Search

Some unidentified minor compounds have been observed in the residue from short-path distillation of transesterified palm oil that are not detected in the original palm oil. A method combining short-path distillation to enrich the unknowns with fractionation using solid-phase extraction is described. The fractionated components were identified using GC coupled with MS. The transesterified palm oil was found to contain methyl esters of up to C32 carbon atoms. In the very long chain FAME with carbon numbers ≥20, both even and odd carbon numbers accounted for 0.26 wt%, with C24 and C26 being the major ones present in the residue after short-path distillation of transesterified palm oil. [ABSTRACT FROM AUTHOR]

This paper discusses a rapid GC-FID technique for the simultaneous quantitative analysis of FFA, MAG, DAG, TAG, sterols, and squalene in vegetable oils, with special reference to palm oil. The FFA content determined had a lower SE compared with a conventional titrimetric method. Squalene and individual sterols, consisting of β-sitosterol, stigmasterol, campesterol, and cholesterol, were accurately quantified without any losses. This was achieved through elimination of tedious conventional sample pretreatments, such as saponification and preparative TLC. With this technique, the separation of individual MAG, consisting of 16∶0, 18∶0, and 18∶1 FA, and the DAG species, consisting of the 1,2(2,3)- and 1,3-positions, was sufficient to enable their quantification. This technique enabled the TAG to be determined according to their carbon numbers in the range of C44 to C56. Comparisons were made with conventional methods, and the results were in good agreement with those reported in the literature. [ABSTRACT FROM AUTHOR]

The application of supercritical fluid chromatography (SFC) coupled with a UV variable-wavelength detector to isolate the minor components (carotenes, vitamin E, sterols, and squalene) in crude palm oil (CPO) and the residual oil from palm-pressed fiber is reported. SFC is a good technique for the isolation and analysis of these compounds from the sources mentioned. The carotenes, vitamin E, sterols, and squalene were isolated in less than 20 min. The individual vitamin E isomers present in palm oil were also isolated into their respective components, α-tocopherol, α-tocotrienol, γ-tocopherol, γ-tocotrienol, and δ-tocotrienol. Calibration of all the minor components of palm as well as the individual components of palm vitamin E was carried out and was found to be comparable to those analyzed by other established analytical methods. [ABSTRACT FROM AUTHOR]

Previous reports showed that vitamin E in palm oil consists of various isomers of tocopherols and tocotrienols [α-tocopherol (α−T), α-tocotrienol, γ-tocopherol, γ-tocotrienol, and δ-tocotrienol), and this is normally analyzed using silica column HPLC with fluorescence detection. In this study, an HPLC-fluorescence method using a C30 silica stationary phase was developed to separate and analyze the vitamin E isomers present in palm oil. In addition, an α-tocomonoenol (α−T1) isomer was quantified and characterized by MS and NMR. α−T1 constitutes about 3–4% (40±5 ppm) of vitamin E in crude palm oil (CPO) and is found in the phytonutrient concentrate (350±10 ppm) from palm oil, whereas its concentration in palm fiber oil (PFO) is about 11% (430±6 ppm). The relative content of each individual vitamin E isomer before and after interesterification/transesterification of CPO to CPO methyl esters, followed by vacuum distillation of CPO methyl esters to yield the residue, remained the same except for α−T and γ−T3. Whereas α−T constitutes about 36% of the total vitamin E in CPO, it is present at a level of 10% in the phytonutrient concentrate. On the other hand, the composition of γ−T3 increases from 31% in CPO to 60% in the phytonutrient concentrate. Vitamin is present at 1160±43 ppm, and its concentrations in PFO and the phytonutrient concentrate are 4,040±41 and 13,780±65 ppm, respectively. The separation and quantification of α−T1 in palm oil will lead to more in-depth knowledge of the occurrence of vitamin E in palm oil. [ABSTRACT FROM AUTHOR]

Recovered fiber from pressed palm fruits, which is normally burned as fuel to provide energy for the palm oil mills, has now been found to be a rich source of carotenoids, vitamin E (tocopherol and tocotrienols), and sterols. Residual oil (5-6% on dry basis) extracted from palm press fibers contains a significant quantity of carotenoids (4000-6000 ppm), vitamin E (2400-3500 ppm), and sterols (4500-8500 ppm). The major identified carotenoids are α-carotene (19.5%), β-carotene (31.0%), lycopene (14.1%), and phytoene (11.9%). In terms of vitamin E, α-tocopherol constitutes about 61% of the total vitamin E present, the rest being tocotrienols (α-, γ-, and δ-). The major sterols present are β-sitosterol (47%), campesterol (24%), and stigmasterol (15%). The oil extracted from palm-pressed fiber is contaminated with about 30% of palm kernel oil. The quality of this fiber oil is slightly lower than that of crude palm oil in terms of the content of free fatty acids, peroxide value, and anisidine value. [ABSTRACT FROM AUTHOR]

Successful separation of triglycerides, diglycerides, free fatty acids, carotenes, tocopherol, and tocotrienols from crude palm oil has been achieved by supercritical fluid chromatography (SFC) with a combination of a C18 and a silica gel column. The separation was carried out by the programmed extraction elution method. Free fatty acids were separated into five components by gas-liquid chromatography; tocopherol and tocotrienols were also separated into four components by SFC analysis, and the pure fractionated carotenes were obtained by preparative SFC. Thus, by using supercritical fluid chromatography, crude palm oil components can be separated and fractionated, based on differences in their functional groups. [ABSTRACT FROM AUTHOR]