Search

Summary: The synergistic effect of microwave and ultrasound irradiations was evaluated for biodiesel production from microalgae biomass (Nannochloropsis sp.) as raw material. A response surface methodology technique based on central composite design was used to understand the process parametric interdependence and optimize the process reaction variables. Reaction kinetics of algal fatty acid methyl ester (FAME) production was also studied. The optimum reaction conditions were determined as wet algal biomass to methanol ratio of 20 g to 30 mL, 1 wt% catalyst concentration, and 7‐minute reaction time at 140 W of microwave power and 140 W of ultrasound power. The estimated activation energy was 17,298 J/mol−1 K−1 for a first‐order reaction kinetics. This study revealed that microwave energy dissipation at a low rate of 140 W combined with 140 W of ultrasound intensity is adequate to produce FAMEs at a maximum yield of 48.2%. Results from this optimization study suggest that a more detailed and mechanistic energy optimization study is critical to increase the FAME yield and maximize energy benefits. [ABSTRACT FROM AUTHOR]

The study of in situ gas explosion to lyse the triglyceride-rich cells involves the solubilization of gas (e.g., carbon dioxide, CO2) in lipid-rich cells under pressure followed by a rapid decompression, which allows the gas inside the cell to rapidly expand and rupture the cell from inside out. The aim of this study was to perform the cell disruption using pressurized CO2 as well as to determine the solubility of CO2 in Rhodotorula glutinis cell suspension, sugar broth media, and spent media. Cell disruption of R. glutinis was performed at two pressures of 2,000 and 3,500 kPa, respectively, at 295.2 K, and it was found from both scanning electron microscopy (SEM) and plate count that a substantial amount of R. glutinis was disrupted due to the pressurized CO2. We also found a considerable portion of lipid present in the aqueous phase after the disruption at P = 3,500 kPa compared to control (no pressure) and P = 2,000 kPa, which implied that more intracellular lipid was released due to the pressurized CO2. Solubility of CO2 in R. glutinis cell suspension was found to be higher than the solubility of CO2 in both sugar broth media and spent media. Experimental solubility was correlated using the extended Henry's law, which showed a good agreement with the experimental data. Enthalpy and entropy of dissolution of CO2 were found to be −14.22 kJ mol−1 and 48.10 kJ mol−1 K−1, 9.64 kJ mol−1 and 32.52 kJ mol−1 K−1, and 7.50 kJ mol−1 and 25.22 kJ mol−1 K−1 in R. glutinis, spent media, and sugar broth media, respectively. © 2017 American Institute of Chemical Engineers Biotechnol. Prog., 33:737-748, 2017 [ABSTRACT FROM AUTHOR]

The study of in situ gas explosion to lyse the triglyceride-rich cells involves the solubilization of gas (e.g., carbon dioxide, CO 2 ) in lipid-rich cells under pressure followed by a rapid decompression, which allows the gas inside the cell to rapidly expand and rupture the cell from inside out. The aim of this study was to perform the cell disruption using pressurized CO 2 as well as to determine the solubility of CO 2 in Rhodotorula glutinis cell suspension, sugar broth media, and spent media. Cell disruption of R. glutinis was performed at two pressures of 2,000 and 3,500 kPa, respectively, at 295.2 K, and it was found from both scanning electron microscopy (SEM) and plate count that a substantial amount of R. glutinis was disrupted due to the pressurized CO 2 . We also found a considerable portion of lipid present in the aqueous phase after the disruption at P = 3,500 kPa compared to control (no pressure) and P = 2,000 kPa, which implied that more intracellular lipid was released due to the pressurized CO 2 . Solubility of CO 2 in R. glutinis cell suspension was found to be higher than the solubility of CO 2 in both sugar broth media and spent media. Experimental solubility was correlated using the extended Henry's law, which showed a good agreement with the experimental data. Enthalpy and entropy of dissolution of CO 2 were found to be -14.22 kJ mol -1 and 48.10 kJ mol -1  K -1 , 9.64 kJ mol -1 and 32.52 kJ mol -1  K -1 , and 7.50 kJ mol -1 and 25.22 kJ mol -1  K -1 in R. glutinis, spent media, and sugar broth media, respectively. © 2017 American Institute of Chemical Engineers Biotechnol. Prog., 33:737-748, 2017., (© 2017 American Institute of Chemical Engineers.)

Citrus byproducts (CBPs) are utilized as a low cost nutritional supplement to the diets of cattle and have been suggested to inhibit the growth of both Escherichia coli O157:H7 and Salmonella. The objective of this study was to examine the effects in vitro that varying concentrations of CBP in the powdered or pelleted variety have on the survival of Shiga-toxin Escherichia coli (STEC) serotypes O26:H11, O103:H8, O111:H8, O145:H28, and O157:H7 in bovine ruminal microorganism media. The O26:H11, O111:H8, O145:H28, and O157:H7 serotypes did not exhibit a change in populations in media supplemented with CBP with either variety. The O103:H8 serotype displayed a general trend for an approximate 1log(10) reduction in 5% powdered CBP and 20% pelleted CBP over 6 h. There was a trend for reductions in populations of a variant form of O157:H7 mutated in the stx1 and stx2 genes in higher concentrations of CBP. These results suggest that variations exist in the survival of these serotypes of STEC within mixed ruminal microorganism fluid media when supplemented with CBP. Further research is needed to determine why CBPs affect STEC serotypes differently.

The use of luminescent plasmids in bacteria may serve as a viable model for the real-time validation of various pre-harvest interventions on the colonization or shedding patterns of Escherichia coli O157:H7 within cattle. The objective of this study was to determine if the growth characteristics of E. coli O157:H7 in mixed ruminal and fecal microbial fluid cultures would be altered when transformed with one of the two luminescent plasmids: pAK1-lux (PAK) or pXEN-13 (XEN). Transformants harboring the luminescent plasmids were compared to the non-transformed parental strain (wild type [WT]) after incubating in mixed ruminal or fecal microbial fluid media for 6 h in triplicate (n=3). The transformants and WT exhibited similar growth rates. Within mixed ruminal microbial fluid fermentations and mixed fecal microbial fluid, all transformants grew similarly (p=0.28) through the 6-h study. The reflective light unit (RLU; photons/pixel per second) photonic emissions of each plasmid within ruminal fluid differed at 0 h (p=0.002) and 2 h (p=0.02) and within fecal fluid at 0 h (p=0.009) and 2 h (p=0.04). The RLU remained the same within rumen fluid at 4 h (p=0.22) and 6 h (p=0.80) and within fecal fluid at 4 h (p=0.06) and 6 h (p=0.29). Growth of E. coli O157:H7 transformed with the bioluminescent plasmids was not altered in comparison to the WT, suggesting that both plasmids may serve as useful models for in vivo studies.

While Shiga toxin-producing Escherichia coli (STEC) reside asymptomatically within ruminants, particularly cattle, these strains pose a serious health risk to humans. Research related to STEC has historically focused upon O157:H7. However, with an increase in foodborne outbreaks of non-O157 origin and recent changes in testing for non-O157 by the U.S. Department of Agriculture Food Safety and Inspection Service (USDA-FSIS), there is now a critical need to understand the biological activity of non-O157 serogroups. The focus of this study was to determine whether variations exist in the ability of different serotypes of STEC to survive within bovine rumen fluid medium and bile salts. The results of this study demonstrated through viable plate count analysis that the five serotypes tested (O157:H7, O111:H8, O103:K.:H8, O145:H28, and O26:H11) were capable of growing in rumen fluid medium. However, the concentrations of the serotypes O103:K.:H8 and O26:H11 after 24 h were significantly less (p < 0.05) than that observed for the other serotypes tested. A significant decrease (p = 0.03) in the survival of O103:K.:H8 in 50 mg/mL of bovine bile salts in comparison to the other STEC strains tested was also observed. Collectively, these data suggest that non-O157 serogroups of E. coli respond differently to the environment of the bovine gastrointestinal tract. Further research is needed to elucidate how these differential physiological variations correlate with alterations in colonization success within ruminants and how they may impact human illnesses.