Search

Additive solutions are used to limit changes that red blood cells (RBCs) undergo during storage. Several studies have shown better preservation of glucose and redox metabolism using the alkaline additive solution PAGGGM (phosphate-adenine-glucose-guanosine-gluconate-mannitol). In this randomized open-label intervention trial in 20 healthy volunteers, the effect of storage, PAGGGM vs SAGM (saline-adenine-glucose-mannitol), on posttransfusion recovery (PTR) and metabolic restoration after transfusion was assessed. Subjects received an autologous biotinylated RBC concentrate stored for 35 days in SAGM or PAGGGM. As a reference for the PTR, a 2-day stored autologous biotinylated RBC concentrate stored in SAGM was simultaneously transfused. RBC phenotype and PTR were assessed after transfusion. Biotinylated RBCs were isolated from the circulation for metabolomics analysis up to 24 hours after transfusion. The PTR was significantly higher in the 2-day stored RBCs than in 35-day stored RBCs 2 and 7 days after transfusion: 96% (90 to 99) vs 72% (66 to 89) and 96% (90 to 99) vs 72% (66 to 89), respectively. PTR of SAGM- and PAGGGM-stored RBCs did not differ significantly. Glucose and redox metabolism were better preserved in PAGGGM-stored RBCs. The differences measured in the blood bag remained present only until 1 day after transfusion. No differences in RBC phenotype were found besides an increased complement C3 deposition on 35-day RBCs stored in PAGGGM. Our data indicate that despite better metabolic preservation, PAGGGM is not a suitable alternative for SAGM because storage in PAGGGM did not result in an increased PTR. Finally, RBCs recovered from circulation after transfusion showed reversal of the metabolic storage lesion in vivo within a day. This study is registered in the Dutch trial register (NTR6492).

Platelet components are commonly transfused to patients for a variety of indications, including patients with low platelet counts or patients with platelet dysfunction who are bleeding or at high risk of bleeding. Although the risk of pathogen contamination of platelet components has declined significantly over the last 40 years, it remains a concern for the patients, for blood banks and for physicians. Pathogen inactivation (PI) technologies have been developed to mitigate this risk. This review focuses on the residual risks of transfusion-transmitted bacterial infections by platelet transfusion after PI. We describe and assess the relationship between the bacterial load and the timing and capacity of reduction of the different PI technologies, as well as the risks that could represent spore-forming microorganisms and the possible introduction of microorganisms after PI.

Background and Objectives: In many countries, whole blood (WB) donations with collection times between 12 and 15 min are not allowed to be used for platelet concentrates (PC). Since the development of guidelines, many process-related changes have been introduced. We aimed to determine the effect of WB with long collection times on PC quality. Materials and Methods: Five participating centres tested buffy coat (BC)-derived PC in platelet additive solution type E prepared from only WB collections lasting 12 min (study group, n = 8). One centre produced platelet-rich plasma (PRP)-derived PC from single donations (12 min). All PC were stored at 22 ± 2°C and sampled on Days 1, 6 and 8 post-collection for in vitro quality determination. Results: Average collection time was significantly longer in the study group compared to controls (8.9 ± 2.6 vs. 7.3 ± 1.3 min, p < 0.001). There were no differences in volume, platelet concentration, basal CD62P expression, soluble-CD62P and CCL5 levels, or nucleotide content between the groups. Stimulation with TRAP-6 resulted in comparable levels of cell surface CD62P. On Day 8, all PC fulfilled requirements for pH. The findings from single PRP-derived PC centre were similar. Conclusion: PC with one BC and single PRP derived from collections lasting >12 min had equivalent in vitro quality to controls during storage. This study provides evidence that 12–15 min donations should not be excluded for PC preparation and justifies to readdress the guidelines to

Background: Transfusion-related acute lung injury (TRALI) is a severe complication of blood transfusion that is thought of as a two-hit event: first the underlying patient condition (e.g., sepsis), and then the transfusion. Transfusion factors include human leukocyte antigen antibodies or biologic response modifiers (BRMs) accumulating during storage. Preclinical studies show an increased TRALI risk with longer stored platelets, clinical studies are conflicting. We aim to discover whether longer platelet concentrate (PC) storage time increases TRALI risk in a controlled human experiment. Study Design and Methods: In a randomized controlled trial, 18 healthy male volunteers received a first hit of experimental endotoxemia (2 ng/kg lipopolysaccharide), and a second hit of fresh (2-day old) or aged (7-day old) autologous PC, or physiological saline. After 6 h, changes in TRALI pathways were determined using spirometry, chest X-ray, and bronchoalveolar lavage (BAL). Results: All subjects reacted adequately to lipopolysaccharide infusion and satisfied SIRS criteria (increased pulse [>90/min] and temperature [>38°C]). There were no differences between the saline, fresh, and aged PC groups in BAL-fluid protein (95 ± 33 μg/ml; 83 ± 21 μg/ml and 104 ± 29 μg/ml, respectively) and relative neutrophil count (1.5 ± 0.5%; 1.9 ± 0.8% and 1.3 ± 0.8%, respectively), nor in inflammatory BAL-fluid BRMs (Interleukin-6, CXCL8, TNFα (Formula presented.) and myeloperoxidase), clinical respiratory parameters, and spirometry results. All chest X-rays were normal. Conclusions: In a human endotoxemia model of autologous platelet transfusion, with an adequate first hit and platelet storage lesion, transfusion of 7-day-old PC does not increase pulmonary inflammation compared with 2-day-old PC.

Background: Platelets (PLTs) differ in glycolytic activity, resulting in rapid acidification of ‘poor’ storing PLT concentrates (PCs) in plasma, or depletion of glucose when stored in PLT additive solution (PAS). We aimed to understand why PLT glycolysis rates vary between donors and how this affects storage performance. Study Design and Methods: Buffy coats from donors 70 years were selected and single-donor PCs in plasma or PAS-E were prepared. PCs were stored for 8 days at 22 ± 2°C and sampled regularly for analysis. Mitochondrial activity was analyzed with an Oroboros oxygraph. Age groups, or subgroups divided into quartiles based on glucose consumption, were analyzed with ANOVA. Results: In each comparison, PCs of the different groups were not different in volume and cellular composition. PLTs with the highest glucose consumption had a higher initial mean platelet volume (MPV) and developed higher CD62P expression and Annexin A5 binding during storage. Higher glycolytic activity in these PLTs was not a compensation for lower mitochondrial ATP production, because mitochondrial ATP-linked respiration of fresh PLTs correlated positively with MPV (R2 = 0.71). Donors of high glucose-consuming PLTs had more health-related issues. Storage properties of PCs from donors over 70 were not significantly different compared to PCs from donors younger than 45 years. Conclusions: High glucose-consuming PCs developing higher activation levels, not only displayed enhanced mitochondrial activity but were also found to contain larger PLTs, as determined by MPV. Storage performance of PLTs was found to be associated with donor health, but not with donor age.

DEHP, di(2-ethylhexyl) phthalate, is the most common member of the class of ortho-phthalates, which are used as plasticizers. The Medical Device Regulation has restricted the use of phthalates in medical devices. Also DEHP has been added to the Annex XIV of REACH, "Registration, Evaluation, Authorisation and Restriction of Chemicals" due to its endocrine disrupting properties to the environment. As such, the sunset date for commercialisation of DEHP-containing blood bags is May 27Based on data as well as the input of relevant stakeholders a rationale for the validation of each component was composed.The red cell components will require the most extensive validation as their quality is directly affected by the absence of DEHP, as opposed to platelet and plasma components.Studies in the scope of evaluating the quality of blood products obtained with non-DEHP devices, under the condition that they are carried out according to these recommendations, could be used by all members of the EBA to serve as scientific support in the authorization process specific to their jurisdiction or for their internal validation use.

Item does not contain fulltext BACKGROUND AND OBJECTIVES: Di-ethyl-hexyl-phthalate (DEHP) is currently the main plasticizer used for whole blood collection systems. However, in Europe, after May 2025, DEHP may no longer be used above 0.1% (w/w) in medical devices. DEHP stabilizes red cell membranes, thereby suppressing haemolysis during storage. Here we compared in vitro quality parameters of red cell concentrates (RCCs) collected and stored in DEHP-, DINCH- or DINCH/BTHC-PVC hybrid blood bags with saline-adenine-glucose-mannitol (SAGM) or phosphate-adenine-glucose-guanosine-saline-mannitol (PAGGSM) storage solution. Last, we performed haemovigilance surveillance for RCC collected in DINCH-PVC and stored in PAGGSM/BTHC-PVC. MATERIALS AND METHODS: In vitro quality parameters of RCC were determined during 42 days of storage. Haemovigilance surveillance was conducted to compare the frequency and type of transfusion reaction. RESULTS: Haemolysis levels were increased in SAGM/BTHC-PVC as compared to SAGM/DEHP-PVC (0.66% ± 0.18% vs. 0.36% ± 0.17%). PAGGSM storage solution was able to adequately suppress haemolysis to levels observed during storage in SAGM/DEHP-PVC, both in BTHC-PVC (0.38% ± 0.12%), and to a slightly lesser extent in DINCH-PVC (0.48% ± 0.17%). A total of 1650 PAGGSM/BTHC-PVC and 5662 SAGM/DEHP-PVC RCC were transfused yielding a transfusion reaction frequency of 0.24% (95% CI 0.0000-0.0048) and 0.44% (95% CI 0.0027-0.0061) respectively. CONCLUSION: The in vitro quality of RCC stored in PAGGSM/BTHC-PVC and SAGM/DEHP-PVC is comparable. There is no indication that transfusion of erythrocytes stored in PAGGSM/BTHC-PVC results in increased transfusion reaction frequency. These initial results provide a basis for further clinical evaluation to narrow down the confidence interval of transfusion reaction frequency.

BACKGROUND AND OBJECTIVES: Di(2-ethylhexyl) phthalate (DEHP) must be removed from blood bag sets in Europe by 27 May 2025. DEHP is known to interact with the red blood cell (RBC) membrane, resulting in reduced haemolysis and thus prolonging shelf-life. Current non-DEHP alternatives result in increased haemolysis requiring reconsideration of the RBC shelf-life. Although the immediate impact of eliminating DEHP is to the European community, the non-DEHP movement could affect blood bag set availability globally. The purpose of this survey is to understand blood centre readiness regarding the transition to non-DEHP blood collection and storage systems. MATERIALS AND METHODS: A 24-question on-line survey was completed by members of the Biomedical Excellence for Safer Transfusion Collaborative research network. RESULTS: Responses were obtained from 16 blood collection or processing institutions. A majority of respondents (12/16) indicated that both shelf-life and haemolysis were equally important in selecting non-DEHP blood bag sets. Six respondents would accept a lower RBC product shelf-life compared to current practice. Respondents were not clear on the best non-DEHP vinyl material or RBC storage solution. Three European blood centres indicated they have developed non-DEHP transition plans. One challenge identified regarding the transition to non-DEHP is the extensive validation testing that will be required. CONCLUSION: Blood centres in Europe are concerned with meeting the sunset date for DEHP, considering that limited non-DEHP blood bag and RBC storage solutions are currently available. Banning DEHP in Europe, which may have global ramifications, represents a major challenge not yet fully understood by the transfusion medicine community.

Gamma irradiation of red cell concentrates (RCCs) is regularly used to prevent transfusion-associated graft-versus-host disease (TA-GvHD) in at-risk patients. While studies have indicated that irradiated RCCs exhibit increased hemolysis, there have been no efforts to differentiate between free- and microvesicle (MV)-bound hemoglobin (Hb). As an increase in the proportion of free-Hb in irradiated RCCs could alter vascular function, we sought to characterize differences in the state of extracellular Hb based on the timing of irradiation.Four separate pools of seven CPD/SAGM leukoreduced RCCs were produced and split into four sets of seven identical units. The units from each set were subject to irradiation (25 Gy) at six different points during storage, with one unit serving as a nonirradiated control. All testing was performed immediately following unit expiry on day 43.The earlier in storage that units were irradiated, the higher the hemolysis and the lower the proportion of MV-bound Hb. Units irradiated earlier in storage (1-8 days post collection) additionally had lower membrane rigidity (KOur findings indicate that irradiation timing can alter the state of extracellular Hb, with "early" irradiation promoting an increased proportion of cell-free Hb as well as mechanical damage to the RBC membrane.

Labeling of platelets (PLTs) is essential for research purposes, in order to measure the recovery and survival of transfused PLTs in vivo. Biotinylation is a promising new alternative to the gold standard of radioactive labeling. This review highlights 4 key publications that provide significant insights into biotin-labeled PLTs (bioPLTs). Stohlawetz et al. established that transfusion of bioPLTs in human recipients is possible. De Bruin et al. developed a standardized, reproducible protocol for biotinylation of PLTs as a promising method to trace and isolate transfused PLTs in vivo, with reduced levels of PLT activation markers. Muret et al. developed a nonwashing biotin labeling method to implement in a blood bank environment. Finally, in a preclinical study, Ravanat et al. showed that different densities of biotin can be used to concurrently monitor multiple populations of human PLTs in the circulation of the same subject. These studies have made major contributions to the development of bioPLTs as a viable option for use in human research, and indicate that bioPLTs can be safely administered, preferably at a low density of biotin.

BACKGROUND: Platelet transfusions can be associated with adverse reactions, such as febrile non-haemolytic transfusion reaction (FNHTR). It has been suggested that damage-associated molecular patterns (DAMP) and complement play a role in FNHTR. This study investigated the nature of DAMPs and complement activation products contained in platelet concentrates during storage, with a specific focus on different platelet storage solutions. MATERIALS AND METHODS: Buffy coats (BC) from healthy donors were pooled (15 BC per pool) and divided into three groups of the same volume. After addition of different storage solutions (plasma, platelet additive solutions [PAS]-C or PAS-E; n=6 for each group), BC pools were processed to platelet concentrates (PC). Leukoreduced PCs were stored on a shaking bed at 20–24°C and sampled on days 1, 2, 6 and 8 after collection for selected quality parameters: platelet activation, DAMPs (High Mobility Group Box 1 [HMGB1], nucleosomes), and complement activation products. RESULTS: During storage, equal levels of free nucleosomes and increasing concentrations of HMGB1 were present in all groups. Complement activation was observed in all PC. However, by day 8, the use of PAS had reduced C3b/c levels by approximately 90% and C4b/c levels by approximately 65%. DISCUSSION: Nucleosomes and HMGB1 were present in PCs prepared in plasma and PAS. Complement was activated during storage of platelets in plasma and in PAS. The use of PAS is associated with a lower amount of complement activation products due to the dilution of plasma by PAS . Therefore, PC in PAS have less complement activation products than platelets stored in plasma. These proinflammatory mediators in PC might induce FNHTR.

Background: Transfusion transmitted bacterial infection (TTBI) due to contamination of platelets is an important risk of blood transfusion. Our strategies to decrease bacterial contamination include skin disinfection, diversion of the first blood flow, and bacterial screening. Despite these intervention strategies, a residual risk remains. Methods: To assess this remaining risk, we retrospectively examined TTBI cases registered in the national notification database Transfusion and Transplantation Reactions in Patients (TRIP) during 2008–2019. In addition, we retrospectively examined all cases in which platelets that tested positive in the bacterial screening had already been transfused from 2013 to 2019. The bacterial screening was performed by sampling platelet concentrates 17–25 hours after blood collection, followed by a 7-day incubation of aerobic and anaerobic blood culture bottles in the BacT/ALERT® system. The distribution of bacterial species in the bacterial screening of platelets was also characterized. Results: We found 16 cases of possible/probable/certain TTBI associated with platelet transfusion in 2008–2019, including two certain TTBI (with one fatal case); in all of these cases, bacterial screening was negative. From 2013 to 2019, 1,382 out of 432,305 distributed platelets were positive (0.32%) in the bacterial screening, and 469 had already been transfused. In 20 of these 469 cases, a transfusion reaction was reported, 5 potentially related to contaminated buffy coat-derived platelets. Bacterial screening showed mostly skin bacteria, including Cutibacterium spp. and coagulase-negative staphylococci. Most virulent bacteria were detected within 48 hours. Conclusions: In summary, our two approaches demonstrate a small residual risk of TTBI due to platelet contamination, with two certain TTBIs, including one fatal case, per 668,896 distributed platelets during 12 years.