Search

Broiler carcasses are often trimmed during evisceration to remove damaged areas of the carcass. Because deboning before rigor mortis development can toughen meat, trimming during evisceration may toughen the meat. This study evaluated the effects of trimming on the tenderness of broiler breast meat. To evaluate the effect of wing removal on tenderness, breast halves from 2 flocks were collected after chilling at a commercial plant. One-third were untrimmed controls, one-third had small amounts of breast meat removed with wing (WMin), and one-third had large amounts of breast meat removed with wing (Wmax). Salvage fillets from the 2 flocks were also collected from the salvage table of the plant. Carcasses were also processed to evaluate the effect of breast blister trimming that removed a superficial amount of muscle tissue, half of which had breast blister trims, and half did not. All front halves or carcasses were aged until 24 h postmortem and deboned. Salvage fillets were held refrigerated until 24 h postmortem. Fillets were cooked and then sheared in 2 locations on the fillet, upper and lower, to determine if tenderness was more affected at areas close to the trim. Carcasses with wing trims had significantly higher shear values compared with the control, and shear values from the upper portion of the fillets from the WMax and WMin (nearer the trim) were significantly greater than for the lower portion. Location, however, did not affect shear values in the control carcasses. This finding indicated that tenderness of the areas nearest the trim might be affected more by the trim process. Salvage table deboning significantly increased shear values throughout the fillet. There was no significant difference in shear value due to breast blister trimming. The results of this study suggest that trimming carcasses by wing or breast fillet removal results in decreased meat tenderness.

Postmortem electrical stimulation (ES) tenderizes meat by acceleration of adenosine triphosphate (ATP) depletion, pH decline, and physical disruption of muscle fibers. It has been demonstrated that rigor development at elevated temperatures, as with slow chilling, can cause meat to develop pale color and poor water-holding capacity. The objective of this study was to compare the functionality of broiler breast meat from control and electrically stimulated carcasses with and without normal rapid chilling. Broilers were either electrically stimulated (450 mA, 450 V, 2 s on, 2 s off for 7 pulses) immediately after bleeding or used as nonstimulated controls. The ES birds were either chilled immediately (ES2) or had chilling delayed for 2 h at room temperature (ESD2). All ES breast fillets were harvested at 2 h postmortem. The control carcasses were chilled immediately and had fillets harvested at 2 h postmortem (C2) or at 8 h postmortem (C8). Electrical stimulation accelerated pH decline and prevented toughening when breast meat was deboned at 2 h postmortem, regardless of chilling rate. The water released from the gels during cooking was higher for the ESD2 than the ES2 group, which was not different from the C2 group, suggesting that ES followed by slow chilling reduced water-holding capacity compared with the ES2 and C2 groups. There were no differences in expressible moisture, gel strength, or lightness among the ES2, ESD2, and C2 treatments. These results indicated that high voltage ES followed by normal chilling did not impair protein functionality or cause pale, soft, exudative meat. However, there was some evidence that slow chilling after ES may negatively affect some water-holding properties of the meat.

Broiler carcass skin color is important in the United States and Mexico. This study evaluated the use of natural and synthetic pigments in broiler diets at commercial levels. Birds were fed natural or synthetic pigments at low or high levels, simulating US and Mexican commercial practices. Skin color was measured during live production (3 to 7 wk of age) and after slaughter and chilling. The natural pigments had consistently greater skin b* values (yellowness) than the synthetic pigments. The high levels produced greater skin b* values than the low levels, regardless of source. The synthetic pigments had a slower increase in skin b* but reached the same level as the natural low by 7 wk. There was no difference in skin a* values (redness) due to pigment source or level or the age of the bird. By 7 wk, all pigment sources approached plateau levels in the blood, but the synthetic pigment diet produced higher blood levels of yellow and red pigments than the natural pigment diets. Processing intensified skin yellowness and reduced skin redness. These data suggest that although synthetic pigments might have been absorbed better than natural ones, natural pigments were more efficient at increasing skin yellowness and there were only small differences between high and low levels for each pigment source. This finding may allow reduction in pigment use and feed cost to achieve the same skin acceptance by the consumer.

Pale, soft, exudative (PSE) turkey meat is a growing problem for the industry of further processed poultry meat. The low pH condition due to rapid glycolysis while the body temperature is still high leads to protein denaturation, causing pale color and reduced water-holding capacity. This condition impacts product yield and quality. These studies were designed to estimate the incidence of PSE broiler meat in a commercial plant and to use response surface methodology to characterize the relationship between pH and lightness (at deboning and at 24 h postmortem), expressible moisture, drip loss, and cook loss. Pale fillets had significantly lower pH, greater L* values at 3 and 24 h postmortem, and higher expressible moisture, drip loss, and cook loss. The lower water-holding capacity of the pale fillets was characteristic of PSE meat. Additionally, L* values were measured on 3,554 boneless broiler breast fillets in a commercial processing line. By using the L* value range (>54) from the pale group of fillets as an indication of paleness, approximately 47% of the 3,554 fillets were pale and could potentially exhibit poor water-holding capacity. These results may not represent the entire industry but indicate that PSE chicken can represent a substantial proportion of commercially processed broiler meat.

Pale, soft, exudative (PSE) turkey meat is a growing problem for industry and has been associated with rapid postmortem pH decline and loss of protein functionality, similar to PSE pork. This study was designed to estimate the incidence of PSE meat in a commercial plant and use response surface methodology to characterize the relationship between pH, lightness (L* value), and water-holding capacity (WHC). One hundred thirty-four turkey breast fillets were selected from the processing line so that 67 had normal color (lightness), and the other 67 were more pale than normal. Fillets were analyzed at time of deboning (1.5 h postmortem) and at 24 h postmortem for color (L* value), pH, drip loss, expressible moisture, and temperature. Additionally, L* values were measured on 2,995 turkey breasts from the processing line to determine the commercial incidence of PSE meat based on color. The pale fillets had significantly lower pH, greater L* value, and less WHC but equal temperature when compared with the fillets with normal color. The L* value and pH were correlated with WHC as measured by expressible moisture, but L* value seems to have more predictive value. By using the L* value range (>53) from the pale-selected fillets as an indication of paleness, approximately 40% of the 2,995 fillets would exhibit poor WHC. These results suggest that PSE meat can represent a significant portion of commercially processed turkey breast meat and that the L* value measurement could be used to sort turkey meat so that PSE type meat could be used in specialized formulations.

High voltage post-mortem electrical stimulation (ES) and muscle tensioning during chilling (MT) were applied to broiler carcasses to determine the effect of this combined treatment on absorbance ratio (R- value), sarcomere shortening, and myofibrillar fragmentation in muscles of differing fiber type composition. The ES + MT treatment resulted in a greater effect on these three parameters in the posterior Latissimus dorsi (predominantly twitch-glycolytic) than in the anterior L. dorsi (predominantly tonic-oxidative). The differing responses of these two muscles to the ES + MT treatment combination may be useful in explaining the effects of rigor-accelerating treatments such as ES + MT in avian and mammalian muscles.