Search

The official method described in Direction Notification Kanshoku No. 99 （May 8, 1981） for the determination of chlorophyll decomposition products including pheophorbide was verified and improved in order to overcome several problems. Firstly, extraction with a mortar required improvement because of the difficulty of maintaining equal power for a long time. Secondly, the saturated sodium sulfate reagent caused a red-shift of the absorption maximum wavelength from the measured wavelength given in the official method; consequently, the absorption was decreased and a new absorption peak was detected around 729 nm. As a result, chlorophyll decomposition products including pheophorbide were underestimated. Lastly, it was impossible to make up the volume of the diethyl ether layer accurately to 20 mL before measuring the absorption. These points were improved in the modified method, and a validation test was performed. The mean recovery was 82.7％ and the within-laboratory reproducibility was 5.8％.

New analytical methods for the determination of free asparagine （Asn）, which is a precursor of acrylamide, in grains were developed using LC-MS and LC-MS/MS. Asn was extracted from a sample with 5％ （w/v） aqueous trichloroacetic acid solution, appropriately diluted with 0.1％ （v/v） formic acid solution, and then analyzed by LC-MS or LC-MS/MS. HPLC separation was performed by isocratic elution on a Penta Fluoro Phenyl （PFP） column using 0.1％ （v/v） formic acid and acetonitrile mixture as the mobile phase. The calibration curve was linear in the range of 0.005-0.1 μg/mL. The mean recoveries from potato starch, non-glutinous rice flour and whole wheat flour ranged from 95.4 to 100.9％, repeatability （RSD） ranged from 0.9 to 6.0％, and within-laboratory reproducibility （RSDwr） ranged from 2.8 to 7.1％. Limits of quantitation （LOQs） were 7 mg/kg for potato starch, and 5 mg/kg for non-glutinous rice flour. In addition, an inter-laboratory study was performed in 10 laboratories using 5 kinds of grains （non-glutinous brown rice flour, corn flour, strong flour, whole wheat flour, and whole rye flour）, which naturally contained free asparagine. The HORRATR values ranged from 0.4 to 1.0. These results are within the range of the procedural manual of the Codex Alimentarius Commission, confirming the effectiveness of the developed procedures.

A novel analytical method was developed for the determination of free asparagine (Asn), which is a precursor of acrylamide, in grains. Asn was extracted from a sample with 5% (w/v) aqueous trichloroacetic acid solution, and the crude extract was cleaned up using a reversed-phase solid-phase cartridge. The cleaned extract was derivatized with dansyl chloride and analyzed by HPLC-UV. HPLC separation was performed by gradient elution on a ODS column using 0.01 mol/L ammonium acetate and acetonitrile mixture as the mobile phase. The calibration curve was linear in the range of 0.5-100 μg/mL. The mean recoveries from potato starch, non-glutinous rice flour and whole wheat flour ranged from 97.7 to 102.6%, the repeatability (RSDs) ranged from 0.8 to 2.0%, and the within-laboratory reproducibility (RSDwr) ranged from 1.4 to 6.2%. Limits of quantitation (LOQs) were 13 mg/kg for potato starch and 4 mg/kg for non-glutinous rice flour. The quantitative values obtained for about 15 kinds of grains using this developed method were approximately equal to those obtained with an automatic amino acid analyzer.

Discriminating vegetable oils and animal and milk fats by infrared absorption spectroscopy is difficult due to similarities in their spectral patterns. Therefore, a rapid and simple method for analyzing vegetable oils, animal fats, and milk fats using TOF/MS with an APCI direct probe ion source was developed. This method enabled discrimination of these oils and fats based on mass spectra and detailed analyses of the ions derived from sterols, even in samples consisting of only a few milligrams. Analyses of the mass spectra of processed foods containing oils and milk fats, such as butter, cheese, and chocolate, enabled confirmation of the raw material origin based on specific ions derived from the oils and fats used to produce the final product.

An LC-MS/MS method for analysis of cereulide, an emetic toxin produced by Bacillus cereus, was developed. Cereulide was extracted from samples, fried rice, pan-fried noodles, red bean paste and baby formula, with methanol and purified using Oasis HLB cartridges. LC separation was performed on a C18 column with a mixture of formic acid solution and methanol containing ammonium formate as a mobile phase, and the mass spectrometer was operated in the positive electrospray ionization mode. Performance evaluation showed that trueness was higher than 70% and repeatability and reproducibility were within 10%. The limits of quantification were lower than 1 µg/kg.

An efficient clean-up procedure was developed for the trace residue determination of tetracyclines (TCs) in dark-colored honeys. TCs were extracted from samples with McIlvaine buffer (pH 4.0) containing 0.01 mol/L Na(2)EDTA. The extracts were treated with both a polymeric cartridge (GL-Pak PLS-2) and a metal chelate affinity column (MCAC) preloaded with copper(II). TCs were eluted and analyzed by high-performance liquid chromatography (HPLC) using fluorescence detection. The method was evaluated for the determination of oxytetracycline (OTC), tetracycline (TC), and chlortetracycline (CTC) in buckwheat honey, because its color is the darkest. The mean recoveries of OTC, TC and CTC from spiked samples, at three fortification levels, were >70%, and the relative standard deviations (RSDs) were

A simple and rapid LC/MS method for simultaneous determination of sedecamyin (SCM) and terdecamycin (TDM) in livestock products has been developed. SCM and TDM were extracted with acetonitrile. The extract was washed with n-hexane and then evaporated to dryness. The residue was dissolved in methanol, and injected into the LC/MS. The mass spectrometer was operated in the positive electrospray ionization (ESI) mode. LC separation was performed on a high-pH-resistant C18 column with 10 mmol/L carbonic acid-ammonia buffer (pH 10.0)-acetonitrile as a mobile pahse. The recoveries from swine muscle and liver fortified at the levels of 0.01 and 0.05 microg/g were 77-88%, and those from poultry muscle and liver fortified at the levels of 0.01 and 0.3 microg/g were 51-93%. The quantitation limits of SCM and TDM were 0.008 microg/g and 0.005 microg/g, respectively.

To validate a modified version of AOAC official method of analysis 995.10 as an official standard in Japan for determination of patulin in apple juice, an inter-laboratory study was performed in 11 laboratories using a non-contaminated sample, 2 naturally contaminated samples and 2 spiked samples of apple juice. For naturally contaminated apple juices, the relative standard deviations for repeatability and reproducibility were 3.2, 7.1% and 10.0, 21.7%, respectively. HORRAT values were 0.4, 0.9. The average recovery of patulin from spiked sample was 83.7%. The limit of quantification was calculated as 10 microg/kg. From these results, the method was thought to be suitable as an official standard for determination of patulin in apple juice in Japan.

畜産食品中のベンジルペニシリン (PCG) の微生物学的試験法について検討した. 水で抽出し, タングステン酸により除タンパクした後, Bond Elut C18で精製を行った. 定量は円筒平板法を用い, 同定はマイクロバイオオートグラフィーにより実施した. 本法によるCodex規格の残留基準値レベルでの平均回収率は, 80.7%であり, 定量下限は肉, 肝臓, 腎臓で5ppb, 牛乳で1ppbであった.

An analytical method for residual oxytetracycline (OTC) in livestock and marine products was evaluated. OTC was extracted from a sample with McIlvaine buffer (pH 4.0) containing 0.01mol/L EDTA-2 Na. The extract was washed with hexane, followed by a Sep-Pak Plus PS2 cartridge clean-up procedure. OTC was determined by HPLC. The results obtained by HPLC were well correlated with those of a microbioassay method. The average recovery at the tolerance limit levels established by the Food Sanitation Law of Japan was 90.4% and the determination limits were 0.02ppm (muscle, seafood, milk), 0.04ppm (liver, kidney, egg) and 0.002ppm (fat).

A biological method for residual tetracyclines (TCs) in propolis was evaluated. Oxytetracycline (OTC), tetracycline (TC) and chlortetracycline (CTC) were extracted from a sample with 5% citric acid containing 0.001M EDTA-2Na. The extract was washed with hexane and diethyl ether, followed by a Sep-pak Plus PS2 cartridge clean-up and TCs adsorbed in the cartridge were eluted with methanol. The eluate was concentrated to dryness, and the residue was redissolved in a phosphate buffer (pH 4.5) and treated with polyamide resin to remove antibacterial substances originating from propolis. The cup-plate method was employed for quantitative determination, and microbioautography for identification of TCs. The recoveries were 97.6% (OTC), 92.7% (TC) and 86.3% (CTC), and the detection limits were 0.1μg/g (OTC, TC) and 0.02μg/g (CTC).