Search

In recent years, photodynamic inactivation (PDI) has emerged as a promising preservation method to complement refrigeration in the fresh produce supply chain. However, due to infrastructural limitations in the supply chain, fresh produce is often exposed to environmental conditions rather than recommended storage conditions. Hence, this study aimed to investigate the influence of two important environmental variables in the fresh produce supply chain - temperature and relative humidity (RH), on the PDI of fruit spoilage molds. It also aimed to demonstrate proof-of-concept of their inactivation on fruit surfaces. In the in vitro stage, Botrytis cinerea and Rhizopus stolonifer, the two molds selected for this study, were illuminated with 405 nm LEDs on Dichloran Rose-Bengal Chloramphenicol (DRBC) agar at three levels of temperature (7, 16 and 25 °C) and relative humidity (40, 60 and 80%). Illumination under these conditions caused reductions greater than 94% in the mold populations, at all temperatures and relative humidities. Even so, a temperature of 25 °C was observed to be marginally better for the inactivation as compared to 7 and 16 °C, as it necessitated the lowest dose (6-7 kJ) for the first log reduction of both the molds. Similarly, an RH of 40% worked slightly better for the inactivation of B. cinerea, as it induced inactivation without any lag phase and required the lowest dose (8.03 kJ) for the first log reduction. When the antifungal effect was investigated on fruit surfaces, it was discovered that the illumination reduced the populations of B. cinerea and R. stolonifer on strawberries by 67% and 19%, whereas on tomatoes, the respective inactivations were 79% and 70% respectively. These results demonstrate further promise of PDI as a postharvest technology for reducing the risk of fruit spoilage. This study is also the first to demonstrate the potential of PDI to add value to supply chains where compliance to ideal storage conditions is not feasible., (Copyright © 2021 Elsevier B.V. All rights reserved.)

Biofilms formed on food contact surfaces are frequently exposed to disinfectants at different concentrations. This study was designed to evaluate how S. Enteritidis in single species and dual species biofilms with P. fluorescens respond to quaternary ammonium compounds (QAC) residues on food contact surfaces. The 48 h-biofilms of S. Enteritidis and P. fluorescens in single/dual species were continuously exposed to 20 ppm QAC for 5 days, followed by QAC challenge at 200 ppm and 100 ppm for attached and detached cells, respectively. Biofilm structures were observed by confocal laser scanning microscopy (CLSM) and extracellular polymeric substances (EPS)-related gene expression was also evaluated. Results showed that QAC stress led to one log lower cell counts of S. Enteritidis and P. fluorescens single species biofilms. More cellulose observed by CLSM images and increased transcript levels of cellulose-related genes (csgD, bcsA and ardA) of S. Enteritidis were induced by QAC stress. Nevertheless, high percentage of membrane damaged cells in QAC pre-exposed biofilms might contribute to the increased sensitivity of S. Enteritidis in both attached and detached cells. Previous QAC exposure did not influence S. Enteritidis viable cell counts in dual specie biofilms, in which S. Enteritidis showed strong resistance to QAC with <2 log CFU/cm 2 reductions. Decreased transcript levels of cellulose-related genes were observed of S. Enteritidis in dual species biofilms, but EPS-related gene expression of P. fluorescens was not affected by single/duals species. The dual species biofilm matrix which has big microcolonies extruding from bottom layers with great amounts of polysaccharides mainly produced by P. fluorescens could possibly protect S. Enteritidis against disinfection. Enhanced survival of S. Enteritidis in dual species biofilms was also found when they were detached from the coupons. Overall, our findings highlight that although repeated exposures to low dose of QAC sensitized S. Enteritidis, the presence of P. fluorescens in dual species biofilms could enhance QAC resistance of S. Enteritidis, probably contributing to survival of S. Enteritidis in food processing plants., (Copyright © 2020 Elsevier B.V. All rights reserved.)

Extracts from medicinal plants have been reported to possess good antimicrobial properties, but a majority of them remain unexplored. This study aimed at identifying a novel plant extract with antimicrobial activity, to validate its efficacy in food model, and to elucidate its composition and antimicrobial mechanism. A total of 125 plant extracts were screened, and Cinnamomum javanicum leaf and stem extract showed potential antimicrobial activity against Listeria monocytogenes (MIC=0.13mg/mL). Total phenolic content of the extract was 78.3mg GAE/g extract and its antioxidant activity was 57.2-326.5mg TE/g extract. When applied on cold smoked salmon, strong strain-dependent antimicrobial effectiveness was observed, with L. monocytogenes LM2 (serotype 4b) and LM8 (serotype 3a) being more resistant compared to SSA81 (serotype 1/2a). High extract concentration (16mg/mL) was needed to inhibit or reduce the growth of L. monocytogenes on smoked salmon, which resulted in surface color change. GC-MS revealed that eucalyptol (25.54 area%) was the most abundant compound in the crude extract. Both crude extract and eucalyptol induced significant membrane damages in treated L. monocytogenes. These results suggest anti-L. monocytogenes activity of C. javanicum plant extract, identified its major volatile components, and elucidated its membrane-damaging antimicrobial mechanisms., (Copyright © 2017 Elsevier B.V. All rights reserved.)

To investigate a potential of 405±5nm light emitting diode (LED) as a novel technology for food preservation, the antibacterial effect of 405±5nm LED on Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella spp. on the surface of fresh-cut mango and its influence on fruit quality were evaluated at different storage temperatures. LED-illumination inactivated 1.0-1.6 logCFU/cm 2 of populations at 4 and 10°C for 36-48h (total dose, 2.6-3.5kJ/cm 2 ) regardless of bacterial species, while those on non-illuminated mange remained unchanged or slightly increased during storage. At 20°C for 24h (total dose, 1.7kJ/cm 2 ), non-illuminated E. coli O157:H7 and Salmonella gradually grew, whereas LED-illumination reduced 1.2 log of Salmonella and inhibited the growth of E. coli O157:H7. Unlike these, non-illuminated L. monocytogenes cells rapidly increased to 7.3 log, while illuminated cells reached 4.6 log, revealing that LED-illumination delayed their growth. There were no significant (P>0.05) differences in color, antioxidant capacity, ascorbic acid, β-carotene, and flavonoid between non-illuminated and illuminated cut mangoes, regardless of storage temperature. These results suggest that 405±5nm LEDs in combination with chilling temperatures could be applied to preserve fresh-cut fruits without deterioration of physicochemical quality of fruits at food establishments, minimizing the risk of foodborne disease., (Copyright © 2017 Elsevier B.V. All rights reserved.)

Fresh mung bean sprouts have been identified as a source of many Salmonella outbreaks worldwide. The aim of this study was to develop a rapid and accurate detection methodology for low levels of healthy and sanitizer-injured Salmonella on mung bean sprouts using real-time PCR coupled with either immunomagnetic separation (PCR-IMS) or centrifugation (PCR-cen). Initially, three parameters of IMS; specificity/sensitivity, bacterial concentration and bead incubation time were optimized. Secondly, limit of detection (LOD) was determined for the optimized PCR-IMS and PCR-cen. These two methods were compared against PCR alone (PCR) and the standard culture method (ISO) for their ability to detect Salmonella using inoculated and uninoculated sprouts. Under optimum IMS conditions (10(5)CFU/ml for 30 min), capture efficiency of Salmonella in sprout suspensions was lower than 40%, most probably due to the non-specific binding of the background microbiota. PCR-IMS and PCR-cen had a similar LOD at 10(3)CFU/ml, which was one log unit lower than PCR. Enrichment of 10h was sufficient to detect 100% of the inoculated sprouts with both PCR-IMS and PCR-cen, which was significantly faster compared to PCR and the ISO method. Moreover, the validation study using uninoculated sprouts revealed that PCR-IMS and PCR-cen were equally effective on Salmonella detection, showing 98.3% accuracy. These results suggest that PCR-cen would be the effective and less costly method for the detection of both healthy and sanitizer-injured Salmonella on mung bean sprouts., (Copyright © 2016 Elsevier B.V. All rights reserved.)

This study evaluated the acid and heat resistance of Salmonella Enteritidis in simulated gastric fluid (pH 2.0) and during thermal treatment (54-60 °C), respectively, after adaptation to lactic acid (LA) or trisodium phosphate (TSP) at various pHs (pH 5.3-9.0). The changes in membrane lipid composition and expression levels of RpoS and RpoH were examined to elucidate their roles in bacterial stress resistance. Transcriptional profile of several virulence-related genes was also analyzed. Results showed that LA-adapted cells at pH 5.3 and 6.3 had higher acid and heat resistance than control cells and cells adapted to TSP at pH 8.3 and 9.0. LA-adapted cells had the lowest ratio of unsaturated to saturated fatty acids, indicating that they might possess a less fluid membrane. It was observed that the expression levels of RpoH and RpoS were upregulated in TSP-adapted cells but not in LA-adapted cells. Thus, these results indicate that the increased acid and heat resistance of LA-adapted S. Enteritidis was possibly due to the decreased membrane fluidity instead of the upregulation of RpoS and RpoH. About 6.0, 2.1, and 2.46-fold upregulation of spvR, avrA, and hilA were observed in cells adapted to TSP at pH 9.0, except sefA that had its highest expression level in the control cells, indicating that the expression of these virulence genes highly depends on environmental conditions. This is the first study to show that the alteration in the cytoplasmic membrane rather than RpoS and RpoH plays a more crucial role in conferring greater acid and heat resistance on LA-adapted S. Enteritidis, thus providing a better understanding on the bacterial stress response to acidic conditions., (Copyright © 2014 Elsevier B.V. All rights reserved.)

Conventional culture detection methods are time consuming and labor-intensive. For this reason, an alternative rapid method combining real-time PCR and immunomagnetic separation (IMS) was investigated in this study to detect both healthy and heat-injured Salmonella Typhimurium on raw duck wings. Firstly, the IMS method was optimized by determining the capture efficiency of Dynabeads(®) on Salmonella cells on raw duck wings with different bead incubation (10, 30 and 60 min) and magnetic separation (3, 10 and 30 min) times. Secondly, three Taqman primer sets, Sal, invA and ttr, were evaluated to optimize the real-time PCR protocol by comparing five parameters: inclusivity, exclusivity, PCR efficiency, detection probability and limit of detection (LOD). Thirdly, the optimized real-time PCR, in combination with IMS (PCR-IMS) assay, was compared with a standard ISO and a real-time PCR (PCR) method by analyzing artificially inoculated raw duck wings with healthy and heat-injured Salmonella cells at 10(1) and 10(0) CFU/25 g. Finally, the optimized PCR-IMS assay was validated for Salmonella detection in naturally contaminated raw duck wing samples. Under optimal IMS conditions (30 min bead incubation and 3 min magnetic separation times), approximately 85 and 64% of S. Typhimurium cells were captured by Dynabeads® from pure culture and inoculated raw duck wings, respectively. Although Sal and ttr primers exhibited 100% inclusivity and exclusivity for 16 Salmonella spp. and 36 non-Salmonella strains, the Sal primer showed lower LOD (10(3) CFU/ml) and higher PCR efficiency (94.1%) than the invA and ttr primers. Moreover, for Sal and invA primers, 100% detection probability on raw duck wings suspension was observed at 10(3) and 10(4) CFU/ml with and without IMS, respectively. Thus, the Sal primer was chosen for further experiments. The optimized PCR-IMS method was significantly (P=0.0011) better at detecting healthy Salmonella cells after 7-h enrichment than traditional PCR method. However there was no significant difference between the two methods with longer enrichment time (14 h). The diagnostic accuracy of PCR-IMS was shown to be 98.3% through the validation study. These results indicate that the optimized PCR-IMS method in this study could provide a sensitive, specific and rapid detection method for Salmonella on raw duck wings, enabling 10-h detection. However, a longer enrichment time could be needed for resuscitation and reliable detection of heat-injured cells., (Copyright © 2014 Elsevier B.V. All rights reserved.)

The influence of growth temperature (10, 25, 37, and 42 °C) on the survival of Salmonella Enteritidis in simulated gastric fluid (SGF; pH=2.0) and during heat treatment (54, 56, 58, and 60 °C), on the membrane fatty acid composition, as well as on stress-/virulence-related gene expression was studied. Cells incubated at temperatures lower or higher than 37 °C did not increase their acid resistance, with the maximum D-value of 3.07 min in cells grown at 37 °C; while those incubated at higher temperature increased their heat resistance, with the maximum D60 °C-values of 1.4 min in cells grown at 42 °C. A decrease in the ratio of unsaturated to saturated fatty acids was observed as the growth temperature increased. Compared to the control cells grown at 37 °C, the expression of rpoS was 16.5- and 14.4-fold higher in cells cultivated at 10 and 25 °C, respectively; while the expression of rpoH was 2.9-fold higher in those cultivated at 42 °C. The increased expression of stress response gene rpoH and the decreased ratio of unsaturated to saturated fatty acids correlated with the greater heat resistance of bacteria grown at 42 °C; while the decreased expression of stress response gene rpoS at 42 °C might contribute to the decrease in acid resistance. Virulence related genes-spvR, hilA, avrA-were induced in cells cultivated at 42 °C, except sefA which was induced in the control cells. This study indicates that environmental temperature may affect the virulence potential of S. Enteritidis, thus temperature should be well controlled during food storage., (Copyright © 2013 Elsevier B.V. All rights reserved.)

The antibacterial effect of light emitting diodes (LEDs) in the visible region (461, 521 and 642 nm) of the electromagnetic spectrum was investigated on Escherichia coli O157:H7, Salmonella typhimurium, Listeria monocytogenes and Staphylococcus aureus. The irradiances of the 461, 521 and 642 nm LEDs were 22.1, 16 and 25.4 mW/cm², respectively. Bacterial cultures suspended in tryptic soy broth were illuminated by 10-watt LEDs at a distance of 4.5 cm for 7.5h at 20, 15 and 10 °C. Regardless of the bacterial strains, bacterial inactivation was observed with the range of 4.6-5.2 logCFU/ml at 10 and 15 °C after illumination with the 461 nm LED, while illumination with the 521 nm LED resulted in only 1.0-2.0 log reductions after 7.5h. On the other hand, no antibacterial effect was observed using the 642 nm LED treatment. The photodynamic inactivation by 461 and 521 nm LEDs was found to be greater at the set temperatures of 10 and 15 °C than at 20 °C. The D-values for the four bacterial strains at 10 and 15 °C after the illumination of 461 nm LED ranged from 1.29 to 1.74 h, indicating that there was no significant difference in the susceptibility of the bacterial strains to the LED illumination between 10 and 15 °C, except for L. monocytogenes. Regardless of the illumination temperature, sublethal injury was observed in all bacterial strains during illumination with the 461 and the 521 nm LED and the percentage of injured cells increased as the treatment time increased. Thus, the results show that the antibacterial effect of the LEDs was highly dependent on the wavelength and the illumination temperature. This study suggests the potential of 461 and 521 nm LEDs in combination with chilling to be used as a novel food preservation technology., (© 2013 Elsevier B.V. All rights reserved.)

The aim of this study was to determine survival or growth of unadapted, acid-adapted and cold-stressed Salmonella spp., and natural microbiota on fresh-cut dragon fruits at different storage temperatures. Dragon fruits were sliced and spot inoculated with five-strain cocktail of Salmonella spp. at two inoculum levels (2.5 or 5.5 log CFU/g). Inoculated fruits were stored at 28°C for 48h and at 4°C and 12°C for 96 h. Salmonella population significantly increased by 2.4 to 3.0 log CFU/g at low inoculum level, whereas the numbers increased by 0.4 to 0.7 log CFU/g at the high inoculum level on fruits held at 28°C for 48h. Only unadapted and acid-adapted cells grew with 0.7 to 0.9log increase at the low inoculum level at 12°C for 96h. No significant growth was observed at both inoculum levels during storage at 4°C. Overall, acid, starved and cold adaptation of Salmonella spp. did not show significant difference in survival or growth on fresh-cut dragon fruits during storage compared to unadapted control cells. For natural microbiota on the fruit, mesophilic bacterial counts reached to 5-log CFU/g at 28 and 12°C by 9.9 and 52.9h. Similar with Salmonella spp. there was no growth of natural microbiota at 4°C. These results showed that Salmonella spp. could grow on fresh-cut dragon fruits under inappropriate storage conditions, indicating that fresh-cut dragon fruits could be a potential vehicle for salmonellosis. Thus, this study suggests that fresh-cut dragon fruits should be stored at 4°C to ensure the safety as well as to extend the shelf life of fresh-cut dragon fruits., (Copyright © 2012 Elsevier B.V. All rights reserved.)

This study evaluated the efficacy of a supercritical carbon dioxide (SCCO(2)) system with a gas-liquid porous metal contactor for eliminating Escherichia coli K12 in apple cider. Pasteurized, preservative-free apple cider was inoculated with E. coli K12 and processed using the SCCO(2) system at CO(2) concentrations of 0-10% (wt.%, g CO(2)/100g product), outlet temperatures of 34, 38, and 42 degrees C, a system pressure of 7.6 MPa, and a flow rate of 1L/min. Increased CO(2) concentrations and temperatures significantly (P<0.05) enhanced the bactericidal effect, resulting in a maximum reduction of 7.31 log CFU/mL at 8% CO(2) and 42 degrees C. A response surface model indicated that minimum CO(2) concentrations of 9.9% at 34 degrees C, 7.4% at 38 degrees C, and 5.4% at 42 degrees C are needed to achieve a 5-log reduction of E. coli K12 in apple cider. SEM observations showed morphological changes in the cell envelope after SCCO(2) processing. At a processing condition of 8% and 38 degrees C, the reduction of E. coli was 6.03 log and the sublethal injury of the survivors was 84%. The regrowth or survival of E. coli in SCCO(2) processed apple cider was not observed during storage for 28 days at 4, 8, and 20 degrees C. Thus this study showed the potential of SCCO(2) processing with a gas-liquid porous metal contactor for the nonthermal pasteurization of apple cider., (Copyright 2009. Published by Elsevier B.V.)

A study was conducted to evaluate the effect of storing Escherichia coli O157:H7 in fruit or vegetable juices with or without pulp and/or calcium lactate, on the bacterial resistance to a simulated gastric fluid (SGF, pH 1.5). Apple, carrot, orange, and tomato juices containing pulp or freed from pulp by filtration were used in this study. Calcium lactate at about 1.4 g/l was added to juices to obtain calcium supplemented juices. Juices with or without pulp and/or calcium lactate were inoculated with E. coli O157:H7 and then were stored at 7 degrees C for 0, 1, 2, or 4 days. The acid resistance of cells stored in juices with or without pulp and/or calcium lactate was determined by incubating in SGF for 90 or 240 min at 37 degrees C. Cells stored in apple juice for 4 days, carrot juice for 2 days, and orange juice for 4 days with pulp only had greater acid resistance, while all cells stored in tomato juice with pulp had greater acid resistance than cells stored in juice without pulp. The D-values of cells stored in supplemented apple and orange juices with calcium lactate declined 1.7-3.5 fold, whereas D-values of cells stored in supplemented tomato juice decreased by about 1.4-fold when compared to cells stored in juice without calcium lactate after exposure in SGF. These results indicate that storing E. coli O157:H7 in juices with pulp had little or no effect on the acid resistance of cells during subsequent exposure in SGF. Calcium lactate supplemented into juices could dramatically decrease the ability of E. coli O157:H7 to survive in SGF, possibly reducing the risk of foodborne illness by juice products.

This study investigated the survival of a five-strain Shigella sonnei cocktail on smooth tomato surfaces, in potato salad and in raw ground beef. All inocula were resistant to the antibiotic rifampicin to allow simple detection of the target culture among the indigenous microflora of the food samples. Inoculated tomatoes were stored at 13 degrees C/85% relative humidity, the standard holding conditions for mature, green tomatoes. Inoculated potato salad and ground beef samples were stored at 2.5 degrees C and 8.0 degrees C to study the effects of varied refrigerated temperatures. Surviving populations were estimated using a three-tube most probable number (MPN) method. Tryptic soy broth tubes supplemented with 100 ppm rifampicin were inoculated with appropriate dilutions of the recovered inocula and scored for growth after overnight enrichment. S. sonnei populations declined rapidly to undetectable levels (2 days) when dried on smooth surfaces of tomatoes. S. sonnei populations did not decrease in potato salad and ground beef stored at 2.5 degrees C and 8.0 degrees C over the shelf-life of the products.

Escherichia coli O157:H7 (HEC), E. coli O157:H7 rpoS mutant (HEC-RM), and nonpathogenic E. coli (NPEC) were step-wise adapted to trisodium phosphate (TSP) by incubation in broths of increasing concentration, from 0% to 0.6%, at 37 degrees C for 24 h. After incubation at each concentration, each population was examined for acid resistance (D value) in simulated gastric fluid of pH 1.5, cell envelope membrane lipid composition, and intracellular and extracellular verotoxin concentrations. The ratio of cis-vaccenic acid (18:1omega7c) to palmitic acid (16:0) increased, indicating increased membrane fluidity with increasing TSP concentration up to 0.4%, but decreased at 0.6%. HEC and HEC-RM adapted at 0.4% TSP had the highest verotoxin concentrations of 1805 and 1879 ng/ml, respectively. In addition, with HEC the ratio of extracellular to intracellular verotoxin concentration decreased at higher TSP concentrations. In contrast, the ratio for HEC-RM increased at 0.4% TSP. HEC adapted to 0.4% TSP had the greatest survival in gastric fluid (58 min D value) among all treatments. For HEC, the increase in membrane fluidity was associated with increased acid resistance and extracellular verotoxin concentration for cells adapted to 0.4% TSP. In contrast, the increase in membrane fluidity was associated with decreased acid resistance of TSP adapted HEC-RM although the extracellular verotoxin concentration increased. Therefore, the deletion of the rpoS gene appeared to affect the changes in verotoxin concentration and acid resistance of TSP adapted E. coli O157:H7.