Search

Synchrotron microfocus small angle X-ray scattering was used to investigate the nanostructure and microscopic variation of eggshells. It uses a microbeam allowing the ability to probe interactions between the organic and inorganic components at nanometer level and is ideal for mapping over small areas to obtain a detailed analysis of structural variations. Thin sections of eggshells were scanned from the shell membrane (inner) to the cuticle (outer) surface. The data collected was used to produce two-dimensional maps showing microscopic changes within the different layers of the eggshell. The structural alterations apparently could have implications at the macroscopic level of the resulting eggshell. As the organic matrix is embedded within the eggshell this may contribute to the variations observed in calcite crystal form and texture. Structural information obtained about a biomaterial at different length scales is important in relating the structure to its functional properties. This knowledge and the principles behind the formation of biomaterials could be used in the attempt of bioengineering new systems.

This study set out to investigate if access to an enriched environment during the rearing phase influences subsequent production and eggshell quality in broiler breeders. Broiler breeder pullets were reared under standard rearing conditions (control treatment) or under standard conditions with an environmental enrichment of bales of plastic-wrapped wood shavings (enriched treatment). At 19 weeks of age both groups were transported to a laying facility and housed in standard pens according to treatment type. Egg weight, shape, shell thickness, non-destructive deformation, breaking strength, stiffness and ultrastructural quality were compared at beginning of lay (25 weeks old), peak production (31 weeks old), mid-lay (45 weeks old) and end of lay (57 weeks old). Production and hatchery data were also collected throughout lay. Significant treatment-age interactions were detected for non-destructive deformation, breaking strength and stiffness, such that birds which had received prior enrichment went on to maintain a better shell quality with age. The measurements of total shell thickness, mammillary thickness and effective shell thickness all showed a trend for a treatment-age interaction. Significant age effects were found for weight, shape index, shell thickness, breaking strength and stiffness. All production and hatchery data also demonstrated significant changes with age. It is concluded that early enrichment with bales of wood shavings may provide a novel approach to the maintenance of eggshell quality at a time when calcium metabolism begins to reduce in efficiency.

The eggshell is a highly ordered structure resulting from the deposition of calcium carbonate and an organic matrix from the acellular uterine fluid. Characterization of the individual matrix components is necessary to determine their influence upon calcite crystal shape, size, and orientation during eggshell calcification. We have purified and sequenced a novel 32-kDa protein, ovocalyxin-32 (OCX-32), which is present at high levels in the uterine fluid during the terminal phase of eggshell formation, and is localized predominantly in the outer eggshell. Database searches identified expressed sequence tags (ESTs) whose alignment yielded the complete cDNA. OCX-32 protein possesses limited identity (32%) to two unrelated proteins: latexin, a carboxypeptidase inhibitor expressed in rat cerebral cortex and mast cells, and to a skin protein that is encoded by a retinoic acid receptor-responsive gene, TIG1. The timing of OCX-32 secretion into the uterine fluid suggests that it may play a role in the termination...

The unilateral avian oviduct is divisible into five functional regions which, moving distally, include the infundibulum, magnum, isthmus, tubular shell gland and shell gland pouch. Each region subs...

1. This study ascertained how bone of modern meat-type chickens develops under typical commercial conditions and compares development with that in genetic precursor stock. 2. A modern fast-growing selected strain and a slower-growing control strain were used. Birds were weighed weekly. A random sample was taken from each population at a range of ages up to 39 d. 3. A tibiotarsus from each bird was X-rayed and its dimensions and estimated resistance to bending were determined. Cortical bone samples were ashed to measure total mineral, calcium and phosphorus content. Cortical samples were also taken for porosity assessment. 4. As expected, the selected strain grew faster and heavier than the control strain. Despite this, both strains demonstrated similar periods of rapid bone formation (days 4 to 18) and mineralisation (days 4 to 11), and achieved similar estimates of resistance to bending. 5. However, cortical bone of the selected strain was less well mineralised and more porous than that of the control strain and showed a significant increase in the molar Ca:P ratios above the expected range of values during the first 2 to 3 weeks of life. 6. Despite production of bones with the correct dimensions for load support, the relatively poor density and mineral content of bone in the selected strain is likely to reduce effective breaking strength of the tibiotarsus. Possible reasons may be either inadequate dietary supply of Ca and P or impaired utilisation of the minerals due to a rapid growth rate or genetic factors.

1. Many of the mechanical tests devised to measure shell quality are inadequate because they fail to recognise the complex interaction between the organic and inorganic aspects of the eggshell. 2. Twelve structural modifications have been observed at the level of the mammillary layer and their presence correlated with a variety of environmental stress events. Occurring as they do in the basal layers of the shell, these morphological variants influence its mechanical properties. 3. The organic matrix proteins which complex with the calcium carbonate derive from a variety of sites within the oviduct and vary in their location within the fully formed shell. In vitro mineralisation reveals the significance of these proteins in the crystal growth mechanism. 4. The isolation and identification of the protein moiety in well-structured eggshells is an essential prerequisite to understanding the abnormalities in crystal growth observed in the shells of older birds challenged by disease and other undesirable 'on fa...

1. Extra and intramineral eggshell matrix proteins were solubilised before and after demineralisation by sequential extractions using guanidine hydrochloride and EDTA. 2. The intramineral electrophoretic profile of SDS‐PAGE showed the presence of 80, 66, 43, 36 and 15 kDa bands with a predominance of a 17 kDa band. In the extramineral part, the major protein was the 15 kDa band. 3. The introduction of intramineral extract to a metastable solution of calcium carbonate delayed the rate of crystal growth. The delay in the rate of precipitation was elicited by a single fraction (MW 50–80 kDa), isolated by gel filtration chromatography, of eggshell extracts. Extramineral extracts had no effect. 4. Addition in vitro of intramineral eggshell extracts modified the morphology of calcite; the crystals aggregated and showed irregular surfaces. 5. These observations suggest that constituents of the eggshell matrix are involved in the control of calcite growth and crytallographic structure of the hen's eggshell.

Cracked eggshells result in economic loss and provide a route for pathogenic organisms to enter the egg. Genetic factors that contribute to shell strength are likely to decrease the risk that an egg will crack when subject to insult. A novel measurement, the dynamic stiffness of the eggshell (Kdyn) was examined to determine if it might be used in the genetic selection of hens with improved eggshell characteristics. The measurement is determined from acoustic resonance frequency analysis. The estimates of heritability for the novel measurement of Kdyn were moderately high and ranged from 0.33 to 0.53 depending on the model used for the estimation. The estimates of genetic correlation of Kdyn with eggshell breaking strength (0.49) and static stiffness (0.57) were positive and relatively large as expected. There was a small negative genetic correlation between Kdyn and egg production from 26 to 50 weeks of age (-0.19) and a moderate one from 58 to 74 weeks of age (-0.36). The moderate heritability and relative independence of Kdyn indicates that this measurement could be used successfully in a breeding programme to improve shell quality and to reduce the incidence of cracks.

Osteoporosis in layers is associated with the modelling and remodelling of medullary bone. Cancellous bone volume (CBV) decreases initially during medullary bone modelling and continues to decrease during subsequent remodelling. In an attempt to maintain peak structural bone mass, the bisphosphonate, alendronate, was administered to pullets before medullary bone modelling. At point of lay CBV was significantly greater (P

Bisphosphonates, used in the prevention and treatment of osteoporosis, in man, can prevent bone loss in experimental models of osteoporosis in mammals. In egg-laying hens there is a high incidence of bone fractures which are due to osteoporosis. Alendronate, a bisphosphonate, was given to three groups of hens in mid-lay. Different doses of alendronate were given to each group and group 4 was a control. The birds were killed after 2 weeks of treatment. The hens receiving the highest dosage of alendronate (1 mg/kg every 2nd day) ceased laying and had reduced serum calcium concentrations. Lower dosages of alendronate (0.1 and 0.01 mg/kg every 2nd day) resulted in normal egg production and serum calcium concentrations. Egg shells with ultra-structural features indicative of reduced shell quality were produced by hens on the two higher dosages, but the egg shells from the controls and from the hens on the lowest dosage were considered normal. When alendronate was administered to hens in mid-lay there was no effect on trabecular bone volumes, but there was a reduction in mean medullary bone volume in some groups. In a second experiment, pullets were treated with alendronate (0.01 mg/kg twice a week) before the onset of lay. The pullets were killed after laying their first egg. In the pullets treated with alendronate, this protocol resulted in a significantly greater volume of trabecular (structural) bone at the onset of lay.

A preliminary survey of the ovary of the green turtle, Chelonia mydas L., shows that as in Aves the smaller ovarian follicles have a prominent zona radiata. In this a mucopolysaccharide is deposited eventually forming a thick band located in a position analogous to that of the avian perivitelline membrane but which appears to be impermanent since it is no longer present in the larger follicles (> 10 mm diameter). Its disappearance is accompanied by a marked increase in the height of the granulosa cells which become very tall and accumulate large globules of basic protein and sugar in their apical cytosome while at the same time a similar substance is found in the yolk. The granulosa also seems to disappear later in development leaving the highly developed theca interna in contact with the yolk. The theca is then very vascular and contains large numbers of fat cells. No structure comparable to a corpus luteum has been distinguished but ovarian material obtained within the first few days after ovulation has not been available for study and it is not, therefore, possible to be dogmatic on this question.

The structure of the calcified layer of egg shells from farm-reared and wild turtles has been examined using scanning electron microscopy and infrared analysis. Farm-reared egg shells contained discrete morphologically distinct regions of blocks of calcite and spherulites of aragonite. In contrast, the egg shells from feral populations consisted only of the spherulites. Differences in the impurity contents of the calcite and aragonite structures have been observed. SEM revealed a thin cuticular membrane.

Unpublished investigations have shown that at the light microscope level the oviduct of the green turtle ( Chelonia mydas L.) has two glandular subdivisions each of which appears to be structurally homogeneous. Histochemical studies suggest that the function of the more cranial of these is albumen secretion and that this is its sole function; in its ultrastructural features also it resembles the albumen secreting subdivision (magnum) of the avian oviduct except that it lacks the terminal mucous region to which the formation of the thick layer of egg albumen has been attributed. Layering of albumen (thick and thin layers) is not a characteristic of turtle eggs. The more caudal glandular segment presents ultrastructural features which tend to support the hypothesis that this is the site of shell-membrane formation but the presence of eggs undergoing calcareous shell formation in this subdivision shows that despite its structural homogeneity it is functionally dualistic, secreting both shell membranes and calcareous shell. In the available material ultrastructural features indicative of the latter function could not be demonstrated and further work is required in relation to calcium localization and acid phosphatase which may play a significant role in calcium transportation. The glands of the avian uterus in which calcareous shell deposition occurs are believed to be concerned with the addition to the albumen of plumping water. There is evidence that this addition is not a feature of turtle eggs and this may explain the absence of comparable glands in turtle.