Search

Anaerobic wastewater treatment is, in many cases, a justified alternative to typical activated sludge processes, from a technological, economic, and ecological point of view. The optimisation of fermentation reactors is primarily concerned with increasing the biodegradation of organic compounds and biogas production, as well as improving efficiency in the removal of nitrogen and phosphorus compounds. The aim of the research was to determine the impact of using low-cost recycled filling on the efficiency of treating real confectionery wastewater in a vertical anaerobic labyrinth flow bioreactor. The experiments focused on selecting the organic loading rate that would allow for the effective biodegradation and removal of pollutants, as well as the efficient production of biomethane. It was found that the tested reactor can operate efficiently at a maximum organic loading rate (OLR) of 7.0–8.0 g of chemical oxygen demand (COD)/L·d. In this OLR range, high efficiency was guaranteed for both wastewater treatment and biogas production. However, increasing the OLR value to 8.0 g COD/L·d had a significant negative effect on the methane (CH4) content in the biogas. The most efficient variants achieved a biodegradation efficiency of around 90% of the organic compounds, a CH4 content of over 70% in the biogas, and a biogas yield of over 400 L/kg of COD removed. A significant influence of the applied OLR on the ratio of free organic acids (FOS) to total alkaline capacity (TAC) and pH was observed, as well as a strong correlation of these indicators with the specific biogas yield and CH4 content. The application of a solution based on the use of a hybrid system of anaerobic granulated sludge and an anaerobic filter resulted in an efficient treatment process and an almost complete elimination of suspensions from the wastewater. [ABSTRACT FROM AUTHOR]

The growing consumption of poultry meat has spurred the development of meat-processing plants and an associated rise in wastewater generation. Anaerobic digestion is one of the preferred processes for treating such waste. The current push towards biogas upgrading and out-of-plant use necessitates new, competitive ways of heating digesters. One such alternative is to use electromagnetic microwave radiation (EMR). The aim of the study was to assessment how EMR used as a heat source impacts the anaerobic processing of high-load poultry slaughterhouse wastewater (H-LPSW) and its performance. Microwave heating (MWH) was found to boost the CH4 fraction in the biogas under mesophilic conditions (35 °C) as long as the organic load rate (OLR) was maintained within 1.0 kgCOD/dm3·d to 4.0 kgCOD/dm3·d. The best performing variant—EPM heating (55 °C), OLR = 3.0 kgCOD/dm3·d, HRT = 5 days—produced 70.4 ± 2.7% CH4. High COD and TOC removal, as well as the highest biogas yields, were achieved for loadings of 1.0 gCOD/dm3·d to 4.0 gCOD/dm3·d. Effluent from the EMR-heated reactors (1.0 gCOD/dm3·d) contained, on average, 0.30 ± 0.07 gO2/dm3 at 55 °C and 0.38 ± 0.10 gO2/dm3 at 35 °C. The corresponding COD removal rates were 97.8 ± 0.6% and 98.1 ± 0.4%, respectively. The 5.0 gCOD/dm3·d and 6.0 gCOD/dm3·d OLR variants showed incremental decreases in performance. Based on the polymerase chain reaction results of 16S rDNA analysis, diversity of bacterial communities were mostly determined by OLR, not way of heating. [ABSTRACT FROM AUTHOR]

The aim of this study was the performance evaluation of anaerobic digestion of dairy wastewater in a multi-section horizontal flow reactor (HFAR) equipped with microwave and ultrasonic generators to stimulate biochemical processes. The effects of increasing organic loading rate (OLR) ranging from 1.0 g chemical oxygen demand (COD)/L·d to 4.0 g COD/L·d on treatment performance, biogas production, and percentage of methane yield were determined. The highest organic compounds removals (about 85% as COD and total organic carbon—TOC) were obtained at OLR of 1.0–2.0 g COD/L·d. The highest biogas yield of 0.33 ± 0.03 L/g COD removed and methane content in biogas of 68.1 ± 5.8% were recorded at OLR of 1.0 g COD/L·d, while at OLR of 2.0 g COD/L·d it was 0.31 ± 0.02 L/COD removed and 66.3 ± 5.7%, respectively. Increasing of the OLR led to a reduction in biogas productivity as well as a decrease in methane content in biogas. The best technological effects were recorded in series with an operating mode of ultrasonic generators of 2 min work/28 min break. More intensive sonication reduced the efficiency of anaerobic digestion of dairy wastewater as well as biogas production. A low nutrient removal efficiency was observed in all tested series of the experiment, which ranged from 2.04 ± 0.38 to 4.59 ± 0.68% for phosphorus and from 9.67 ± 3.36 to 20.36 ± 0.32% for nitrogen. The effects obtained in the study (referring to the efficiency of wastewater treatment, biogas production, as well as to the results of economic analysis) proved that the HFAR can be competitive to existing industrial technologies for food wastewater treatment. [ABSTRACT FROM AUTHOR]