Search

1. The objective of this study was to investigate wheat genotypes bred for increased intrinsic phytase activity for InsP 6 disappearance and the formation of lower inositol phosphates in such wheat-fed broiler chickens. The influence of monocalcium phosphate (MCP) supplementation on these characteristics and the utilisation of P and Ca were also determined. A three-step in vitro assay and a broiler trial were performed.2. In the 63 wheat genotypes tested in vitro , phytase activity varied from 1900 FTU/kg to 5200 FTU/kg, and InsP 6 disappearance increased with higher phytase activity of wheat in a linear manner. The addition of MCP significantly reduced in vitro InsP 6 disappearance by one-third, independent of the inclusion level of wheat in the feed. When exogenous phytase was added to wheat, in vitro InsP 6 disappearance increased independently of the phytase activity of the wheat used.3. In the broiler trial, four wheat genotypes with phytase activities between 2400 and 3700 FTU/kg were included at 400 g/kg in diets with and without MCP. The diets were not pelleted. Separately, wheat 1, without MCP, was tested with the addition of exogenous phytase. Unsexed Ross 308 broiler chickens were allocated to 72 metabolic units of 10 birds each and assigned one of the nine diets. Mineral utilisation was measured based on excreta collection from 20 to 23 d of age. Digesta from the crop and terminal ileum were collected on d 24.4. In the crop and ileum, InsP 6 disappearance was not affected by the wheat genotypes, but the addition of MCP significantly decreased InsP 6 disappearance. Precaecal P disappearance was significantly reduced by the addition of MCP, with wheat genotypes also exerting an effect. Wheat genotypes and the addition of exogenous phytase significantly affected P utilisation. Exogenous phytase had no effect on InsP 6 disappearance in the crop but did up to the terminal ileum, the precaecal InsP 6 and P disappearance increased with the addition of exogenous phytase.5. Although the intrinsic wheat phytase activity exerted distinct effects on in vitro InsP 6 disappearance, no such effect was found in the broiler trial. The addition of MCP significantly inhibited InsP 6 degradation in vitro and in vivo .

Straw is the main by-product of grain production, used as bedding material and animal feed. If produced or stored under adverse hygienic conditions, straw is prone to the growth of filamentous fungi. Some of them, e.g. Aspergillus, Fusarium and Stachybotrys spp. are well-known mycotoxin producers. Since studies on mycotoxins in straw are scarce, 192 straw samples (wheat n = 80; barley n = 79; triticale n = 12; oat n = 11; rye n = 12) were collected across Germany within the German official feed surveillance and screened for the presence of 21 mycotoxins. The following mycotoxins (positive samples for at least one mycotoxin n = 184) were detected: zearalenone ( n = 86, 6.0-785 μg/kg), nivalenol ( n = 51, 30-2,600 μg/kg), deoxynivalenol ( n = 156, 20-24,000 μg/kg), 15-acetyl-deoxynivalenol ( n = 34, 20-2,400 μg/kg), 3-acetyl-deoxynivalenol ( n = 16, 40-340 μg/kg), scirpentriol ( n = 14, 40-680 μg/kg), T-2 toxin ( n = 67, 10-250 μg/kg), HT-2 toxin ( n = 92, 20-800 μg/kg), T-2 tetraol ( n = 13, 70-480 μg/kg). 15-monoacetoxyscirpenol (30 μg/kg) and T-2 triol (60 μg/kg) were only detected in one barley sample. Macrocyclic trichothecenes (satratoxin G, F, roridin E, and verrucarin J) were also found in only one barley sample (quantified as roridin A equivalent: total 183 μg/kg). The occurrence of stachybotrylactam was monitored for the first time in four samples ( n = 4, 0.96-7.4 μg/kg). Fusarenon-X, 4,15-diacetoxyscirpenol, neosolaniol, satratoxin H and roridin-L2 were not detectable in the samples. The results indicate a non-negligible contribution of straw to oral and possibly inhalation exposure to mycotoxins of animals or humans handling contaminated straw.

Here, it was investigated whether substitution of amino acids (AA) from soy protein isolate with free AA in low crude protein diets influences the growth performance and N utilisation in broilers, and whether interactions with dietary glycine equivalent (Glyequi) concentration exist. Birds were distributed in two 2 × 2 factorial arrangements of 48 floor pens containing 10 birds each, plus 48 metabolism cages containing two birds each. Experimental feed was provided for ad libitum consumption from d 7 to 22. Diets contained either a soy protein isolate at 79 g/kg or a mix of free AA, which supplied the same amount of 18 proteinogenic AA. A mix of free glycine and l-serine was used to obtain low and high (12.0 and 20.5 g/kg dry matter) levels of dietary Glyequi. Substitution of soy protein isolate with free AA reduced the average daily gain and feed efficiency, mainly due to reduced feed intake. Efficiency of N accretion was not influenced by the AA source or Glyequi concentration on d 21, possibly due to the lower AA digestibility of soy protein isolate and higher urinary excretion of nitrogenous substances in the treatments with the AA mix. The average daily weight gain of the treatments with high Glyequi concentration was higher for both AA sources. This increase was due to higher average daily feed intake by broilers in the treatments with soy protein isolate and due to the increased feed efficiency in the treatments with the AA mix. Broilers exhibited different growth responses to dietary Glyequi between the AA sources; however, these responses could not be attributed to the different utilisation of Glyequi for uric acid synthesis.

Genotypes of cereal grains, including winter barley (n = 21), maize (n = 27), oats (n = 14), winter rye (n = 22), winter triticale (n = 21) and winter wheat (n = 29), were assayed for their chemical composition and physical characteristics as part of the collaborative research project referred to as GrainUp. Genotypes of one grain species were grown on the same site, except maize. In general, concentrations of proximate nutrients were not largely different from feed tables. The coefficient of variation (CV) for the ether extract concentration of maize was high because the data pool comprised speciality maize bred for its high oil content. A subset of 8 barley, 20 rye, 20 triticale and 20 wheat samples was analysed to differ significantly in several carbohydrate fractions. Gross energy concentration of cereal grains could be predicted from proximate nutrient concentration with good accuracy. The mean lysine concentration of protein was the highest in oats (4.2 g/16 g N) and the lowest in wheat (2.7 g/16 g N). Significant differences were also detected in the concentrations of macro elements as well as iron, manganese, zinc and copper. Concentrations of arsenic, cadmium and lead were below the limit of detection. The concentration of lower inositol phosphates was low, but some inositol pentaphosphates were detected in all grains. In barley, relatively high inositol tetraphosphate concentration also was found. Intrinsic phytase activity was the highest in rye, followed by triticale, wheat, barley and maize, and it was not detectable in oats. Substantial differences were seen in the thousand seed weight, test weight, falling number and extract viscoelasticity characteristics. The study is a comprehensive overview of the composition of different cereal grain genotypes when grown on the same location. The relevance of the variation in composition for digestibility in different animal species will be subject of other communications.

The effect of diets differing in enzyme supplements, mineral phosphorus (P) and microwave wheat treatment on phytate hydrolysis and lower inositol phosphate isomers (InsPs) appearance in broiler crops was studied. The broilers (16- and 15-day-old) were assigned to 48 pens of 15 or 20 birds each (n = 8 pens per treatment) in Experiments 1 and 2, respectively. In Experiment 1, birds received a low-P wheat-soybean meal diet where the wheat was either microwave treated or not. These diets were offered without further supplementation or with added phytase (500 FTU/kg diet), alone or in combination with a xylanase (16,000 BXU/kg diet). In Experiment 2, two maize-soybean meal-based diets were fed, without or with monocalcium phosphate supplementation. Furthermore, these diets were offered without further supplementation or with phytase at 500 or 12,500 FTU/kg diet. On day 23 or 24 (Experiments 1 and 2, respectively), crop digesta were pooled per pen, freeze-dried and analysed for InsPs and the marker TiO2. Microwaving reduced the intrinsic phytase activity and InsP6 hydrolysis, but increased the concentration of Ins(1,2,3,4,5)P5 and Ins(1,2,4,5,6)P5 in the digesta of crop (Experiment 1). Microwave treatment significantly interacted with enzyme supplementation for Ins(1,2,5,6)P4 concentration, indicating a synergistic effect of intrinsic and supplied phytase in the crop. Xylanase tended to support phytase hydrolysis in diets with microwave-treated wheat. Phytase addition increased InsP6 hydrolysis up to 79% (Experiment 2). Thus, wheat phytase activity can cause high InsP6 hydrolysis in the crop. Treatment differences in lower InsPs indicated that hydrolysis of the first InsP6 phosphate group is not the only step in the degradation cascade in the crop of broilers that is influenced by dietary factors.

The objective of this study was to evaluate the effects of diet composition on phytate (InsP6) degradation in dairy cows. In Experiment 1, four diets that differed in the amount and source of phosphorus (P) were fed to 24 lactating cows in a 4 × 4 Latin Square design. The control diet (Diet C) contained 4.18 g P/kg dry matter (DM). Diet MP contained additional mineral P (5.11 g P/kg DM), Diet RS contained rapeseed and rapeseed meal as organic P sources (5.26 g P/kg DM) and Diet RSM contained rapeseed meal and rapeseed oil (5.04 g P/kg DM). Total P (tP) and InsP6 excretion in faeces were measured. In Experiment 2, we used a rumen simulation technique (Rusitec) to estimate ruminal disappearance of tP and InsP6 from Diets C, MP and RSM. In Experiment 1, tP concentration in faeces increased with tP intake and was highest for Diets RS and RSM. The source of supplemented P had no influence on tP digestibility, but tP digestibility was reduced for Diets MP, RS and RSM in comparison to that for Diet C. InsP6 disappearance decreased in Diet MP (85.0%) and increased in Diets RS (92.7%) and RSM (94.0%) compared to that in Diet C (90.0%). In Experiment 2, P source influenced ruminal tP disappearance (Diet MP, 78.6%; Diet RSM, 75.3%). InsP6 disappearance for Diet C (98.1%) was higher than that for Diets MP (95.6%) and RSM (94.9%). The results confirmed the high potential of ruminants to degrade InsP6, but differences in diet composition influenced InsP6 disappearance. Further studies of the site of InsP6 degradation are required to understand the relevance of InsP6 degradation for the absorption of P.

The objective of the study was to investigate the effects of monensin on silage fermentation and microbial net protein synthesis. In Experiment 1, monensin (0.5, 1, 2, 4, 6, or 10 µg) was added to syringes that contained 120 mg of grass silage (GS), grass silage and concentrate (GS + C), or maize silage (MS), resulting in concentrations of 4.2, 8.3, 16.7, 33.3, 50.0 and 83.3 mg monensin/kg feed. Samples were incubated for 24 h to determine the monensin concentration that resulted in the maximum reduction in methane production without effects on the total gas production. In Experiment 2, GS and GS + C were incubated in a rumen simulation technique (Rusitec) to assess the monensin effects (133 and 266 mg/kg feed) on the production of total gas, methane and volatile fatty acids (VFA), degradation of nutrients and microbial net protein synthesis. In Experiment 1, methane production was reduced without significant effects on the total gas production; the reductions were 17% (GS), 10% (GS + C) and 13% (MS) with 16.7 (GS), 50.0 (GS + C) and 33.3 (MS) mg monensin/kg feed. Monensin reduced the total gas and methane production in GS and GS + C in Experiment 2. Propionate production was enhanced by monensin, accompanied by a decrease in acetate production. Along with a reduction in crude protein (CP) degradation, monensin reduced the ammonia nitrogen concentration in the effluent of both treatments. While the protein produced by liquid-associated microbes increased with monensin, protein production by solid-associated microbes was reduced. Total microbial net protein synthesis increased in the presence of monensin. Monensin influenced the production of total gas, methane and VFA from the silages without an effect on the degradation of organic matter (OM). Different microbial fractions were affected differently by monensin supplementation. If monensin is used as a tool to reduce methane emission, the supplementation level must be carefully chosen to avoid negative effects on overall fermentation in the rumen.

The fatty acid pattern of dietary lipids can be modified during rumen biohydrogenation (BH). The objective of the present study was to assess changes in the FA pattern of different oilseed products supplied either as crushed full fat oilseed or as free oil after in vitro incubation with buffered rumen liquor. The FA patterns were determined at the beginning and compared with those measured after 24 h of incubation. The contents of fatty acids (FA) < C18 increased (p < 0.05) in nearly all treatments, eventually due to microbial de novo synthesis and fermentation of carbohydrates and proteins during incubation. In contrast, the contents of the dominating C18 FA, (oleic acid - C18:1c9, linoleic acid - C18:2c9,12, linolenic acid - C18:3c9,12,15) were reduced due to BH, resulting in the accumulation of characteristic BH intermediates, such as conjugated linoleic acid (CLA) isomer C18:2c9t11 (rumenic acid). However, both for crushed full fat oilseeds and their free oils the process of BH was not completed at the end of incubation. The disappearance was highest for C18:3c9,12,15, followed by C18:2c9,12 and C18:1c9. The rate of BH of unsaturated FA was higher in the crushed form compared to the oil form. Higher amounts of BH intermediates accumulated in the crushed form. Obviously, the physical form affects the degree of BH in vitro. The current results suggest that feeding crushed full fat seeds instead of their free oils to dairy cows might stimulate the formation of beneficial BH intermediates such as CLA in the rumen.

Fusarium infections do not only affect the grain, but also the rest of the plant, which result in contamination of plants with the mycotoxin deoxynivalenol (DON). The bioavailability of DON may be influenced by the matrix due to the differences in nutrient composition between grain and straw, particularly the high fibre component in straw. The experiment was carried out by exposing 18 male castrated pigs (30-40 kg live weight) with a single dose of DON from wheat grain, straw and chaff in the diet. The courses of DON serum concentrations were evaluated using toxicokinetic methods. The absorption of DON was not influenced by the source of DON. The invasion half-life of DON from grain, straw and chaff amounted to 0.76, 0.77 and 0.48 h, respectively, and were not significantly different. The elimination of DON was also not affected by the DON source. The bioavailability of DON, calculated by the dose corrected area under the curve of the serum-DON-concentrations, amounted to 81.9, 87.3 and 109.8% for straw, grain and chaff, respectively, without significant differences. Thus, the uptake of DON from straw may contribute comparably to the overall exposure of animals.

An experiment was carried out to examine the effects of feeding Fusarium toxin-contaminated wheat (8.21 mg deoxynivalenol (DON) and 0.09 mg zearalenone (ZON) per kg dry matter) at different feed intake levels on the biotransformation and carry-over of DON in dairy cows. For this purpose, 14 ruminal and duodenal fistulated dairy cows were fed a diet containing 60% concentrate with a wheat portion of 55% (Fusarium toxin-contaminated wheat (mycotoxin period) or control wheat (control period)) and the ration was completed with maize- and grass silage (50 : 50) on a dry matter basis. Daily DON intakes ranged from 16.6 to 75.6 mg in the mycotoxin period at dry matter intakes of 5.6-20.5 kg. DON was almost completely biotransformed to de-epoxy DON (94-99%) independent of the DON/feed intake, and the flow of DON and de-epoxy DON at the duodenum related to DON intake ranged from 12 to 77% when the Fusarium toxin-contaminated wheat was fed. In the serum samples, de-epoxy DON was detected in the range of 4-28 ng ml-1 in the mycotoxin period, while concentrations of DON were all below the detection limit. The daily excretion of DON and de-epoxy DON in the milk of cows fed the contaminated wheat varied between 1 and 10 microg and between 14 and 104 microg, respectively. The total carry-over rates as the ratio between the daily excretion of DON and de-epoxy DON into milk and DON intake were in the ranges of 0.0001-0.0002 and 0.0004-0.0024, respectively. Total carry-over rates of DON as DON and de-epoxy DON into the milk increased significantly with increasing milk yield. In the urine samples, de-epoxy DON was the predominant substance as compared with DON with a portion of the total DON plus de-epoxy DON concentration to 96% when the Fusarium toxin-contaminated wheat was fed, whereas the total residues of DON plus de-epoxy DON in faeces ranged between 2 and 18% of DON intake in the mycotoxin period. The degree of glucuronidation of de-epoxy DON was found to be approximately 100% in serum. From 33 to 80% of DON and from 73 to 92% of de-epoxy DON, and from 21 to 92% of DON and from 86 to 100% of de-epoxy DON were glucuronidated in the milk and urine, respectively. It is concluded that DON is very rapidly biotransformed to de-epoxy DON in the rumen and only negligible amounts of DON and de-epoxy DON were transmitted into the milk within the range of 5.6-20.5 kg day-1 dry matter intake and milk yields (fat corrected milk) between 10 and 42 kg day-1.

The Fusarium head blight (FHB)-susceptible winter wheat cv. Ritmo was inoculated with spores of Fusarium culmorum at the beginning of full blossom. Samples of whole wheat plants were taken once weekly from anthesis until harvest and subsequently fractionated into straw, glumes and spindles, which were examined for deoxynivalenol (DON) and zearalenone (ZON). Additionally, the content of crude protein (CP) and non-starch polysaccharides (NSP) was scrutinized. Synthesis of the Fusarium toxins DON and ZON generally differed in terms of date of formation and concentration. Final mean DON concentrations of 37.5, 28.1 and 5.0 mg/kg DM were measured in glumes, spindles and straw, respectively, at the time of harvest. At this time, maximal mean ZON concentrations of 587, 396 and 275 microg/kg DM in spindles, glumes and straw, respectively, were determined. Moreover, Fusarium infected wheat residues contained higher CP but lower NSP contents at the last three sampling dates. In addition, collective samples of wheat straw and chaff were taken to investigate the effect of the Fusarium contamination on their in sacco DM degradation in dairy cows. Samples were analysed for mycotoxins and selected quality parameters. The dried and milled collective samples of straw and chaff were weighed into nylon bags and subjected to ruminal incubation for 4, 8, 16, 24, 48, 72, 96 and 120 h in two dairy cows equipped with a permanent rumen cannula. Marked differences in level of mycotoxin contamination as well as in ingredient composition between the variants of straw and chaff were detected. Moreover, after 120 h rumen incubation the in sacco DM degradation of inoculated straw and chaff were lower compared to the accordant controls. The soluble fraction was increased in inoculated samples, whereas a diminishment in the potentially degradable but insoluble fraction was more pronounced. Thereby, a decrease in the potential degradability was obtained for inoculated straw and even if less pronounced for chaff compared to the non inoculated corresponding controls. In conclusion, infection with F. culmorum of wheat involves an increased risk of mycotoxin contamination in straw. Also, a Fusarium infection may have an impact on chemical composition and may result in Fusarium growth-related modifications of host cell wall components.

Deoxynivalenol (DON), a Fusarium toxin belonging to the trichothecene group, has been reported to produce a variety of adverse health effects in farm animals, such as inhibition of protein synthesis, reduction of feed intake, and alteration of the immune system. In pigs, the effects of increasing levels of chemically pure DON in a semisynthetic diet on performance, health, and serum immunglobulin A (IgA) levels were examined. A diet, without grain components and trichothecene free (8 main trichothecenes), with doses of 0, 300, 600, and 1200 microg pure DON/kg was fed to 34 female pigs for a period of 8 wk after weaning under standardized conditions. Body weight gain and biochemical and hematological values in the blood and serum, including concentrations of IgA, blood glucose, cortisol, and insulinlike growth factor 1 (IGF-1), were determined. Increasing levels of DON in the feed induced a significant depression of glucose levels. Cortisol and IGF-1 levels were not significantly affected but differed between groups at the end of the experiment. A significant increase of IgA concentration in the serum even at a dosage level of 600 microg DON/kg feed was observed. This is the first report demonstrating in vivo that limited dosages of DON are able to stimulate IgA levels in the serum of growing piglets., (Copyright Taylor and Francis Inc.)