Search

Residual host cell proteins (HCPs) in the drug product can affect product quality, stability, and/or safety. In particular, highly active hydrolytic enzymes at sub-ppm levels can negatively impact the shelf life of drug products but are challenging to identify by liquid chromatography-mass spectrometry/mass spectrometry (LC-MS/MS) due to their high dynamic range between HCPs and biotherapeutic proteins. We employed new strategies to address the challenge: (1) native digest at a high protein concentration; (2) sodium deoxycholate added during the reduction step to minimize the inadvertent omission of HCPs observed with native digestion; and (3) solid phase extraction with 50% MeCN elution prior to LC-MS/MS analysis to ensure effective mAb removal. A 50 cm long nanoflow charged surface hybrid column was also packed to allow for higher sample load for increased sensitivity. Our workflow has increased the sensitivity for HCP identification by 10- to 100-fold over previous reports and showed the robustness as low as 0.1 ppm for identifying HCPs (34.5 to 66.2 kDa MW). The method capability was further confirmed by consistently identifying85% of 48 UPS-1 proteins (0.10 to 1.34 ppm, 6.3 to 82.9 kDa MW) in a monoclonal antibody (mAb) and the largest number (746) of mouse proteins from NIST mAb reported to date by a single analysis. Our work has filled a significant gap in HCP analysis for detecting and demonstrating HCP clearance, in particular, extremely low-level hydrolases in drug process development.

Hydrolytic degradation of polysorbate during 2–8°C storage of monoclonal antibody drug products has been attributed to residual enzymes (e.g., esterases) from bioprocessing steps. Robust detection of esterase activity using sensitive, non-polysorbate surrogate substrates can provide an alternate method to assess polysorbate degradation risk, if the correlation between the esterase activity and polysorbate degradation is established. A general esterase activity assay was developed as a monitoring and characterization tool during bioprocess development of monoclonal antibodies. We report a fluorescence plate-based assay for quantifying esterase activity, utilizing 4-methylumbelliferyl caprylate (MU-C8) as the esterase substrate. The assay was first assessed for substrate, inhibitor and pH specificity using both model enzymes and purified protein samples. The assay was then extensively tested to understand sample matrix effects on activity rates. The use of this high-throughput method will allow for rapid characterization of protein samples in under three hours. The esterase activity correlated directly with polysorbate degradation and can provide valuable information on polysorbate degradation risk throughout drug development.

Chinese hamster ovary (CHO) cell engineering based on CRISPR/Cas9 knockout (KO) technology requires the delivery of guide RNA (gRNA) and Cas9 enzyme for efficient gene targeting. With an ever-increasing list of promising gene targets, developing and optimizing a multiplex gene KO protocol is crucial for rapid CHO cell engineering. Here, we describe a method that can support efficient targeting and KO of up to ten genes through sequential transfections. This method utilizes Cas9 protein to first screen multiple synthetic gRNAs per gene, followed by Sanger sequencing indel analysis, to identify effective gRNA sequences. Using sequential transfections of these potent gRNAs led to the isolation of single cell clones with the targeted deletion of all ten genes (as confirmed by Sanger sequencing at the DNA level and mass spectrometry at the protein level). Screening 704 single cell clones yielded 6 clones in which all 10 genes were deleted through sequential transfections, demonstrating the success of this decaplex gene editing strategy. This pragmatic approach substantially reduces the time and effort required to generate multiple gene knockouts in CHO cells. This article is protected by copyright. All rights reserved.

Degradation of polysorbate (PS) by hydrolytically active host cell proteins (HCPs) in drug products may impair the protein-stabilizing properties of PS and lead to the formation of particles due to the accumulation of poorly soluble free fatty acids upon long-term storage. The identification of the causative enzymes is challenging due to their low-abundance even when using state-of-the-art instrumentation and workflows. To overcome these challenges, we developed a rigorous enrichment strategy for HCPs, utilizing both Protein A and anti-HCP affinity chromatography, which facilitated the in-depth characterization of the HCP population in a monoclonal antibody formulation prone to PS hydrolysis. Based on the HCPs identified by liquid chromatography coupled to tandem mass spectrometry, a number of enzymes annotated as hydrolases were recombinantly expressed and characterized in terms of polysorbate degradation. Among the selected candidates, Lipoprotein Lipase, Lysosomal Acid Lipase (LIPA) and Palmitoyl-Protein Thioesterase 1 (PPT1) exhibited notable activity towards PS. To our knowledge, this is the first report to identify LIPA and PPT1 as residual HCPs that can contribute to PS degradation in a biological product.

Hydrolytic degradation of polysorbate during 2-8°C storage of monoclonal antibody drug products has been attributed to residual enzymes (e.g., esterases) from bioprocessing steps. Robust detection of esterase activity using sensitive, non-polysorbate surrogate substrates can provide an alternate method to assess polysorbate degradation risk, if the correlation between the esterase activity and polysorbate degradation is established.A general esterase activity assay was developed as a monitoring and characterization tool during bioprocess development of monoclonal antibodies.We report a fluorescence plate-based assay for quantifying esterase activity, utilizing 4-methylumbelliferyl caprylate (MU-C8) as the esterase substrate. The assay was first assessed for substrate, inhibitor and pH specificity using both model enzymes and purified protein samples. The assay was then extensively tested to understand sample matrix effects on activity rates.The use of this high-throughput method will allow for rapid characterization of protein samples in under three hours. The esterase activity correlated directly with polysorbate degradation and can provide valuable information on polysorbate degradation risk throughout drug development.

Cryopreservation provides the foundation for research, development, and manufacturing operations in the CHO-based biopharmaceutical industry. Despite its criticality, studies are lacking that explicitly demonstrate that the routine cell banking process and the potential stress and damage during cryopreservation and recovery from thaw have no lasting detrimental effects on CHO cells. Statistics are also scarce on the decline of cell-specific productivity (Qp ) over time for recombinant CHO cells developed using the glutamine synthetase (GS)-based methionine sulfoximine (MSX) selection system. To address these gaps, we evaluated the impact of freeze-thaw on 24 recombinant CHO cell lines (generated by the GS/MSX selection system) using a series of production culture assays. Across the panel of cell lines expressing one of three monoclonal antibodies (mAbs), freeze-thaw did not result in any significant impact beyond the initial post-thaw passages. Production cultures sourced from cryopreserved cells and their non-cryopreserved counterparts yielded similar performance (growth, viability, and productivity), product quality (size, charge, and glycosylation distributions), and flow cytometric profiles (intracellular mAb expression). However, many production cultures yielded lower Qp at increased cell age: 17 of the 24 cell lines displayed ≥20% Qp decline after ∼2-3 months of passaging, irrespective of whether the cells were previously cryopreserved. The frequency of Qp decline underscores the continued need for understanding the underlying mechanisms and for careful clone selection. Because our experiments were designed to decouple the effects of cryopreservation from those of cell age, we could conclusively rule out freeze-thaw as a cause for Qp decline. © 2018 American Institute of Chemical Engineers Biotechnol. Prog., 34:463-477, 2018.

The extent of afucosylation, which refers to the absence of core fucose on Fc glycans, can correlate positively with the antibody-dependent cellular cytotoxicity (ADCC) activity of a monoclonal antibody (mAb). Therefore, it is important to maintain consistent afucosylation during cell culture process scale-up in bioreactors for a mAb with ADCC activity. However, there is currently a lack of understanding about the impact of partial pressure of carbon dioxide (pCO2 )-a parameter that can vary with bioreactor scale-on afucosylation. Using a small-scale (3 L) bioreactor model that can modulate pCO 2 levels through modified configurations and gassing strategies, we identified three cell culture process parameters that influence afucosylation of a mAb produced by a recombinant Chinese Hamster Ovary (CHO) cell line: pCO 2 , media hold duration (at 37°C), and manganese. These three-independent parameters demonstrated a synergistic effect on mAb afucosylation; increase in pCO 2 , media hold duration, and manganese consistently increased afucosylation. Our investigations into the underlying mechanisms through proteomic analysis indicated that the synergistic interactions downregulated pathways related to guanosine diphosphate-fucose synthesis and fucosylation, and upregulated manganese transport into the CHO cells. These new findings highlight the importance of considering potential differences in culture environment and operations across bioreactor scales, and understanding the impact of their interactions on product quality.

Protein carbonylation is a posttranslational modification referring to the occurrence of aldehydes and ketones in proteins. The current understanding of how carbonylation, in particular, metal-catalyzed carbonylation, occurs in recombinant mAbs during production and storage is very limited. To facilitate investigations into mAb carbonylation, we developed a protein carbonylation assay with improved assay robustness and precision over the conventional assays. We applied this assay to investigate mAb carbonylation under production, storage, and stress conditions and showed that iron, hydrogen peroxide, and polysorbate 20 at pharmaceutically relevant levels critically influence the extent of mAb carbonylation. In addition, we found that while carbonylation correlates with mAb aggregation in several cases, carbonylation cannot be used as a general indicator for aggregation. Furthermore, we observed that mAb carbonylation level can decrease during storage, which indicates that carbonylation products may not be stable. Finally, we report for the first time a positive correlation between carbonylation and acidic charge heterogeneity of mAbs that underwent metal-catalyzed oxidation. This finding shows that the impact of protein carbonylation on product quality for mAbs is not limited to aggregation but also extends to charge heterogeneity.

To understand the diversity in the cell culture harvest (i.e., feedstock) provided for downstream processing, we compared host cell protein (HCP) profiles using three Chinese Hamster Ovary (CHO) cell lines in null runs which did not generate any recombinant product. Despite differences in CHO lineage, upstream process, and culture performance, the cell lines yielded similar cell-specific productivities for immunogenic HCPs. To compare the dynamics of HCP production, we searched for correlations between the time-course profiles of HCP (as measured by multi-analyte ELISA) and those of two intracellular HCP species, phospholipase B-like 2 (PLBL2) and lactate dehydrogenase (LDH). Across the cell lines, proteins in the day 14 supernatants analyzed by two-dimensional polyacrylamide gel electrophoresis (2D-PAGE) showed different spot patterns. However, subsequent analysis by liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) indicated otherwise: the total number of peptides and proteins identified were comparable, and 80% of the top 1,000 proteins identified were common to all three lines. Finally, to assess the impact of culture viability on extracellular HCP profiles, we analyzed supernatants from a cell line whose viability dropped after day 10. The amounts of HCP and PLBL2 (quantified by their respective ELISAs) as well as the numbers and major populations of HCPs (identified by LC-MS/MS) were similar across days 10, 14, and 17, during which viabilities declined from ∼80% to 107 cells/mL)—operated in fed-batch mode and exhibiting high viabilities (>70%) throughout the culture duration—can accumulate a considerable amount of immunogenic HCP (∼1–2 g/L) in the extracellular environment at the time of harvest (day 14). This work also demonstrates the potential of using LC-MS/MS to overcome the limitations associated with ELISA and 2D-PAGE for HCP analysis. Biotechnol. Bioeng. 2015;112: 2068–2083. © 2015 Wiley Periodicals, Inc.

To understand the diversity in the cell culture harvest (i.e., feedstock) provided for downstream processing, we compared host cell protein (HCP) profiles using three Chinese Hamster Ovary (CHO) cell lines in null runs which did not generate any recombinant product. Despite differences in CHO lineage, upstream process, and culture performance, the cell lines yielded similar cell-specific productivities for immunogenic HCPs. To compare the dynamics of HCP production, we searched for correlations between the time-course profiles of HCP (as measured by multi-analyte ELISA) and those of two intracellular HCP species, phospholipase B-like 2 (PLBL2) and lactate dehydrogenase (LDH). Across the cell lines, proteins in the day 14 supernatants analyzed by two-dimensional polyacrylamide gel electrophoresis (2D-PAGE) showed different spot patterns. However, subsequent analysis by liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) indicated otherwise: the total number of peptides and proteins identified were comparable, and 80% of the top 1,000 proteins identified were common to all three lines. Finally, to assess the impact of culture viability on extracellular HCP profiles, we analyzed supernatants from a cell line whose viability dropped after day 10. The amounts of HCP and PLBL2 (quantified by their respective ELISAs) as well as the numbers and major populations of HCPs (identified by LC-MS/MS) were similar across days 10, 14, and 17, during which viabilities declined from ∼80% to20% and extracellular LDH levels increased several-fold. Our findings indicate that the CHO-derived HCPs in the feedstock for downstream processing may not be as diverse across cell lines and upstream processes, or change as dramatically upon viability decline as originally expected. In addition, our findings show that high density CHO cultures (10(7) cells/mL)-operated in fed-batch mode and exhibiting high viabilities (70%) throughout the culture duration-can accumulate a considerable amount of immunogenic HCP (∼1-2 g/L) in the extracellular environment at the time of harvest (day 14). This work also demonstrates the potential of using LC-MS/MS to overcome the limitations associated with ELISA and 2D-PAGE for HCP analysis.