Search

Rice plays an important role in the daily diet in China and therefore its quality and safety have been of great concern. However, few systematic studies have investigated Fusarium community and toxins in rice grains. Here, we collected 1381 rice samples from Jiangsu Province in eastern China and found a higher frequency of zearalenone (ZEN), deoxynivalenol (DON), fumonisins (FBs), and beauvericin (BEA). The positive samples were individually contaminated with a minimum of one and a maximum of ten toxins. Fusarium was isolated and identified as the major fungus, which exhibited temporal and geographical distribution. The most prevalent species complexes within this genus were Fusarium incarnatum-equiseti species complex (FIESC), Fusarium fujikuroi species complex (FFSC), and Fusarium sambucinum species complex (FSAMSC). Nevertheless, the amplicon sequence analysis revealed a low relative abundance of Fusarium in the rice panicles, and the fungal community exhibited an irregular change along with the symptom's emergence. In vitro toxigenic profiles of Fusarium strains showed significant complexity and specificity depending on the type and content. FIESC strains were non-pathogenic to wheat heads and weakly pathogenic to maize ears, respectively, accumulating lower amounts of toxins than F. asiaticum and F. fujikuroi. There was no significant variation in the ability to cause panicle blight in rice among the various species tested. Our study provides detailed information about the contamination of Fusarium toxins and community in rice after harvest. This information is valuable for understanding the relationship between Fusarium and rice and for developing effective control strategies., Competing Interests: Declaration of competing interest The authors declare the following financial interests/personal relationships which may be considered as potential competing interests: Jianhong Xu reports financial support was provided by Jiangsu Agriculture Science and Technology. If there are other authors, they declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2024 Elsevier Ltd. All rights reserved.)

Maize (Zea mays L.) is an important cereal crop worldwide. Contaminated maize kernels pose a significant mycotoxin exposure risk for humans in Latin America. Fumonisins, the most prevalent mycotoxin in maize, typically occur during pre-harvest conditions leading to significant economic losses. Various factors, including weather conditions, may influence this contamination. This study aimed to determine the association between fumonisin B 1 (FB 1 ) contamination, prevalence of Fusarium verticillioides, weather conditions and kernel quality in the two primary maize production areas in Costa Rica (Brunca and Chorotega). All maize samples (100%) showed FB 1 contamination, with higher concentrations in samples from Brunca region, consistent with the presence of F. verticilliodes. Weather conditions appeared to play an important role in this contamination, since Brunca region had the highest mean temperature and relative humidity after maize silking (R1) and the total monthly rainfall in this region was significantly higher during the last two months of maize cultivation (grain-filling and physiological maturity stages R3 to R6). Interestingly, this study found a negative correlation between grain damage and kernel contamination with FB 1 and F. verticillioides. The concentration of mineral nutrients in kernels from both regions was largely similar. Most nutrients in kernels exhibited a negative correlation with FB 1 , particularly nitrogen. Zinc and phosphorus were the only nutrients in kernels showing a positive correlation with FB 1 in samples from the Brunca region. The results highlight elevated levels of FB 1 contamination in maize and contribute to a better understanding of pre-harvest factors influencing FB 1 contamination in tropical conditions., (© 2024. The Author(s) under exclusive licence to Society for Mycotoxin (Research Gesellschaft für Mykotoxinforschung e.V.) and Springer-Verlag GmbH Germany, part of Springer Nature.)

Fusarium verticillioides, a major fungal pathogen of maize, produces fumonisins, mycotoxins of global food safety concern. Control practices are needed to reduce the negative health and economic impacts of fumonisins. Therefore, we investigated volatile organic compounds (VOCs) emitted by fumonisin-producing (wild-type) and nonproducing (mutant) strains of F. verticillioides. VOC emissions were analyzed by gas chromatography-mass spectrometry following inoculation of maize kernels, and fumonisin accumulation was analyzed by high-performance liquid chromatography. Mutants emitted VOCs, including ethyl 3-methylbutanoate, that the wild type did not emit. In particular, ANOVA analysis showed significant differences between mutants and wild type for 4 VOCs which emission was correlated with absence of fumonisins. Exogenous ethyl 3-methylbutanoate reduced growth and fumonisin production in wild-type F. verticillioides, showing its potential in biocontrol. Together, our findings offer valuable insights into how mycotoxin production can impact VOC emissions from F. verticillioides and reveal a potential biocontrol strategy to reduce fumonisin contamination., Competing Interests: Declaration of Competing Interest The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper., (Copyright © 2023 The Authors. Published by Elsevier Ltd.. All rights reserved.)

Mycotoxins that contaminate grain can cause the devaluation of agricultural products and create health risks for the consumer. Fumonisins are one such mycotoxin. Produced primarily by Fusarium verticillioides (Hypocreales: Nectriaceae) (Nirenberg, 1976) on corn, fumonisins' economic impact can be significant by causing various diseases in livestock if contaminated corn is not monitored and removed from animal feed. Finding safe alternatives to the destruction and waste of contaminated grain and restoring its economic value is needed for a sustainable future. Safe reintroduction into the farm food web may be possible through a consumable intermediary such as insects. This study demonstrates the suitability of the house cricket, Acheta domesticus L., as an alternative protein source in domestic animal feed by quantifying fumonisin B1 (FB1) levels in their subsequent insect meal and frass. Small colonies of 2nd instar A. domesticus were reared to 5th instar adults on nutrient-optimized corn-based diets treated with 4 levels of FB1 from 0 to 20 ppm. Increasing levels of FB1 had no adverse effects on the survivorship or growth of A. domesticus. Insect meals prepared from A. domesticus had significantly lower levels of FB1, at 3%-5% of their respective diets, while frass did not differ significantly from their diet. The successful rearing to adulthood of A. domesticus on fumonisin-contaminated diet paired with lower levels of FB1 in their processed insect meal supports the idea that more sustainable agricultural practices can be developed through remediation of low-value mycotoxin-contaminated grain with safer, higher-value insects as livestock feed components., (Published by Oxford University Press on behalf of Entomological Society of America 2024.)

Maize production in South Africa is concentrated in its central provinces. The Eastern Cape contributes less than 1% of total production, but is steadily increasing its production and has been identified as a priority region for future growth. In this study, we surveyed ear rots at maize farms in the Eastern Cape, and mycotoxins were determined to be present in collected samples. Fungal isolations were made from mouldy ears and species identified using morphology and DNA sequences. Cladosporium, Diplodia, Fusarium and Gibberella ear rots were observed during field work, and of these, we collected 78 samples and isolated 83 fungal strains. Fusarium was identified from Fusarium ear rot (FER) and Gibberella ear rot (GER) and Stenocarpella from Diplodia ear rot (DER) samples, respectively. Using LC-MS/MS multi-mycotoxin analysis, it was revealed that 83% of the collected samples contained mycotoxins, and 17% contained no mycotoxins. Fifty percent of samples contained multiple mycotoxins (deoxynivalenol, 15-acetyl-deoxynivalenol, diplodiatoxin and zearalenone) and 33% contained a single mycotoxin. Fusarium verticillioides was not isolated and fumonisins not detected during this survey. This study revealed that ear rots in the Eastern Cape are caused by a wide range of species that may produce various mycotoxins.

Fumonisins are one of the main problems affecting maize production in the Texas High Plains (THP), where its agroclimatic conditions make it a perennial hotspot for mycotoxin contamination. In 2017, a fumonisin outbreak in the THP maize motivated stakeholders' request to repeal a subsection of the Texas Administrative Code, §61.61(a)(7) (Fumonisin Rule), and its related Texas Feed Industry Memorandum (Memo 5-20), which previously permitted the blending of maize containing high fumonisin levels with maize containing ≥ 5 mg/kg under state authority, and pivot to FDA fumonisin guidance. Shortly after, the USDA Risk Management Agency (RMA's) reintroduced Discount Factors (DFs) in annual Special Provisions (SP) that outline price reductions related to fumonisin contamination in maize. In this research, we estimate the potential economic burden posed by these changes through a two-part approach. In part one, we construct a decision model that explores the final disposition of fumonisin-contaminated maize based on blending permissions, fumonisin levels, and crop insurance status. In part two, we estimate the economic impact by inserting output values of the decision model into financial equations that consider testing costs, transportation fees, and discounts from crop insurance and grain elevators when applicable. Our economic analysis projects that the financial losses during a THP crop year with high fumonisin levels could range from $15.1 to $135.5 million without the option to blend under conditions of the revised RMA discount schedule. Findings further highlight crop insurance as the most promising risk management strategy for farmers in areas susceptible to fumonisin contamination.

Fumonisins comprise structurally related metabolites mainly produced by Fusarium verticillioides and Fusarium proliferatum . Contamination with fumonisins causes incalculable damage to the economy and poses a great risk to animal and human health. Fumonisins and their covert products are found in cereals and cereal products. Food processing significantly affects the degradation of toxins and the formation of covert toxins. However, studies on fumonisins and their covert mycotoxins remain inadequate. This review aims to summarize changes in fumonisins and the generation of covert fumonisins during processing. It also investigates the toxicity and determination methods of fumonisins and covert fumonisins, and elucidates the factors affecting fumonisins and their covert forms during processing. In addition to the metabolic production by plants and fungi, covert fumonisins are mainly produced by covalent or noncovalent binding, complexation, or physical entrapment of fumonisins with other substances. The toxicity of covert fumonisins is similar to that of free fumonisins and is a non-negligible hazard. Covert fumonisins are commonly found in food matrices, and methods to analyze them have yet to be improved. Food processing significantly affects the conversion of fumonisins to their covert toxins.

Fusarium species are common fungal pathogens of maize. Fusarium graminearum and Fusarium verticillioides, among others, can cause maize ear rot, and they are also mycotoxin producers. The aims of this work were to determine the frequency and diversity of Fusarium species in Uruguayan maize kernels, evaluate the toxigenic potential of the isolates, determine toxin contamination levels on freshly harvested grain, and assess the sensitivity of main Fusarium species against fungicides. Fusarium verticillioides was the most frequent species isolated, followed by Fusarium graminearum sensu stricto. Of F. verticillioides isolates studied for fumonisin production, 72% produced fumonisin B1 and 32% fumonisin B2. Considering in vitro toxin production by F. graminearum sensu stricto isolates, deoxynivalenol was the main toxin produced, followed by zearalenone and nivalenol. Fumonisins were the most frequently found toxins on freshly harvested maize samples (98% in 2018 and 86% in 2019), and also, fumonisin B1 was the toxin with highest concentration in both years studied (4860 µg/kg in 2018 and 1453 µg/kg in 2019). Deoxynivalenol and zearalenone were also found as contaminants. Metconazole and epoxiconazole were the most effective fungicides tested on F. verticillioides isolates. Fusarium graminearum sensu stricto isolates also were more sensitive to metconazole compared to other fungicides; nevertheless, epoxiconazole was less efficient in controlling this species. This is the first study that reports Fusarium species and mycotoxin contamination levels associated with maize grain in Uruguay. Its detection is the main step to develop management strategies in order to minimize fungal infection in maize crops., (© 2023. The Author(s) under exclusive licence to Society for Mycotoxin (Research Gesellschaft für Mykotoxinforschung e.V.) and Springer-Verlag GmbH Germany, part of Springer Nature.)

Fusarium species infect maize crops leading to the production of fumonisin by their toxigenic members. Elimination of microbes is critical in mitigating further postharvest spoilage and toxin accumulation. The current study investigates the efficacy of a previously described multispectral sorting technique to analyze the reduction of fumonisin and toxigenic Fusarium species found contaminating maize kernels in Kenya. Maize samples (n = 99) were collected from six mycotoxin hotspot counties in Kenya (Embu, Meru, Tharaka Nithi, Machakos, Makueni, and Kitui County) and analyzed for aflatoxin and fumonisin using commercial ELISA kits. Aflatoxin levels in majority (91%) of the samples were below the 10 ng/g threshold set by the Kenya Bureau of Standards and therefore not studied further. The 23/99 samples that had >2,000 ng/g of fumonisin were selected for sorting. The sorter was calibrated using kernels sourced from Ghana to reject visibly high-risk kernels for fumonisin contamination using reflectance at nine distinct wavelengths (470-1,550 nm). Accepted and rejected streams were tested for fumonisin using ELISA, and the presence of toxigenic Fusarium using qPCR. After sorting, there was a significant (p < 0.001) reduction of fumonisin, by an average of 1.8 log ng/g (98%) and ranging between 0.14 and 2.7 log ng/g reduction (28-99.8%) with a median mass rejection rate of 1.9% (ranged 0% to 48%). The fumonisin rejection rate ranged between 0 and 99.8% with a median of 77%. There was also a significant reduction (p = 0.005) in the proportion of DNA represented by toxigenic Fusarium, from a mean of 30-1.4%. This study demonstrates the use of multispectral sorting as a potential postharvest intervention tool for the reduction of Fusarium species and preformed fumonisin. The spectral sorting approach of this study suggests that classification algorithms based on high-risk visual features associated with mycotoxin can be applied across different sources of maize to reduce fumonisin., Competing Interests: Declaration of Competing Interest The authors declare the following financial interests/personal relationships which may be considered as potential competing interests: Asha B. Mohamed reports financial support was provided by International Atomic Energy Agency. Editorial Board member of the Journal of Food Protection – MJS., (Copyright © 2023 The Author(s). Published by Elsevier Inc. All rights reserved.)

Rice spikelet rot disease (RSRD) caused by Fusarium proliferatum seriously reduces rice yield and produces mycotoxins that threaten human health. The root symbiotic endophytic fungus Phomopsis liquidambaris reduces RSRD incidence and fumonisins accumulation in grain by 21.5 and 9.3%, respectively, while the mechanism of disease resistance remains largely elusive. Here, we found that B3 significantly reduced the abundance of pathogen from 79.91 to 2.84% and considerably enriched resistant microbes Pseudomonas and Proteobacteria in the spikelet microbial community. Further study revealed that B3 altered the metabolites of spikelets, especially hordenine and l-aspartic acid, which played a key role in reshaping the microbiome and supporting the growth of the functional core microbe Pseudomonas , and inhibited the pathogen growth and mycotoxin production. This study provided a feasibility of regulating the function of aboveground microbial communities by manipulating plant subsurface tissues to control disease and mycotoxin pollutants in agricultural production.

The present work investigated the potential of fungal species from grain maize farms in Malaysia as antagonists against the indigenous mycotoxigenic fungal species and their subsequent mycotoxin production. Dual-culture assay was conducted on grain maize agar (GMA) with 12 strains of potential fungal antagonists namely Bjerkandra adusta, Penicillium janthinellum, Schizophyllum commune, Trametes cubensis, Trichoderma asperelloides, Trichoderma asperellum, Trichoderma harzianum, and Trichoderma yunnanense against seven mycotoxigenic strains namely Aspergillus flavus, Aspergillus niger, Fusarium verticillioides, and Fusarium proliferatum producing aflatoxins, ochratoxin A, and fumonisins, respectively. Based on fungal growth inhibition, Trichoderma spp. showed the highest inhibitory activity (73-100% PIRG, Percentage Inhibition of Radial Growth; 28/0 I D , Index of Dominance) against the tested mycotoxigenic strains. Besides, B. adusta and Tra. cubensis showed inhibitory activity against some of the tested mycotoxigenic strains. All fungal antagonists showed varying degrees of mycotoxin reduction. Aflatoxin B 1 produced by A. flavus was mainly reduced by P. janthinellum, Tra. cubensis, and B. adusta to 0 ng/g. Ochratoxin A produced by A. niger was mainly reduced by Tri. harzianum and Tri. asperellum to 0 ng/g. Fumonisin B 1 and FB 2 produced by F. verticillioides was mainly reduced by Tri. harzianum, Tri. asperelloides, and Tri. asperellum to 59.4 and 0 µg/g, respectively. Fumonisin B 1 and FB 2 produced by F. proliferatum were mainly reduced by Tri. asperelloides and Tri. harzianum to 244.2 and 0 µg/g, respectively. This is the first study that reports on the efficacy of Tri. asperelloides against FB 1 , FB 2 , and OTA, P. janthinellum against AFB 1 , and Tra. cubensis against AFB 1 ., (© 2023. The Author(s) under exclusive licence to Society for Mycotoxin (Research Gesellschaft für Mykotoxinforschung e.V.) and Springer-Verlag GmbH Germany, part of Springer Nature.)

Breakfast processed products are remarkably at risk of fungal contamination. This research surveyed the fumonisins concentration in different breakfast products and carried out in vitro experiments measuring fumonisins content in different substrates inoculated with Fusarium verticillioides. The pipeline started with the identification of combinations of ingredients for 58 breakfast products. Twenty-three core ingredients, seven nutritional components and production types were analyzed using a Pearson correlation, k-means clustering, and principal component analysis to show that no single factor is responsible for high fumonisins detection in processed cereals products. Consequently, decision tree regression was used as a means of determining and visualizing complex logical interactions between the same factors. We clustered the association of ingredients in low, medium, and high risk of fumonisin detection. The analysis showed that high fumonisins concentration is associated with those products that have high maize concentrations coupled especially with high sodium or rice. In an in vitro experiment, different media were prepared by mixing the ingredients in the proportion found in the first survey and by measuring fumonisins production by Fusarium verticillioides. Results showed that (1) fumonisins production by F. verticillioides is boosted by the synergistic effect of maize and highly ready carbohydrate content such as white flour; (2) a combination of maize > 26% (w/w), rice > 2.5% (w/w), and NaCl > 2.2% (w/w) led to high fumonisins production, while mono-ingredient products were more protective against fumonisins production. The observations in the in vitro experiments appeared to align with the decision tree model that an increase in ingredient complexity can lead to fumonisins production by Fusarium. However, more research is urgently needed to develop the area of predictive mycology based on the association of processing, ingredients, fungal development, and mycotoxins production., (© 2023. The Author(s).)

In temperate world-wide regions, maize kernels are often infected with the fumonisin-producing fungus Fusarium verticillioides which poses food and feed threats to animals and humans. As maize breeding has been revealed as one of the main tools with which to reduce kernel contamination with fumonisins, a pedigree selection program for increased resistance to Fusarium ear rot (FER), a trait highly correlated with kernel fumonisin content, was initiated in 2014 with the aim of obtaining inbred lines (named EPFUM) with resistance to kernel contamination with fumonisins and adapted to our environmental conditions. The new released EPFUM inbreds, their parental inbreds, hybrids involving crosses of one or two EPFUM inbreds, as well as commercial hybrids were evaluated in the current study. The objectives were (i) to assess if inbreds released by that breeding program were significantly more resistant than their parental inbreds and (ii) to examine if hybrids derived from EPFUM inbreds could be competitive based on grain yield and resistance to FER and fumonisin contamination. Second-cycle inbreds obtained through this pedigree selection program did not significantly improve the levels of resistance to fumonisin contamination of their parental inbreds; however, most EPFUM hybrids showed significantly better resistance to FER and fumonisin contamination than commercial hybrids did. Although European flint materials seem to be the most promising reservoirs of alleles with favorable additive and/or dominance effects for resistance to kernel contamination with fumonisins, marketable new Reid × Lancaster hybrids have been detected as they combine high resistance and yields comparable to those exhibited by commercial hybrids. Moreover, the white kernel hybrid EPFUM-4 × EP116 exploits the genetic variability within the European flint germplasm and can be an alternative to dent hybrid cultivation because white flint grain can lead to higher market prices.

Maize is a significant crop to the global economy and a key component of food and feed, although grains and whole plants can often be contaminated with mycotoxins resulting in a general exposure of the population and animals. To investigate strategies for mycotoxins control at the grain production level, a pilot study and exploratory research were conducted in 2019 and 2020 to compare levels of mycotoxins in grains of plants treated with two fertilizers, F-BAC and Nefusoil, under real agricultural environment. The 1650 grains selected from the 33 samples were assessed for the presence of both Fusarium species and mycotoxins. Only fumonisins and deoxynivalenol were detected. Fumonisin B1 ranged from 0 to 2808.4 µg/Kg, and fumonisin B2 from 0 to 1041.9 µg/Kg, while deoxynivalenol variated from 0 to 465.8 µg/Kg. Nefusoil showed to be promising in regard to fumonisin control. Concerning the control of fungal contamination rate and the diversity of Fusarium species, no significant differences were found between the two treatments in any of the years. However, a tendency for was observed Nefusoil of lower values, probably due to the guaranteed less stressful conditions to the Fusarium spp. present in the soil, which do not stimulate their fumonisins production.

Fusarium verticillioides is a key maize pathogen and produces fumonisins, a group of mycotoxins detrimental to humans and animals. Unfortunately, our understanding on how this fungus interacts with maize to trigger mycotoxin biosynthesis is limited. We performed a systematic computational network-based analysis of large-scale F. verticillioides RNA-seq datasets to identify gene subnetwork modules associated with virulence and fumonisin regulation. F. verticillioides was inoculated on two different maize lines, moderately resistant line hybrid 33K44 and highly susceptible line maize inbred line B73, to generate time-course RNA-Seq data. Among the highly discriminative subnetwork modules, we identified a putative hub gene FvLCP1, which encodes a putative a type-D fungal LysM protein with a signal peptide, three LysM domains, and two chitin binding domains. FvLcp1 is a unique protein that harbors these domains amongst five representative Fusarium species. FvLcp1 is a secreted protein important for fumonisin production with the LysM domain playing a critical role. The chitin-binding domain was essential for in vitro chitin binding. Using Magnaporthe oryzae, we learned that FvLcp1 accumulates in appressoria, suggesting that FvLcp1 is involved in host recognition and infection. Full length FvLcp1 suppressed BAX-triggered plant cell death in Nicotiana benthamiana. This unique type-D LysM secreted protein with a chitin-binding domain in F. verticillioides was shown to be potentially involved in suppressing host cell death and promoting fumonisin biosynthesis while the pathogen colonizes maize kernels., (Copyright © 2022 Elsevier GmbH. All rights reserved.)

We have previously published six esterified O -acyl (EFB1) and three N -acyl fumonisin B 1 derivatives extracted from rice cultures inoculated with Fusarium verticillioides , amongst these the identification of N -palmitoyl-FB1 has been clearly established in a spiking experiment. At that time, it was assumed that as in the case of O -acyl-FB1 derivatives, linoleic-, oleic- or palmitic acid esterify through the OH group on the 3C or 5C atom of the carbon chain of the fumonisins. In our most recent experiments, we have synthetically acylated the FB1 toxin and subsequently purified 3- O -palmitoyl- and 5- O -palmitoyl-FB1 toxins in addition to the N -palmitoyl-FB1 toxin. They were identified and characterised using 1 H and 13 C NMR as well as LC-HRMS. Our aim was the identification of the previously detected O -acyl-FB1 derivatives over the course of a spiking experiment, which were obtained through the solid-phase fermentation of Fusarium verticillioides . By spiking the three synthesized and identified components one-by-one into the fungal culture extract and analysing these cultures using LC-MS, it was clearly demonstrated that the F. verticillioides strain produced both the 5- O -palmitoyl-FB1 and N -palmitoyl-FB1 toxins, but did not produce 3- O -palmitoyl-FB1. Thus, it is highly probable that the components thought to be 3- O -acyl-(linoleoyl-, oleoyl-, palmitoyl-) FB1 derivatives in our previous communication are presumably 10- O -acyl-FB1 derivatives. Since these acylated FB1 derivatives can occur naturally in e.g. maize, the use of these synthesized components as reference materials is of great importance in order to obtain accurate qualitative and quantitative data on the occurrence of acylated fumonisins in different matrices including maize based feed samples. The production of these substances has also made it possible to test their toxicity in cell culture and small animal experiments.

Maize is considered one of the most susceptible crops to mycotoxin-producing fungi throughout the world, mainly belonging to the Fusarium spp. and Aspergillus spp. Maize is mainly used as animal feeds in Italy, as well as for human consumption, being essential for all the protected designation of origin (DOP) products. Our study investigated the occurrence of regulated mycotoxins in 3769 maize grain samples collected from 88 storage centers by the National Monitoring Network over an 11-year period (2011-2021). Moreover, an in-depth survey over a 4-year period, characterized by extremely different meteorological conditions, was conducted to investigate the co-occurrence of regulated, masked, and emerging mycotoxins. The survey confirmed that Fusarium spp. was the most frequent fungi and fumonisins were the main mycotoxins that were constantly detected in the different years and areas. Moreover, the areas characterized by high fumonisin levels were also the most prone to contamination by emerging mycotoxins produced by the same Fusarium species of the Liseola section. On the other hand, as a result of climatic changes, maize grains have also been affected by the increased frequency of aflatoxin accumulation. Deoxynivalenol, zearalenone, and other emerging mycotoxins produced by the same Fusarium species as the Discolor section occurred more abundantly in some areas in Northern Italy and in years characterized by predisposing meteorological conditions., Competing Interests: The authors declare no conflict of interest.

Fumonisins are a group of closely related mycotoxins produced by Fusarium, Alternaria alternata and Aspergillus species. Their occurrence is correlated with various factors during growth, processing and storage. Fumonisins occurrence data in the literature mainly include the B group of fumonisins (FB1 & FB2) in raw materials, showing high frequency of positive samples in a wide range of concentrations. In this study, a total of 933 grains (63.7%) and poultry feed (36.3%) samples, collected in the 16-year period (2006-2021), were analysed with commercial enzyme-linked-immunosorbent assay for detection of three fumonisins (FB1, FB2 & FB3). All positive and suspect samples were confirmed with high-performance-liquid-chromatography method with fluorescence detection. Overall, we have determined high occurrence of FBs in grains and poultry feed in all tested years, while the lowest occurrence was determined in 2019, followed by 2009 and 2008. Although, contamination levels varied from year-to-year, majority of analyzed samples in all tested years were around 1 mg/kg, while the maximum values varied from 3 mg/kg to 22.23 mg/kg. This study highlights the importance of regular monitoring of raw materials and understanding of the fate of FBs in the food chain in order to avoid undesirable health effects in animals and accompanied economic losses.

The fungal ear rot of maize cultivated in temperate areas is mainly due to the Fusarium species. The use of insecticides against European Corn Borer (ECB) reduces the severity of fungal ear rot as well as the fumonisin (FB) and moniliformin (MON) levels in maize kernels at harvest, which in turn results in a lowering of their effect on deoxynivalenol (DON) control. However, the direct fungicidal control of ear rot has rarely been implemented for maize, and the first studies reported conflicting results on the reduction of mycotoxins. In the present experiment, field trials were carried out in North Italy over three growing seasons to study the effect of fungicide application timings on maize to control mycotoxins, considering the interaction of the application with the insecticide treatment, according to a full factorial split plot design. The mycotoxin content was determined through LC-MS/MS analysis. The field trials showed a significant reduction in ECB severity (75%), fungal ear rot severity (68%), Fusarium Liseola section infection (46%), FBs (75%) and MON (79%) as a result of the insecticide application for all the years, while the DON content increased by 60%. On the other hand, a fungicide application alone or applied in plots protected by an insecticide was never effective for the fungal symptoms, infection or mycotoxin content. The results confirm that a correct insecticide application to control ECB damage is the most effective agrochemical solution for the control of fungal ear rot, FBs and MON.

Maize and other cereals are the commodities most contaminated with fumonisins. The maize acreage is increasing in Africa, and the maize harvest provides important foods for humans and feeds for domestic animals throughout the continent. In North Africa, high levels of fumonisins have been reported from Algeria and Morocco, while low levels have been detected in the rather few fumonisin analyses reported from Tunisia and Egypt. The West African countries Burkina Faso, Cameroon, Ghana, and Nigeria all report high levels of fumonisin contamination of maize, while the few maize samples analysed in Togo contain low levels. In Eastern Africa, high levels of fumonisin contamination have been reported from the Democratic Republic of Congo, Ethiopia, Kenya, Tanzania, and Uganda. The samples analysed from Rwanda contained low levels of fumonisins. Analysis of maize from the Southern African countries Malawi, Namibia, South Africa, Zambia, and Zimbabwe revealed high fumonisin levels, while low levels of fumonisins were detected in the few analyses of maize from Botswana and Mozambique.

Silo-bags are hermetic storage systems that inhibit fungal growth because of their atmosphere with low humidity, as well as low pH and O 2 concentrations, and a high CO 2 concentration. If a silo-bag with stored maize loses its hermetic nature, it favors the development of fungi and the production of mycotoxins. To the best of our knowledge, this is the first review on the diversity of fungal species and mycotoxins that were reported in maize stored under the environmental conditions provided by silo-bags. The genera Penicillium, Aspergillus and Fusarium were found more frequently, whereas Acremonium spp., Alternaria sp., Candida sp., Cladosporium sp., Debaryomyces spp., Epiconum sp., Eupenicillium spp., Eurotium sp., Eurotium amstelodami, Hyphopichia spp., Hyphopichia burtonii, Moniliella sp., Wallemia sp. and genera within the orden Mucorales were reported less recurrently. Despite finding a great fungal diversity, all of the studies focused their investigations on a small group of toxins: fumonisins (FBs), aflatoxins (AFs), deoxynivalenol (DON), zearalenone (ZEA), patulin (PAT), toxin T2 (T2) and ochratoxin (OT). Of the FBs, fumonisin B 1 and fumonisin B 2 presented higher incidence percentages, followed by fumonisin B 3 . Of the AFs, the only one reported was aflatoxin B 1. The mycotoxins DON, ZEA and OT were found with lower incidences, whereas PAT and T2 were not detected. Good management practices of the silo-bags are necessary to achieve a hermetically sealed environment, without exchange of gases and water with the external environment during the storage period. © 2022 Society of Chemical Industry., (© 2022 Society of Chemical Industry.)

Mycotoxins are secondary metabolites of molds and mainly produced by species of the genera Aspergillus , Penicillium and Fusarium . They can be synthesized on the field, during harvest as well as during storage. They are fairly stable compounds and difficult to remove. Among several hundreds of mycotoxins, according to the WHO, ochratoxin A, aflatoxins, zearalenone, deoxynivalenol, patulin, fumonisins as well as T-2 and HT-2 toxins deserve special attention. Cytotoxicity is one of the most important adverse properties of mycotoxins and is generally assessed via the MTT assay, the neutral red assay, the LDH assay, the CCK-8 assay and the ATP test in different cell lines. The apoptotic cell ratio is mainly assessed via flow cytometry. Aside from the assessment of the toxicity of individual mycotoxins, it is important to determine the cytotoxicity of mycotoxin combinations. Such combinations often exhibit stronger cytotoxicity than individual mycotoxins. The cytotoxicity of different mycotoxins often depends on the cell line used in the experiment and is frequently time- and dose-dependent. A major drawback of assessing mycotoxin cytotoxicity in cell lines is the lack of interaction typical for complex organisms (for example, immune responses).

Fumonisins are mainly produced by Fusarium verticillioides and proliferatum , which causes a variety of toxicities in humans and animals, including fumonisin Bs (FBs) as the main form. After they are metabolized by plants or microorganisms, modified fumonisins are difficult to detect by conventional methods, which result in an underestimation of their contamination level. Fumonisins widely contaminate maize and maize products, especially in broiler feed. As an economically important food, broilers are often adversely affected by mycotoxins, leading to food safety hazards and high economic losses. However, there are few studies regarding the adverse effects of FBs on broiler growth and health, especially modified FBs. Our data shows that after exposure to FBs or hydrolyzed fumonisin Bs (HFBs), the body weight and tissue weight of broilers decreased significantly, especially the testes. Moreover, they significantly affect the intestinal microbiota and the relative abundance of bacteria from phylum-to-species levels, with the differentially affected bacteria mainly belonging to Firmicutes and Proteobacteria . Our findings suggest that both the parent and hydrolyzed FBs could induce growth retardation, tissue damage and the imbalance of intestinal microbiota in broilers. This indicated that the harmful effects of HFBs cannot be ignored during food safety risk assessment.

Fusarium proliferatum and Fusarium subglutinans are common pathogens of maize which are known to produce mycotoxins, including moniliformin (MON) and fumonisins (FBs). Fungal secondary metabolism and response to oxidative stress are interlaced, where hydrogen peroxide (H 2 O 2 ) plays a pivotal role in the modulation of mycotoxin production. The objective of this study is to examine the effect of H 2 O 2 -induced oxidative stress on fungal growth, as well as MON and FBs production, in different isolates of these fungi. When these isolates were cultured in the presence of 1, 2, 5, and 10 mM H 2 O 2 , the fungal biomass of F. subglutinans isolates showed a strong sensitivity to increasing oxidative conditions (27-58% reduction), whereas F. proliferatum isolates were not affected or even slightly improved (45% increase). H 2 O 2 treatment at the lower concentration of 1 mM caused an almost total disappearance of MON and a strong reduction of FBs content in the two fungal species and isolates tested. The catalase activity, surveyed due to its crucial role as an H 2 O 2 scavenger, showed no significant changes at 1 mM H 2 O 2 treatment, thus indicating a lack of correlation with MON and FB changes. H 2 O 2 treatment was also able to reduce MON and FB content in certified maize material, and the same behavior was observed in the presence and absence of these fungi, highlighting a direct effect of H 2 O 2 on the stability of these mycotoxins. Taken together, these data provide insights into the role of H 2 O 2 which, when increased under stress conditions, could affect the vegetative response and mycotoxin production (and degradation) of these fungi.

Fumonisin mycotoxins are a persistent challenge to human and livestock health in tropical and sub-tropical maize cropping systems, and more efficient methods are needed to reduce their presence in food systems. We constructed a novel, low-cost device for sorting grain, the "DropSort", and tested its effectiveness on both plastic kernel models and fumonisin-contaminated maize. Sorting plastic kernels of known size and shape enabled us to optimize the sorting performance of the DropSort. The device sorted maize into three distinct fractions as measured by bulk density and 100-kernel weight. The level of fumonisin was lower in the heaviest fractions of maize compared to the unsorted samples. Based on correlations among fumonisin and bulk characteristics of each fraction, we found that light fraction 100-kernel weight could be an inexpensive proxy for unsorted fumonisin concentration. Single kernel analysis revealed significant relationships among kernel fumonisin content and physical characteristics that could prove useful for future sorting efforts. The availability of a low-cost device (materials~USD 300) that can be used to reduce fumonisin in maize could improve food safety in resource-limited contexts in which fumonisin contamination remains a pressing challenge.

The levels of fumonisins (FUMO)-mycotoxins produced by Fusarium verticillioides- in maize for food and feed are subject to European Union regulations. Compliance with the regulations requires the targeting of, among others, the agroclimatic factors influencing fungal contamination and FUMO production. Arvalis-Institut du végétal has created a national, multiyear database for maize, based on field survey data collected since 2003. This database contains information about agricultural practices, climatic conditions and FUMO concentrations at harvest for 738 maize fields distributed throughout French maize-growing regions. A linear mixed model approach highlights the presence of borers and the use of a late variety, high temperatures in July and October, and a water deficit during the maize cycle as creating conditions favoring maize contamination with Fusarium verticillioides . It is thus possible to target a combination of risk factors, consisting of this climatic sequence associated with agricultural practices of interest. The effects of the various possible agroclimatic combinations can be compared, grouped and classified as promoting very low to high FUMO concentrations, possibly exceeding the regulatory threshold. These findings should facilitate the creation of a national, informative and easy-to-use prevention tool for producers and agricultural cooperatives to manage the sanitary quality of their harvest.

The actinobacteria Streptomyces sp. AV05 appears to be a potential biocontrol agent (BCA) against mycotoxigenic fungi. It was found to significantly inhibit F. verticillioides growth and mycotoxin production during their co-cultivation. F. verticillioides growth was durably affected while the decrease of the toxin production levels was reversible, suggesting different BCA actions. The study of both transcriptomes brought useful information on the microbial interaction. RNA-seq data indicated that the dual interaction modified genetic expression of both microorganisms as 18.5 % of the genes were differentially expressed for the fungus against 3.8 % for the actinobacteria. Fungal differentially expressed genes (DEGs) were equally up and down regulated while bacterial ones were mainly upregulated. We especially focused the analysis of DEGs on fungal defense reaction to bacterial attack. For example, if this potential BCA implements a strategy of antibiosis with the over expression of 'siderophore-interacting protein' linked to the production of bacteriocins, the fungus in a state of stress is able to adapt its metabolism by up-regulation of amidase. It could correspond to the induction of resistance gene clusters and suggest a detoxification process. Moreover fumonisins-related pathway appears underexpressed in the presence of Streptomyces that explain the reduction of fumonisin accumulation observed., Competing Interests: Declaration of Competing Interest The authors declare no conflict of interest., (Copyright © 2019 British Mycological Society. Published by Elsevier Ltd. All rights reserved.)

The aim of the current study was to investigate the entomopathogenic capacity of the mold Fusarium verticillioides and the effect of its mycotoxins fumonisins, on the grain beetle Sitophilus zeamais. We evaluated the capacity of this fungus to infect live insects, the antifungal activity of constituents of the insect's epicuticle, and the effect of a fumonisin extract on the fitness of the insects. We found that F. verticillioides could not penetrate the cuticle of S. zeamais and that the fumonisin extract had no negative effects on the fitness of the insects. However, the progeny of the insects increased, and the fumonisin extract had repellent effects. This is the first report about the effects of fumonisins on the relationship between F. verticillioides and S. zeamais, which may provide useful information about interactions between pathogenic microorganisms and insects, especially on stored product pests.

Fumonisins (FB1+FB2) and deoxynivalenol (DON) are mycotoxins produced by Fusarium species that might be present in maize and maize products. Knowledge on their occurrence in nixtamalized maize from Mexico together with an accompanying risk assessment are scarce, while nixtamalized maize is an important food in Mexico. This study presents the occurrence of FB1 + FB2 and DON in nixtamalized maize samples collected in Mexico City and analyses their distribution and resulting estimated daily intake for Mexican consumers by a probabilistic approach using a two-dimensional Monte-Carlo simulation. The results obtained reveal that for FB1 + FB2, 47% of the Mexican men and 30% of the Mexican women might exceed the provisional tolerable daily intake (PMTDI) of 2 µg/kg bw/day for fumonisins and for DON, 9% of men and 5% of women would be exceeding the PMTDI of 1 µg/kg bw/day, corresponding to the high consumers. The results raise a flag for risk managers in Mexico, to consider regulations and interventions that lower mycotoxin levels in nixtamalized maize for human consumption.

This paper demonstrates the development of an analytical method based on CE coupled to ESI-MS for the identification and quantification of fumonisin mycotoxins. Separation and detection parameters (pH of background electrolyte (BGE), organic modifier content, sheath liquid (SL) composition, MS mode and nebuliser pressure) were optimised. Ammonium formate/ammonia (pH = 9.5) with 10% ACN modifier was found the most suitable BGE. Positive mode MS was used for detection by scanning the m/z range of 400-1200. Separation was highly affected by the nebuliser pressure, a 25% improvement in peak resolution was achieved by applying the optimised parameters. The 'dilute and shoot' approach was applied to overcome disturbing effects caused by the matrix of fungi supernatant samples. The available sample volume affected the reproducibility of the measurements greatly: the scattering of peak intensities were between 4 and 11 RSD% instead of 27-195 RSD% for fumonisin B 1 and fumonisin B 2 when the available volume was ~200 µL instead of ~20 µL. Quantitative determinations were carried out in Fusarium verticillioides and Fusarium proliferatum culture supernatant (raw) and mycelium (cleaned up) samples. The optimised method enabled the detection of 11 fumonisins in Fusarium proliferatum inoculated rice samples; 2 of them were quantified based on external calibration and 4 other compounds with fumonisin-like formulas were detected.

Fusarium subglutinans and Fusarium temperatum are common maize pathogens that produce mycotoxins and cause plant disease. The ability of these species to produce beauvericin and fumonisin mycotoxins is not settled, as reports of toxin production are not concordant. Our objective was to clarify this situation by determining both the chemotypes and genotypes for strains from both species. We analyzed 25 strains from Argentina, 13 F. subglutinans and 12 F. temperatum strains, for toxin production by ultraperformance liquid chromatography mass spectrometry (UPLC-MS). We used new genome sequences from two strains of F. subglutinans and one strain of F. temperatum , plus genomes of other Fusarium species, to determine the presence of functional gene clusters for the synthesis of these toxins. None of the strains examined from either species produced fumonisins. These strains also lack Fum biosynthetic genes but retain homologs of some genes that flank the Fum cluster in Fusarium verticillioides None of the F. subglutinans strains we examined produced beauvericin although 9 of 12 F. temperatum strains did. A complete beauvericin ( Bea ) gene cluster was present in all three new genome sequences. The Bea1 gene was presumably functional in F. temperatum but was not functional in F. subglutinans due to a large insertion and multiple mutations that resulted in premature stop codons. The accumulation of only a few mutations expected to disrupt Bea1 suggests that the process of its inactivation is relatively recent. Thus, none of the strains of F. subglutinans or F. temperatum we examined produce fumonisins, and the strains of F. subglutinans examined also cannot produce beauvericin. Variation in the ability of strains of F. temperatum to produce beauvericin requires further study and could reflect the recent shared ancestry of these two species. IMPORTANCE Fusarium subglutinans and F. temperatum are sister species and maize pathogens commonly isolated worldwide that can produce several mycotoxins and cause seedling disease, stalk rot, and ear rot. The ability of these species to produce beauvericin and fumonisin mycotoxins is not settled, as reports of toxin production are not concordant at the species level. Our results are consistent with previous reports that strains of F. subglutinans produce neither fumonisins nor beauvericin. The status of toxin production by F. temperatum needs further work. Our strains of F. temperatum did not produce fumonisins, while some strains produced beauvericin and others did not. These results enable more accurate risk assessments of potential mycotoxin contamination if strains of these species are present. The nature of the genetic inactivation of BEA1 is consistent with its relatively recent occurrence and the close phylogenetic relationship of the two sister species., (Copyright © 2020 Fumero et al.)

The pink ear rot is one of the most damaging maize diseases, caused by the mycotoxigenic fungal pathogen, Fusarium verticillioides. The application of biological control agents, like antagonistic and/or resistance inducer microorganisms, is an option to reduce fungal infection and kernel contamination in a sustainable and environmentally friendly way. It is well known that Trichoderma species are non-pathogenic fungi able to antagonize plant pathogens and to induce systemic resistance in plants. The present work aimed to verify if Trichoderma spp., applied to maize kernels, affect the plant growth and induce systemic responses to F. verticillioides. Besides, the capability to reduce fumonisin concentration in liquid cultures was investigated. Two T. gamsii (IMO5 and B21), and one T. afroharzianum (B75) isolates, selected both for antagonism and for the ability to reduce root infections, significantly reduced the endophytic development of the stem-inoculated pathogen, compared to the control. The mechanisms of action appeared to be strain-specific, with IMO5 enhancing transcript levels of marker genes of Induced Systemic Resistance (ZmLOX10, ZmAOS, and ZmHPL) while B21 enhancing marker genes of Systemic Acquired Resistance (ZmPR1 and ZmPR5), as evinced by measuring their expression profiles in the leaves. Moreover, IMO5 promoted plant growth, while B21 was able to significantly reduce the fumonisin content in a liquid medium. The results of this work give new evidence that the seed application of T. gamsii is a promising tool for controlling F. verticillioides to be integrated with breeding and the adoption of good agricultural practices., (Copyright © 2019 Elsevier GmbH. All rights reserved.)

Cereal grains are essential ingredient in food, feed and industrial processing. One of the major causes of cereal spoilage and mycotoxin contamination is the presence of toxigenic Fusarium spp. Nanoparticles have immense applications in agriculture, nutrition, medicine or health but their possible impact on the management of toxigenic fungi and mycotoxins have been very little explored. In this report, the potential of silver nanoparticles (AgNPs) (size 14-100 nm) against the major toxigenic Fusarium spp. affecting crops and their effect on mycotoxin accumulation is evaluated for the first time. The studied Fusarium spp. (and associated mycotoxins) were F. graminearum and F. culmorum (deoxynivalenol, 3-acetyldeoxynivalenol and zearalenone), F. sporotrichioides and F. langsethiae (T-2 and HT-2 toxins), F. poae (nivalenol), F. verticillioides and F. proliferatum (fumonisins B 1 and B 2 ) and F. oxysporum (mycotoxins no detected). The factors fungal species, AgNP dose (range 2-45 μg/mL), exposure time (range 2-30 h) and their interactions significantly influence spore viability, lag period and growth rate (GR) in subsequent cultures in maize-based medium (MBM) of all the studied species. The effective lethal doses (ED 50 , ED 90 and ED 100 ) to control spore viability and GR were in the range 1->45 μg/mL depending on the remaining factors. At high exposure times (20-30 h), the three effective doses ranged 1-30 μg/mL for all the studied species. At the end of the incubation period (10 days) mycotoxin levels in MBM cultures inoculated with fungal spores from treatments were strongly related with the size reached by the colony at that time. None of the treatments produced stimulation in conidia germination, GR or mycotoxin biosynthesis with respect to controls. Thus, the antifungal effect of the assayed AgNPs against the tested Fusarium spp. suggests that AgNPs could be a new antifungal ingredient in bioactive polymers (paints, films or coating) likely to be implemented in the agro-food sector for controlling these important toxigenic Fusarium spp. and their main associated mycotoxins., (Copyright © 2019 Elsevier B.V. All rights reserved.)

Fusarium diseases, including corn root rot, sheath rot, stalk rot, and ear rot are frequently occurring in maize producing areas of China. Fusarium stalk rot and ear rot are the most serious diseases and often occur at the same time, but it is unclear whether there is a correlation between Fusarium composition and disease occurrence. This study was conducted to clarify the relationship between the two diseases. A total of 49 corn stalk rot samples were collected from 15 regions of eight provinces in China from 2016 to 2018. The pathogens were isolated and identified separately from stalks, ear stems, and kernels. The contents of the fumonisins (FB 1 and FB 2 ) were detected in kernels. The results showed that the main Fusarium species were found in corn kernels, ear stems and stalks at the same time. The results showed that 1201 strains of Fusarium verticillioides , 668 strains of Fusarium oxysporum , 574 strains of Fusarium graminearum species complex (FGSC), 318 strains of Fusarium equiseti , 95 strains of Fusarium proliferatum , and 40 strains of Fusarium subglutinans were isolated from 1470 corn kernels, 245 ear stems, and 1225 stalks randomly selected from 49 samples. The contamination rate of fumonisins in the 49 samples was 57.1% with an average content of 1.9 μg/g, of which four samples exhibited higher levels as set by the European Commission (4.0 μg/g). These results provide a certain association between stalk rot and ear rot and lay a foundation to study the relationships among Fusarium maize diseases.

Brown marmorated stink bug ( Halyomorpha halys Stål) is an invasive agricultural pest that causes severe damage to many crops. To determine potential associations between H. halys feeding damage, Fusarium infection, and mycotoxin contamination in field corn, a field survey was conducted in eight counties in Virginia. Results indicated an association between H. halys feeding damage and fumonisin contamination. Subsequent field experiments in Delaware, Maryland, and Virginia examined the ability of H. halys to increase Fusarium verticillioides (Sacc.) Nirenberg infection and fumonisin concentrations in corn. At the milk stage, H. halys (0 or 4 adults) and Fusarium (with or without F. verticillioides inoculum) treatments were applied to bagged ears in a two by two factorial randomized complete block design with 12 replicates. H. halys treatments increased levels of feeding damage ( P < 0.0001) and Fusarium infection ( P = 0.0380). Interaction between H. halys and Fusarium treatments influenced severity of infection ( P = 0.0018) and fumonisin concentrations ( P = 0.0360). Results suggest H. halys has the ability to increase both Fusarium infection and fumonisin concentrations in field corn. Further studies are needed to understand mechanisms by which H. halys increases fumonisin and to develop management strategies to mitigate impacts of H. halys on field corn in the region.

Maize (Zea mays), sorghum (Sorghum bicolor) and pearl millet (Pennisetum glaucum) are basic staple foods for many rural or poorer communities. These crops are susceptible to plant diseases caused by multiple species of Fusarium, some of which also produce mycotoxins, including fumonisins and moniliformin that are detrimental to both humans and domesticated animals. Eighteen potentially toxigenic Fusarium strains were isolated from maize (n = 10), sorghum (n = 7) and pearl millet (n = 1) growing in the same field in Nigeria. The 17 strains from maize and sorghum were all F. proliferatum and the one strain from pearl millet was F. pseudonygamai. Under conducive conditions, the 17 F. proliferatum strains produced fumonisins, 11 in relatively large quantities (700-17,000 mg total fumonisins, i.e., FB 1  + FB 2  + FB 3 /kg culture material), and six at <45 mg/kg. Ten F. proliferatum strains produced >100 mg of moniliformin per kg culture material with a maximum of 8900 mg/kg culture material. All strains could use all grains for growth and toxin production, regardless of the host from which they were isolated. Isolates varied in the amount of toxin produced on each substrate, with toxin production a property of the strain and not the host from which the strain was recovered. However, the extent to which a toxin-producing phenotype could be altered by the grain on which the fungus was grown is consistent with subtle genetic × environment interactions that require a larger data set than the one presented here to rigorously identify. In conclusion, there is significant variation in the ability of strains of F. proliferatum to produce fumonisins and moniliformin on maize, sorghum and millet. If the amount of toxin produced on the various grains in this study reflects real-world settings, e.g., poor storage, then the consumers of these contaminated grains could be exposed to mycotoxin levels that greatly exceed the tolerable daily intakes., (Copyright © 2019 Elsevier B.V. All rights reserved.)

Fumonisins are mycotoxins (MTs) produced mainly by the fungus Fusarium verticillioides , the main pathogens of maize which cause ear rot. The aim of this work was to evaluate some factors that may lead to high fumonisin production by F. verticillioides in maize grains, correlating the pathogen inoculation method with different genotypes grown in four Brazilian states. Experiments were conducted in 2015-2016 in maize crops from experimental maize fields located in four distinct states of Brazil. Results showed that contamination by fumonisin mycotoxins occurred even on symptomatic or asymptomatic grains. In all municipalities, the samples showed levels of fumonisin B1 that were higher than would be tolerable for the human consumption of corn products (the current tolerance limit for fumonisin is 1.5 μg g -1 ). High severity of grains infected with F. verticillioides does not always show high concentrations of fumonisins. Environments with higher temperatures may influence the production of high concentrations of fumonisin in maize hybrids. Spray inoculation methods and inoculation at the center of spikes did not influence fumonisin concentrations. Results showed that the hybrids P3630H, P32R48 and P3250 presented higher disease severity, as well as higher mycotoxin levels in the studied locations with higher temperatures.

Fusarium temperatum is an emerging maize pathogen that causes maize ear and stalk rot diseases and produces various mycotoxins including moniliformin, beauvericin, enniatins and fumonisin B1, which poses a potential risk to the human food or animal feed supply chains. Early detection of F. temperatum is crucial to prevent its derived mycotoxins from entering the food chain, and is also a useful tool in disease management practices. Here, we describe a loop-mediated isothermal amplification (LAMP) assay for rapid diagnosis of F. temperatum. The 28S ribosomal DNA sequences (28S rDNA) of F. temperatum were used to design a set of six primers. The reaction conditions were optimized for developing a fast assay with high specificity and sensitivity, and were able to detect the presence of less than 10 pg of target DNA per reaction within 60 min. Furthermore, the resulting amplicons were visualized by adding SYBR Green I to the reaction tubes. Suspected F. temperatum infected maize stalk samples collected from Yunnan province, China were identified using the developed LAMP assay. In conclusion, the method not only provides a rapid and specific screening for the existence of F. temperatum in a bulk of maize samples without using sophisticated equipment, but also is potentially useful for other agriculturally important toxigenic fungi., (Copyright © 2018 Elsevier B.V. All rights reserved.)

The influence of processing methods used to produce traditional Nigerian infant foods (ogi and processed soybean powder) on four European Union regulated Fusarium mycotoxins using naturally and artificially contaminated raw materials was studied using liquid chromatography-tandem mass spectrometry. Generally, there was a significant reduction of all the mycotoxins when compared to the initial concentration of the raw materials. Reduction in concentrations of the mycotoxins during ogi-processing started immediately after 36 h' steeping/fermentation for all the mycotoxins (fumonisin B 1 , zearalenone, deoxynivalenol, and T-2 toxin), and proceeded along the process chain (milling and sieving). In addition, deoxynivalenol-3-glucoside (16 ± 3.2 μg/kg) and 3-acetyl-deoxynivalenol (9 ± 5.5 μg/kg) initially absent in the raw maize were detected in the final ogi product. β-zearalenol, hydrolysed fumonisin B 1 , and HT-2 toxin were also detected at varying concentrations. Regarding soybean processing, a similar trend was observed with fumonisin B 1 , zearalenone, deoxynivalenol, and T-2 toxin, irrespective of the method used or the initial concentration. Other mycotoxins detected in soybean product include 3-acetyl-deoxynivalenol, 15-acetyl-deoxynivalenol, deoxynivalenol-3-glucoside, HT-2 toxin, neosolaniol, α-zearalenol, β-zearalenol, and zearalenone-14-glucoside. Although there was a reduction in the concentration of the free mycotoxin because of processing, other mycotoxins were detected in the products and thus, may present an additional health risk on consumers., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

Fumonisins are a group of toxic secondary metabolites that are produced by Fusarium verticillioides which are associated with poultry health hazard and great economic losses. The objective of the present study was to develop an immunological method to detect F. verticillioides in poultry feed samples. An indirect competitive enzyme-linked immunosorbent assay (ic-ELISA) based on a polyclonal antibody against 67 kDa protein of the F. verticillioides 97K exoantigen was developed to detect this fungus. Antibody anti-67 kDa protein showed cross-reactivity against F. graminearum (2⁻7%) and F. sporotrichioides (10%), but no or low cross-reactivity against Aspergillus sp. and Penicillium sp. exoantigens. The detection limit for the 67 kDa protein of F. verticillioides was 29 ng/mL. Eighty-one poultry feed samples were analyzed for Fusarium sp. count, 67 kDa protein of F. verticillioides and fumonisin concentrations. Eighty of the 81 feed samples (98.6%) showed Fusarium sp. contamination (mean 6.2 x 10⁴ CFU/g). Mean 67 kDa protein and fumonisin concentration in the poultry feed samples was 21.0 µg/g and 1.02 µg/g, respectively. The concentration of 67 kDa protein, as determined by ic-ELISA correlated positively (p < 0.05) with fumonisin levels (r = 0.76). These results suggest that this ic-ELISA has potential to detect F. verticillioides and predict fumonisin contamination in poultry feed samples.

Background: Systemic infection through the seed is one of the routes used by the mycotoxinogenic pathogen Fusarium verticillioides for colonizing maize plants. The prohibition of the use of most chemical fungicides by the EU has promoted research on plant resistance inducers as an effective and sustainable alternative. Induction of a priming state in maize seeds might affect their susceptibility to contamination and accumulation of fumonisins. This state by application of a natural fertilizer called Chamae on maize seeds, was investigated in two varieties to control the colonization by the fungus and the accumulation of fumonisins B 1 , B 2 and B 3 , germinating seeds, dead plants and yield., Results: After inoculation of F. verticillioides on germinating seeds, the colonization by the fungus and the accumulation of fumonisins were significantly lower in seedlings coming from treated seeds, but a significant number of plants stopped their development by necrosis. In a field trial, the 0.01% (v/v) application dilution showed a lower plant density, although the level of biomass at harvest was not affected., Conclusion: The priming state contributed to the control of F. verticillioides development from seed infection and fumonisin accumulation in the early stage of plant growth, without affecting the final crop yield, and could reduce fungicide use and environmental contamination. © 2018 Society of Chemical Industry., (© 2018 Society of Chemical Industry.)

The fungus Fusarium verticillioides can infect maize ears, contaminating the grain with mycotoxins, including fumonisins. This global public health threat can be managed by breeding maize varieties that are resistant to colonization by F. verticillioides and by sorting grain after harvest to reduce fumonisin levels in food systems. Here, we employed two F. verticillioides inoculation techniques representing distinct infection pathways to dissect ear symptomatology and morphological resistance mechanisms in a diverse panel of maize inbred lines. The "point" method involved penetrating the ear with a spore-coated toothpick and the "inundative" method introduced a liquid spore suspension under the husk of the ear. We evaluated quantitative and qualitative indicators of external and internal symptom severity as low-cost proxies for fumonisin contamination, and found that kernel bulk density was predictive of fumonisin levels (78 to 84% sensitivity; 97 to 99% specificity). Inundative inoculation resulted in greater disease severity and fumonisin contamination than point inoculation. We also found that the two inoculation methods implicated different ear tissues in defense, with cob morphology being a more important component of resistance under point inoculation. Across both inoculation methods, traits related to cob size were positively associated with disease severity and fumonisin content. Our work demonstrates that (i) the use of diverse modes of inoculation is necessary for combining complementary mechanisms of genetic resistance, (ii) kernel bulk density can be used effectively as a proxy for fumonisin levels, and (iii) trade-offs may exist between yield potential and resistance to fumonisin contamination.

Mycotoxins are secondary metabolites of fungi that are damaging to both animals and humans. Extensive contamination of foods and feeds with mycotoxins is an important problem. Fumonisins, trichothecenes, zearalenone, and aflatoxins are mycotoxins produced by Fusarium species and occur naturally in sugarcane and cereal-based foods, threatening health and food security worldwide. Their distribution in the contaminated material is of great interest for obtaining insight into infection mechanisms and the potential for reducing contamination during food processing. In this study, mycotoxins were evaluated by high-performance liquid chromatography, liquid chromatography-electrospray ionization-tandem mass spectrometry (LC-ESI-MS/MS), and matrix-assisted laser/desorption ionization time of flight mass spectrometry (MALDI-TOF MS) of Fusarium species-infected sugarcane materials. A simple, sensitive, and reliable analytical method was developed for rapidly detecting eight mycotoxins in Fusarium species: fumonisin B1 and fumonisin B2, B-trichothecene mix (deoxynivalenol, nivalenol, 3-acetyl- deoxynivalenol, 15-acetyl-deoxynivalenol), zearalenone, and aflatoxin G1. Analyses were carried out in multiple reaction monitoring mode using the two primary product ions. The results generated by LC/MS and MALDI-TOF MS/MS revealed various mechanisms regulating mycotoxins production, which may help to clarify the roles of sensitive and selective compounds. The results demonstrate that this procedure is suitable for simultaneous determination of mycotoxins in sugarcane and can be performed in routine analysis in mycotoxin laboratories., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

This paper presents data on the occurrence of Fusarium toxins - zearalenone (ZEA), deoxynivalenol (DON) and fumonisins (FUMs) B1 and B2 - in corn flours and corn flakes marketed in Serbia. A total of 71 samples were collected over 2013-2016 and analysed using HPLC with UV or fluorescence detection. In the case of corn flours, none of the samples taken in 2013 exhibited the presence of ZEA or DON, whereas 90% were positive for FUMs. In 2015, occurrence was very high: ZEA 93%, DON 86% and FUMs 100% (mean 43.3, 322.6 and 323.0 μg kg -1 , respectively), with 21% of the samples exceeding the maximum level for ZEA and 7% for DON and FUMs. In 2016, a lower occurrence was recorded in the case of ZEA (75%) and DON (38%), with drastically lower mean contamination levels (six- and 10-fold, respectively), while FUMs stayed at 97%, with twofold lower mean. The maximum level was exceeded only for ZEA (3%). The frequency of ZEA-DON-FB1 co-occurrence was 86% in 2015 and 25% in 2016. Regarding corn flakes, occurrence summarised for the study period was 87% ZEA, 73% FUMs and 40% DON. One sample (7%) exceeded the maximum levels for both ZEA and DON. Observed occurrence changes were in agreement with the climatic conditions during corn growing seasons preceding the market release of the processed products.

Fungicides and, for the first time, microalgal phenolic extracts (MPE) from Spirulina sp. and Nannochloropsis sp. were applied on maize culture media under field conditions to evaluate their ability to minimize Fusarium species development and fumonisin production. An in vitro assay against F. verticillioides was carried out using maize grains as the culture medium. An open-field experiment was carried out in Northwest Italy under natural infection conditions. The compared treatments were factorial combinations of two insecticide treatments (an untreated control and pyrethroid, used against European Corn Borer), four antifungal treatments (an untreated control, MPE from Spirulina sp., MPE from Nannochloropsis sp., and a synthetic fungicide), and two timings of the application of the antifungal compounds (at maize flowering and at the milk stage). The MPE compounds were capable of inhibiting fumonisin production in vitro more efficiently than tebuconazole. Insecticide application reduced the infection by Fusarium species and subsequent fumonisin contamination. However, fumonisins in maize fields were not significantly controlled by either fungicide or MPE application.

To assess the risk of fumonisin contamination in Korean cereals, we isolated colonies of the Fusarium fujikuroi species complex (FFSC) from barley, maize, rice and soybean samples from 2011 to 2015. A total of 878 FFSC strains were isolated mostly from maize and rice, and species identity of the isolates were determined using the DNA sequence of the translation elongation factor 1-α (TEF-1α) and RNA polymerase II (RPB2) genes. Fusaria recovered from Korean cereals included F. fujikuroi (317 isolates and a frequency of 36%), F. proliferatum (212 isolates and 24.1%), F. verticillioides (170 isolates and 19.4%), F. concentricum (86 strains and 9.8%), F. andiyazi (56 isolates and 6.4%), F. subglutinans (28 isolates and 3.2%), F. thapsinum (5 isolates and 0.6%), and F. circinatum (2 isolates and 0.2%). The rice samples were dominated by F. fujikuroi (47.4%), F. proliferatum (27.3%), and F. concentricum (15.1%), whereas maize samples were dominated by F. verticillioides (33.9%), F. fujikuroi (25.3%), and F. proliferatum (21.1%). A phylogenetic analysis of 70 representative isolates demonstrated that each species was resolved as genealogically exclusive in the ML tree. Fumonisin production potential was evaluated using a PCR assay for the fumonisin biosynthesis gene, FUM1 in all of the isolates. Most of the isolates tested (94%) were positive for FUM1. All of the isolates assigned to F. fujikuroi, F. proliferatum, F. verticillioides and F. thapsinum were positive for FUM1 irrespective of their host origin. Seventy-seven representative isolates positive for FUM1 were examined for fumonisin production in rice medium. The majority of F. proliferatum (26/27, 96.3%), F. verticillioides (16/17, 94.1%) and F. fujikuroi (19/25, 76.0%) produced both FB 1 and FB 2 . Notably, 16 of 19 fumonisin-producing F. fujikuroi produced >1000μg/g of fumonisins (FB 1 +FB 2 ) in rice medium, which is higher than that in previous reports. These results suggest that F. fujikuroi can produce high levels of fumonisins similar to F. verticillioides and F. proliferatum., (Copyright © 2017 Elsevier B.V. All rights reserved.)

Fusarium verticillioides is the most common fungal pathogen associated with maize ear rot in Tanzania. In a two-year trial, we investigated the efficacy of crop protection (insecticide and/or fungicide) and fertilizer (nitrogen and/or phosphorus) treatments in reducing the occurrence of F. verticillioides and its mycotoxins in maize grown in Tanzania. Seasonal differences were seen to have a substantial influence on the incidence and severity of insect infestation, Fusarium ear and kernel rot, biomass of F. verticillioides and contamination with fumonisins. With regard to the application of fertilizers, it was concluded that the impact on maize stalk borer injury, Fusarium symptoms and fumonisin levels was not significant, whereas crop protection significantly reduced maize damage. The application of an insecticide was most effective in reducing insect injury and as a result of the reduced insect injury the insecticide treatment also resulted in a significant decrease in Fusarium symptoms. In 2014, fumonisin levels were also significantly lower in maize treated with an insecticide. Additionally, significant positive correlations between insect damage and Fusarium symptoms were observed. In conclusion, this study clearly shows that application of an insecticide alone or in combination with a fungicide at anthesis significantly reduces insect damage and consequently reduces F. verticillioides infection and associated fumonisin contamination., Competing Interests: The authors declare no conflict of interest.

Fusarium verticillioides is one of the main pathogens of maize, causing ear and stalk rots. This fungus is also able to produce high levels of fumonisins, which have been linked to various illnesses in humans and animals. Previous studies have shown that maize hybrids genetically modified with the cry genes from the bacterium Bacillus thuringiensis (Bt) presented lower incidence of F. verticillioides and fumonisin levels, presumably through the reduction of insects, which could act as vectors of fungi. The aim of this study was to assess the incidence of F. verticillioides and the concentration of fumonisins in Bt and isogenic non-Bt hybrids (2B710Hx, 30F35YG, 2B710, and 30F35, respectively). The samples of 2B710Hx and 30F35YG presented lower F. verticillioides frequency than 2B710 and 30F35 samples. However, there was no statistical difference between fumonisin contamination when Bt and non-Bt samples were compared (P > 0.05). The results suggest that other environmental parameters could possibly trigger fumonisin production during plant development in the field; consequently, other management strategies should be applied to aid controlling fumonisin contamination in maize.

Maize is most often infected by the fumonisin-producing Fusarium verticillioides. Total fumonisins of natural infected grain is made up of FB 1 , FB 2 and FB 3 with FB 1 occurring naturally at higher levels. A maize plant can be infected with more than one F. verticillioides isolate, and finding a reliable method to elucidate the toxigenic potential of these isolates is important to extrapolate the possible fumonisin risk to consumers of grain. It is not clear whether F. verticillioides produces similar fumonisin levels, as well as fumonisin analogue ratios, across media. In this study, nine F. verticillioides isolates were subjected to three methods of fumonisin testing using liquid media, maize patties and a field trial (silk inoculation of grain) in Potchefstroom, South Africa. Spore concentrations of 1 × 10 6 conidia ml - 1 of each isolate were used to inoculate the different media and levels fumonisin analogues were measured using HPLC. Fumonisin production per isolate was highly variable and was influenced by the two-way interaction of F. verticillioides isolate × growth media. Total fumonisins produced in the liquid medium ranged from 0 to 21.3 ppm, on maize patties fumonisins they ranged from 0 to 21.5 ppm, and in the silk inoculation technique they ranged from 0 to 15.5 ppm. The fumonisin analogue FB 1 occurred at higher levels followed by FB 3 in both in vitro studies. In the silk inoculation technique, fumonisin analogue FB 2 was the second highest occurring analogue after FB 1 . Isolate GCI 282 produced higher FB 2 and FB 3 levels than FB 1 in the patties and grain, respectively. In order not to miscalculate the fumonisin and analogue ratio levels per F. verticillioides isolate, the growth medium will have to be optimised for each isolate and more than one growth medium used.

Natural contamination of sorghum grains by aflatoxin B 1 and total fumonisin and their producing toxigenic fungi has been studied. A total of 90 sorghum grain samples were collected from small-scale farmers' threshing floors and 5-6 months later from underground pits during 2013 harvest from three districts of East Hararghe, Ethiopia. Mycotoxin analysis was done using enzyme-linked immunosorbent assay (ELISA). The limits of detection were in the range 0.01-0.03 μg kg -1 . The results revealed that all sorghum grain samples were contaminated with both Aspergillus and Fusarium species. Aflatoxin B 1 was detected at levels ranging from -1 grain. There were marked variations in aflatoxin B 1 concentrations between fresh and stored samples, with much higher levels in the latter. Total fumonisin levels varied between 907 and 2041 µg kg -1 grain across the samples. Lowest total fumonisin was recorded in freshly harvested sorghum grain samples. Sorghum is a main staple cereal in the studied districts and its consumption per day per person is high. Daily intake of low doses of mycotoxin-contaminated food stuff over a period of time could lead to chronic mycotoxicosis.