Search

[Display omitted] • The impact of biomass withdrawal strategy is compared in MMCs for PHA production. • Biomass withdrawal at the end of the famine led to higher global PHA productivity. • Biomass withdrawal at the end of the feast requires a smaller accumulation reactor. • Global PHA productivity is highly dependent on volumetric biomass productivity. The production of polyhydroxyalkanoates (PHA) by mixed microbial cultures (MMC) has been studied as an alternative to pure cultures in order to reduce the price of PHA through use of open systems and low-cost substrates, such as agro-industrial sub-products. However, the widespread applicability of this process depends on the optimization of operational factors impacting PHA productivity. This study addresses the impact of biomass withdrawal strategy on the performance of MMC selection reactors and consequently on biomass productivity and global PHA productivity. Two selection reactors were operated in parallel under similar conditions, except for the timing of biomass withdrawal, at the end of the famine phase (Reactor 1, R1) versus at the end of the feast phase (Reactor 2, R2) at an organic loading rate of 100 Cmmol.L−1.d−1 and solids retention time of 4 days. The biomass selected in both conditions had similar PHA storing capacity as shown by the similar yields of PHA per substrate obtained in the accumulation assays; however, R1 reached a higher biomass productivity (about 4-fold higher than R2). This study demonstrated that removing the excess biomass at the end of the famine phase resulted in a much higher global PHA productivity and that the key parameter affecting the global PHA productivity of the 2-stage system was the volumetric biomass productivity. Results obtained provide important insight into how MMC systems can be best operated to maximize PHA productivity. [ABSTRACT FROM AUTHOR]

• Acetate and propionate uptakes were inhibited in the presence of butyrate and valerate. • Higher abundance of Plasticicumulans led to a more significant inhibitory effect. • HB:HV ratio was close to theoretical value in Plasticicumulans- dominating cultures. Polyhydroxyalkanoates (PHAs) are biobased, biodegradable polymers that can be produced efficiently by mixed microbial cultures (MMCs) at low cost. Substrate preferences have been found to vary depending on the microbial composition in the MMCs. In this study, the competition between the uptake of different substrates has been related for the first time to the abundance of certain microbial communities. With a higher abundance of Plasticicumulans enriched in the culture, the inhibitory effect of butyrate and valerate on the uptake of acetate and propionate increased and the hydroxybutyrate:hydroxyvalerate (HB:HV) ratio in the final PHA polymer approached the theoretical value calculated from the volatile fatty acid (VFA) composition. This finding can help understanding of the metabolism of PHA accumulating microorganisms and thus predict better the VFA consumption and PHA composition. [ABSTRACT FROM AUTHOR]

Polyhydroxyalkanoates (PHAs) are biobased and biodegradable polyesters with the potential to replace conventional plastics. Aeration requires large amounts of energy in PHA production by mixed microbial cultures (MMCs), particularly during the feast phase due to substrate uptake. The objective of this study was to investigate the impact of DO concentrations on microbial selection, substrate competition and PHA production performance by MMCs. This represents the first study investigating DO impact on PHA production while feeding the multiple volatile fatty acids (VFAs) typically encountered in real fermented feedstocks, as well as the substrate preferences at different DO levels. Efficient microbial cultures were enriched under both high (3.47 ± 1.12 mg/L) and low (0.86 ± 0.50 mg/L) DO conditions in the feast phase containing mostly the same populations but with different relative abundance. The most abundant microorganisms in the two MMCs were Plasticicumulans, Zoogloea, Paracoccus, and Flavobacterium. Butyrate and valerate were found to be the preferred substrates as compared to acetate and propionate regardless of DO concentrations. In the accumulation step, the PHA storage capacity and yield were less affected by the change of DO levels when applying the culture selected under low DO in the feast phase (PHA storage capacity >60% and yield > 0.9 Cmol PHA/Cmol VFA). A high DO level is required for maximal PHA accumulation rates with the four VFAs (acetate, propionate, butyrate and valerate) present, due to the lower specific uptake rates of acetate and propionate under low DO conditions. However, butyrate and valerate specific uptake rates were less impacted by DO levels and hence low DO for PHA accumulation may be effective when feed is composed of these substrates only. [ABSTRACT FROM AUTHOR]

In wastewater treatment plants (WWTPs), aeration is the major energetic cost, thus its minimisation will improve the cost-effectiveness of the process. This study shows that both the dissolved oxygen (DO) concentration and aerobic hydraulic retention time (HRT) affect the competition between polyphosphate accumulating organisms (PAOs) and glycogen accumulating organisms (GAOs). At low DO levels, Accumulibacter PAOs were shown to have an advantage over Competibacter GAOs, as PAOs had a higher oxygen affinity and thus largely maintained their aerobic activity at low DO levels, while GAO activity decreased. Bioreactor operation at low DO levels was found to increase the PAO fraction of the sludge. Furthermore, an increase in aerobic HRT (at a DO level of 2 mg O 2 /L), promoted the proliferation of GAOs over PAOs, decreasing the EBPR efficiency. Overall, this study shows that low aeration can be beneficial for EBPR performance through selecting for PAOs over GAOs, which should be incorporated into WWTP models in order to minimise energetic costs and improve WWTP sustainability. [ABSTRACT FROM AUTHOR]

This study investigates, for the first time, the application of metabolic models incorporating polyphosphate accumulating organisms (PAOs) and glycogen accumulating organisms (GAOs) towards describing the biochemical transformations of full-scale enhanced biological phosphorus removal (EBPR) activated sludge from wastewater treatment plants (WWTPs). For this purpose, it was required to modify previous metabolic models applied to lab-scale systems by incorporating the anaerobic utilisation of the TCA cycle and the aerobic maintenance processes based on sequential utilisation of polyhydroxyalkanoates, followed by glycogen and polyphosphate. The abundance of the PAO and GAO populations quantified by fluorescence in situ hybridisation served as the initial conditions of each biomass fraction, whereby the models were able to describe accurately the experimental data. The kinetic rates were found to change among the four different WWTPs studied or even in the same plant during different seasons, either suggesting the presence of additional PAO or GAO organisms, or varying microbial activities for the same organisms. Nevertheless, these variations in kinetic rates were largely found to be proportional to the difference in acetate uptake rate, suggesting a viable means of calibrating the metabolic model. The application of the metabolic model to full-scale sludge also revealed that different Accumulibacter clades likely possess different acetate uptake mechanisms, as a correlation was observed between the energetic requirement for acetate transport across the cell membrane with the diversity of Accumulibacter present. Using the model as a predictive tool, it was shown that lower acetate concentrations in the feed as well as longer aerobic retention times favour the dominance of the TCA metabolism over glycolysis, which could explain why the anaerobic TCA pathway seems to be more relevant in full-scale WWTPs than in lab-scale systems. [ABSTRACT FROM AUTHOR]

Enhanced biological phosphorus removal (EBPR) is usually limited by organic carbon availability in wastewater treatment plants (WWTPs). Polyphosphate accumulating organisms (PAOs) and glycogen accumulating organisms (GAOs) were operated under extended periods with low organic carbon loading in order to examine its impact on their activity and survival. The decrease in organic carbon load affected PAOs and GAOs in different ways, where the biomass decay rate of GAOs was approximately 4 times higher than PAOs. PAOs tended to conserve a relatively high residual concentration of polyhydroxyalkanoates (PHAs) under aerobic conditions, while GAOs tended to deplete their available PHA more rapidly. This slower oxidation rate of PHA by PAOs at residual concentration levels enabled them to maintain an energy source for aerobic maintenance processes for longer than GAOs. This may provide PAOs with an advantage over GAOs in surviving the low organic loading conditions commonly found in full-scale wastewater treatment plants. [ABSTRACT FROM AUTHOR]

The type of carbon source present in the wastewater is one factor that affects the competition between polyphosphate accumulating organisms (PAO) and glycogen accumulating organisms (GAO) and therefore, the efficiency of the enhanced biological phosphorus removal (EBPR) process. This study investigated the impact of the carbon source composition on the anaerobic and aerobic kinetics of PAOs and the EBPR performance of an 85% PAO enrichment. When both acetate (HAc) and propionate (HPr) were present, propionate was depleted more quickly, with a constant uptake rate of 0.18 ± 0.02 C-mol/(C-mol biomass·h), while the acetate uptake rate decreased with an increase in propionate concentration, due to the substrate competition between acetate and propionate. The metabolic model for PAOs was modified to incorporate the anaerobic substrate competition effect. The aerobic rates for phosphorus (P) uptake, glycogen production and polyhydroxyalkanoates (PHA) degradation were within the same range for all tests, indicating that these rates are essentially independent of the acetate and propionate concentration, simplifying the calibration procedure for metabolic models. The metabolic model applied to describe the anaerobic and aerobic activity agreed well with the experimental data of HAc, HPr, P, PHA and biomass growth. The low glycogen consumption observed suggest that some reducing equivalents were generated anaerobically through the TCA cycle. The results of this work suggest that the propionate uptake kinetics by PAOs can provide them an advantage over GAOs in EBPR systems, even when the propionate fraction of the influent is relatively low. [ABSTRACT FROM AUTHOR]

Abstract: Large engineering programs like sociotechnical infrastructure constructions of airports, plant constructions, or the development of radically innovative, high-tech industrial products such as electric vehicles or aircraft are affected by a number of serious risks, and subsequently commonly suffer from large cost overruns. Significant problems in program execution can be traced back to practices performed, or more frequently not performed, in the so-called “fuzzy front end” of the program. The lack of sufficient and effective efforts in the early stages of a program can result in unstable, unclear and incomplete requirements, unclear roles and responsibilities within the program organization, insufficient planning, and unproductive tensions between program management and systems engineering. This study intends to clarify the importance of up-front planning to improve program performance, to propose a model for the front-end of large-scale engineering programs based on a review of existing, suitable models in literature and to better understand the complexity drivers that are impeding reliable planning and common planning mistakes made in large-scale engineering programs. [Copyright &y& Elsevier]

Abstract: There is a large and growing body of knowledge regarding so-called Lean best practices, including most recently in the area of program management and systems engineering. However, there is little elaboration of how these documented best practices are to be introduced to a professional workforce. One way of introducing new practices to a workforce is through the use of training workshops. Such workshops often emerge from training programs or consulting arrangements, but there is no well-defined method or framework to systematically design workshops for the implementation of a new body of knowledge. This study focuses on the development of a framework that facilitates the systematic design of workshops focused specifically on the introduction of Lean principles and practices to program management and the professional workforce in a program environment. The framework is based on a thorough review of literature on training, workshop delivery, and Lean principles, as well as empirical evidence obtained from data collection and interactions with training professionals from industry. The framework provides a systematic design process for workshops, including: a) the assessment of the need for a workshop, b) the definition of workshop goals and objectives, c) the definition of workshop topics, d) the development of an agenda and the theoretical content of the workshops, and e) the selection of the right teaching techniques as well as the right simulations and active learning devices. In each of these steps the framework provides content for the prospective educators. The framework is embodied in an Excel-based tool that allows the user to quickly assemble a structure for the workshop, including the topic, an agenda and defined goals, and also the theoretical content about the Lean principles. Another element of the framework is the designation of the organizational hierarchy levels to be addressed, with educational techniques adapted to each level. The framework was validated through interactions with training professionals in a large automobile manufacturer, and using subject matter experts from a variety of industrial sectors. [Copyright &y& Elsevier]

Abstract: This study analysed the enhanced biological phosphorus removal (EBPR) microbial community and metabolic performance of five full-scale EBPR systems by using fluorescence in situ hybridisation combined with off-line batch tests fed with acetate under anaerobic–aerobic conditions. The phosphorus accumulating organisms (PAOs) in all systems were stable and showed little variability between each plant, while glycogen accumulating organisms (GAOs) were present in two of the plants. The metabolic activity of each sludge showed the frequent involvement of the anaerobic tricarboxylic acid cycle (TCA) in PAO metabolism for the anaerobic generation of reducing equivalents, in addition to the more frequently reported glycolysis pathway. Metabolic variability in the use of the two pathways was also observed, between different systems and in the same system over time. The metabolic dynamics was linked to the availability of glycogen, where a higher utilisation of the glycolysis pathway was observed in the two systems employing side-stream hydrolysis, and the TCA cycle was more active in the A2O systems. Full-scale plants that showed higher glycolysis activity also exhibited superior P removal performance, suggesting that promotion of the glycolysis pathway over the TCA cycle could be beneficial towards the optimisation of EBPR systems. [Copyright &y& Elsevier]

Highlights: [•] Dark/light periods increased PHA production by a photosynthetic mixed culture. [•] The mixed culture was enriched in PHA accumulating bacteria, algae were out-competed. [•] A direct relation existed between light availability and specific acetate uptake rate. [•] The specific PHA production rate doubled in relation to continuous illumination. [•] The mixed photosynthetic culture reached a PHA content of 30% PHA/VSS. [Copyright &y& Elsevier]

Abstract: A model describing ibuprofen and ketoprofen biodegradation by activated sludge from three different wastewater treatment plants (WWTP) was developed in this study. This model successfully described the biodegradation profiles observed at two different initial concentrations of each compound, where a lag-phase was observed prior to the biodegradation of each compound. Twelve ibuprofen and ketoprofen degrading isolates were identified in this study from the WWTP sludge showing the best removal performance. One of these isolates was characterised via another model, where biodegradation was dependent on biomass growth rate as well as the ibuprofen concentration. The fact that different models were needed to describe the biodegradation by activated sludge and a pure culture suggests that the biodegradation of non-steroidal anti-inflammatory drugs (NSAIDs) depends on the microbial community, thus pharmaceutical biodegradation models may require adaptation depending upon the system. This study provides an advance towards modelling pharmaceutical biodegradation in WWTPs. [Copyright &y& Elsevier]

Abstract: This study investigated ways of stimulating the biodegradation rates of the commonly applied herbicide, 3,4-dichloropropionanilide (propanil), and its metabolite, 3,4-dichloroaniline (DCA), as well as the growth rate of propanil- and DCA-degrading organisms in a mixed culture. Propionate, the other metabolite of propanil, stimulated the specific degradation rates of both propanil and DCA after a brief acclimation period. A metabolic model developed to characterise the metabolism of propanil and DCA biodegradation showed that the efficiency of oxidative phosphorylation (i.e. P/O ratio), which measures the metabolic efficiency, increased over time by 6- to 10-fold. This increase was accompanied by a 5- to 10-fold increase in the propanil and DCA biodegradation degradation rates. The biodegradation rates of the culture were unaffected when using an irrigation water matrix (Tejo river, Portugal), highlighting the utility of the culture for bioaugmentation purposes. [Copyright &y& Elsevier]

Abstract: Previous studies have shown that polyphosphate-accumulating organisms (PAOs) are able to behave as glycogen-accumulating organisms (GAOs) under different conditions. In this study we investigated the behavior of a culture enriched with Accumulibacter at different levels of polyphosphate (poly-P) storage. The results of stoichiometric ratios Glydegraded/HAcuptake, PHBsynthesized/HAcuptake, PHVsynthesized/HAcuptake and Prelease/HAcuptake confirmed a metabolic shift from PAO metabolism to GAO metabolism: PAOs with high poly-P content used the poly-P to obtain adenosine tri-phosphate (ATP), and glycogen (Gly) to obtain nicotinamide adenine dinucleotide (NADH) and some ATP. In a test where poly-P depletion was imposed on the culture, all the acetate (HAc) added in each cycle was transformed into polyhydroxyalkanoate (PHA) despite the decrease of poly-P inside the cells. This led to an increase of the Glydegraded/HAcuptake ratio that resulted from a shift towards the glycolytic pathway in order to compensate for the lack of ATP formed from poly-P hydrolysis. The shift from PAO to GAO metabolism was also reflected in the change in the PHA composition as the poly-P availability decreased, suggesting that polyhydroxyvalerate (PHV) is obtained due to the consumption of excess reducing equivalents to balance the internal NADH, similarly to GAO metabolism. Fluorescence in situ hybridization analysis showed a significant PAO population change from Type I to Type II Accumulibacter as the poly-P availability decreased in short term experiments. This work suggests that poly-P storage levels and GAO-like metabolism are important factors affecting the competition between different PAO Types in enhanced biological phosphorus removal systems. [Copyright &y& Elsevier]

Abstract: Nitrite is known to accumulate in wastewater treatment plants (WWTPs) under certain environmental conditions. The protonated form of nitrite, free nitrous acid (FNA), has been found to cause severe inhibition to numerous bioprocesses at WWTPs. However, this inhibitory effect of FNA may possibly be gainfully exploited, such as repressing nitrite oxidizing bacteria (NOB) growth to achieve N removal via the nitrite shortcut. However, the inhibition threshold of FNA to repress NOB (∼0.02mg HNO2-N/L) may also inhibit other bioprocesses. This paper reviews the inhibitory effects of FNA on nitrifiers, denitrifiers, anammox bacteria, phosphorus accumulating organisms (PAO), methanogens, and other microorganisms in populations used in WWTPs. The possible inhibition mechanisms of FNA on microorganisms are discussed and compared. It is concluded that a single inhibition mechanism is not sufficient to explain the negative impacts of FNA on microbial metabolisms and that multiple inhibitory effects can be generated from FNA. The review would suggest further research is necessary before the FNA inhibition mechanisms can be more effectively used to optimize WWTP bioprocesses. Perspectives on research directions, how the outcomes may be used to manipulate bioprocesses and the overall implications of FNA on WWTPs are also discussed. [Copyright &y& Elsevier]