Search

This study aimed to evaluate the effects of exogenous epiphytic microbiota inoculation on the fermentation quality and microbial community of sudan grass silage. Gamma irradiated sudan grass was ensiled with distilled water (STR), epiphytic microbiota of sudan grass (SUDm), forage sorghum (FSm), napier grass (NAPm) and whole crop corn (WCCm). The FSm inoculated silage have significantly lower lactic acid (LA) concentration and higher pH during early ensiling, while LA concentration gradually and significantly increased with the progression of ensiling and have lower pH in relation to other treatments for terminal silage. Inoculation of NAPm resulted in lower LA and higher acetic acid (AA) concentrations, higher pH, ammonia-N and dry matter losses for terminal silage, followed by SUDm silage. Inoculations of WCCm significantly increased LA production and pH decline during early ensiling and have higher LA and pH then NAPm and SUDm silages during final ensiling. The early fermentation of SUDm silage was dominated by genus of Pediococcus. The genera of Lactobacillus were predominant in WCCm and NAPm silages during 3 days of ensiling, while Weissella dominated initial microbial community of FS silage. The terminal silage of NAPm was dominated by Enterobacter and Rosenbergiella, while Enterobacter and Lactobacillus dominated terminal SUDm silage. The final silage of FSm was dominated by Lactobacillus, Weissella and Pediococcus, while Lactobacillus and Acetobacter dominated terminal WCCm silages. The results demonstrated that among the four forages the epiphytic microbiota from forage sorghum positively influenced the microbial community and fermentability of sudan grass silage.

A kinetic model of acetone-butanol-ethanol (ABE) fermentation taking into account butyric acid effects was developed and implemented in COPASI. The model was validated by comparing the simulation results with experimental data in batch cultures of Clostridium saccharoperbutylacetonicum under various concentrations of initial glucose (97.1 to 152.6 mM) and butyric acid (90.7 to 153.2 mM). The modeling results suggested that increasing the conversion rates from butyryl-CoA (BCoA) to butanol, from butyrate to BCoA, or from pyruvate to lactate would increase butanol synthesis. Similarly, reducing glucose uptake rate or the reaction rates from pyruvate to acetyl CoA (ACoA), from acetoacetyl CoA (AACoA) to BCoA, or from BCoA to butyrate would improve butanol production. Overall, the kinetic model developed can accurately predict the dynamic behavior of metabolites in ABE fermentation with butyric acid addition, which may subsequently be used to identify genetic manipulation strategies for higher bio-butanol production., (Copyright © 2019 Elsevier B.V. All rights reserved.)

Butyrate is known to play a significant role in energy metabolism and regulating genomic activities that influence rumen nutrition utilization and function. Thus, this study investigated the effects of an isolated butyrate-producing bacteria, Clostridium saccharobutylicum , in rumen butyrate production, fermentation parameters and microbial population in Holstein-Friesian cow. An isolated butyrate-producing bacterium from the ruminal fluid of a Holstein-Friesian cow was identified and characterized as Clostridium saccharobutylicum RNAL841125 using 16S rRNA gene sequencing and phylogenetic analyses. The bacterium was evaluated on its effects as supplement on in vitro rumen fermentation and microbial population. Supplementation with 10 6 CFU/ml Clostridium saccharobutylicum increased ( p < 0.05) microbial crude protein, butyrate and total volatile fatty acids concentration but had no significant effect on NH3-N at 24 h incubation. Butyrate and total VFA concentrations were higher ( p < 0.05) in supplementation with 10 6 CFU/ml Clostridium saccharobutylicum compared with control, with no differences observed for total gas production, NH 3 -N and propionate concentration. However, as the inclusion rate (CFU/ml) of C. saccharobutylicum was increased, reduction of rumen fermentation values was observed. Furthermore, butyrate-producing bacteria and Fibrobacter succinogenes population in the rumen increased in response with supplementation of C. saccharobutylicum , while no differences in the population in total bacteria, protozoa and fungi were observed among treatments. Overall, our study suggests that supplementation with 10 6 CFU/ml C. saccharobutylicum has the potential to improve ruminal fermentation through increased concentrations of butyrate and total volatile fatty acid, and enhanced population of butyrate-producing bacteria and cellulolytic bacteria F. succinogenes .

Butyrate and its derivates pertain to the key aroma contributors of strong-flavour baijiu, a kind of Chinese liquors, that is produced from grains by solid-state multispecies anaerobic fermentation in a mud cellar. Microbes inhabiting in the fermentation pit mud largely determines baijiu's flavour and quality. In order to shed light on the microbial functional groups driving butyrate production in pit mud, clone library analysis was firstly performed and the results demonstrated that Clostridia (relative abundance: 50%) and Bacilli (37%) were major groups possessing butyrate kinase (buk) pathway and Clostridia (98%) dominated butyryl-CoA:acetate CoA-transferase (but) pathway. According to Clostridial specific-16S rRNA gene sequencing analysis, we found the resilience character of Clostridial community in pit mud. Amongst Clostridial groups, 32.0% of the sequences were grouped into Clostridiales incertae sedis, followed by Heliobacteriaceae (18.3%) and Clostridiaceae 1 (8.4%). Moreover, Hydrogenispora, Sedimentibacter and Clostridium were the top three abundant genera. Relative abundance of Hydrogenispora was higher in the late days of fermentation, while Sedimentibacter exhibited higher proportion in the early days. Different from the previous studies using universal bacterial primer sets, Hydrogenispora was first reported as one dominant genus in pit mud. As for the reported potential butyrate producer Clostridium, nineteen species were obtained and ten of them were first isolated from the pit mud. Amongst them, buk was identified in eleven species by PCR analysis, while but was identified in the other seven, indicating the species-specific butyrate synthesis pathways of Clostridium. This study provides a perspective on targeting and isolating specific functional microbes in baijiu microbiota with the gene sequence-based medium prediction method., (Copyright © 2019 Elsevier B.V. All rights reserved.)

A three-chamber electrodialysis bioreactor comprising fermentation, cathode and anode chambers was proposed to remove in situ volatile fatty acids during hydrogen fermentation. The electrodialysis voltage of 4 V resulted in a volumetric hydrogen productivity of 1878.0 mL/L from the fermentation chamber, which is 55.4% higher than that (1208.5 mL/L) of the control group without voltage applied. Gas production was not observed in the cathode and anode chambers throughout fermentation. By applying different voltages (0-6 V), the hydrogen content accumulated to 54.6%-84.7%, and it exhibited increases of 7.1%-66.4% compared with that of the control. Meanwhile, the maximum concentrations of acetate and butyrate in the fermentation chamber decreased to 10.3 and 13.1 mmol/L at a voltage of 4 V, respectively, which are 68.0% and 62.4% lower than that for the control., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

Butyric acid is an important platform chemical, which is widely used in the fields of food, pharmaceutical, energy, etc. Microbial fermentation as an alternative approach for butyric acid production is attracting great attention as it is an environmentally friendly bioprocessing. However, traditional fermentative butyric acid production is still not economically competitive compared to chemical synthesis route, due to the low titer, low productivity, and high production cost. Therefore, reduction of butyric acid production cost by utilization of alternative inexpensive feedstock, and improvement of butyric acid production and productivity has become an important target. Recently, several advanced strategies have been developed for enhanced butyric acid production, including bioprocess techniques and metabolic engineering methods. This review provides an overview of advances and strategies in process and strain engineering for butyric acid production by microbial fermentation. Additionally, future perspectives on improvement of butyric acid production are also proposed., (Copyright © 2018 Elsevier Ltd. All rights reserved.)

An experiment with 288 male (Ross 308) 1-d-old broilers was conducted to test the hypothesis that a coarse diet supplemented with butyric acid (BA) and fermentable carbohydrates (FC) improves performance of broilers with a poorly digestible protein source. The interaction effects of diet structure (fine or coarse), FC supplementation (with or without), and BA supplementation (with or without) in a poorly digestible diet based on rapeseed meal (RSM) were tested in a factorial arrangement of 8 (2×2×2) dietary treatments. The coarseness of the diet affected feed intake (FI) (P<0.001), BW gain (P=0.001), and the feed conversion ratio (FCR) (P=0.001) positively. Broilers fed the coarse diets had, on average, 14% heavier gizzards and 11, 7, 5, and 6% lower relative empty weights of the crop, duodenum, jejunum, and ileum, respectively, compared with those fed the fine diets. Dietary coarseness resulted in, on average, 6% greater ileal protein digestibility, 20% lower gizzard pH, 19% greater villus height, 18% lower crypt depth, and 23% reduced cecal branched chain fatty acids (BCFA) compared with chickens fed the fine diets. Broilers fed BA-supplemented diets had an improved FCR (P=0.004) and decreased crypt depth (P<0.001) compared with those fed diets without BA. Fermentable carbohydrate supplementation did not influence growth performance, gut development, or contents of total BCFA and total biogenic amines in the cecal digesta (P>0.05). Supplementation with FC, however, decreased the cecal concentration of spermine by approximately 31% compared with broilers fed diets without FC (P=0.002). In conclusion, feeding a coarse diet supplemented with BA improved performance of broilers fed a diet containing a poorly digestible protein source. The negative effects of a poorly digestible protein source can thus be partly counterbalanced by coarse grinding and BA supplementation in the diet., (© The Author 2015. Published by Oxford University Press on behalf of Poultry Science Association.)

The effect of γ-alumina as a fermentation advancing tool and as carrier for culture immobilisation, regarding VFAs and ethanol production during acidogenic fermentation of glucose, was examined at various process conditions (sugar concentration, pH) and operation modes (continuous with and without effluent recirculation and batch). The results showed that at high initial pH (8.9) the continuous acidogenic fermentation of glucose led to high yields of VFAs and favoured the accumulation of butyric acid. The batch process on the other hand at pH 6.5, favoured the ethanol-type fermentation. The results indicate that in the frame of technology development for new generation biofuels, using γ-alumina as a process advancing tool at optimum process conditions (pH, initial glucose concentration and mode of operation), the produced VFAs profile and ethanol concentration may be manipulated., (Copyright © 2014. Published by Elsevier Ltd.)

An experiment was carried out to determine the effect of a grass diet and a concentrate supplement on rumen fermentation and nutrient flows to the duodenum. Perennial ryegrass was cut and fed indoors to eight rumen- and duodenum-cannulated Friesian cows with or without 3 kg/d of molassed beet pulp in a randomized design experiment. The dry matter intake of grass was significantly lower for cows fed the concentrate supplement (13.6 vs. 11.5 kg of dry matter/d), but total dry matter and organic matter (OM) intakes were similar for cows fed both diets. Cows fed the supplement had higher mean concentrations of total volatile fatty acids (108 vs. 89 mmol/L) and a higher percentage of butyrate in total volatile fatty acids (13.5 vs. 11.6 mol/100 mol). There were no differences between the diets in the flow of OM to the duodenum or in the extent of OM digestion in the rumen. Flows of nonammonia N, microbial N, and amino acids to the duodenum tended to be higher for cows fed the supplemented diet than for those fed ryegrass only. The efficiency of microbial protein synthesis also tended to be higher for cows fed the supplemented diet (42 vs. 37.7 g/kg of OM apparently digested in the rumen and 28.2 vs. 26 g/kg of OM truly digested in the rumen). Overall, there were indications that the supplement caused better capture of N in the rumen and increased the efficiency of microbial protein synthesis.

The effects of selenium (Se) on ruminant microbial fermentation were investigated in vitro using rumen microflora collected from a rumen-fistulated dairy cow. First, the effects of L-selenomethionine (SeMet; at 0.2 or 2 ppm Se) in the presence or absence of wheat bran (WB, 500 mg per incubation flask) were evaluated. Second, the effects of several forms of Se (elemental Se: 50 ppm Se; sodium selenite: 2 ppm Se; SeMet: 2 ppm Se) were compared. Results showed that the amounts of short-chain fatty acids (SCFAs) tended to be increased by SeMet treatment, whereas SeMet in the presence of WB transiently suppressed fermentation. The addition of SeMet tended to increase the production of acetate while reducing the production of butyrate with the without WB supplementation. Among the different Se compounds tested, the amounts of SCFAs were greater with SeMet treatment, which yielded a higher proportion of acetate compared to other treatments. Selenite did not influence the total SCFAs concentrations; however, it increased the relative proportion of butyrate at the expense of acetate. Elemental Se did not significantly affect fermentation. Higher bacterial Se concentrations were observed for selenite than for SeMet. It was concluded that Se supplementation can influence rumen microbial fermentation and that Se compounds differ in this regard.

The effect of adding nitrate and nitrite (0.05% and 0.01% N in DM) of two inoculants or formic acid on the ensiling of orchardgrass and a grass-legumes-mixture, both low in nitrate, was proved in two experiments during ensiling starting in an early stage of fermentation silages without additives contained butyric acid, with increasing amounts up to 180 day of storage period. Silages with added nitrate or nitrite (0.1% N in DM) contained no butyric acid despite of a delay in the formation of lactic acid Nitrite was more effective as nitrate (both 0.05% N in DM) to suppress butyric acid fermentation. However, both additives, nitrite and nitrate, increased the lactic acid fermentation. Interpreting this facts it was hypothesized that the clostridia was inhibited by nitrate and nitrite. Addition of inoculants improved the formation of lactic acid, and decreased pH-value in comparison to control silages. The formation of butyric acid was limited, but not suppressed. The effect of inoculants differed in the intensity of fermentation and the formation of by-products of lactic acid fermentation. The effect of formic acid was not sure.

Rumen and caecal contents, obtained from slaughterhouse cattle and rumen contents obtained from a fistulated wether were incubated in vitro with ground hay in the presence and absence of, respectively, casein hydrolysate and mucin. Differences in stoichiometry of rumen and caecal fermentations, indicative of reductive acetogenesis in the caecum, were confirmed, except for incubations with free amino acids. Net fermentation end product production was determined after correction for amounts formed in incubations without the substrate. These determined amounts of hay fermentation end products were compared with the amounts calculated from incubations of hay with added casein hydrolysate or mucin, corrected for amounts formed from the latter added substrates incubated alone. With casein hydrolysate, no differences between the determined and calculated amounts were observed, excluding the occurrence of reductive acetogenesis from hay in the presence of free amino acids. With mucin, the calculated amounts indicated an inhibition of methanogenesis, accompanied by increased amounts of proprionate, butyrate and valerate production. This finding was probably related to the greater availability of easily fermented carbohydrates in the presence of mucins. The absence of an increased acetate production in the incubations with added head space hydrogen gas, also indicate the absence of reductive acetogenesis from hay in the presence of mucin. Stoichiometric considerations also indicate that neither free amino acids, nor mucin, induce reductive acetogenesis in short-term in vitro incubations of rumen contents with hay.

Three midlactation Holstein cows with ruminal and duodenal cannulas were used in a 3 x 3 Latin square design to determine whether ruminal or postruminal alterations in metabolism were responsible for the changes in milk composition that frequently are associated with dietary fish meal. Cows were offered a diet of 60:40 forage to concentrate (aliquots at 6-h intervals) that was supplemented with isonitrogenous amounts of soybean meal (1.3 kg of DM/d) dosed into the rumen or fish meal (1.0 kg DM/d) dosed either into the rumen or into the duodenum. The DMI, ruminal NDF digestion, and flows of total N and microbial N to the duodenum decreased for cows receiving fish meal. Dietary N flow increased when fish meal was dosed into the rumen. Total concentration of ruminal VFA was greater for cows receiving the soybean meal treatment; however, treatment had no effect on the ratio of ruminal acetate plus butyrate to propionate. Milk and FCM yields were unaffected by treatment, but milk fat content decreased, and milk protein content increased when cows were supplemented with fish meal. The difference in mammary arteriovenous glucose difference decreased when cows were dosed with fish meal. Changes in plasma NEFA and triglycerides were small and inconsistent. Results from this experiment suggest that effects of fish meal on milk composition are due to postruminal alterations in metabolism.

Colonic SCFA formation from fermentable carbohydrate is important for the maintenance of morphologic and functional integrity of the colonic epithelium. Carbohydrate-induced diarrhea occurs when the amount of carbohydrate entering the colon exceeds its fermentation capacity. Deficient availability or utilization of SCFA, mainly of n-butyrate, is the cause of diversion colitis and may play important roles in colonic carcinogenesis, in starvation and enterotoxigenic diarrhea, and in idiopathic UC.

Continuous culture fermenters were used to evaluate effects of extrusion of whole soybeans and changes in forage composition of diets on microbial fermentation. Treatments were arranged in a 2 x 4 factorial design with soybeans (raw or extruded) and dietary treatment (ratio of alfalfa hay to corn silage; 82:18, 61:39, 43:57, and 27:73 of dietary forage) as main effects. Soybeans constituted 9.6, 14.4, 19.2, and 23.9% of DM for each of the respective dietary treatments. True digestion of DM, ADF, and NDF was unaffected by processing of soybeans or dietary treatment, but true digestion of OM decreased as concentration of corn silage and soybeans increased. Total VFA concentration was unaffected by source of soybeans or dietary treatments; however, molar concentration of butyrate decreased in fermenters supplied with diets containing extruded soybeans. Degradation of CP was not influenced by soybean source but decreased as the concentration of corn silage and soybeans increased. Bacterial N output decreased, and dietary N flow from the fermenters increased, as concentration of corn silage and soybeans increased. Changes in the ratio of alfalfa hay to corn silage and alteration of dietary soybean concentration affected true OM digestion and dietary CP degradation, but extrusion of whole soybeans had little effect on fermentation.

Rice straw (Rs) was treated by a sodium chlorite/acetic acid mixture (Sct), ammoniation (At) and alkaline hydrogen peroxide (Athp) methods. The objective was to compare their degradation and fermentation products in the presence or suppression of anaerobic fungi. Significant differences (P < 0.01) in degradation of straws were observed during all periods of incubation with Sct having the highest digestibilities during the 48-h and 72-h incubations. The degradation of Sct straw was highest in both of the incubations with whole rumen fluid (WRF) and WRF plus cycloheximide. In sacco digestion followed the order of Sct > At > Rs > Athp. Suppressing fungal activity with cycloheximide resulted in a decrease in dry matter degradation, with concomitant decrease in total volatile fatty-acid concentration. While the suppression of fungal activity with cycloheximide depressed acetate and butyrate production, it favored an increase in propionate production.

The aim of the present study was to assess the relationship between the disappearance of dietary fibre sugars and the production of individual short-chain fatty acids (SCFA). The bacterial degradation of five dietary fibres whose sugars were quantified was investigated in vitro using a human faecal inoculum. Involvement of the main fibre sugars in SCFA production was evaluated by a stepwise multiple linear regression. The results show first that the nature and chiefly the associations between the fibre sugars were key variables in the fermentability. Second, the nature and the amounts of SCFA produced were closely related to the in vitro fermentation of the main sugars available: uronic acids seemed to be principally involved in the production of acetic acid whereas the production of propionic acid could be promoted by the fermentation of glucose and, to a lesser extent, by that of xylose and arabinose. Xylose tended to have a greater impact than uronic acids and glucose on the production of butyric acid. Thus, it would be possible to predict which SCFA could be specifically produced during the fermentation of a fibre, as far as the chemical composition and structure of this fibre are known.

Five mature wethers fitted with rumen fistulas were fed grass hay and a sugarbeet-pulp-based concentrate or maize silage and a cereal-based concentrate (50/50 digestible organic matter basis), or without with 5 g yeast supplement (Saccharomyces cerevisiae, Biosaf) per day in a latin square design. Diets were given for a 28-d adaptation period, followed by a 10-d collection period to determine digestibility and nitrogen retention data. Afterwards, rumen samples were taken on 3 consecutive days and analysed for volatile fatty acids, pH and ammonia. Digestibility and nitrogen balance were not affected by yeast treatment. Supplementation of yeast increased acetate: propionate ratio, butyrate, isoacids, pH and ammonia. The effects were more pronounced for the maize silage diet. These results demonstrate that the effect of yeast culture on rumen fermentation may depend on the nature of the diet. Living yeast cell number in the rumen fluid rapidly declined when dietary yeast was ceased. Furthermore, yeast cells survived the passage through the digestive tract.

Experiments used unadapted mixed cultures of ruminal microorganisms in batch or continuous culture fermentation to investigate the effect of a thiopeptide, A10255, on ruminal fermentation and microbial populations. After 24 h of fermentation in batch culture, addition of A10255 (.5 to 20 ppm of the culture fluid) to 0, 45, 60, and 75% concentrate diets had no effect on total VFA but increased molar proportion of propionate and decreased butyrate. The molar proportion of acetate was decreased by treatment only in the 0 and 75% concentrate diets. The increase in molar proportion of propionate by 20 ppm of A10255 was less than the increase caused by a similar concentration of monensin. The same concentration of A10255 (20 ppm) decreased ADF digestion less than 20 ppm of monensin. In continuous culture, A10255 (33 mg/kg of dietary DM) did not affect total VFA concentration, culture pH, OM digestion, or ADF digestion. Ruminal bacterial populations of total anaerobes and lactate-producing, lactate-utilizing, cellulolytic and amylolytic bacteria were unaffected by treatment. However, molar proportions of acetate, butyrate, and isovalerate were decreased, and propionate was increased, by addition of A10255.

The aim of this study was to determine the effect of soluble fiber on indexes of colon-cancer risk in postpolypectomy and nonpolyp patients. Forty-five postpolypectomy and 49 nonpolyp volunteers completed 2-wk metabolic studies where half of the group received oat-bran supplements and the other half took wheat-brain supplements. Colonic biopsies taken before and after the intervention showed no difference in the index of thymidine colonic-crypt-cell labeling, thymidine-labeling pattern, or nuclear aberrations. Nevertheless, fecal pH was significantly reduced by 0.23 +/- 0.07 pH units (P less than 0.002) as an index of increased colonic fermentation on oat bran. This was not associated with increased basal breath hydrogen concentrations; fecal butyrate concentrations were higher on wheat bran. We conclude that soluble fiber as oat brain appears to have no advantage over wheat bran in modifying putative risk factors for colonic cancer.

A Rusitec semi-continuous flow fermentor was used to study the influence of enzyme pretreatment of food substrates on the fermentation profile over a 2-week period following inoculation with rabbit caecal contents. Three types of substrate were examined: 1) homogenized commercial rabbit feed; 2) the solid remains of this feed after digestion with alpha-amylase for 24 h; and 3) substrate 2 digested for 4 h with pepsin (double enzyme treatment). One of a pair of nylon pouches containing 15 g substrate was replaced each day, thus producing a uniform 48-h fermentation. Fermentation of the untreated feed (1) for 5-6 days produced a fermentation profile quite different from that obtained in vivo in the rabbit caecum: propionic acid accounted for over 35% of total volatile fatty acid (VFA), and butyric acid for about 15%. Amylase digestion (2) gave a stable ferment profile closer to the in vivo profile, except that propionic and butyric acids were similar at 15% of total VFA. Digestion with both amylase and pepsin (3) produced a stable fermentation profile very close to the in vivo profile: C2 > 60%, C3 < 11% and 17% < C4 < 21%. The rate at which membrane constituents (acid detergent fibre, ADF) were lost in 48 h was similar to the digestibility coefficient measured in vivo by others for the same basic feed. Lastly, there was a high percentage (about 5%) of volatile C5 fatty acids; this could be due to the discontinuous fermentor input of one pouch per 24 h. Thus, feed pretreated with both amylase and pepsin simulates, in vitro, rabbit caecal fermentation in a semi-continuous Rusitec type fermentor.

A new technique for caecal cannulation in adult rabbit was validated in order to perform in vivo studies of caecal fermentation under a physiological status. The cannulation did not modify the digestibility of the diet, and it was possible to collect digesta (10 g fresh matter) after a few minutes without stress for animals only 10 days post-surgery. Volatile fatty acid (VFA) (60 mM/l) and ammonia (11 mM/l) concentration of caecal digesta collected in vivo was not different from that obtained from slaughtered rabbits. VFA measurements were reproducible (CV = 6.8%) and were not dependent on the daily collection frequency (1-5/day). Caecal VFA level in the starved rabbit was very low (23 mM/l) while the butyrate/propionate rate was the inverse (C4/C3 = 0.6). Five h after feeding, the in vivo VFA level reached 96 mM/l and the butyrate proportion (12%) over-reached those of propionate (3.5%). The caecal fermentations of a 7-week-old rabbit differed from those of an adult by a higher VFA level and by a greater post-feeding variation in the fermentation pattern.

The aim of the study was the investigation of rumen fermentation during alkalosis in cows. The study comprised some parameters of rumen fermentation, such as: pH, ammonia and volatile fatty acids (VFA) levels, also relationship between VFA, numbers of population of protozoa and bacteria, total production of gases in vitro particularly CO2 and CH4, amounts of lactic and total protein in rumen fluid and non-glucogenic/glucogenic ratio (NGGR) in the VFA mixture. On the basis of obtained results the amounts of fermented hexose, cell yield, ATP produced and hydrogen utilization were calculated. During alkalosis there was observed significant fall of VFA production, especially acetic and butyric acids, also lower production of gases, particularly CH4--probably as a result of selective reduction of methanogenic strain bacteria. The levelling of value of rumen pattern of fermentation occurred after the beginning of lactation probably as a result of metabolism products excretion together with milk.

Effects of isoacids, monensin, or a combination of them on fermentation by mixed rumen bacteria were investigated using a continuous culture technique. The culture was allowed to stabilize for 4 d before treatments were imposed. Comparisons between treatments were made on d 11 and 12 of the culture. Isoacids (equal proportions of isobutyric, 2-M-butyric, isovaleric, and valeric acids) at 15 mg/dl of culture media increased acetate (6.17 vs. 5.48 meq/dl) and total VFA production (8.93 vs. 7.87 meq/dl) compared with that of controls. Monensin at 150 micrograms/dl reduced acetate (3.74 vs. 6.02 meq/dl) and VFA (6.84 vs. 8.54 meq/dl) but increased propionate (2.28 vs. 1.74 meq/dl) relative to control. The combination of isoacids and monensin increased acetate relative to monensin alone (5.24 vs. 3.74 meq/dl) but did not alter the effect of monensin on propionate concentration (2.32 vs. 2.28 meq/dl). It is concluded that monensin decreases acetate production by 35% and when isoacids are added to the cultures containing monensin, acetate production is restored.

The actions of butyric and acetic acids on acetone-butanol fermentation are investigated. Production of butyric and acetic acids are controlled by the extracellular concentrations of both acids: acetic acid added to the medium inhibits its own formation but has no effect on butyric acid formation, and added butyric acid inhibits its own formation but not that of acetic acid. The ratio of end metabolites depends upon acetic and butyric acid quantities excreted during the fermentation. In contrast to acetic acid, which specifically increases acetone formation, butyric acid increases both acetone and butanol formations. Acetate and butyrate kinase activities were also examined. Both increase at the start of fermentation and decrease when solvents appear in the medium. Coenzyme A transferase activity is weak in the acidogenic phase and markedly increases in the solvent phase. Acetic and butyric acids appear to be co-substrates. On the basis of these results, a mechanism of acetic and butyric acid pathways, coupled to solvent formation by C. acetobutylicum glucose fermentation is proposed.

The fermentation of 13C-labeled ethanol and acetate into butyrate and caproate by Clostridium kluyveri has been studied by using 13C NMR. The pathway involves the conversion of both ethanol and acetate into acetyl coenzymes A, two of which condense to form CoA-linked precursors of butyrate. If butyryl-CoA is involved in the condensation, caproate is the ultimate product. ATP is produced from acetyl-CoA via the reactions catalyzed by phosphotransacetylase and acetate kinase with acetate, a required carbon source, as a co-product. In spectra of whole cells incubated with the labeled carbon sources, label from ethanol appears rapidly in acetate, which then reaches a lower, steady-state concentration due to its re-entry into the pathway. The rapid initial production of acetate indicates equally rapid production of ATP. Label from acetate appears in ethanol only if ethanol is already present, indicating that this process is one of isotopic equilibration rather than net synthesis of ethanol from acetate. The ratio of butyrate to caproate produced depends strongly on the initial ratio of ethanol to acetate in the medium. The relative rates of utilization of ethanol and acetate vary as the fermentation proceeds. 13C-13C coupling in the butyrate and caproate produced from [1-13C]ethanol and [2-13C]acetate can be used to determine if the acetyl-CoA molecules arising from ethanol and acetate enter the same pool or if they remain separated. The data are consistent with random mixing of the acetyl-CoA produced from the two carbon sources.

The two components, delta pH and delta psi, of the membrane protonmotive force (delta p) effect and are affected by the transport of many substrates and metabolites. Because the integrity (or restoration) of the delta p requires the expenditure of metabolic energy, such transport processes affect the overall cell bioenergetics. However, the transport or high concentrations of certain substrates and metabolites can have more serious effects on cell metabolism because they partially or completely abolish either or both the delta pH and delta psi. If the cells cannot eventually restore the collapsed component(s) of the delta p, complete growth inhibition and cell death become inevitable. In the butanol/acetone fermentation of Clostridium acetobutylicum, the transport and the presence of key metabolites (acetic and butyric acids, and butanol) have serious and some necessary effects on the delta p. Acetic and butyric acids act as uncouplers of the delta pH, thereby reducing the internal pH. Using other acid uncouplers (such as acetoacetate, which is metabolized by the cells, or FCCP, which is not metabolized by the cells), we found that a lower pHo combined with the metabolic-energy drain of the uncoupling effect and high internal acid concentrations are implicated in the mechanism(s) of solventogenesis. Thus, the production or presence (or both) of the two acids (acetic and butyric) is beneficial to the initiation of solvent production. The transport mechanisms of CH3OH, CH2O, and HCOOH in obligate CH3OH utilizers (methylotrophs) were also discussed in detail. We showed that CH3OH is actively transported by the cells at the expense of metabolic energy and that its transport significantly affects the dynamics of continuous bioreactors. The accumulation of CH2O was found to be driven by the membrane delta p. Finally, formate was accumulated by the delta pH according to the general transport mechanism of short-chain fatty acids. The inhibition of growth by formate was explained by its uncoupling effect on the cells. Growth inhibition by CH3OH appeared to be related to the severe reduction of the membrane delta pH and cell pHi by relatively low CH3OH concentrations.

The fermentation of glucose and corn starch by faecal suspensions from two subjects was examined over a three and a half year period. The substrate specificity and products of the faecal fermentations of each subject were relatively stable during this period and were significantly different between subjects. The major soluble end products of fermentation of glucose or starch were acetate, propionate, and butyrate. Hydrogen temporarily accumulated and was subsequently used in fermentations by both subjects. Hydrogen was used without methane production in fermentations of subject 1, but was used for methane formation in fermentations of subject 2. Although the rates of glucose fermentation were similar between both subjects; subject 1 produced a significantly greater molar ratio of propionate than did subject 2. The rate of fermentation of starch by faecal suspensions from subject 1 was faster than that of subject 2. The molar ratio of butyrate was greater for starch fermentations by subject 2, while the molar ratio of propionate was greater with subject 1. Significant differences were found between subjects in molar ratios and concentration of acetate and propionate and concentrations of butyrate in faeces.

Camelina cake (CAM) is a co-product proposed as an alternative protein source; however, piglet data are still limited. This study aimed to evaluate the effect of different doses of CAM in substitution of soyabean meal on the growth, health and gut health of weaned pigs. At 14 d post-weaning (d0), sixty-four piglets were assigned either to a standard diet or to a diet with 4 %, 8 % or 12 % of CAM. Piglets were weighed weekly. At d7 and d28, faeces were collected for microbiota and polyamine and blood for reactive oxygen metabolites (ROM) and thyroxine analysis. At d28, pigs were slaughtered, organs were weighed, pH was recorded on gut, colon was analysed for volatile fatty acids (VFA) and jejunum was used for morphological and gene expression analysis. Data analysis was carried out using a mixed model including diet, pen and litter as factors; linear and quadratic contrasts were tested. CAM linearly reduced the average daily gain from d0–d7, d0–d14, d0–d21 and d0–d28 (P ≤ 0·01). From d0–d7 increasing CAM linearly decreased feed intake (P = 0·04) and increased linearly the feed to gain (P = 0·004). CAM increased linearly the liver weight (P < 0·0001) and affected the cadaverine (P < 0·001). The diet did not affect the ROM, thyroxine, intestinal pH, VFA and morphology. All doses of CAM increased the α diversity indices at d28 (P < 0·05). CAM at 4 % promoted the abundance of Butyricicoccaceae_UCG-008. Feeding with CAM enhanced resilience in the gut microbiome and can be evaluated as a potential alternative protein source with dose-dependent limitations on piglet growth performance. [ABSTRACT FROM AUTHOR]

The objective of this study was to investigate the effect of microencapsulated bioactive compounds from lemongrass mixed dragon fruit peel pellet (MiEn-LEDRAGON) supplementation on fermentation characteristics, nutrient degradability, methane production, and the microbial diversity using in vitro gas production technique. The study was carried out using a completely randomized design (CRD) with five levels of MiEn-LEDRAGON supplementation at 0, 1, 2, 3, and 4% of the total dry matter (DM) substrate. Supplementation of MiEn-LEDRAGON in the diet at levels of 3 or 4% DM resulted in increased (p < 0.05) cumulative gas production at 96 hours (h) of incubation time, reaching up to 84.842 ml/ 0.5 g DM. Furthermore, supplementation with 3% MiEn-LEDRAGON resulted in higher in vitro nutrient degradability and ammonia–nitrogen concentration at 24 h of the incubation time when compared to the control group (without supplementation) by 5.401% and 11.268%, respectively (p < 0.05). Additionally, supplementation with MiEn-LEDRAGON in the diet led to an increase in the population of Fibrobacter succinogenes at 24 h and Butyrivibrio fibrisolvens at 12 h, while decreasing the population of Ruminococcus albus, Ruminococcus flavefaciens, and Methanobacteriales (p < 0.05). Moreover, supplementation of MiEn-LEDRAGON in the diet at levels of 2 to 4% DM resulted in a higher total volatile fatty acids (VFA) at 24 h, reaching up to 73.021 mmol/L (p < 0.05). Additionally, there was an increased proportion of propionic acid (C3) and butyric acid (C4) at 12 h (p < 0.05). Simultaneously, there was a decrease in the proportion of acetic acid (C2) and the ratio of acetic acid to propionic acid (C2:C3), along with a reduction of methane (CH4) production by 11.694% when comparing to the 0% and 3% MiEn-LEDRAGON supplementation (p < 0.05). In conclusion, this study suggests that supplementing MiEn-LEDRAGON at 3% of total DM substrate could be used as a feed additive rich in phytonutrients for ruminants. [ABSTRACT FROM AUTHOR]

The extract of Dendrobium huoshanense, a traditional Chinese medicinal and food homologous plant belonging to the family Orchidaceae, was previously reported to have hypoglycemic and antioxidant effects. In this study, the direct effects of polysaccharide (DHP) and non-polysaccharide (NDHP) components of D. huoshanense, as well as its water extract (DHWE) were compared with that of metformin (an antidiabetic drug) on the gut microbiota (collected from fecal flora) of rats with streptozotocin-induced type 1 diabetes (T1D) using an in vitro fermentation method. The results showed that DHWE, DHP, and NDHP reduced pH and increased bacterial proliferation and short-chain fatty acid (SCFA) content in fermentation broth. DHWE, DHP, NDHP and metformin promoted the production of acetic and propionic acid, acetic acid, propionic acid and butyric acid, and propionic acid, respectively. DHWE, DHP, and NDHP reduced the abundance of Proteobacteria (subdominant pathogenic bacteria) and increased the abundance of Firmicutes (dominant beneficial gut bacteria). NDHP also reduced the abundance of Bacteroidetes (beneficial and conditional pathogenic). Metformin increased the abundance of Proteobacteria and reduced the abundance of Firmicutes and Bacteroidetes. At the genus level, NDHP promoted the proliferation of Megamonas and Megasphaera and decreased harmful bacteria (e.g., Klebsiella), and DHP increased the abundance of Prevotellaceae (opportunistic and usually harmless). By contrast, metformin increased the abundance of harmful bacteria (e.g., Citrobacter) and reduced the abundance of beneficial bacteria (e.g., Oscillospira). Our study indicates that DHWE, DHP, and NDHP are potentially more beneficial than metformin on the gut microbiota of T1D rats in vitro. [ABSTRACT FROM AUTHOR]

Simple Summary: This study investigated the impact of adding 1% processed coconut meal (hydrolyzed copra meal, HCM) to the diets of weaned pigs, comparing it to regular coconut meal (CM) and a control diet with no coconut meal. Processed to enhance digestibility, HCM showed better digestion than CM. Both treatments supported a diverse gut microbiome, with potential benefits for producing beneficial fatty acids crucial for gut health. More research is needed to fully evaluate HCM's impact on pig growth and health, but initial findings suggest that incorporating HCM could enhance digestive health and overall well-being in young pigs. This study aimed to compare the effects of hydrolyzed copra meal (HCM) inclusion at 1% on its in vitro digestibility and the microbiota and cecum fermentation using the gut microbiota of weaned swine, targeting microbial community and short-chain fatty acids (SCF). For this reason, three treatments were considered: control (no copra meal), 1% non-hydrolyzed copra meal (CM), and 1% HCM. Non-defatted copra meal was hydrolyzed and analyzed (reducing sugars and total carbohydrates) in our laboratory. For digestion, microbiota identification, and fermentation assays, fresh fecal samples from two weaned pigs (1 month old) were used. Three replicates of each treatment were employed. HCM was more digestible, with approximately 0.68 g of hydrolysate recovered after simulated digestion compared to 0.82 g of hydrolysate recovered from CM. This was shown by Scanning Electron Microscope (SEM) images. Also, the three swine shared the majority of microbial species identified at the phylum and family levels. There were no differences (p > 0.05) between treatments in the microbial community and SCFA during fermentation. However, higher Chao-1 and Shannon indexes were observed in CM and HCM treatments. HCM was also found to be capable of preserving Actinobacterota and Proteobacteria at the phylum level, while at the family level, both treatments may help Lactobacillaceae, Peptostreptococcaceae, Lachnospiraceae, and Ruminococcaceae survive in the long term. Also, there was a potential trend of increasing acetic acid and butyric acid in the CM and HCM treatments. While HCM shows promise in potentially modulating the gut microbiota of weaned swine, additional research is required to investigate the effects of higher doses of HCM on swine performance parameters. [ABSTRACT FROM AUTHOR]

Melanoidins are heterogeneous polymers with a high molecular weight and brown color formed during the Maillard reaction by the combination of sugars and amino acids at high temperatures with the potential to inhibit the microbial activity in bioprocesses. This study assessed the impacts of melanoidins on the kinetic of substrate conversion and production of organic acids via dark fermentation using microbial consortia as inoculum. The investigations were carried out in fed-batch reactors using synthetic melanoidins following glucose-to-melanoidin ratios (G/M; g-glucose g−1 melanoidins) of 0.50, 1.50, 1.62, 1.67, and 5.00, also considering a melanoidin-free control reactor. The results showed that melanoidins negatively impacted the kinetics of glucose fermentation by decreasing the first-order decay constant (k1): when dosing equivalent initial concentrations of glucose (ca. 3 g L−1), the absence of melanoidins led to a k1 of 0.62 d−1, whilst dosing 2 g L−1 (G/M = 1.5) and 6.0 g L−1 (G/M = 0.5) of melanoidins produced k1 values of 0.37 d−1 and 0.27 d−1, respectively. The production of butyric and acetic acids was also negatively impacted by melanoidins, whilst the lactic activity was not impaired by the presence of these compounds. Lactate production reached ca. 1000 mg L−1 in G/M = 1.67, whilst no lactate was detected in the control reactor. The presence of melanoidins was demonstrated to be a selective metabolic driver, decreasing the microbial diversity compared to the control reactor and favoring the growth of Lactobacillus. These results highlight the importance of further understanding the impacts of melanoidins on melanoidin-rich organic wastewater bioconversion, such as sugarcane vinasse, which are abundantly available in biorefineries. [ABSTRACT FROM AUTHOR]

Optimization of additives was achieved for hydrogen and butyric acid production modelled through a three-level Box-Behnken Design of the response surface methodology. Seventeen runs were designed with variables of sodium chloride (0.1–5 g/L), sodium thiosulphate (0–200 mg/L) and minerals (Zinc, iron, cupper and nickel (0–0.8 mM). The model fit to a cubic model with a high R2 of 96% and P value of 0.03. Some of the interactive variables have significant effect on butyrate production. The butyrate concentrations were close to the predicted ones. The model showed that higher butyric acid concentrations were observed with low sodium chloride and high sodium thiosulphate and minerals concentrations. Butyrate/Acetate ratios (BA/A), hydrogen production yield and rates increased with mean values of the independent variables. A cumulative hydrogen formation of 155 mL, yield of 2.6 mmol H 2 /mmol lactose, and rate of 3.6 mL/g/h was observed with the highest BA/AA ratio obtained from experiments. [Display omitted] • Box-Behnken design was applied to enhance butyric acid production. • A modified third-order polynomial regression models were developed with high accuracy. • The interactive variables have significant effect on butyric acid production. • The biohydrogen amount produced was the highest among the literature compared. • The highest BA/AA ratio maximizing butyric acid gave a high hydrogen production potential. [ABSTRACT FROM AUTHOR]

Simple Summary: The black soldier fly (BSF) contains protein, fat, chitin, and rich minerals and has the potential to be used as a protein feed source. The purpose of this experiment was to evaluate the effects of different levels of BSF on rumen in vitro fermentation gas production, methane (CH4) production, ammonia nitrogen (NH3-N), and volatile fatty acids (VFAs). The results have shown that the supplementation of 10% BSF yielded in vitro fermentation indicators similar to those of the non-supplementation group. Although supplementing BSF of 15% reduced methane production, it also reduced the concentrations of rumen VFA. Therefore, it is recommended to supplement the diet with 10% BSF instead of soybean meal. The purpose of this experiment was to evaluate the effects of different levels of BSF on rumen in vitro fermentation gas production, methane (CH4) production, ammonia nitrogen (NH3-N), and volatile fatty acids (VFAs). The experiment comprised four treatments, each with five replicates. The control group contained no BSF (BSF0), and the treatment groups contained 5% (BSF5), 10% (BSF10), and 15% (BSF15) BSF, respectively. Results showed that at 3 h, 9 h, and 24 h, gas production in BSF5 and BSF10 was significantly higher than in BSF0 and BSF15 (p < 0.05). Gas production in BSF5 and BSF10 was higher than in BSF0, while gas production in BSF15 was lower than in BSF0. At 6 h and 12 h, CH4 emission in BSF15 was significantly lower than in the other three groups (p < 0.05). There were no differences in the pH of in vitro fermentation after BSF addition (p > 0.05). At 3 h, NH3-N levels in BSF10 and BSF15 were significantly higher than in BSF0 and BSF5 (p < 0.05). At 6 h, NH3-N levels in BSF5 and BSF10 were significantly higher than in BSF0 and BSF15 (p < 0.05). Acetic acid, propionic acid, butyric acid, and total VFAs in BSF0, BSF5, and BSF10 were significantly higher than in BSF15 (p < 0.05). In conclusion, gas production, CH4 emission, NH3-N, acetic acid, propionic acid, butyric acid, and VFAs were highest in BSF5 and BSF10 and lowest in BSF15. [ABSTRACT FROM AUTHOR]

The simulated digestion and fermentation characteristics in vitro of exopolysaccharide (EPS) of Levilactobacillus brevis M‐10 were studied to evaluate its postbiotic properties. The simulated digestion results showed that EPS could not be degraded in saliva but could be very slightly degraded in gastric juice and could be degraded in intestinal juice. The results of simulated fermentation demonstrated that EPS could lower the intestine pH and be utilized by gut microbes to produce short‐chain fatty acids such as propionic acid and butyric acid. Meanwhile, EPS significantly raised the diversity of human gut microbiota, and the relative abundances of Phascolarctobacterium were significantly increased, whereas Fusobacterium and Morganella significantly decreased. In conclusion, EPS from L. brevis M‐10 was a good postbiotic as inulin. This was the first report about EPS as the postbiotic of L. brevis M‐10 screened from broomcorn millet sour porridge in northwestern Shanxi Province, China. [ABSTRACT FROM AUTHOR]

The objective of this study was to assess the effects of dietary supplementation with tannic acid (TA) on the growth performance, digestibility, antioxidant status, intestinal morphology and the caecal fermentation and microbiota in rabbits. A total number of 120 Ira rabbits (30 days of age) were randomly allotted to four dietary treatment groups: TA 0 (control), TA 0.75, TA 1.5 and TA 3, administered basal diets with 0, 0.75, 1.5 and 3 g TA/kg of feed for 28 days. Compared to the control group, dietary 3 g TA/kg inclusion decreased the average daily feed intake (p < 0.05). No significant differences were found in the digestibility among the groups (p > 0.05). Serum total antioxidant capacity was significantly higher in the 3 g/kg TA group than in the other groups (p < 0.05). There was a significant increase in the concentration of propionic acid and butyric acid in the 3 g/kg TA group. The addition of TA had no effect on villus height and crypt depth of small intestine (p > 0.05). The 16S rRNA high‐throughput sequencing results showed that at the phylum level, dietary 3 g/kg TA increased the abundance of Bacteroidetes in the caecum of rabbits (p < 0.05). Based on the results, dietary TA is effective in antioxidant capacity of rabbits, improving caecal fermentation and optimizing the caecal microflora. However, the appropriate dosage supplementation of TA in rabbits needs further research. [ABSTRACT FROM AUTHOR]

Simple Summary: The use of various fermentation modifiers in ruminant diets is one of the best strategies for regulating greenhouse gas emissions, primarily carbon dioxide and methane (CH4). Feeding complex mineral substances of natural origin can provide a quick and safe result. Our in vitro studies confirmed these expectations, and saponite clay, due to its high adsorption properties, significantly reduced the production of CH4 and other gases. Reducing the emission of global warming gases currently remains one of the strategic tasks. Therefore, the objective of our work was to determine the effect of saponite clay on fermentation in the rumen of cows. The pH, total gas production, CH4, and volatile fatty acid (VFA) production in ruminal fluid was determined in vitro. Saponite clay from the Tashkiv deposit (Ukraine) has a high content of silicon, iron, aluminum, and magnesium. The addition of 0.15 and 0.25 g of saponite clay to the incubated mixture did not change the pH but reduced the total production (19% and 31%, respectively) and CH4 (24% and 46%, respectively) in the ruminal fluid compared to the control group and had no significant effect on the total VFA levels, but propionic acid increased by 15% and 21% and butyric acid decreased by 39% and 32%, respectively. We observed a decrease in the fermentation rates, with a simultaneous increase in the P:B ratio and an increase in the fermentation efficiency (FE) in the groups fermented with saponite clay, probably a consequence of the high efficiency in the breakdown of starch in the rumen. Therefore, further in vivo studies to determine the effective dose and effect of saponite clay on cow productivity and the reduction of gas emissions are promising and important. [ABSTRACT FROM AUTHOR]

Background: In ruminants, fibrous feedstuffs must be included in the ration to ensure normal rumen physiology and to prevent the occurrence of rumen‐related metabolic diseases. In addition to being a source of fibrous feedstuffs, they contain energy depending on the level of digestion and protein, minerals, fatty acids, minerals, and secondary compounds. Objectives: This study aimed to determine the nutrient matter, fatty acid, mineral and in vitro rumen fermentation values of the pennyroyal (Mentha pulegium L.) plant. Methods: The pennyroyal plant samples were collected at different phenological stages (vegetative, full flowering, and seed bulking) from the natural meadow. The samples were analysed for core nutrients, condensed tannins, minerals, fatty acids, and in vitro ruminal fermentation parameters. Results: The calcium (Ca) and iron (Fe) contents and in vitro ruminal fermentation parameters (total gas production and methane production, organic matter digestion (OMd), and the ammonia‐nitrogen) decreased with increasing phenological stage (p < 0.05). The percentages of linoleic, α‐linolenic, ω‐3, ω‐6 and polyunsaturated fatty (PUFA) acids of the pennyroyal plant linearly increased with the phenological stages (p < 0.05). However, butyric acid (BA) concentration in the in vitro ruminal fermentation fluid in the full flowering stage was lower than that of other stages (p < 0.05). Conclusions: Pennyroyal plant is a functional plant in terms of high values of ether extract (EE), α‐linolenic acid, linoleic acid, ∑ω‐3 fatty acids, Ca, Fe and Zn contents. For this plant to be used as animal feed, the stage when it has the highest values for Ca, Mg, S and Zn minerals and in vitro OMd were vegetative and full flowering. The stage with good potential as animal feed for ∑ω‐3 and ∑ω‐6 fatty acids and core nutrients (CP and EE) is the seed bulking stage. [ABSTRACT FROM AUTHOR]

Butyric acid, a four-carbon fatty acid, is an important industrial chemical and feedstock. To produce this chemical, a control fermentation was run with a 126.5 g.L−1 glucose concentration in the feed medium. In this medium, the strain produced 44.8 g.L−1 total acid with a productivity of 0.23 g.L−1h−1 and a yield of 0.41 g.g−1. The strain (Clostridium tyrobutyricum ATCC 25755) was also able to utilize glucose and xylose simultaneously with similar fermentation performance. The culture was also used to produce butyric acid from wheat straw hydrolysate (WSH) employing a hot water pretreatment. In a batch system, the strain resulted in a productivity and yield of 0.27 g.L−1h−1 and 0.44 g.g−1, respectively, which was an improvement over the use of glucose or xylose alone or mixtures of both. To improve reactor productivity, a membrane cell recycle bioreactor was used which resulted in a productivity of 1.89 g.L−1h−1. This productivity was 822% of that achieved in the glucose or xylose batch fermentation. Furthermore, a butyric acid recovery method was developed using XAD-4 adsorbent resin. In this system, up to 206.1 g.L−1 of butyric acid was used in the feed and, as a result of the quick adsorption, the residual butyric acid concentration was 29.5 g.L−1. In this experiment, the rate of acid removal of 1059.4 g.L−1h−1 was achieved. [ABSTRACT FROM AUTHOR]

In this paper, the change characteristics of DOM (dissolved organic matter) and acid production characteristics of anaerobic fermentation in waste activated sludge(WAS) pretreated with rhamnolipid (RL) were studied. The results showed that RL at the dose of 80 mg/gTS could significantly promote the disintegrating of EPS (extracellular polymers) and cell wall in WAS, and a large number of proteins and carbohydrates were dissolved. Three dimensional fluorescence parallel factor analysis showed that the addition of RL enhanced the dissolution and biodegradability of humus-like substances. LC-OCD (Liquid chromatography – organic carbon detection) analysis showed that RL promotes the dissolution of biodegradable components such as Biopolymer, Building Blocks and LMW Neutrals, and ensures the increase of VFA (volatile fatty acids) production in the process of anaerobic fermentation. Under the RL dose of 80 mg/gTS, the maximum VFA production of WAS was obtained at 108 h of anaerobic fermentation, which was 2699.39 mg/L. Acetic acid and propionic acid were the main components in the WAS fermentation broth pretreated by RL. The concentration of butyric acid increased with the increase of RL dose. The RL dose can significantly affect the composition of VFA in WAS fermentation broth. [ABSTRACT FROM AUTHOR]

The objective of this paper is to gain insights into the synergistic advantage of anaerobic co-fermentation of heat-treated sludge (HS) with food waste (FW) and heat-treated food waste (HFW) for hydrogen production. The results showed that, compared with raw sludge (RS) mixed with FW (RS-FW), the co-substrate of HS mixed with either FW (HS-FW) or HFW (HS-HFW) effectively promoted hydrogen production, with HS-HFW promoted more than HS-FW. The maximum specific hydrogen production (MSHP) and the maximum hydrogen concentration (MHC) of HS-HFW were 40.53 mL H2/g dry weight and 57.22%, respectively, and 1.21- and 1.45-fold as high as those from HS-FW. The corresponding fermentation was ethanol type for HS-HFW and butyric acid type for HS-FW. The net energy production from RS-FW and HS-FW was both negative, but it was positive (2.57 MJ) from 40% HFW addition to HS-HFW. Anaerobic fermentation was more viable for HS-HFW. [ABSTRACT FROM AUTHOR]

Dark fermentation (DF) of kitchen waste (KW) is a promising technology for the production of renewable biohydrogen. It can be both a method of obtaining clean energy and a sustainable waste management. Despite its potential, this process requires further research to improve efficiency. The aim of the research was to test the effect of thermal pretreatment of the inoculum on H2 and volatile fatty acids (VFAs) production in the DF process. The process was carried out at 37 °C, in batch mode. The digested sludge from the Group Wastewater Treatment Plant in Lodz was used as inoculum. KW from households was used as substrate. The inoculum was pre-treated at 70 °C for 15 and 30 min. Two control reference experiments were also used. The first without the inoculum, and the second without heating the inoculum. The thermal pretreatment inhibited methane production and increased hydrogen production. After the thermal pretreatment, the amount of CO2 produced during the process decreased compared to the bioreactor without inoculum pretreatment. Additionally, the main VFAs in the samples with pretreated inoculum were acetic and butyric acids, which are associated with hydrogen production in the biochemical pathways of the DF process. However, the time of thermal pretreatment had no significant effect on H2 production. [ABSTRACT FROM AUTHOR]

With the rapid development of the livestock industry, finding new sources of feed has become a critical issue that needs to be addressed urgently. China is one of the top five sunflower producers in the world and generates a massive amount of sunflower stalks annually, yet this resource has not been effectively utilized. Therefore, in order to tap into the potential of sunflower stalks for animal feed, it is essential to explore and develop efficient methods for their utilization. In this study, various proportions of alfalfa and sunflower straw were co-ensiled with the following mixing ratios: 0:10, 2:8, 4:6, 5:5, 6:4, and 8:2, denoted as A0S10, A2S8, A4S6, A5S5, A6S4, and A8S2, respectively. The nutrient composition, fermentation quality, microbial quantity, microbial diversity, and broad-spectrum metabolomics on the 60th day were assessed. The results showed that the treatment groups with more sunflower straw added (A2S8, A4S6) could start fermentation earlier. On the first day of fermentation, Weissella spp.dominated overwhelmingly in these two groups. At the same time, in the early stage of fermentation, the pH in these two groups dropped rapidly, which could effectively reduce the loss of nutrients in the early stage of fermentation. In the later fermentation period, a declining trend in acetic acid levels was observed in A0S10, A2S8, and A4S6, while no butyric acid production was detected in A0S10 and A2S8 throughout the process. In A4S6, butyric acid production was observed only after 30 days of fermentation. From the perspective of metabolites, compared with sunflower ensiling alone, many bioactive substances such as flavonoids, alkaloids, and terpenes are upregulated in mixed ensiling. [ABSTRACT FROM AUTHOR]

Background: Soybean meal (SBM) is the main protein source for animal diets but its anti‐nutritional constituents affect animal growth and immunity. The yeast culture of soybean meal (SBM‐YC) that fermented with yeast and hydrolyzed by protease simultaneously could reduce anti‐nutritional factors effectively and accumulate beneficial metabolites. Results: The crude protein and acid‐soluble protein content of SBM‐YC reached 542.5 g kg−1 and 117.2 g kg−1, respectively, and the essential amino acid content increased by 17.9%. Raffinose and stachyose decreased over 95.0%, and the organic acid content such as acetic acid, butyric acid, citric acid, lactic acid, succinic acid, and propionic acid produced by fermentation reached 6.1, 3.8, 3.6, 2.5, 1.2, and 0.4 g kg−1, respectively. As biomarkers of yeast culture, nucleosides and their precursors reached 1.7 g kg−1; in particular, the inosine content increased from 0 to 0.3 g kg−1. The total antioxidant capacity, 2,2'‐azinobis‐(3‐ethylbenzothiazoline‐6‐sulfonic acid (ABTS) free radical activity, metal chelating ability, and 1,1‐diphenyl‐2‐picrylhydrazyl (DPPH) scavenging ability were increased by 50.3%, 46.1%, 43.9%, and 20.6%, respectively. Conclusion: This study established a diversified evaluation index, which could lay the foundations for the production and quality control of SBM‐YC in the future. © 2023 Society of Chemical Industry. [ABSTRACT FROM AUTHOR]

(1) Aim: This study aimed to evaluate the fermentation quality, chemical composition, aerobic stability, in vitro digestibility, and rumen degradation characteristics of silage mixtures with different ratios of sweet sorghum (SS) and aerial parts of licorice (LC). (2) Methods: Five mixtures were produced on a dry matter (DM) basis: (i) 0%SS + 100%LC (0%SS); (ii) 25%SS + 75%LC (25%SS); (iii) 50%SS + 50%LC (50%SS); (iv) 75%SS + 25%LC (75%SS); and (v) 100%SS + 0%LC (100%SS). First, the chemical composition of the silages was measured before and after fermentation. Next, the aerobic stability, dynamic microbial colonization and dynamic volatile fatty acids of the mixed silage after fermentation were determined for 0, 5, 10, 15, 20, and 25 days. Finally, the parameters related to gas production and the characteristics of the gas production were determined. At the same time, the rate of degradation of the chemical composition of the mixed silage in the rumen was studied. (3) Results: (a) As the proportion of SS increased, pH, ammonia, butyric acid, acetate, and aerobic stability showed a decreasing trend, but lactic acid content gradually increased. (b) The content of the fermentation and gas production parameters were significantly higher in 100%SS and 50%SS than others (p < 0.05). (c) The rate of degradation of DE, ME, Neg, DM, CP, ADF, NDF, and ADL of 50%SS in the rumen of sheep was significantly higher than others (p < 0.05). (4) Conclusions: In conclusion, ensiling SS and LC mixtures can improve silage quality, especially if the SS and LC are ensiled together at a ratio of 50:50. [ABSTRACT FROM AUTHOR]

BACKGROUND: β‐Glucans are widely sourced and have various physiological effects, including anti‐inflammatory effects. However, the strength of the anti‐inflammatory activity of β‐glucans from different sources remains unknown due to the lack of rapid and effective biomarkers. This study therefore aimed to screen out the β‐glucans with strong anti‐inflammatory activity from five different sources and to further screen out possible biomarkers in metabolites after fermenting the β‐glucans with gut microorganisms. RESULTS: The results showed that all five β‐glucans inhibited the production of lipopolysaccharide (LPS)‐induced pro‐inflammatory mediators and suppressed the mRNA expression level of TLR4/MyD88. Their anti‐inflammatory mechanisms involved the inhibition of intracellular reactive oxygen species (ROS) production and suppression of mRNA expression of the NF‐κB pathway and JNK pathway. Among them, barley β‐glucan exhibited the strongest anti‐inflammatory effect, followed by Ganoderma lucidum β‐glucan. Enhanced anti‐inflammatory activity of β‐glucan was found after fermentation and may be related to the increased abundance of metabolites such as vanillin, dihydroxyphenylacetic acid, caffeic acid, acetic acid, butyric acid, and lactic acid. They were strongly positively correlated to the abundance of beneficial bacteria such as Blautia, suggesting that the production of those metabolites may be responsible for the flourishing of the beneficial bacteria. CONCLUSION: In conclusion, barley was a preferred raw material for the preparation of β‐glucans with strong anti‐inflammatory activity. Vanillin, dihydroxyphenylacetic acid, caffeic acid, acetic acid, butyric acid, and lactic acid were the possible biomarkers that could be utilized to evaluate the anti‐inflammatory effect of β‐glucans. © 2023 Society of Chemical Industry. [ABSTRACT FROM AUTHOR]

Ensiling density has significant importance for the quality and preservation of silage. Appropriate ensiling density could improve the nutritional value, extend the storage time of silage and reduce the risk of mold and spoilage. This work aimed to evaluate the effect of ensiling densities on the fermentation quality and aerobic stability of rice straw. The rice straw was obtained after threshing, then chopped and ensiled into a 10 L laboratory silo with three ensiling densities (high density at 700 g/L, medium density at 600 g/L and low density at 500 g/L). Five silos per density were opened after 3, 5, 7, 14, 30 and 60 days of ensiling, and then, the fermentation quality and aerobic stability were analyzed. During ensiling, high density had the highest lactic acid content, and the lowest pH and ammonia nitrogen. There was no difference (p > 0.05) in the propionic acid, butyric acid and ethanol contents among all silage, and the contents of propionic acid and butyric acid were trace amounts. On day 60 of ensiling, the Flieg's point of high density and medium density were higher than the low density. During aerobic exposure, the continuous lactic acid decrease and pH increase were observed in all silage. The aerobic bacteria and yeasts count in the high density and medium density were lower than that in the low density. The aerobic stability of the high density (26 h) and the medium density (24 h) were higher than that of the low density (13 h). It was suggested that if the ensiling density is higher than 600 g/L, it could effectively improve the fermentation quality and aerobic stability of rice straw. [ABSTRACT FROM AUTHOR]