Search

Bone allografts were used in our department since twenty-five years to reconstruct segmental bone loss and our data were retrospectively reviewed to assess the complications related to the use of a bone allograft. A consecutive series of 128 patients who received a bone allograft was analyzed. The minimal follow-up was 18 months. Fracture, nonunion, infection and explantation were investigated using a multivariate analysis and logistical regression. Kaplan-Meier survival of the allograft was performed, using allograft removal as the end point. Tumour disease was excluded from this study. Patients were followed up for an average 103 months. Bone tumour occurred in 78% of the patients whereas revision arthroplasty was the cause of implantation in 15% of them. Nonunion was the most prevalent complication, occurring in 35% of the grafts. For nonunion occurrence, the type of reconstruction was found to be a significant variable, the intercalary allograft being the most exposed. Primary bone autografting at the anastomotic site was not significant to prevent nonunion. Fracture of the allograft was the second most frequent complication with a prevalence of 16.4%. The length of the allograft and an osteoarticular allograft were two significant variables in that occurrence. Infection of the allograft was present with a rate of 5.4% of patients. Explantation of failed allografts occurred in 30% of them. The duration of the frozen storage of the allograft and the donor age of the allograft were not significant on any local complication occurrence. Bone allografts are a reliable material but a high rate of local complications must be anticipated.

Bone and tissue allografts are widely used in transplantation. The increasing demand for safe allografts must be met, while minimizing disease transmission. We analysed the incidence and potential risk factors of allograft contamination and the effectiveness of disinfection, by reviewing 22 years of tissue bank activity and 474 donor procurements. We also compared different disinfection procedures used over the 22 years. The overall contamination rate was 10.1%. Risk factors were related to the donor or procurement method. Immediate culture at the tissue recovery site diminished the rate of false positives by reducing later sample manipulation. High-virulence allograft contamination was mainly related to donor factors, while low-virulence contamination was related to procurement methods. Analysis of donor-related risk factors showed no statistical differences for age, sex, or cause of death. An intensive care unit stay was associated with less contamination with high-virulence microbes. Procurement in a setting other than an operating theatre was associated with higher contamination rate. Team experience reduced contamination. Pelvic and tendon allografts were most frequently contaminated. Proper disinfection considerably reduced the contamination rate to 3.6%. We conclude that procurement must be performed under aseptic conditions, with short delays, and by trained personnel. Grafts should be disinfected and packed as soon as possible.

Adipose tissue was only recently considered as a potential source of mesenchymal stem cells (MSCs) for bone tissue engineering. To improve the osteogenicity of acellular bone allografts, adipose MSCs (AMSCs) and bone marrow MSCs (BM-MSCs) at nondifferentiated and osteogenic-differentiated stages were investigated in vitro and in vivo. In vitro experiments demonstrated a superiority of AMSCs for proliferation (6.1±2.3 days vs. 9.0±1.9 days between each passage for BM-MSCs, respectively, P<0.001). A significantly higher T-cell depletion (revealed by mixed lymphocyte reaction, [MLR]) was found for AMSCs (vs. BM-MSCs) at both non- and differentiated stages. Although nondifferentiated AMSCs secreted a higher amount of vascular endothelial growth factor [VEGF] in vitro (between 24 and 72 h of incubation at 0.1-21% O(2)) than BM-MSCs (P<0.001), the osteogenic differentiation induced a significantly higher VEGF release by BM-MSCs at each condition (P<0.001). After implantation in the paraspinal muscles of nude rats, a significantly higher angiogenesis (histomorphometry for vessel development (P<0.005) and VEGF expression (P<0.001)) and osteogenesis (as revealed by osteocalcin expression (P<0.001) and micro-CT imagery for newly formed bone tissue (P<0.05)) were found for osteogenic-differentiated AMSCs in comparison to BM-MSCs after 30 days of implantation. Osteogenic-differentiated AMSCs are the best candidate to improve the angio-/osteogenicity of decellularized bone allografts., (Copyright © 2011 Elsevier Ltd. All rights reserved.)

Background: After a tumor resection, the reestablishment of the bone continuity at the forearm remains a challenge for restoring the biomechanics of hand and elbow. Bone allograft might be one option to consider amongst other suitable alternatives but there are insufficient data available to substantiate its value., Patients and Methods: We retrospectively investigated a series of 10 consecutive patients that had presented a bone tumor at the forearm. After bone excision, the segmental loss was replaced either by a bone allograft or an osteochondral allograft. Patients were reviewed clinically and with radiographs., Results: The mean follow-up was 110 ± 99 months. Fracture of the allograft was the most prevalent complication occurring in four patients, mainly in the osteoarticular group. Four patients were surgically revised: two of them had a fracture of the allograft that required a new one, another one had a painful stiff wrist requiring removal of the allograft and arthrodesis with autograft and the fourth one had a non-union of an intercalary allograft that was treated by a distal ulnar joint resection. Intercalary allograft had fewer complications than osteoarticular allografts and they had a better functional MSTS score with an average of 79% of a normal function compared to osteoarticular allografts with an average score of 62%. There was no infection. At the latest follow-up, one reconstruction of the forearm with an allograft failed and concerned the distal radius joint., Discussion: A bone allograft when available can be considered as one amongst other suitable options for the reconstruction of the forearm skeleton., (Copyright © 2011 Elsevier Masson SAS. All rights reserved.)

Background and Purpose: Massive bone allografts are used when surgery causes large segmental defects. Shape-matching is the primary criterion for selection of an allograft. The current selection method, based on 2-dimensional template comparison, is inefficient for 3-dimensional complex bones. We have analyzed a 3-dimensional (3-D) registration method to match the anatomy of the allograft with that of the recipient., Methods: 3-D CT-based registration was performed to match the shapes of both bones. We used the registration to align the allograft volume onto the recipient's bone. Hemipelvic allograft selection was tested in 10 virtual recipients with a panel of 10 potential allografts, including one from the recipient himself (trap graft). 4 observers were asked to visually inspect the superposition of allograft over the recipient, to classify the allografts into 4 categories according to the matching of anatomic zones, and to select the 3 best matching allografts. The results obtained using the registration method were compared with those from a previous study on the template method., Results: Using the registration method, the observers systematically detected the trap graft. Selections of the 3 best matching allografts performed using registration and template methods were different. Selection of the 3 best matching allografts was improved by the registration method. Finally, reproducibility of the selection was improved when using the registration method., Interpretation: 3-D CT registration provides more useful information than the template method but the final decision lies with the surgeon, who should select the optimal allograft according to his or her own preferences and the needs of the recipient.

Background: Impaction bone grafting with large particles is considered as mechanically superior to smaller morsels. Interest of freeze-dried irradiated bone for impaction bone grafting has been observed with small particles. Influence of bone process on other particle sizes still needed to be assessed., Material and Methods: Twenty-four osteoarthrotic femoral heads were used to prepare fresh-frozen and freeze-dried irradiated cancellous bone. Each group was divided into four batches of different particle sizes, each batch containing 18 samples. The different particle sizes were obtained with a Retsch Cross Beater Mill SK 100, Noviomagus rotating bone mills with two sizes of rasps and a Luer bone rongeur. Bone grafts were impacted in a contained cylinder. Stiffness was monitored during impaction., Results: Freeze-dried irradiated grafts showed higher stiffness than fresh-frozen bone whatever the size of the particles. Large particles obtained with the rongeur and the large rasp from the Noviomagus bone mill were mechanically superior than small particles up to 30 impactions., Interpretation: Large particles offer better mechanical performance as a greater magnitude of force would be required to deform and break the particles. Freeze-dried irradiated bone brittleness reduces this advantage after 30 impactions. Large particles embrittlement leads to similar mechanical results as small particles at higher impaction rate. This may account for partial collapse of the graft layer in clinical situation when impaction rate is lower. This model supports the use of small particles obtained with thin rasp bone mill when freeze-dried irradiated bone for impaction bone grafting and large particles obtained with the Rongeur when fresh-frozen bone is available.

Background and Purpose: Osseous pelvic tumors can be resected and reconstructed using massive bone allografts. Geometric accuracy of the conventional surgical procedure has not yet been documented. The aim of this experimental study was mainly to assess accuracy of tumoral resection with a 10-mm surgical margin, and also to evaluate the geometry of the host-graft reconstruction., Methods: An experimental model on plastic pelvises was designed to simulate tumor resection and reconstruction. 4 experienced surgeons were asked to resect 3 different tumors and to reconstruct pelvises. 24 resections and host-graft junctions were available for evaluation. Resection margins were measured. Several methods were created to evaluate geometric properties of the host-graft junction., Results: The probability of a surgeon obtaining a 10-mm surgical margin with a 5-mm tolerance above or below, was 52% (95% CI: 37-67). Maximal gap, gap volume, and mean gap between host and graft was 3.3 (SD 1.9) mm, 2.7 (SD 2.1) cm3 and 3.2 (SD 2.1) mm, respectively. Correlation between these 3 reconstruction measures and the degree of contact at the host-graft junction was poor., Interpretation: 4 experienced surgeons did not manage to consistently respect a fixed surgical margin under ideal working conditions. The complex 3-dimensional architecture of the pelvis would mainly explain this inaccuracy. Solutions to this might be to increase the surgical margin or to use computer- and robotic-assisted technologies in pelvic tumor resection. Furthermore, our attempt to evaluate geometry of the pelvic reconstruction using simple parameters was not satisfactory. We believe that there is a need to define new standards of evaluation.

The use of massive bone allografts is increasing year by year and selection method remains unchanged. Superposition of patient's radiograph over allograft image and comparison of distances is the gold standard. Experiment was led to test selection procedure of a major european tissue bank. Four observers were asked to select an allograft for 10 fictive recipients. Nine allografts were provided. To simulate a perfect allograft, recipient himself was inserted in the pool of allografts (trap graft). The 10 potential bone transplants were classified in four categories (from adequate to unacceptable). In addition, observers were asked to choose the three best grafts for a given recipient. Quadratic kappa measuring agreement on classification between two observers ranged between 0.74 (substantial) and 0.47 (moderate). Trap graft was quoted by observers as adequate four times (10%) and was cited eight times (20%) among the three best matching allografts. None of the observers discovered that recipient was among allograft panel. This study demonstrates that current selection method is inaccurate for hemipelvic allograft selection. New methods should be developed and tested to assist tissue banks in bone allograft selection.

Autograft harvesting in a growing child sometimes leads to disastrous consequences. Allograft can advantageously replace autograft in the majority of the cases. This overview presents the most frequently used allografts in paediatric orthopaedic surgery and discusses their benefits. Illustrative cases are presented to highlight specific indications.

Reconstruction of a major bone loss remains a challenge for the orthopaedic surgeon. Most of the bone defects result from a bone tumour resection whereas a post-traumatic bone loss is more rare due to the numerous options available for bone fixation. However in high-energy trauma, the injury to bone may be so extensive as to justify removal of fragmented bone. A 57-year-old man presented with a severe injury at the thigh after a hunting accident, including a comminuted fracture of the femoral shaft. After thorough debridement, he was left with a large diaphyseal bone defect which was subsequently treated with a structural bone allograft, autogenous graft and rhBMP-7. Bone healing was achieved after several months.

Bone allografts can be used in any kind of surgery involving bone from minor defects to major bone loss after tumour resection. This review describes the various types of bone grafts and the current knowledge on bone allografts, from procurement and preparation to implantation. The surgical conditions for optimising the incorporation of bone are outlined, and surgeon expectations from a bone allograft discussed.

Background: Reconstruction of the pelvic arch after resection of a malignant pelvic tumor remains a major surgical challenge because of the high rate of associated complications. The purpose of this investigation was to assess the functional outcome and complication rate following treatment with a bone allograft to reconstruct the pelvis., Methods: Twenty-four consecutive patients underwent excision of a malignant pelvic bone tumor and reconstruction with a pelvic bone allograft. The living patients were followed for a minimum of twenty-four months. There were nineteen primary malignant bone tumors, sixteen of which were high-grade sarcomas, and there were five isolated metastases. Patients were examined clinically and radiographically and were assessed functionally with the Musculoskeletal Tumor Society score., Results: The mean age of the patients at the time of the index surgery was thirty-four years, and the mean duration of follow-up was forty-one months. Eighteen of the twenty-four resections involved the periacetabular area and were followed by reconstruction either with a hip prosthesis (thirteen) or with an osteochondral allograft alone (five). The six other resections involved the iliac bone. All patients received a massive bone allograft that had been sterilely procured without secondary irradiation. At the time of our last evaluation, eight patients were alive and free of disease. Seven patients had a local recurrence. Neurological deficits were present in six patients, and three had a deep infection. Nonunion of three of the sixteen allografts that could be evaluated was observed. Neither graft fracture nor lysis was observed. Eleven patients underwent surgical revision, with nine of these revisions related to the reconstruction. The average Musculoskeletal Tumor Society score at the time of the latest follow-up was 73% of the maximal possible score. The average score was 82% for the eleven patients with an age of less than twenty years at the time of the index procedure and 65% for the thirteen older patients. Ten patients walked without any assistive device, and five of them had normal function with no or only a slight limp., Conclusions: Pelvic reconstruction after a limb-sparing resection is associated with a high risk of surgical complications and usually should be reserved for patients with a primary bone sarcoma. A pelvic allograft can restore the anatomy and provide good functional results, especially in young patients. Nonunion was the most common allograft-related complication.

Autograft is considered as the gold standard in bone grafting. However, the development of tissue banks has allowed for a wider use of bone allografts, with good results. Demineralised Bone Matrix (DBM) and recombinant human Bone Morphogenetic Proteins (rh-BMP's) were also introduced to replace the time-honoured autograft. Is there currently still a place for bone autograft? The authors reviewed the orthopaedic surgical activity in their institution during the period 2003-2005, and traced all the surgical procedures in which bone grafting was performed. Tracking forms from the tissue bank were reviewed to assess the surgical indications. Between 2003 and 2005, the use of autografts decreased from 1.3% to 0.9% of all surgical interventions, particularly owing to their decreased use in primary fusions, while the use of allografts increased from 10.7% to 12.7%. Indications for allografts covered all fields of orthopaedic surgery, including nonunions. Processed allografts represented 90% of all grafts used. DBM and rh-BMP were used on an exceptional basis. There is currently a trend for surgeons to use allografts as substitutes for autografts, as processing of the allografts increases their safety while preserving most of their biological and mechanical properties. Autografting is now limited to revision operations after failed fusions, and to combined use at the junction with massive allografts. DBM and rh-BMP are still controversial but they might replace autografts, even in their currently remaining indications, if their cost effectiveness and efficiency are established.

Background: On the assumption that an aneurysmal bone cyst has an intrinsic potential to heal by ossification, a new, minimally invasive protocol was developed. Demineralized bone powder mixed with bone-marrow aspirate was introduced into the cyst to halt the expansion phase and to allow the cyst to ossify. We hypothesized that, in order to induce bone-healing, cells from the cyst are needed to respond to the inductive material but that curettage or extensive surgery is not necessary. The goals of the present study were to assess cyst-healing and to determine the prevalence of recurrence associated with this new procedure., Methods: Thirteen biopsy-proven primary aneurysmal bone cysts were entered through a small incision, and a paste of demineralized bone and autologous bone marrow was introduced with an applicator. The study group included three male and ten female patients with a mean age of 16.6 years. The cyst was located in a long bone in six patients, the pelvis in five patients, and the scapular glenoid and the calcaneus in one patient each. Five patients had not received treatment previously, whereas one had had a preoperative embolization and seven had recurrent lesions that had been treated previously., Results: After a mean duration of follow-up of 3.9 years, healing was achieved in eleven patients., Conclusions: This minimally invasive method is able to promote the self-healing of a primary aneurysmal bone cyst. As no curettage is required, the proposed treatment avoids extensive surgery and blood loss and is convenient for the treatment of poorly accessible lesions such as those occurring in the pelvis., Level of Evidence: Therapeutic Level IV.

Fractures and nonunions are the main complications associated with bone allografts. Although the osteogenic role of recombinant human bone morphogenetic proteins (rhBMPs) has been demonstrated in experimental models and human tibial nonunions, the results are unknown for allograft nonunions. In this study, the efficacy of rhBMPs was evaluated in nonunions of femoral allografts. The results of six allograft nonunions in five patients who underwent resection of malignant bone tumours and allograft bone transplantation were analysed one to five years following application of rhBMPs at the nonunion site. There were two osteoarticular allografts and three intercalary allografts. Of three intercalary allografts, one demonstrated nonunion at both ends. Four patients received adjuvant chemotherapy and three had additional radiation therapy. There were two allograft fracture nonunions and four nonunions at the allograft-host junction. Two allograft fracture nonunions and one nonunion at the allograft-host junction were treated with 12 mg of rhBMP-2. The remaining three nonunions were treated with 7 mg of rhBMP-7 (Osigraft). The outcome and radiological evidence of healing were evaluated at a minimal follow-up of twelve months. There was neither healing of allograft fractures nor union of allograft-host junction. There was elongation or enlargement of the callus from the host. One patient continued to develop resorption of the allograft, which led to allograft fracture. Two patients who were treated with rhBMP-7 and corticocancellous allografts developed sterile drainage. There was no tumour recurrence with the use of rhBMPs after a mean follow-up of 39+/-25 months. rhBMP's alone were not sufficient to achieve healing in allograft nonunions and fractures following wide resection including periosteum and soft tissues.

Background: The need for safe bone allografts is increasing and preservation of femoral heads from patients being operated on with hip arthroplasty should be encouraged. However, should we preserve femoral heads from patients operated on for neck fracture as tissue mechanical quality may not be satisfactory?, Material and Methods: We compared the evolution of stiffness and compactness of fresh-frozen morselized bone obtained from osteoarthrotic femoral heads and those from neck fractures. Both materials were also compared after freeze-drying and irradiation. We used 6 osteoarthrotic and 6 neck-fracture femoral heads to prepare 4 batches of morselized bone. 18 samples from each batch were impacted in a contained cylinder. Frozen bone grafts were tested after thawing at room temperature for 2 hours and freeze-dried grafts were tested after 30 minutes of rehydration., Results: The stiffness of fresh-frozen neck fracture bone was lower than that of fresh-frozen osteoarthrotic bone at 150 impactions. The stiffness of freeze-dried irradiated bone was higher than that of the fresh-frozen bone and did not differ between osteoarthrotic and neck-fracture bone., Interpretation: Solvent-treated freeze-dried bone from femoral heads procured during arthroplasty for sub-capital hip fractures represents a valuable source of material for allografts, addressing concerns regarding serological testing, medical history and bone quality.

Background: Defatted bone chips with or without freeze-drying and irradiation have mechanical advantages as compared to fresh-frozen controls in in vitro models of impaction. These improved results have been ascribed to replacement of viscous bone marrow by saline and embrittlement of the freeze-dried bone by irradiation., Material and Methods: To determine which of these hypotheses is correct, we compared the development of stiffness and compactness of morselized bone graft that had been: 1) fat-reduced with saline, and 2) fresh-frozen, solvent-detergent defatted, 3) freeze-dried irradiated and 4) not irradiated. We used 12 osteoarthrotic femoral heads to prepare these four batches of morselized bone, and impacted 18 samples from each batch in a cylinder. The frozen bone grafts were tested after thawing at room temperature for 2 hours and the freeze-dried grafts were tested after 30 minutes of rehydration. We monitored the development of compactness and stiffness of the material during impaction., Results: The stiffness of the freeze-dried irradiated bone was greater than that of the other three series after 10, 50 and 150 impactions. The freeze-dried bone chips that were not irradiated and the chips defatted with saline alone were less stiff than the fresh-frozen control after 150 impactions., Interpretation: The brittleness of freeze-dried irradiated bone, caused by loss of the capacity to absorb energy in a plastic way, increases the compactness and stiffness of the morselized grafts. Washing bone with saline alone or treating bone with solvent-detergent but no irradiation had no similar mechanical advantage and the bone did not impact better than fresh-frozen undefatted bone in our model.

Processed freeze-dried irradiated allografts seem to be used less than instead of fresh-frozen allografts for impaction bone grafting in revision hip arthroplasties. Although biologically acceptable, their use is discouraged because of their questionable mechanical properties following freeze-drying and irradiation procedures. To address this question, we impacted freeze-dried grafts in 6 cadaveric femurs and loaded with a cemented Charnley prosthesis. The routinely used fresh-frozen allografts were used as controls in the contralateral side. These constructs were compared simultaneously in a walking hip simulator for their stability during 900,000 loading cycles. The mechanical parameters were axial inducible displacement and subsidence of the implant. The former parameter was lower in the implant mounted on freeze-dried impacted grafts than that mounted on the fresh-frozen bone. The latter parameter was also lower in the freeze-dried group. At the end of the test, we found no implant loosening in either group and their 'pull out' resulted in cement-prosthesis debonding, which showed the mechanical integrity of the impacted grafts. Freeze-dried grafts provide more stable fixation of the stem than fresh-frozen morselized grafts, when tested in a hip simulator.

In the technique of impaction bone grafting, implant stability depends on the mechanical properties of the impacted morselized grafts. Although the procedure is usually performed with fresh-frozen femoral heads, there is still some concern about their supply and safety. Bone processing is a potential solution, but the mechanical properties of this material during and after impaction need to be determined. We used 6 osteoarthrotic femoral heads to prepare two paired batches of morselized bone. One batch was morselized and frozen. The other batch was chemically treated, morselized, freeze-dried and then gamma-irradiated. We impacted 18 samples from each batch in a contained cylinder. Freeze-dried bone grafts were tested after 30 minutes of rehydration. The changes in the compactness and stiffness of the material were monitored during the impaction. The compaction of the freeze-dried bone was faster than that of their fresh-frozen control. The maximal stiffness reached by both materials was the same (55 MPa), but the freeze-dried grafts required three to four times fewer impactions to achieve that stiffness. After 3, 10 and 50 impactions the freeze-dried bone was stiffer than the fresh-frozen bone. As it is easier to impact, the freeze-dried bone may be mechanically more efficient than the fresh-frozen bone in surgical conditions. Moreover, the processed bone meets the highest safety standards, as regards the risk of disease transmission.

The incorporation of a bone graft is the result of creeping and substitutional activities that remove the original grafted bone and replace it by newly formed bone from the host cells. However, this intricate process is very limited in time and space. A bone allograft is poorly remodeled and is almost non viable even after several years of implantation. This lack of vitality accounts for the high rate of complications such as non union and fracture. One way to minimize the allograft complications is to improve its incorporation. The process of incorporation in animals and human beings is reviewed as well as the various avenues for a biologic improvement either through modulation on the host: the immune response, the inhibition of bone resorption, the use of bone morphogenetic proteins, the autogenous cell augmentation or through processing the bone allograft: bisphosphonate adsorption or bone perforations. In 2002, biologic enhancement of the incorporation is still in its infancy but will be in a near future a reality through influence on both the host and the allograft.

The authors review the various bone substitutes which are currently available on the market place in Belgium. After describing the requirements for clinical use of such materials, they compare the biological and mechanical values of bone autografts, bone allografts, demineralised bone, xenografts, coral and synthetic materials such as calcium sulfate, calcium phosphate, ionic cement and bioactive glass. They stress the current paucity of data pertaining to the biological value of these materials and call for in vivo validation tests. They also review biomolecules such as BMP-2 or OP-1, whose osteoinductive properties are currently under investigation. Finally, they present the emergent field of cell therapy, in which osteoprogenitor cells are isolated from the patient's bone marrow and reinjected after in vitro cultivation. They stress the therapeutic and medicolegal problems raised by the combination of medical devices, grafts, medicinal products and cells, all of which have a different status within the complex European legal framework.

The incorporation of perforated cortical bone allografts was compared with non-perforated allografts. A 5-cm circumferential defect in the middiaphysis at the tibia was created in adult sheep. A frozen tibial allograft was implanted and fixed with a locked nail for 6 months. There was no postoperative immobilization. Group I consisted of eight sheep with non-perforated allografts, whereas Group II was comprised of 10 sheep with perforated allografts. Union was evaluated radiographically, whereas the central part of the allograft had a densitometric evaluation. Creeping substitution was assessed on microradiographs from cross-sections of the central 3 cm of graft by measurement of porosity and percentage of new and old bone area within the confines of the graft. The width of periosteal and endosteal callus also was determined. There was no statistical difference between both groups for the union score and bone density. However, the cortical bone graft porosity and the amount of new bone within the cortical bone differed significantly between the perforated allografts and the non-perforated ones. Periosteal callus was similar in both groups, whereas endosteal callus was significantly more wide and extended in the perforated allografts. Perforation of a cortical bone substantially improved the amount of newly formed bone by the host when compared with a non-perforated bone. The creation of channels seemed to increase the interface between living soft tissues of the host and the allografted bone with a resulting enhanced incorporation.

The mechanical properties of the impacted material is important when using impaction bone grafting in revision arthroplasty. We did an in vitro study to monitor the stiffness and compactness of morsellized bone grafts during impaction. Using human osteoarthrotic femoral heads as the bone source we prepared 3 types of morselized grafts with the same bone mill: (1) purely cancellous grafts, (2) cortico-cancellous grafts and (3) cortico-cancellous bone with cartilage remnants. 5 g of bone samples were progressively impacted up to 150 times in a contained cavity. All types of grafts became stiffer and stiffer during the first 30 impactions. After 30 impactions, the grafts' compactness continued to increase slowly without concomitant changes in their stiffness. Over-impaction was not useful, but did not jeopardize the implant stability. The presence of cartilage remnants considerably compromised the increase in stiffness. In contrast, the addition of cortical bone from the femoral neck did not affect the impaction and resultant stiffness.

An overview of bone grafts and, in particular, the allografts is presented. The availability of bone allografts, has promoted their use at the expense of the autograft. However, the loss of the cellular activity in an allograft, makes them less performant than an autograft. The use of an allograft in a small size defect can be advocated provided that the implantation technique is stringent. In case of a large segmental bone defect, an allograft can be considered whereas an autograft is not anymore possible. A massive bone allograft allows an anatomical reconstruction and the preservation of strong tendon insertions. In tumor surgery, a bone allograft has become one of the best options to reshape the skeleton. To offset the poor remodeling of the massive bone allografts, and to improve the take of small size bone allografts, researches are presently carried on, using tissue engineering in order to recover a cellular population. The aim is to combine an acellular bone graft with the cells of the recipient. Cells are procured from the bone marrow. Stromal cells are isolated, cultured, so that they will grow with an osteoblastic phenotype. They can be used alone or in association with a bone graft. It is believed that tomorrow such cellular therapy will become a routine procedure.

Ten femoral heads (six patients) with avascular necrosis were operated on using a fibular allograft. The procedure included core decompression followed by insertion of a cortical bone graft in order to relieve mechanical stresses from the overlying subchondral bone. The presence of the supporting graft should avoid an expected collapse or prevent its worsening if already present. A freeze-dried and processed cortical bone allograft was preferred to an autograft. Weightbearing was normally and fully resumed at the second postoperative month. There were three failures within the first year, four satisfactory results, in which the hip was replaced after 4 years while there are still 3 hips that have been preserved from arthroplasty in young patients after 5 years. The technique is easy and able to substantially delay an arthroplasty in an active patient.

We compared the reliability of computer-assisted radiographic analysis (CARA) and visual evaluation of radiographs to assess host-graft junctions. 68 host bone/allograft junctions were obtained from an ongoing study on bone allografting in sheep. At 6 months, the grafted tibias were explanted and healing of the host-graft junctions were macroscopically determined. 49 junctions were macroscopically healed, whereas 19 had not united. 51 (0.8) of the junctions were correctly classified by radiographs, while 63 (0.9) of the junctions were correctly classified by CARA (p = 0.03). These findings warrant further evaluation in a clinical setting.

We examined the influence of ethylene oxide (EO) and gamma irradiation on the osteoinductive capacity of demineralized bone. Demineralized bone powder prepared from Wistar rats was exposed to EO (55 degrees C or 40 degrees C) or gamma irradiation (25 KGy) or was preserved in ethanol. Sterilely-prepared bones served as controls. The powder was packed in a gelatin capsule and implanted for 6 weeks in muscles of 6-week-old female rats. Exposure of demineralized bone particles to EO 55 degrees C resulted in an almost complete loss of osteoinductivity. Irradiated bones lost about 40% of their osteoinductive capacity, while sterilization with EO at 40 degrees C resulted in only a slight alteration of the osteoinductivity, as assessed by the recovered weight ratio, calcium content, alkaline phosphatase activity measurements and histomorphometry. Ethanol treatment had no influence on the new bone yield when compared to controls. As EO exposure at 40 degrees C is a true sterilization procedure, it can be recommended in a clinical setting for its small effect on osteoinductive capacity as assessed experimentally in rats.

In order to assess the potential influence of various physical or chemical treatments on bone grafts, and in particular, on femoral heads to be used as bone grafts, the mechanical symmetry of the femoral head was investigated. Pairs of proximal human femora were harvested and transversally sliced using a coordinate system to orient correctly the head. After being embedded and polished, bone slices were loaded to failure between two steel columns (6 mm of diameter) in a sequential and symmetrical manner for both heads. From ten pairs, 592 mechanical assays on the cancellous bone of femoral heads were performed. There was a high variation in the mechanical properties of the specimens from the different donors. However, no statistical difference could be observed within each pair when side-to-side symmetry was tested for the different mechanical characteristics. Ultimate stress at failure and stiffness were also highly correlated for each mirror location of each pair. Provided that an accurate and reproducible method of slicing femoral head can be achieved, an excellent mechanical symmetry is observed using a static compressive test. Such a method could be used to determine the mechanical influence of any treatment applied to bone.

Two cases of induced healing of aneurysmal bone cyst (ABC) following intralesional implantation of a bone paste made of autogeneic bone marrow and allogeneic bone powder are reported. The calcaneum in one case and the superior pubic ramus in the other were blown out by an ABC and would have required extensive surgery. Via a minimal exposure, the cyst was partially evacuated and filled with an admixture of a partially demineralized bone particles with bone marrow. Ossification of the peripheral shell was the first sign of healing and was observed within the first 3 postoperative months. Successful healing was observed in both cases. The rationale underlying this intralesional treatment was that the bone grafting material might reverse ABC expansion by promoting ossification through a bone induction mechanism. The concept of this treatment was to retain the ABC tissue, using its own intrinsic osteogenic potential to promote healing. By triggering intralesional new bone formation, the bone paste represented an effective means to reverse the expanding phase of ABC. The particulated bone allograft was easy to handle and to introduced in an irregular cavity. Moreover, as a complete cyst evacuation was not required, a minimal surgical approach could be used so that the risks and morbidity associated with an extensive approach were reduced. Its use is of particular interest in poorly accessible areas like the pelvis and spine.

We retrospectively investigated the fate of bone auto- and allografts in 64 patients who underwent a tibial tubercle elevation with bone graft. Half of them received an autograft and the other half, an allograft that had been processed and freeze-dried. The two groups had similar preoperative characteristics concerning age, sex and pathology. Roentgenograms were reviewed by three independent observers and scored for fusion, resorption and collapse. Clinical charts were analysed for different variables. The overall radiological score for both groups did not differ statistically. Comparison of graft fixation with one or two screws demonstrated more bone resorption in the case of a single-screw fixation. In such a case, the occurrence of a preoperative tubercle fracture had a significant adverse influence, due to a less stable fixation. From the clinical charts review, only the mean stay at hospital was significantly shorter when an allograft was performed. A bone allograft appears to be suitable to maintain an osteotomy but requires a more careful surgical technique fixation to obtain a similar result to an autograft.

Two groups of 36 patients who underwent posterior vertebral fusion for scoliosis were compared retrospectively; the postoperative follow-up was 2 years. Autogenous bone taken from the iliac crest was used in group A, whereas the patients in group B received freeze-dried allograft from our bone bank. There was no significant difference between the two groups in maintenance of the curve correction after the same delay, nor in incidence of complications. A reduction of blood loss or operating time, however, could not be demonstrated in our study.

Incorporation of massive cortical bone allografts in the human is slow and remains incomplete. Late biopsies of implanted allografts or histological studies of explanted allografts always show the partial substitution of necrotic bone by new bone from the host. The aim of the present study was to evaluate the value of drilling the massive deep-frozen cortical allografts in order to induce osteogenesis. Thirteen sheep were operated on and a standard segment of the proximal ulna was removed and the gap filled either by an unperforated allograft or by a perforated one. Based on histological and microradiographic examination, a complete substitution of the perforated allografts was observed but in this model no statistically significant difference was observed between perforated and unperforated allografts. Further study is needed to assess the effect of the perforations.

Cortical bone grafts were implanted for six months in mature dogs using an osteoperiosteal 3-cm defect in the ulna to evaluate their respective morphometric and physical values compared with autografts. The bone-grafting material included fresh auto- and allografts, frozen and thimerosal preserved allografts, and partially demineralized bone allografts. The grafts were evaluated by roentgenograms, microradiograms, photon absorptiometry, porosity, fluorescence labeling measurements, and torsional loading at failure. Autografts achieved a better union score than the allografts, but intracortical bone porosity, percentage of cumulative new bone, and mineral apposition rate were not variables with statistical significance. Lamellar bone was found earlier and in greater quantity in autografts. Within the graft, new bone was deposited at a slower rate than in the recipient bone. Autografts showed less peripheral resorption and a greater torsional resistance than allografts. Photon absorptiometry demonstrated that nondemineralized allografts underwent a substantial loss of peripheral bone. This marked reduction in the outer diameter of the graft had more influence on torsional resistance than did the intracortical porosity of the graft. Demineralized allografts were osteoinductive in only 28% of the cases and appeared to respond in an all-or-nothing pattern. Frozen and thimerosal preserved allografts were the most acceptable substitutes to autografts.

Incorporation of massive cortical bone allografts in human is slow and remains incomplete. Late biopsies of implanted allografts or histological studies of explanted allografts always show the partial substitution of necrotic bone by new bone from the host. The aim of the present study was to evaluate the effect of drilling the massive deep-frozen cortical allografts in order to induce osteogenesis. Thirteen sheep were operated on and a standard segment of the proximal ulna was removed and the gap filled either by an unperforated allograft or by a perforated one. Based on histological and microradiographic examination, a quite complete substitution of the perforated allografts was observed but in this model no statistically significant difference was observed between perforated and unperforated allografts. Further study is needed to assess the effect of the perforations.

Osteochondral allografting can restore the skeletal continuity anatomically after a limb salvage procedure. Evaluation of the clinical function indicates that a good result can be anticipated. Fracture was the most frequent complication, and the fixation technique we used initially predisposed the problem. The major advantage of allograft is the possibility of reinsertion of soft tissue to help stabilize the new joint. In addition, any part of the limb can potentially be reconstructed with an allograft.

Our experience with the bone banking methodology that we have used over the last years is reported. The technical and investigational aspects of the procurement, storage and treatment of the donor bone and related tissues are presented. For different purposes, we have prepared sterile and nonsterile procured implants. Appropriate donor selection and sterility controls remain the two major concerns of bone banking activities.

The authors present their experience with freeze-dried bone of human origin. Since 1983, 500 preserved allografts have been implanted in 228 patients. The implants were monitored radiographically and, based on perfect fusion with the recipient bone, the results were as follows: excellent: 78%; good: 8.6%; failure: 12.4%. In nearly all the cases of failure this was attributed to an erronous implant method or an improper use of the graft. Bank bone is only osteoconductive: thus, in the absence of osteogenetic properties, a perfect method of implant and its correct use are essential.

Three procedures to obtain bone inductive implants were tested heterotopically in 3-month-old allogeneic rats: 1) antigen-extracted HCl-decalcified at 4 degrees C, autolysed implant (AAA bone); 2) HCl-decalcified implant at 4 degrees C; 3) HCl-decalcified implant at room temperature. Each type of implant was either deep-frozen at -35 degrees C for at least 2 months or immediately freeze-dried. The bone inductive capacity of the differently HCl-decalcified cortical bone implant was evaluated at 2 months by isotopic strontium incorporation and by ash-weight measurements. Bone HCl-decalcification alone, either at 4 degrees C or at room temperature, gave a higher new bone yield than the freeze-dried AAA bone. The type or short-term preservation technique had no effect on the osteoinductive capacity of either of the differently treated implants, AAA bone expected.

Two stored frozen massive bone allografts were implanted after resection of femoral and tibial tumours in two patients. Eighteen and thirty months later the authors had the opportunity to make a microscopic examination of the grafts. The cortical bone grafts were incorporated by the classic "creeping substitution." The repair of the cortical transplant was very incomplete and showed large resorption cavities. The newly-formed living bone was not fully mineralized. These phenomena related only to the outer area of the cortical bone, the dead intra-cortical area being left unaffected by the process. Cancellous bone graft repair was faster and more efficient.

The authors share their experience of the use of allografts in the reconstruction of the tympano-ossicular chain. The implants were cut from the cortical substance of the long bone in patients deceased for a maximum of six hours; the donors were tested for syphilis, hepatitis, AIDS, systemic diseases or a neoplasm. These bone allografts were cut to size, degreased, demineralized, frozen and then lyophilized in order to be presented to the surgeon in a sterile container (Bone Bank). The implants were all tolerated well. The anatomical results were satisfactory. Optical microscopic studies showed that the implant was: a) covered with mucosa, b) full of osteoblasts and c) the site of a bone neoformation. Experimental research is currently underway in order to perfect the implant preparation methodology.

Massive deep-frozen bone allografts were implanted in 13 patients after en bloc tumor resection. Patients were followed up for 14 months to 17 years. Most of the reconstructive procedures included a segmental bone allograft with knee or ankle fusion. Graft infections were the most critical complications in regard to the end results, finally requiring amputation in two cases. There were three stress fractures; two of which were successfully treated without further complication. Graft incorporation was assessed by bone scintimetry in four cases. Isotope uptake by the center of the graft was found to be superior to control bone segments at only 15 years after surgery. Two recovered allograft specimens were available for a microradiographic study. Creeping substitution was a very slow process, initiated at the outer surface of the graft and characterized at 2-3 years after implantation by large, incompletely filled osteons. The present investigation demonstrates that massive bone allografts are very slowly revascularized and are intimately anchored by the host bone. Provided that tumor control is effective and graft infection is avoided, reconstructive surgery with massive bone allografts represents a successful alternative to prosthetic implants in young adult with a long life expectancy.

The authors present their current experience with stored bone grafts, using allografts shaped from the cortices of long bones for reconstructing the tympano-ossicular chain. The materials and the methods are described. The anatomical results have been good in 97% of the cases, while the functional results are as satisfactory as those obtained with bioceramics. In addition to ossiculoplasty, the bone allografts can also be used in otology for reconstructing large bony defects of the temporal bone.