. On the last day of each period (day 16), the pigs were fasted and fasting HP was measured. The digestible energy value was 16.0, 17.1 and 15.3 MJ/kg DM, the metabolizable energy value was 14.6, 15.5 and 13.7 MJ/kg DM and the NE value was 10.7, 11.0 and 9.4 MJ/kg DM, for the high-oil, medium-oil and low-oil corn DDGS, respectively. The NE obtained with indirect calorimetry in the present study did not differ from values calculated using previously published prediction equations. [ABSTRACT FROM AUTHOR]

This study was conducted to determine and compare the DE and ME content as well as the apparent total tract digestibility (ATTD) of GE in 28 samples of sorghum grain fed to growing pigs and to generate prediction equations for DE, ME, and the ATTD of GE based on chemical analysis. The 28 samples included 8 low-tannin sorghum cultivars (LTS; tannin ≤ 0.16%), 10 medium-tannin sorghum cultivars (MTS: 0.67% ≤ tannin ≤ 0.98%), and 10 high-tannin sorghum cultivars (HTS; 1.11% ≤ tannin ≤ 1.51%) obtained from 9 provinces in China and 3 samples of LTS cultivars were obtained internationally. The 28 diets were formulated to contain 96.9% of 1 of the 28 sorghum grains and 3.1% of vitamins and minerals. Eighty-four barrows (36.5 ± 3.4 kg initial BW) were used in a randomized complete block design conducted during 2 consecutive periods (n = 6 per treatment) with the pigs fed different diets during the 2 periods. For each period, pigs were placed in metabolic crates for a 5-d total collection of feces and urine following 7 d of adaptation to the diets. Among the 28 samples, GE, CP, and ADF content (DM basis) ranged from 4,363 to 4,496 kcal/kg, 8.26 to 13.41%, and 3.26 to 5.78%, respectively. The average tannin content was 0.08, 0.84, and 1.29% in the LTS, MTS, and HTS samples, respectively. The DE and ME content (DM basis) ranged from 3,861 to 3,989 and from 3,784 to 3,905 kcal/kg, respectively, in LTS; from 3,646 to 3,740 and from 3,588 to 3,669 kcal/kg, respectively, in MTS; and from 3,481 to 3,617 and from 3,418 to 3,538 kcal/kg, respectively, in HTS. The mean DE, ME, DE/ GE, ME/GE, and ATTD of GE in MTS were less than those in LTS (P < 0.05) and greater than those in HTS (P < 0.05). The correlation coefficients between DE, ME, or the ATTD of GE and tannin content were all -0.96 (P < 0.01). The best-fit equations for DE and ME (kcal/kg DM) for the complete set of 28 sorghum grains were 6,974 - (236 × % tannin) - (43.27 × % ADF) + (24.96 × % CP) - (0.71 × % GE) for DE and 3,973 - (262 × % tannin) - (27.24 × % ADF) for ME. Our results strongly indicate that the DE and ME content of sorghum grains are related to their chemical composition, especially their tannin content. The DE and ME content could decrease by more than 200 kcal/kg when the tannin content is increased by 1% in the sorghum grain. Overall, tannin is a key predictor for the DE and ME content as well as the ATTD of GE in sorghum grains, and the potent antinutritive properties from tannin should not be ignored when sorghum is used as an energy source for pigs. [ABSTRACT FROM AUTHOR]

Ten ileal T-cannulated pigs (19.26 ± 1.06 kg) were used to evaluate the effects of a novel Buttiauxella phytase on apparent ileal digestibility (AID) of AA and apparent total tract digestibility (ATTD) and hindgut disappearance of DM, GE, CP, crude fiber, NDF, and ADF as well as minerals balance. Pigs were fed in a duplicated 5 ? 4 incomplete Latin square design (5 diets with 4 periods). Each period consisted of a 5-d adjustment period followed by a 3-d total collection of feces and urine and then a 2-d collection of ileal digesta. The 5 diets included a P-deficient basal diet (0.43% Ca and 0.38% total P) that was supplemented with 0 (negative control [NC]), 500, 1,000, or 20,000 phytase units (FTU)/kg phytase and a positive control (PC) diet that was P adequate (0.64% Ca and 0.52% total P). The addition of phytase to the NC diet improved (P < 0.05) AID of phytate from 11.1 to 62.8, 70.6, and 90.5% at the inclusion rates of 500, 1,000, and 20,000 FTU/kg, respectively. In general, phytase supplementation at a dose of 20,000 FTU/kg further increased (P < 0.05) AID of Ca, total P, and phytate and reduced (P < 0.05) the ileal phytate concentration compared with diets with 500 or 1,000 FTU/kg phytase. Pigs fed the diet with 20,000 FTU/kg phytase but not diets with 500 and 1,000 FTU/kg phytase showed improved (P < 0.05) ATTD of CP and AID of DM, GE, CP, Leu, Lys, Thr, Val, Asp, and Ser compared with pigs fed the PC or NC diet. However, hindgut disappearance of crude fiber and NDF (P < 0.05) were reduced in pigs fed the diet with 20,000 FTU/kg phytase compared with pigs fed the PC or NC diet. Pigs fed diets with 500 or 1,000 FTU/ kg phytase had greater ATTD and retention of Ca and P than pigs fed the NC diet but less compared with pigs fed the diet with 20,000 FTU/kg phytase. Supplementation of 20,000 FTU/kg phytase to the NC diet improved (P < 0.05) digestibility of Na, Mn, and Zn as well as retention (%) of Zn. Increasing phytase supplementation doses from 0 to 1,000 FTU/kg linearly improved (P < 0.05) retention of Mg; meanwhile, digestibility of Mg and Mn and AID of Thr showed a linear increase trend (P = 0.084). In conclusion, supplementation of the novel Buttiauxella phytase at doses up to 20,000 FTU/kg hydrolyzed most of the phytate (90%) and consequently further improved mineral and protein utilization. [ABSTRACT FROM AUTHOR]

The purpose of this experiment was to determine and compare the digestibility of crude protein (CP) and amino acids (AA) in full-oil (no oil extracted) and de-oiled (oil extracted) corn distillers dried grains with solubles (DDGS) with different condensed distillers solubles (CDS) ratios. Six barrows (29.6±2.3 kg) fitted with ileal T-cannula were allotted into a 6×6 Latin square design. Each period was comprised of a 5-d adaption period followed by a 2-d collection of ileal digesta. The five test diets contained 62% DDGS as the sole source of AA. A nitrogen-free diet was used to measure the basal endogenous losses of CP and AA. Chromic oxide (0.3%) was used as an index in each diet. The results showed that CP and AA were very similar in 5 DDGS, but the standardized ileal digestibility (SID) of lysine (from 56.16% to 71.15%) and tryptophan (from 54.90% to 68.38%) had the lowest values and largest variation within the essential AA, which suggests reduced availability of AA and different levels of Maillard reactions in the five DDGS. The apparent ileal digestibility and SID of CP and most of AA in full-oil DDGS (sources 1 and 2) were greater (p<0.05) than de-oiled DDGS (sources 3, 4, and 5). Comparing the AA SID in the 5 DDGS, full-oil with low CDS ratio DDGS (source 1) had non-significantly higher values (p >0.05) than full-oil with high CDS ratio DDGS (source 2); however, the SID of most AA of de-oiled with low CDS ratios DDGS (source 3) were non-significantly lower (p>0.05) than de-oiled with high CDS ratio DDGS (source 4); and the de-oiled DDGS with middle CDS ratio (source 5) but with different drying processing had the lowest SID AA values. In conclusion, de-oiled DDGS had lower SID of CP and AA than full-oil DDGS; a higher CDS ratio tended to decrease the SID of AA in full-oil DDGS but not in de-oiled DDGS; and compared with CDS ratio, processing, especially drying, may have more of an effect on AA digestibility of DDGS. [ABSTRACT FROM AUTHOR]

A new strategy of co-inoculating Bacillus subtilis MA139 with Streptococcus thermophilus and Saccharomyces cerevisiae was used to produce fermented soybean meal (FSBM). Three experiments were conducted to determine the concentration of digestible energy (DE) and metabolizable energy (ME) (Exp. 1), apparent ileal digestibility (AID) and standardized ileal digestibility (SID) of amino acids (AA) (Exp. 2), and feeding value (Exp. 3) of FSBM produced by this new strategy (NFSB) compared with soybean meal (SBM) and conventionally available FSBM (Suprotein). In Exp. 1, twenty-four barrows (initial body weight [BW] of 32.2 ±1.7 kg) were randomly allotted to 1 of 4 diets with 6 replicates per diet. A corn basal diet and 3 diets based on a mixture of corn and 1 of 3 soybean products listed above were formulated and the DE and ME contents were determined by the difference method. The results showed that there were no differences in DE and ME between SBM and either FSBM product (p>0.05). In Exp. 2, eight barrows (initial BW of 26.8±1.5 kg) were fitted with ileal T-cannulaes and used in a replicated 4×4 Latin square design. Three corn-starch-based diets were formulated using each of the 3 soybean products as the sole source of AA. A nitrogen-free diet was also formulated to measure endogenous losses of AA. The results showed that the SID of all AA except arginine and histidine was similar for NFSB and SBM (p>0.05), but Suprotein had greater (p<0.05) SID of most AA except lysine, aspartate, glycine and proline than NFSB. In Exp. 3, a total of 144 piglets (initial BW of 8.8±1.2 kg) were blocked by weight and fed 1 of 4 diets including a control diet with 24% SBM as well as diets containing 6% and 12% NFSB or 12% Suprotein added at the expense of SBM. During d 15 to 28, replacing SBM with 6% NFSB significantly improved average daily gain (ADG) and average daily feed intake (ADFI) (p<0.05) for nursery piglets. During the overall experiment, ADG of piglets fed diets containing 6% NFSB was significantly greater (p<0.05) than that of piglets fed SBM. In conclusion, fermentation with the new strategy did not affect the energy content or the AID and the SID of AA in SBM. However, inclusion of 6% NFSB in diets fed to nursery piglets improved performance after weaning likely as a result of better nutritional status and reduced immunological challenge. [ABSTRACT FROM AUTHOR]

This study was conducted to determine the total endogenous Ca output and to determine the effects of dietary Ca concentrations on endogenous Ca outputs, the true total tract digestibility (TTTD), and balance of Ca, P, and N in growing pigs. Thirty-six growing barrows (initial BW: 42.2 ± 2.0 kg) were placed in metabolism crates and allotted to a randomized complete block design with 6 diets and 6 pigs per diet. Diets were based on cornstarch and casein, and were formulated to provide the following levels of total Ca: 0.13,0.31,0.50,0.68, 0.87, and 1.05%, and the analyzed ratio of total Ca to total P was between 1.16:1 and 1.23:1. Calcitic limestone and mono-sodium phosphate provided the majority of the Ca and P in the diets. Feces and urine samples were collected from d 8 to d 12. Total endogenous Ca and P outputs and values for TTTD of Ca and P were determined using the regression procedure. Results indicate that the estimated total endogenous Ca and P outputs were 0.508 and 0.428 g/kg DMI, respectively. The TTTD of Ca in calcitic limestone was estimated at 76.8% and the TTTD of P in monosodium phosphate was estimated at 88.8%. It is concluded that the dietary concentration of Ca affects the retention of P significantly (P < 0.01), but does not affect the retention of Ca or N. [ABSTRACT FROM AUTHOR]

This study assessed the effects of proteinate complex zinc (Zn) on oxidative stress, trace elements concentrations and immune functions in weaned piglets. Three hundred newly weaned barrows (Duroc x Landrace x Yorkshire), 28 d of age, were randomly allotted to 3 dietary groups of 5 replicate pens per group for 4 wk of feeding. Experimental diets were: (1) zinc deficient diet (ZnD, 24 mg/kg Zn supplementation fromZnSO4), (2) inorganic Zndiet supplemented by 120 mg/ kg of Zn from Zn sulfate (ZnSO4), and (3) organic Zn diet supplemented by 120 mg/kg of Zn from proteinate complex Zn (PC-Zn). The Zn, Cu, Fe and Mn concentrations in the spleen and liver were measured using inductively coupled plasma-mass spectrometry (ICP-MS) technology. The activities of serous alkaline phosphatase (ALP), alanine transaminase (ALT) and aspartate transaminase (AST) were measured with a biochemical autoanalyzer. The concentration of malondialdehyde (MDA) was determined according to the thiobarbituric acid reactive substances (TBARS) assay and the activity of Mn and Cu/Zn superoxide dismutase (SOD) and glutathione peroxidase (GSH-Px) in the spleen and liver were analyzed according to the xanthine oxidase and ammonium molybdate chromogenic methods, respectively. The hepatic MT content was examined by the Cd/hemoglobin affinity assay The levels of splenic interleukin (IL)-2, IL-4, IL-10 and interferon (IFN)-γ were determined by IL-2, IL-4, IL-10 and IFN-γ enzyme linked immunosorbent assay (ELISA) kits, respectively. The proportions of CD3+, CD4+ and CD8+ T lymphocyte were analyzed with ELISA methods. The results showed that the accumulation of Zn in the spleen, levels of SOD, GSH-Px, IL-4, IL-10, the proportions of CD3+ and CD4+ T lymphocyte, and the ratio of CD47CD8+ T lymphocyte were increased by organic Zn supplementation, while the levels of MDA, IFN-γ and proportion of CD8+T lymphocyte were lowered. These findings indicate that Zn can improve the antioxidant potential and immune functions related to T lymphocyte production in the spleen of weaned piglets. [ABSTRACT FROM AUTHOR]