Search

Preserving the highly appreciated natural freshness of Aloreña de Málaga table olives and preventing their progressive darkening during processing is a major challenge. In this work, heat-shocked (60°C, 5 min) fruits were processed according to the three denominations referred to in the Protected Designation of Origen (cured, fresh green, and traditional) and their characteristics compared with those that followed the habitual industrial process (controls). The results revealed that the effects of the heat treatment on the evolution of pH, titratable acidity, salt, sugar, organic acid, ethanol content, texture, and color of fruits as well as on microbial populations (yeasts and lactic acid bacteria) were slight in the case of the fresh green and cured presentations. However, the differences between heat-shocked and its control were remarkable in the traditional process. Notably, the heat treatment favored lactic acid fermentation, retention of the green appearance of the fruits, stability during packaging, and led to the highest sensory evaluation. The metagenomic analysis carried out at the end of the fermentation revealed the presence in all samples of three genera (Lactobacillus, Pediococcus, and Celerinatantimonas) which encompassed most of the sequences. The number of Lactobacillus sequences was statistically higher (p ≥ 0.05) in the case of traditional heat-shocked fruits than in its control. [ABSTRACT FROM AUTHOR]

This work studies the inoculation conditions for allowing the survival/predominance of a potential probiotic strain (Lactobacillus pentosus TOMC-LAB2) when used as a starter culture in large-scale fermentations of green Spanish-style olives. The study was performed in two successive seasons (2011/2012 and 2012/2013), using about 150 tons of olives. Inoculation immediately after brining (to prevent wild initial microbiota growth) followed by re-inoculation 24 h later (to improve competitiveness) was essential for inoculum predominance. Processing early in the season (September) showed a favorable effect on fermentation and strain predominance on olives (particularly when using acidified brines containing 25 L HCl/vessel) but caused the disappearance of the target strain from both brines and olives during the storage phase. On the contrary, processing in October slightly reduced the target strain predominance on olives (70-90%) but allowed longer survival. The type of inoculum used (laboratory vs. industry pre-adapted) never had significant effects. Thus, this investigation discloses key issues for the survival and predominance of starter cultures in large-scale industrial fermentations of green Spanish-style olives. Results can be of interest for producing probiotic table olives and open new research challenges on the causes of inoculum vanishing during the storage phase. [ABSTRACT FROM AUTHOR]

A probabilistic/logistic model, based on binary data (growth/no growth), was used to assess the effects of sodium metabisulphite (SM) and cinnamaldehyde (CIN; 0-1000 mg/L) against the main microbial groups found in table olive environment [lactic acid bacteria (LAB), yeasts, and Enterobacteriaceae], according to pH (range 3.5-5.0), and type of acidifying agent (HCl or pyruvic acid). The inhibitory effect of SM depended on the pH while that of CIN was scarcely influenced by it (except for LAB). LAB were more sensitive to SM, while yeasts were to CIN. The use of pyruvic acid for correction of pH always produced a reduction (compared to HCl) of the inhibitory power of both preservatives. The in silico models for HCl showed that, at pH 4.0, and growth probability 0.01, the LAB population might be inhibited by the presence in the medium of 150 mg/L SM or 1000 mg/L CIN, while in the case of yeasts, 450 mg/L SM, or 150 mg/L CIN are required. No growth of Enterobacteriaceae was observed at this (or lower) pH level. The results obtained may contribute to the stabilization of non-thermally treated table olive packaging. [ABSTRACT FROM AUTHOR]

Aloreña de Málaga is a table olive especially characterised by its natural freshness and short shelf-life. In this work, we applied a metataxonomic approach to unravel the microbial diversity of bacterial and fungi populations through the shelf-life of traditionally packed Aloreña de Málaga. A significant increase in lactic acid bacteria and mesophilic aerobic populations was observed during shelf-life, reaching the maximum population levels (4–5 log10 CFU) at the end of the study (260 days). On the contrary, a rapid reduction in yeast and mould populations was reported. The use of a metataxonomic analysis based on the amplification of 16S (bacteria) and internal transcribed spacer (ITS) region (fungi) regions revealed a low diversity for both microbial groups. Lactiplantibacillus (65.05 ± 8.65% in brine vs. 58.70 ± 15.70% in fruit), Pediococcus (28.17 ± 7.36% in brine vs. 27.20 ± 15.95% in fruit), and Celerinatantimonas (4.64 ± 1.08% in brine vs. 11.82 ± 18.17% in fruit) were the main genera found among bacteria, and an increase in Lactiplantibacillus and a reduction in Celerinatantimonas populations during the shelf-life were observed. On the other hand, Citeromyces was the dominant fungi genus (54.11 ± 2.00% in brine vs. 50.91 ± 16.14% in fruit), followed by Candida (8.80 ± 2.57% in brine vs. 12.32 ± 8.61% in fruit) and Penicillium (6.48 ± 1.87% vs. 8.48 ± 4.43% in fruit). No food-borne pathogen genera were detected in any of the samples analysed, indicating the high level of food safety found in this ready-to-eat fermented vegetable. Data obtained in this work will help in the design of new strategies for the control of microbial populations during the shelf-life of Aloreña de Málaga. [ABSTRACT FROM AUTHOR]

The Clostridium sp. is a large group of spore-forming, facultative or strictly anaerobic, Gram-positive bacteria that can produce food poisoning. The table olive industry is demanding alternative formulations to respond to market demand for the reduction of acidity and salt contents in final products. while maintaining the appearance of freshness of fruits. In this work, logistic regression models for non-adapted and acid-adapted Clostridium sp. strains were developed in laboratory medium to study the influence of pH, NaCl (%) and time on the probability of germination of their spores. A Clostridiumsporogenes cocktail was not able to germinate at pH < 5.0, although the adaptation of the strains produced an increase in the probability of germination at 5.0–5.5 pH levels and 6% NaCl concentration. At acidic pH values (5.0), the adapted strains germinated after 10 days of incubation, while those which were non-adapted required 15 days. At pH 5.75 and with 4% NaCl, germination of the adapted strains took place before 7 days, while several replicates of the non-adapted strains did not germinate after 42 days of storage. The model was validated in natural green olive brines with good results (>81.7% correct prediction cases). The information will be useful for the industry and administration to assess the safety risk in the formulation of new processing conditions in table olives and other fermented vegetables. [ABSTRACT FROM AUTHOR]