Search

In this paper, injection molding is used as a method of plastic molding, which is a method in which plastic in the molten state is injected into a closed mold cavity by compression, and the molten material fills the cavity and is then cured by cooling to maintain the shape in the mold. The basic structural form and parameters of the mold’s parting surface, winding injection system, and cooling system are determined by mold flow analysis. CAE analysis is used to move the mold filling analysis to the computer, and the mold casting and cooling system’s design scheme can be evaluated and optimized according to the analysis results. After Moldflow software analysis of warpage deformation, the total warpage deformation of the molded part was obtained, the maximum deformation reached 0.931mm, the maximum deformation from uneven cooling was 0.192mm, the maximum deformation from uneven shrinkage was up to 0.942mm, the deformation from shrinkage was even larger than the integrated deformation, which had a greater impact on the final deformation of the molded part. It has a relatively large impact on the final deformation of the plastic part. Therefore, using CAE can improve the efficiency of mold design, optimize the structural design of the mold, effectively improve the quality of the mold and reduce the mold manufacturing cost. The promotion of its application is in line with the development of the times and promotes the rapid development of the injection mold field.

In order to rapidly determine aflatoxin B1 (AFB1), zearalenone (ZEN) and deoxynivalenol (DON) in maize, a AFB1-ZEN-DON three-in-one combined detection method has been established. This quantitative immunofluorescence assay based on superconductor coating was used to detect multiple maize samples. Combined with the recovery rate, stability, detection limit, precision and other indexes, the applicability of the method were evaluated and compared with the results of liquid chromatography. The results showed that the AFB1-ZEN-DON three-in-one combined detection method had the good linearity in the range of 0.5~30 µg/mL for AFB1, 5~200 µg/kg for ZEN and 100~2 500 µg/mL for DON, respectively. The relative deviation of AFB1, ZEN and DON detected by this method was –2.84%~11.91%, –3.43%~18.12% and 1.83%~12.91%, respectively, which were within the allowable deviation of 20%, 15% and 23%. The detection limit of AFB1 was 0.41 μg/kg and the corresponding limit of quantification was 1.12 μg/kg. The limit of detection of ZEN was 3.22 μg/kg and the corresponding limit of quantitation was 9.15 μg/kg. The detection limit of DON was 35.42 μg/kg and the corresponding limit of quantitation was 100.84 μg/kg. Compared with the results of liquid chromatography, the superconductor coated immunofluorescence test strip method is an effective, practical, rapid and quantitative analysis method within the allowable deviation range, suggesting that it could meet the requirements of simultaneous detection of AFB1, ZEN and DON in maize.

In order to rapidly determine deoxynivalenol (DON) and Zearalenone (ZEN) in maize, a rapid quantitative immunofluorescence assay based on superconductor coating was used to detect multiple maize samples. Combined with the recovery rate, stability, detection limit, precision and other indexes, the applicability of the method was evaluated and compared with the results of liquid chromatography. The results showed that the superconductor coated immunofluorescence diaper method had the good linearity in the range of 100 ng/mL~2 500 ng/mL for DON and 5~200 µg/kg for ZEN. The recoveries of DON were 103.72%~108.17% in the range of 500~2 000 µg/kg, and 97.81%~111.27% in the range of ZEN 50~150 µg/kg. Compared with the results of liquid chromatography, the superconductor coated immunofluorescence diaper method is an effective, practical, rapid and quantitative analysis method within the allowable deviation range, which can meet the requirements of simultaneous detection of DON and ZEN in maize.

Organic pollution of agricultural land will cause environmental problems and agricultural economic effects. To explore the reliable effect of remediation of organic pollution in agricultural land, wheat straw biochar was prepared in this paper. Moreover, this paper uses experimental research and comparison methods to study the difference in the adsorption performance of biochar at different pyrolysis temperatures on polycyclic aromatic hydrocarbons (PAHs) and the effect of pyrolysis biochar on the availability of phenanthrene and pyrene microorganisms in the soil at the same temperature. Additionally, statistical methods are utilised in this research to do analytics and data processing on test data, and test findings are visually displayed using a combination of graphs and tables. Finally, to understand the experimental research findings, this system employs analytical approaches. The results of the experiment show that wheat straw biochar can effectively reduce soil organic pollution, which can expand the research on the restoration of other crop straw biochar on agricultural land.

Abstract Walnut is an important economic tree species while confronting with global environmental stress, resulting in decline in quality and yield. Therefore, it is urgent to elucidate the molecular mechanism for the regulation of walnut response to adversity. The protein phosphatase 2C (PP2C) gene family participates in cellular processes in eukaryotes through reversible phosphorylation of proteins and signal transduction regulation. However, the stress response function of PP2C genes was far to be clarified. Therefore, to understand the stress response mechanism of walnut tree, in this study, a total of 41 PP2C genes with complete ORFs were identified from Juglans regia, whose basic bio-information and expression patterns in response to multiple stresses and ABA were confirmed. The results showed that the ORFs of JrPP2Cs were 495 ~ 3231 bp in length, the predicted JrPP2C proteins contained 164 to 1076 amino acids and the molecular weights were 18,581.96 ~ 118,853.34 Da, the pI was 4.55 ~ 9.58. These JrPP2C genes were unevenly distributed on 14 chromosomes, among which Chr11 and Chr13 contained the most genes. Phylogenetic analysis found that these JrPP2C proteins were classed into 9 subfamilies, among which group F covered most JrPP2Cs. The JrPP2Cs in the same subfamily exhibited similarities in the composition of conserved domains, amino acid sequences of motifs and exon/intron organization in DNA sequences. Each JrPP2C includes 4 ~ 10 motifs and each motif contained 15 ~ 37 amino acids. Among the motifs, motif1, motif2, motif3 and motif8 were most abundant. Most of the JrPP2C genes diversely response to osmotic, cadmium, and Colletotrichum gloeosporioide stress as well as ABA treatments, among which JrPP2C28, JrPP2C17, JrPP2C09, JrPP2C36 were more obvious and deserves further attention. All these results indicated that JrPP2C genes play potential vital roles in plant response to multiple stimulus, and are possibly involved in ABA-dependent signaling pathway.

Wheat bran was taken as raw material to extract bran starch by alkaline protease method and ultrasonic-assisted alkaline protease method respectively. After extraction conditions of the two methods were optimized, the granular structure and molecular structure of bran starch were analyzed. The results showed that the optimal extraction conditions by alkaline protease method were as follows: solid-liquid ratio 1∶10 (g∶mL), enzyme dosage 529.92 U/mL, enzyme reaction time 50 min, reaction temperature 45 ℃and pH 12. The yield of starch was 30.40% and its content was 59.24%, while the powder was light brown;the optimal conditions by ultrasonic-assisted alkaline protease method were as follows: solid-liquid ratio 1∶15 g/mL, ultrasonic power 150 W and ultrasonic time 15 min. The yield of bran starch was 21.06% and its content was 90.64%, while the powder was white. The purity and extraction rate of bran starch extracted by ultrasonic-assisted alkaline protease method were better than those by single alkaline protease method.Analysis results showed that branch/straight ratio of the wheat bran starch was 4.69 and broken starch content was 1.78%. The starch bran particles were ellipsoidal, with an average particle size of 15.86 μm and radial crystal structure of A-type.

The effect of temperature (T) on stability of squeezed soybean oil (SSO) were studied by four characterization parameters (CPs, conductivity, peroxide value, isovolumetric combustion heat and acid value)similarities and differences of CPs characterization results were further compared.Under the fixed conditions of relative humidity was 40%, partial pressure of oxygen was 21 kPa, illumination was 800 lx and initial headspace rate was 50%, regulated and controled T to 30 ℃, 40 ℃, 50 ℃, 60 ℃ and 70 ℃ respectively,SSO test samples were oxidized continuously in airtight container for a long time, four CPs at different oxidation time (t) were multiple measured in the same time, curve of CP～t was plotted, kinetic equation was regressed, rate constant (k) and apparent activation energy were calculated, the prediction model of metamorphic time was established and coincidence rate was verified.The results show that CP changed significantly with the increase of T and the extension of t, the oxidative rancidity of SSO has characteristic of simple series reaction,the prediction model of metamorphic time has a good coincidence, CP was different, and there was a big difference in k.The stability of squeezed soybean oil of SSO should be described by multiple CPs.

Background. Noninvasive ventilation (NIV) has been reported to be beneficial for patients with acute respiratory failure in intensive care unit (ICU); however, factors that influence the clinical outcome of NIV were unclarified. We aim to determine the factors that predict the failure of NIV in critically ill patients with acute respiratory failure (ARF). Setting. Adult mixed ICU in a medical university affiliated hospital. Patients and Methods. A retrospective clinical study using data from critical adult patients with initial NIV admitted to ICU in the period August 2016 to November 2017. Failure of NIV was regarded as patients needing invasive ventilation. Logistic regression was employed to determine the risk factor(s) for NIV, and a predictive model for NIV outcome was set up using risk factors. Results. Of 101 included patients, 50 were unsuccessful. Although more than 20 variables were associated with NIV failure, multivariate logistic regression demonstrated that only ideal body weight (IBW) (OR 1.110 (95%1.027–1.201), P=0.009), the maximal heart rate during NIV period (HR-MAX) (OR 1.024 (1.004–1.046), P=0.021), the minimal respiratory rate during NIV period (RR-MIN) (OR 1.198(1.051–1.365), P=0.007), and the highest body temperature during NIV period (T-MAX) (OR 1.838(1.038–3.252), P=0.037) were independent risk factors for NIV failure. We set up a predictive model based on these independent risk factors, whose area under the receiver operating characteristic curve (AUROC) was 0.783 (95% CI: 0.676–0.899, P

Purpose: This study explores a novel approach to compiling life-oriented moral textbooks for elementary schools in China, specifically focusing on "Morality and Law." Design/Approach/Methods: Adopting Aristotle's "Poetics" as its theoretical perspective, this study illustrates and analyzes the mimetic approach used in compiling the life-oriented moral education textbook, "Morality and Law." Findings: The mimetic approach involves imitating children's real activities, thoughts, and feelings in textbooks. The mimetic approach to compiling life-oriented moral textbooks comprises three strategies: constructing children's life events as building blocks for textbook compilation, designing an intricate textual device exposing the wholeness of children's life actions, and designing inward learning activities leading to children's inner worlds. Originality/Value: From the perspective of Aristotle's "Poetics," the approach to compilation in "Morality and Law" can be defined as mimetic. And the compilation activity in the life-oriented moral education textbook also can be described as a process of mimesis. So this article presents a new approach to compile moral education textbooks and an innovative way to understand the nature of one compiling activity.