Search

Underground brine waste containing high concentrations of ammonium and with a salinity of 3% is usually generated during the production of methane gas and iodine in the gas field of Chiba Prefecture, Japan. In this study, one swim-bed reactor, packed with a novel acrylic fiber biomass carrier (Biofringe), was applied to the partial nitritation treatment of this kind of underground brine waste. A stable nitrite production rate of 1.6 kg NO(2)-N m(-3) d(-1) was obtained under a nitrogen loading rate of 3.0 kg-N m(-3) d(-1), at a pH of 7.5 and a temperature of 25 degrees C. Nitrate production was negligible and the effluent NO(2)-N/NO(x)-N ratio was above 98% due to the successful inhibition of nitrite-oxidizing bacterial activity. Free ammonia was considered to be the main factor for inhibiting the activity of nitrite-oxidizing bacteria. A microbial community shift was demonstrated by 16S rRNA analysis, and it was shown that the ammonium-oxidizing bacteria became the predominant species after successful nitrite accumulation was observed.

In this study, combination of a partial nitritation reactor, using immobilized polyethylene glycol (PEG) gel carriers, and a continuous stirred granular anammox reactor was investigated for nitrogen removal from livestock manure digester liquor. Successful nitrite accumulation in the partial nitritation reactor was observed as the nitrite production rate reached 2.1 kg-N/m(3)/day under aerobic nitrogen loading rate of 3.8 kg-N/m(3)/day. Simultaneously, relatively high free ammonia concentrations (average 50 mg-NH(3)/l) depressed the activity of nitrite oxidizing bacteria with nitrate concentration never exceeding 3% of TN concentration in the effluent of the partial nitritation reactor (maximum 35.2 mg/l). High nitrogen removal rates were achieved in the granular anammox reactor with the highest removal rate being 3.12 kg-N/m(3)/day under anaerobic nitrogen loading rate of 4.1 kg-N/m(3)/day. Recalcitrant organic compounds in the digester liquor did not impair anammox reaction and the SS accumulation in the granular anammox reactor was minimal. The results of this study demonstrated that partial nitritation-anammox combination has the potential to successfully remove nitrogen from livestock manure digester liquor.

Effect of high salt concentration on the anammox treatment was investigated to establish an acclimation strategy under high salt concentration conditions. An anammox fixed-bed reactor with non-woven biomass carrier was used and the salt concentration was gradually increased from 2.5 g L− 1 to 33 g L− 1. The anammox reactor demonstrated stable nitrogen removal rate (NRR) of 1.7 kg-N m− 3 d− 1 for 65 days under a salt concentration of 30 g L− 1. However, the NRR sharply declined at a salt concentration of greater than 30 g L− 1. The bacterial community was examined by 16S rRNA gene analysis and DGGE after the acclimation of the anammox sludge to high salt conditions. Although the salt concentration was almost sea level, the freshwater anammox bacteria, KU2, were detected. In addition, the unidentified bacteria which perhaps belong to candidate division OP10 and Lysobacter sp. were found to coexist with anammox bacteria at a salt concentration of 30 g L− 1.

PVA-gel beads were used as a biocarrier in a lab-scale UASB reactor treating synthetic wastewater composed of corn steep liquor (CSL) with the aim of evaluating its use as a growth nucleus to enhance granule formation. Over 117 days of operation, the organic loading rate was increased to 22.5 kg COD/m 3 /day with an influent COD of about 10.8 g/L at an HRT of 12 h with COD removal efficiencies greater than 87%. By the end of the study period, the PVA-gel turned black and granule formation was achieved as compared with the formation of much fewer natural granules without the PVA-gel nucleus. No filamentous bacteria were found on the surface or interior of the PVA-gel beads. The PVA-gel granules had an average settling velocity 200 m/h (5 cm/s), and a biomass attachment of 0.93 g VSS/g PVA-gel. The required time for formation of PVA-gel granules was thus demonstrated to be shorter than that of ordinary sludge granules under the experimental conditions used in this study.