Search

In this study, combination of a partial nitritation reactor, using immobilized polyethylene glycol (PEG) gel carriers, and a continuous stirred granular anammox reactor was investigated for nitrogen removal from livestock manure digester liquor. Successful nitrite accumulation in the partial nitritation reactor was observed as the nitrite production rate reached 2.1 kg-N/m(3)/day under aerobic nitrogen loading rate of 3.8 kg-N/m(3)/day. Simultaneously, relatively high free ammonia concentrations (average 50 mg-NH(3)/l) depressed the activity of nitrite oxidizing bacteria with nitrate concentration never exceeding 3% of TN concentration in the effluent of the partial nitritation reactor (maximum 35.2 mg/l). High nitrogen removal rates were achieved in the granular anammox reactor with the highest removal rate being 3.12 kg-N/m(3)/day under anaerobic nitrogen loading rate of 4.1 kg-N/m(3)/day. Recalcitrant organic compounds in the digester liquor did not impair anammox reaction and the SS accumulation in the granular anammox reactor was minimal. The results of this study demonstrated that partial nitritation-anammox combination has the potential to successfully remove nitrogen from livestock manure digester liquor.

Effect of high salt concentration on the anammox treatment was investigated to establish an acclimation strategy under high salt concentration conditions. An anammox fixed-bed reactor with non-woven biomass carrier was used and the salt concentration was gradually increased from 2.5 g L(-1) to 33 g L(-1). The anammox reactor demonstrated stable nitrogen removal rate (NRR) of 1.7 kg-N m(-3) d(-1) for 65 days under a salt concentration of 30 g L(-1). However, the NRR sharply declined at a salt concentration of greater than 30 g L(-1). The bacterial community was examined by 16S rRNA gene analysis and DGGE after the acclimation of the anammox sludge to high salt conditions. Although the salt concentration was almost sea level, the freshwater anammox bacteria, KU2, were detected. In addition, the unidentified bacteria which perhaps belong to candidate division OP10 and Lysobacter sp. were found to coexist with anammox bacteria at a salt concentration of 30 g L(-1).

A swim-bed reactor using the biofringe acryl-fiber biomass carrier was used for partial nitritation treatment for anaerobic digestion liquor of swine wastewater. The sludge in the reactor demonstrated excellent settling properties, and the sludge volumetric index (SVI) was always about 50 ml g(-1). The mixed liquor suspended solids (MLSS) concentration was maintained above 10,000 mg l(-1) with a maximum of 16,800 mg l(-1). Satisfactory and stable partial nitritation was obtained at a nitrogen loading rate (NLR) of 1.9 kg-N m(-3) d(-1) without any operational control. Only a little nitrate was produced almost during the whole operational period and the nitrite to total oxidized nitrogen ratio (NO(2)-N/(NO(2)-N+NO(3)-N)) was always above 95%. In addition, the influence of temperature on partial nitritation efficiencies was also investigated and non-controlled efficiencies were maintained stably between 15 degrees C and 30 degrees C at an NLR of 1.9 kg-N m(-3) d(-1), but suddenly deteriorated when the temperature fell below 15 degrees C. Nitrite oxidizing bacteria were inhibited by free ammonia and free nitric acid, which prevented the conversion of nitrite to nitrate and the inhibition due to free nitric acid weaken with a decrease in temperature. It was apparent that these phenomena were crucial to the control of partial nitritation treatment.

Partial nitritation using inhibition of free ammonia and free nitric acid is an effective technique for the treatment of high concentrations of ammonium in wastewaters. This technique was applied to the digester liquor of swine wastewater and the stability of its long-term operation was investigated. Partial nitritation was successfully maintained at a nitrogen loading rate (NLR) of 1.0kgNm−3 d−1 for 120 days without acclimatization of nitrite oxidizing bacteria (NOB) to the inhibitory compounds (free ammonia and free nitric acid). The conversion efficiencies of NH4–N to NO2–N and to NO3–N were determined to be around 58% and <5%, respectively. After the establishment of partial nitritation, the influence of swine wastewater on the Anammox reaction was examined using continuous flow treatment experiments. Consistent nitrogen removal was achieved for 70 days at a nitrogen removal rate (NRR) of 0.22kgNm−3 d−1 and the color of Anammox bacteria changed from red to greyish black. The NO2–N consumption and the NO3–N production increased concurrently and the Anammox reaction ratio was estimated to be 1:1.67:0.53, which is different from that reported previously (1:1.32:0.26). [Copyright &y& Elsevier]