Search

The low-amylose rice flour, seeded banana (Musa balbisiana, ABB) and carambola (Averrhoa carambola L.) pomace blends were extruded to prepare ready to eat breakfast cereal in a single-screw extruder. Response surface methodology using a central composite design was used to evaluate effect of independent variables, namely blend ratio (80:10:10 - 60:30:10 of low-amylose rice flour, seeded banana and carambola pomace), screw speed (200 - 400 rpm), barrel temperature (90 - 130 (°)C) and feed moisture content (9 - 21 g/100 g, wet basis) on product responses. Quadratic polynomial equations were also obtained by multiple regression analysis. The predicted models were adequate based on lack-of-fit test and coefficient of determination obtained. The feed moisture content had critical effect on all response variables. The compromised optimal conditions obtained by numerical integration for development of extrudates were: screw speed of 350 rpm, barrel temperature of 120 (°)C, feed moisture content of 12 g/100 g and 65:25:10 of blend ratio of feed. In the optimized condition low-amylose rice blend is found to have better physicochemical properties (water absorption index of 481.79 g/100 g; water solubility index of 44.13 g/100 g) and dietary fiber content of 21.35 g/100 g respectively. The developed breakfast cereal showed considerable amount of minerals (Mg and K) and overall acceptability was found to be 7.8.

Rheological and nutritional quality of ready-to-eat rice (Oryza sativa ) -legume viz. black gram (Vigna mungo), green gram (Vigna radiata), lentil (Lens culinaris) and peas (Pisum sativum) based extrudates were studied using low cost collet extruder. Extrudates were prepared keeping constant feed rate (25 kg/h) and moisture content (14% wb) at 0, 5, 10 and 15% legume incorporation levels. Rheological properties of porridge made of extrudate flour were evaluated using Rapid Visco Analyser (RVA). Maximum and minimum peak viscosity for rice extrudates alone and rice extrudates blended with 15% peas were 697 cp and 523 cp, respectively. There was a decreasing trend in degree of gelatinization with increase in legume incorporation level. Other RVA rheological parameters like trough break down and final viscosity were in the range of 266-226 cp, 431-297 cp and 452-375 cp respectively. Maximum values of protein, fat, fibre and ash contents were found in rice extrudates at 15% legumes blend levels. There was an increasing trend in nutrient contents with legume content in rice extrudates. Degree of gelatinization for rice alone extrudate was 29.4% and showed a decrease in gelatinization with increase in legumes extrudate and was minimum (22.4%) for rice blended with 15% dehulled green gram. Sensory evaluation scores for all extrudates showed the most acceptable range of 6 to 8. Thus, legume blend level (up to 15%) of dehulled legumes fetched good scores and showed promising trend for the production of low cost expanded extrudates and its instant flour.

Use of extracts of kinnow and pomegranate by-products as source of natural antioxidant in salted chicken patties during refrigerated storage was evaluated. Five treatments viz., I. Control (meat), II.MS (meat + 2%salt), III. KRP (meat + 2% salt + 2% kinnow-rind-powder extract), IV. PRP (meat + 2% salt + 2% pomegranate-rind-powder extract), and V. PSP (meat + 2% salt + 2% pomegranate seed powder extract). Results showed that salt significantly (P < 0.05) reduced lightness and yellowness but increased chroma and TBARS values. The average increase in TBARS was significantly (P < 0.05) higher in MS (114%) and Control (108%) but lower in KRP (90%), PRP (81%) and PSP (73%). Lipid oxidation (TBARS) in salted meat during the storage was significantly reduced (P < 0.05) by KRP (39%), PRP (43%) and PSP (68%). Thus it was observed that addition of 2% salt accelerated the TBARS formation but inclusion of extracts of pomegranate and kinnow fruit by-products effectively counteracted this effect. The overall antioxidant effect was in the order of PSP>PRP>KRP. Further a significant (P < 0.05) negative correlation between total phenolics contents and TBARS values was also observed. Therefore, it was concluded that extracts of these fruit by-products have potential to be used as natural antioxidants to minimize the oxidative problems in poultry meat products.

Toughness of goat meat is a major problem with regard to consumer acceptance. Keeping this in view a blade tenderizer was developed for tenderization of goat meat. Pomegranate fruit products were also explored for tenderization effect on goat meat. Tenderization of goat meat with pomegranate seed powder improved the textural properties marginally with slight adverse colour change and taste. Samples treated with PRP got lower score for colour in sensory evaluation and there was adverse effect on taste of treated meat. Blade tenderization and 4% PSP proved better for tenderization and were compared with control and 0.2% papain in goat meat chunks. The cooked samples treated with papain and blade incisions got better sensory scores and required lesser shear force compared to 4% PSP and control. Overall the papain treated meat was superior in terms sensory attributes followed by blade incision and PSP. The results suggested that the blade incisions can be used for tenderization of goat meat. Pomegranate seed powder maybe considered for mixing with other spices to marinate goat meat mainly for its beneficial effects.