Search

The objectives of this study were to evaluate the effects of feeding 5 different energy and nutrient dense diets to Hy-Line W-36 hens on long-term performance and economics. A total of 480 19 wk old Hy-Line W-36 Single Comb White Leghorn hens were weighed and randomly allocated to 6 replicate groups of 16 hens each (2 adjacent cages containing 8 hens per cage, 60.9×58.4 cm) per dietary treatment in a randomized complete block design. The hens were fed 5 treatment diets formulated to contain 85, 90, 95, 100, and 105% of the energy and nutrient recommendations stated in the 2009 Hy-Line Variety W-36 Commercial Management Guide. Production performance was measured for 52 wk from 19 to 70 wk age. Over the course of the trial, a significant increasing linear response to increasing energy and nutrient density was seen for hen-day egg production, egg weight, egg mass, feed efficiency, energy intake, and body weight (BW). Feed intake showed no significant linear level response to increasing energy and nutrient density except during the early production cycle. No consistent responses were noted for egg quality, percent yolk, and percent egg solids throughout the study. Significant linear responses due to energy and nutrient density were seen for egg income, feed cost, and income minus feed cost. In general, as energy and nutrient density increased, egg income and feed cost per hen increased, but income minus feed cost decreased. Overall, these results indicate that feeding Hy-Line W-36 hens increasing energy and nutrient-dense diets will increase egg production, egg weight, egg mass, feed efficiency, energy intake, BW, egg income, and feed cost, but decrease egg income minus feed cost. However, these benefits do not take effect in early production and seem to be most effective in later stages of the production cycle, perhaps "priming" the birds for better egg-production persistency with age., (© 2015 Poultry Science Association Inc.)

The objectives of this study were to evaluate and compare the effects of production, physiology, egg quality, and economics of laying hens housed in a cage system when offered a calcium premolt treatment and low-energy molt diets versus a traditional feed withdrawal (FW) treatment during and after molt. In total, 981 Hy-Line W-36 laying hens (85 wk of age) housed 3 per cage were used. Six treatments were compared in a 2 × 3 factorial design with 2 calcium premolt treatments (fine and coarse) and 3 molt diets (FW, soybean hulls, and wheat middlings). The coarse Ca was a 50:50 mix of fine (0.14-mm mean diameter) and coarse (2.27-mm mean diameter) CaCO(3), whereas the fine Ca was an all-fine CaCO(3). Both diets were formulated to contain 4.6% Ca, such that only the particle size of the CaCO(3) differed. Production parameters in experiment 1 included egg production, egg weight and mass, specific gravity, Haugh units, egg components, feed consumption and utilization, and BW. Physiological parameters in experiment 2 included ovary and oviduct weights, femur- and humerus-ash percentages, heterophil to lymphocyte ratios, plasma Ca and inorganic P concentrations, and alkaline phosphatase activity. Data were analyzed by ANOVA and P < 0.05 was significant. The fine-Ca premolt treatment was more effective than the coarse-Ca treatment at decreasing egg production during molt and increasing it postmolt, regardless of the molt diet. The FW molt diet resulted in the greatest decrease in production, but the soybean hulls diet resulted in lower production and ovary and oviduct weights during molt compared with those of the wheat middlings molt diet. Therefore, a fine-Ca premolt treatment and a low-energy molt diet, particularly soybean hulls, can be useful alternatives to a FW molt.

The objectives of this study were to compare the behaviors, postures, and heterophil-to-lymphocyte ratios (H:L) of laying hens housed in a cage system when offered a Ca premolt treatment and low-energy molt diets vs. a traditional feed withdrawal (FW) treatment during and after molt. A total of 144 Hy-Line W-36 hens (85 wk of age), housed 3 hens/cage (413 cm(2)/hen), were used. Hens were allotted to treatments according to a randomized complete block design, with the cage location and initial BW as the blocking criteria. Six treatments were compared in a 2 × 3 factorial arrangement with 2 Ca premolt treatments (fine or coarse) and 3 low-energy molt diets (FW, soybean hulls, or wheat middlings). The 2 Ca premolt treatments differed only in Ca particle size (fine was 0.14 mm and coarse was 2.27 mm mean diameter). Two postures and 5 behaviors were recorded and H:L was measured. Data were analyzed using the MIXED procedure of SAS, with P < 0.05 considered significant. There were no differences in behaviors, postures, or H:L during the premolt baseline period. The Ca premolt treatment had no carryover effects during or after molt for behaviors or postures. During molt, hens in the FW treatment were more active, and they ate and drank less compared with hens fed soybean hulls or wheat middlings, but there were no differences in aggression, nonnutritive pecking, or sitting. Drinking and aggression during and after molt were not different, but hens postmolt engaged in more sitting and feeding and less activity, nonnutritive pecking, and preening compared with during molt. There were no differences in H:L during or after molt. In conclusion, a Ca premolt treatment did not affect the behavior of the laying hen. The low-energy molt diets did not adversely affect behavior compared with FW and did not increase H:L; therefore, they could be useful alternatives for inducing molt in laying hens.

A study was conducted to determine the influence on broiler chicken growth and laying hen performance of chemical and physical traits of corn kernels from different hybrids. A total of 720 male 1-d-old Ross-308 broiler chicks were allotted to floor pens in 2 replicated experiments with a randomized complete block design. A total of 240 fifty-two-week-old Hy-Line W-36 laying hens were allotted to cages in a randomized complete block design. Corn-soybean meal diets were formulated for 3 broiler growth phases and one 14-wk-long laying hen phase to be marginally deficient in Lys and TSAA to allow for the detection of differences or correlations attributable to corn kernel chemical or physical traits. The broiler chicken diets were also marginally deficient in Ca and nonphytate P. Within a phase, corn- and soybean-based diets containing equal amounts of 1 of 6 different corn hybrids were formulated. The corn hybrids were selected to vary widely in chemical and physical traits. Feed consumption and BW were recorded for broiler chickens every 2 wk from 0 to 6 wk of age. Egg production was recorded daily, and feed consumption and egg weights were recorded weekly for laying hens between 53 and 67 wk of age. Physical and chemical composition of kernels was correlated with performance measures by multivariate ANOVA. Chemical and physical kernel traits were weakly correlated with performance in broiler chickens from 0 to 2 wk of age (P<0.05, | r |<0.42). However, from 4 to 6 wk of age and 0 to 6 wk of age, only kernel chemical traits were correlated with broiler chicken performance (P<0.05, | r |<0.29). From 53 to 67 wk of age, correlations were observed between both kernel physical and chemical traits and laying hen performance (P<0.05, | r |<0.34). In both experiments, the correlations of performance measures with individual kernel chemical and physical traits for any single kernel trait were not large enough to base corn hybrid selection on for feeding poultry.

Seven separate experiments were conducted with Hy-Line W-36 hens to determine the ideal ratio of Arg, Ile, Met, Met+Cys, Thr, Trp, and Val relative to Lys for maximal egg mass. The experiments were conducted simultaneously and were each designed as a randomized complete block design with 60 experimental units (each consisting of 1 cage with 2 hens) and 5 dietary treatments. The 35 assay diets were made from a common basal diet (2,987 kcal/kg of ME; 12.3% CP; 4.06% Ca, 0.47% nonphytate P), formulated using corn, soybean meal, and meat and bone meal. The true digestible amino acid contents in the basal diet were determined using the precision-fed assay with adult cecectomized roosters. Crystalline L-Arg (free base), L-Ile, L-Lys.HCl, DL-Met, L-Thr, L-Trp, and L-Val (considered 100% true digestible) were added to the basal diet at the expense of cornstarch to make the respective assayed amino acid first limiting and to yield 5 graded inclusions of the assayed amino acid. Hens were fed the assay diets from 26 to 34 wk of age, with the first 2 wk considered a depletion period. Egg production was recorded daily and egg weight was determined weekly on eggs collected over 48 h; egg mass was calculated as egg production x egg weight. The requirement for each amino acid was determined using the broken-line regression method. Consumption of Arg did not affect egg mass, thus a requirement could not be determined. The true digestible amino acid requirements used to calculate the ideal amino acid ratio for maximum egg mass were 426 mg/d of Ile, 538 mg/d of Lys, 253 mg/d of Met, 506 mg/d of Met+Cys, 414 mg/d of Thr, 120 mg/d of Trp, and 501 mg/d of Val. The ideal amino acid ratio for maximum egg mass was Ile 79%, Met 47%, Met+Cys 94%, Thr 77%, Trp 22%, and Val 93% on a true digestible basis relative to Lys. The ideal Met and Met+Cys ratios were verified in an ensuing identical experiment with 52- to 58-wk-old hens.

An experiment was conducted with laying hens to determine the AME(n) value of crude glycerol, a coproduct of biodiesel production. Crude glycerol (87% glycerol, 9% water, 0.03% methanol, 1.26% Na, and 3,625 kcal/kg of gross energy) was obtained from a commercial biodiesel production facility (Ag Processing Inc., Sergeant Bluff, IA). A total of forty-eight 40-wk-old laying hens (Hy-Line W-36) were placed in metabolic cages (2 hens/ cage) and given free access to the experimental diets. A corn and soybean meal-based basal diet (18% CP, 2,875 kcal/kg of AME(n), 4.51% Ca, 0.51% nonphytate P) was formulated with 15% glucose.H(2)O and 1% Celite. Four dietary treatments were created by substituting 0, 5, 10, or 15% crude glycerol for glucose.H(2)O (3,640 kcal/kg of AME(n)). After 7 d of dietary adaptation, excreta were collected twice daily for 3 d, freeze-dried, and analyzed for contents of DM, Kjeldahl N, acid-insoluble ash, and gross energy. Egg production was recorded daily, and eggs were collected on d 7 and 8 of the experiment for calculation of egg mass (egg production x egg weight). Feed consumption was measured over the 10-d experimental period. Egg-production data were analyzed by ANOVA with 4 treatments and 6 replications in a completely randomized experimental design. The AME(n) value of crude glycerol was estimated as the slope of the linear relationship between the inclusion rate of dietary crude glycerol and the glucose-corrected AME(n) value of the experimental diets. No significant treatment effects (P > 0.1) were apparent for egg-production rate (93.0%), egg weight (56.1 g), egg mass (52.2 g/d), or feed consumption (104 g/d). Linear regression analysis (P < 0.001, r(2) = 0.92, n = 24) revealed that the AME(n) value of the crude glycerol used in this study was 3,805 +/- 238 kcal/kg (mean +/- SEM; as-is basis) for laying hens.

Ammonia (NH(3)) emission is a major concern for the poultry industry. The objective of this research was to determine whether inclusion of dietary fiber and a reduced dietary CP content would decrease NH(3) emission from laying-hen manure. A total of 256 Hy-Line W-36 hens were fed diets with 2 levels of CP (normal and reduced) and 4 fiber treatments in a 2 x 4 factorial arrangement. The fiber treatments included a corn and soybean meal-based control diet and diets formulated with either 10.0% corn dried distillers grains with solubles (DDGS), 7.3% wheat middlings (WM), or 4.8% soybean hulls (SH) to contribute equal amounts of additional neutral detergent fiber. The CP contents of the reduced-CP diets were approximately 1 percentage unit lower than those of the normal-CP diets. All diets were formulated on the basis of digestible amino acid content and were formulated to be isoenergetic. Fresh manure was collected such that pH, uric acid, and Kjeldahl N contents could be measured. The NH(3) emission from manure was measured over 7 d by placing pooled 24-h manure samples in NH(3) emission vessels. Data were analyzed by ANOVA with Dunnett's multiple-comparisons procedure to compare results from the fiber treatments with the control, whereas the main effect of protein was used to compare the normal- and reduced-CP treatments. Dietary corn DDGS, WM, or SH lowered (P

Ammonia emission is a major concern for the poultry industry and can be lowered by dietary inclusion of fibrous ingredients and by lowering the dietary CP content. The objectives of this research were to determine the effects of dietary fiber and reduced-CP diets, which may lower NH(3) emission, on egg production and N balance in laying hens. A total of 256 Hy-Line W-36 hens were fed diets with 2 contents of CP (normal and reduced) and 4 fiber treatments in a 2 x 4 factorial arrangement from 23 to 58 wk of age. The fiber treatments included a corn and soybean meal-based control diet and diets formulated with either 10.0% corn dried distillers grains with solubles (DDGS), 7.3% wheat middlings (WM), or 4.8% soybean hulls (SH) added to contribute equal amounts of neutral detergent fiber. The CP contents of the reduced-CP diets were approximately 1 percentage unit lower than that of the normal-CP diets. All diets were formulated on a digestible amino acid basis to be isoenergetic. There were no effects (P > 0.05) of including corn DDGS, WM, or SH in the diet on egg production, egg weight, egg mass, yolk color, feed consumption, feed utilization, or BW gain. Although the corn DDGS and WM diets resulted in an increase (P < 0.001) in N consumption, N excretion was not affected (P > 0.10) compared with hens fed the control diet. The reduced-CP diets did not affect egg weight, feed consumption, or BW gain (P > 0.05); however, egg production, egg mass, feed utilization, N consumption, and N excretion were lower than that from the hens fed the normal-CP diets (P < 0.05). The results of this study show that the diets containing 10% corn DDGS, 7% WM, or 5% SH did not affect egg production or N excretion. However, the 1% lower CP diets caused a lower egg production and lower N excretion.