Search

The DEREK knowledge-based computer system contains a subset of approximately 50 rules describing chemical substructures (toxophores) responsible for skin sensitization. This rulebase, based originally on Unilever historical in-house guinea pig maximization test data, has been subject to extensive validation and is undergoing refinement as the next stage of its development. As part of an ongoing program of validation and testing, the predictive ability of the sensitization rule set has been assessed by processing the structures of the 84 chemical substances in the list of contact allergens issued by the BgVV (German Federal Institute for Health Protection of Consumers). This list of chemicals is important because the biological data for each of the chemicals have been carefully scrutinized and peer reviewed, a key consideration in an area of toxicology in which much unreliable and potentially misleading data have been published. The existing DEREK rulebase for skin sensitization identified toxophores for skin sensitization in the structures of 71 out of the 84 chemicals (85%). The exercise highlighted areas of chemistry where further development of the rulebase was required, either by extension of the scope of existing rules or by generation of new rules where a sound mechanistic rationale for the biological activity could be established. Chemicals likely to be acting as photoallergens were identified, and new rules for photoallergenicity have subsequently been written. At the end of the exercise, the refined rulebase was able to identify toxophores for skin sensitization for 82 of the 84 chemicals in the BgVV list.

Virtually all current detergent formulations contain mixtures of surfactants. Our experience and test data on these formulations, which is in agreement with that of many others, has shown that in use the formulations exhibit lower acute irritation potential than predicted by simple summation of the irritation potential of the individual actives. Using the criteria of the Dangerous Preparations Directive (EC Directive 88/379/EEC), many of these formulations classify as irritant in the neat state, with consequent labelling requirements. Such classification is based on addition of irritant components giving a total concentration which exceeds a nominal threshold. In this study, mixtures of surfactants were tested by application to a panel of 31 human volunteers for up to 4 hr, using the technique established for the assessment of acute skin irritation potential. The positive control, sodium dodecyl sulfate (SDS) at 20% concentration, gave an 84% positive response. Dimethyl dodecyl amido betaine (DDAB) at the same concentration gave a 94% response. However, a combination of 20% of each of these surfactants in the same panellists gave a response of only 44%--a significant reduction in the irritation potential. A further test conducted with a mixture of 10% SDS and 10% DDAB in a second panel gave a 31% positive response compared with a 94% positive response to the 20% SDS control in that panel. These results clearly demonstrate that the acute irritation potential of mixed surfactants cannot be predicted by simple summation of the irritation potential of the component substances. Initial results of the mechanistic investigation indicate that the reduced irritation induced by the mixed surfactant systems correlates with a reduced critical micelle concentration (CMC). However, the reduced CMC itself seems not to be responsible for the lowered irritation, since these experiments were conducted at concentrations well above the CMC. It is proposed that the critical event leading to skin irritation is binding to skin protein and that in mixed surfactant systems, the individual surfactants exhibit less affinity for this protein.

For over half a century, guinea pig methods have dominated the field of toxicology concerned with the identification of skin sensitizers. Specific protocols, for example the guinea pig maximization test (GPMT), have been pre-eminent in the identification of skin sensitization hazard for regulatory purposes. However, there are increasingly several forces driving change, not least animal use/welfare considerations. In response to this and to address the need for a rapid screen for chemical allergens, an alternative strategy has been developed. In the first instance, a chemical is assessed by a computer-based expert system. This system is constructed from some 50 rules describing the key chemically reactive substructures of known skin sensitizers. The output from the expert system is also evaluated in the light of the understanding of the skin penetration characteristics of the chemical. In this way, and without use of animals, the likelihood that a chemical represents a skin sensitization hazard is assessed based on the two key characteristics of a skin sensitizer: (1) its direct or indirect ability to react with skin protein (i.e. does it contain a structural alert?); and (2) the ability of the chemical to partition into the appropriate epidermal compartment. When the chemical does possess a structural alert and has the capacity to penetrate skin sufficiently, then it may be regarded as a potential skin sensitizer. Subsequent to this screening phase, if necessary the chemical may be assessed in the murine local lymph node assay. This assay is quicker and cheaper than traditional guinea pig assays and importantly is less stressful to the fewer animals that it requires. The assay is well validated and produces objective results which are equivalent to the GPMT in terms of identifying significant skin sensitization hazard. In this paper, the above strategy is described in more detail, focusing on its relevance to hazard identification and its value in animal welfare terms. It is concluded that the strategy provides an important opportunity for both substantial reduction and refinement of animal use in a manner which will not compromise the existing standard of classification and labelling of skin sensitization hazard in the European Union.

Quantitative structure activity relationships (QSARs) have been derived relating skin corrosivity data of organic acids, bases and phenols to their log(octanol/water partition coefficient), molecular volume, melting point and pKa. Datasets were analysed using principal components analysis; plots of the first 2 principal components of the above parameters, which broadly model skin permeability and cytotoxicity, for each group of chemicals showed that the analysis was able to discriminate well between corrosive and non-corrosive chemicals. The derived QSARs should be useful for the prediction of the skin corrosivity potential of new or untested chemicals.

Although many simple chemicals can give rise to the phenomenon of allergic contact dermatitis, it is rare that the mechanism of reaction between the chemical hapten and skin protein is known. A further complication is that metabolic processes may produce substantial changes to a chemical penetrating skin. Thus the skin contactant may be regarded as a prohapten which will give rise to the true hapten in vivo. In this study, the possible reaction mechanisms for a number of related simple aromatic chemicals have been investigated. The approach taken was to evaluate potential reaction mechanisms by assessing the degree to which chemicals could cross-react in sensitization tests. By careful choice of chemicals, it was then possible to confirm (or reject) options. Using this approach, a number of reaction schemes were investigated for eugenol, isoeugenol, dihydroeugenol, anethole and several related chemicals. The patterns of sensitization obtained and the cross-reactions observed indicated clearly that electrophile/nucleophile interactions were unlikely to provide a complete explanation of the sensitization processes. Eugenol and isoeugenol are not mutually cross-reactive, yet both cross-reacted with dihydroeugenol. Examination of the possible reaction mechanisms allows the speculation that eugenol reacts in part via a phenolic radical mechanism, whilst isoeugenol reacts largely via formation of an orthoquinone. Both reaction mechanisms are proposed for dihydroeugenol.