Search

Polyethylcyanoacrylate (PECA) nanoparticles (NPs) have been employed as biodegradable polymeric carriers for oral (PO) delivery of ketorolac. The nanoparticles were prepared by polymerization technique at room temperature in a continuous aqueous phase at pH 2.5. This polymerization technique was able to hold 76-96% of ketorolac and the drug loading was a monomer concentration dependent. The feasibility of PECA NPs as PO controlled drug delivery systems of ketorolac was investigated in two groups of rats which were given orally either ketorolac tromethamine solution (1.5 mg/kg) or the selected ketorolac NPs aqueous dispersion (1.6 mg/kg). Ketorolac plasma concentrations were measured by a new fully validated specific, precise and accurate ultra-performance liquid chromatography tandem mass spectrometry (UPLC MS/MS) assay. The detection was performed on Waters TQ detector via negative electrospray ionization in a multiple reaction monitoring mode. Linear response (r(2)> or =0.995) was observed over the range of 10-10,000 ng/ml of ketorolac, with the lower limit of quantification of 5 ng/ml with 1 microl injection volume. The intra- and inter-day precision (relative standard deviation, R.S.D.) values were <10% and the accuracy (relative error) was < or =8 for ketorolac concentrations. The drug solution is rapidly absorbed, distributed, and eliminated and shows a monophasic elimination phase. The assay was sensitive to follow pharmacokinetics of ketorolac in rats up to 24 h after a PO dose of its aqueous solution or NPs suspension. After NPs administration the mean Cmax, 5.0+/-1.3 mg/l, was attained at 1 h. The drug was successfully maintained around this elevated plasma drug concentration up to 6h (>2t(1/2)), in rats. The AUC was significantly higher after the NPs suspension than the solution of ketorolac. This present study provides evidence that the sorption of ketorolac to PECA NPs could control the drug release/elimination in rats., (Copyright 2010 Elsevier B.V. All rights reserved.)

Various amide prodrugs of ketorolac were synthesized and their rat skin permeation characteristics were determined. The solubility of the prodrugs in propylene glycol (PG) was determined at 37 degrees C while lipophilicity was obtained as 1-octanol/water partition coefficient (logP) and capacity factor (k') using HPLC. Stability of the prodrugs in rat skin homogenate, plasma and liver homogenate was investigated to observe the enzymatic degradation. Rat skin permeation characteristics of the prodrugs saturated in PG were investigated using the Keshary-Chien permeation system at 37 degrees C. The logP value of the prodrugs increased up to 4.28 with the addition of various alkyl chain to ketorolac which has a logP of 1.04. Good linear relationship between logP and capacity factor was observed (r(2)=0.89). Amide prodrugs were converted to ketorolac only in rat liver homogenate. However, the skin permeation rate of amide prodrugs did not significantly increase, probably due to their low aqueous solubility. Chemical modification of the ketorolac amide prodrug and/or the selection of proper vehicle to increase aqueous solubility would be necessary for an effective transdermal delivery of ketorolac.

The potential for iontophoresis facilitated transdermal transport of ketorolac was investigated using rat skin. Studies of electrical, physicochemical and device-related factors acting on the permeation kinetics of in vitro iontophoresis were performed. Iontophoresis increased the transdermal permeation flux of ketorolac as compared to the diffusion. Increase in applied current density or decrease in ionic strength of the donor solution enhanced the flux of the drug. Use of either platinum or silver/silver chloride electrodes resulted in similar enhancement of drug flux. Continuous current was more potent than pulsed current in promoting ketorolac transdermal permeation. Increasing the frequency or on:off ratio of pulse current induced an enhancement of the flux through the skin. An increase in donor drug loading dose or increasing the duration of current application resulted in enhancement of the drug flux. Pretreatment of the skin with D-limonene in ethanol or D-limonene in ethanol + ultrasound significantly enhanced the iontophoretic flux of the drug in comparison to passive flux with or without pretreatment. Trimodality treatment comprising of pretreatment with D-limonene in ethanol + ultrasound in combination followed by iontophoresis was found to be most potent for enhancing the rate of permeation of ketorolac.