Search

An investigation was undertaken to establish the concentration in paper products of dehydroabietic (DHA) and abietic (AA) resin acids, present in rosin, which are major toxicants of pulp- and paper-mill effluent. Their migration was studied from paper and paperboard products into various food-simulating solvents and the substitute fatty food simulant Tenax TA (modified polyphenylene oxide). DHA and AA were detected in five of 10 virgin paper products and in all 10 recycled paperboard products for food-contact use at concentrations of 14–500 and 110–1200  µg/g, respectively. In virgin paper products, the highest migration was into 95% ethanol or heptane, with negligible or no migration into other solvents. In recycled paperboard products, migration was highest into 95% ethanol, but was also observed into 20% ethanol, water and heptane. Migration to Tenax TA was also observed and the migration level increased with time. The maximum migration levels of DHA and AA into food simulants were 0.853 and 3.14  µg/g, respectively. The results suggest that, in the worst case, the daily intake of DHA and AA from paper and paperboard products was 50 times lower than the tolerable daily intake of rosin. [ABSTRACT FROM AUTHOR]

In order to identify potential genotoxicant(s) in recycled paperboard, samples were fractionated using multiple liquid/liquid extraction, and gel permeation chromatography, and analysed by gas chromatography/mass spectrometry and liquid chromatography/mass spectrometry. The rec -assay was used as an indicator of genotoxicity. Genotoxicants in the recycled paperboard were identified as dehydroabietic acid (DHA) and abietic acid (AA). DHA and AA were detected in two out of five virgin products, and in all seven recycled products for food-contact use. Total amounts of DHA and AA were 240 and 990  µg/g in the virgin products and 200-990  µg/g in the recycled products. A good correlation was observed in the total amount of DHA and AA content determined in paper products and DNA-damaging activity. Moreover, genotoxic effects in paper products showed a good match with standard compounds, indicating that the genotoxic effects of these paper products was mostly attributable to DHA and AA. [ABSTRACT FROM AUTHOR]

The migration of five surrogate contaminants, anthracene, benzophenone, dimethyl phthalate, methyl stearate and pentachlorophenol, from paper and paperboard into water through a polyethylene (PE) coating layer was investigated. Virgin paper and paperboard coated with PE films of 0.012 and 0.030mm thickness were spiked evenly with standard 1-ml solutions containing 5mg of each surrogate. The spiked papers were placed in contact with the PE coating layer at 10 and 24 °C for 21 days. The resulting surrogate migration through the PE layer into 100ml water was measured by an analytical method developed here that used gas chromatography equipped with a flame ionization detector. Non-polar surrogates of anthracene and methyl stearate did not show any significant migration. In the case of the thin layer coating of 0.012mm, polar water-soluble contaminants of benzophenone, dimethyl phthalate and pentachlorophenol showed an equilibrated or maximized migration after 1 day, even at a refrigerated temperature of 10 °C. A thick PE coating of 0.030mm thickness delayed the progress of contaminant migration, which was also slower at lower temperature. Our results indicate that polyethylene coatings should not be seen as a complete barrier against possible contaminants in paper packaging materials under chilled or ambient conditions. Several variables such as coating thickness, temperature and suspected contaminants need to be considered to control the possible contamination risk from recycled or printed paper. [ABSTRACT FROM AUTHOR]

Stimulated by new ecology-driven European and national regulations, new routes of recycling waste appear on the market. Since food packages represent a large percentage of the plastics consumption and since they have a short lifetime, an important approach consists in making new packages from post-consumer used packages. On the other hand, food-packaging regulations in Europe require that packaging materials must be safe. Therefore, potential mass transfer (migration) of harmful recycling-related substances to the food must be excluded and test methods to ensure the safety-in-use of recycled materials for food packaging are needed. As a consequence of this situation, a European research project FAIR-CT98-4318, with the acronym 'Recyclability', was initiated. The project consists of three sections each focusing on a different class of recycled materials : polyethylene terephthalate (PET), paper and board, and plastics covered by functional barriers. The project consortium consists of 28 project members from 11 EU countries. In addition, the project is during its lifetime in discussion with the US Food and Drug Administrations (FDA) to consider also US FDA regulatory viewpoints and to aim, as a consequence, to harmonizable conclusions and recommendations. The paper introduces the project and presents an overview of the project work progress. [ABSTRACT FROM AUTHOR]

Food-contact materials, including paper, have to comply with a basic set of criteria concerning safety. This means that paper for food contact should not give rise to migration of components, which can endanger human health. The objectives of this pilot study were, first, to compare paper of different qualities as food-contact materials and to perform a preliminary evaluation of their suitability, from a safety point of view, and, second, to evaluate the use of different in vitro toxicity tests for screening of paper and board. Paper produced from three different categories of recycled fibres (B-D) and a raw material produced from virgin fibres (A) were obtained from industry, and extracts were examined by chemical analyses and diverse in vitro toxicity test systems. The products tested were either based on different raw materials or different treatments were applied. Paper category B was made from 40% virgin fibres, 40% unprinted cuttings from newspapers, and 20% de-inked newspapers and magazines. Paper categories C and D were based on newspapers and magazines. However, paper D was de-inked, whereas C was not. To identify constituents of the papers with a potential to migrate into foodstuff, samples of the paper products were extracted with either 99% ethanol or water. Potential migrants in the extracts were identified and semiquantified by GC-IR-MS or GC-HRMS. In parallel to the chemical analyses, a battery of four different in vitro toxicity tests with different endpoints were applied to the same extracts: (1) a cytotoxicity test using normal human skin fibroblasts. The test was based on measurements of the reduction of resazurin to resorufin by cellular redox processes and used as a screening test for acute or general toxicity; (2) a Salmonella/microsome assay (Ames test) as a screening test for mutagenic and potentially carcinogenic compounds; (3) a recombinant yeast cell bioassay as a screening test for compounds with oestrogenic activity; (4) an aryl hydrocarbon (Ah)-receptor assay (CALUX assay) as a screening test for compounds with dioxin-like activity. In addition, the papers were tested for microbial content and, in general, the microbiological load was quite low. The following microorganisms were counted and identified on both surface and homogenized pulp samples: the total number of aerobic bacteria, the number of aerobic and anaerobic spore formers, the number of Bacillus cereus/thuringiensis, and the number of yeast and moulds. The chemical analyses showed a significantly higher amount and different composition pattern of chemicals extracted with ethanol compared with water. Analyses of the ethanol extracts showed a distinctly smaller number and lower concentrations of chemicals in extracts prepared from sample A compared with extracts of samples B–D. The compounds identified in B–D were similar, but the amounts were lower in B compared with C and D. In accordance with the chemical analyses, the water extracts were less cytotoxic than the ethanol extracts. The extract prepared from virgin fibres was less cytotoxic than the extracts prepared from paper made from recycled fibres, and extracts prepared from C was the most cytotoxic. None of the extracts showed mutagenic activity. No conclusion about the oestrogenic activity could be made, because all extracts were cytotoxic to the test organism (yeast cells). Ethanol extracts of A and B showed a negligible positive response in the Ah-receptor assay at the highest nontoxic concentration, whereas C and D showed a more pronounced effect with C being the most potent. A comparable weak effect of water extracts of samples B–D was observed, too. However, the active compound(s) was not identified by chemical analyses. [ABSTRACT FROM AUTHOR]

The question of recycled papers in contact with foods is discussed in detail with respect to regulatory and technical aspects. The legal context is given, and major existing regulations are reviewed. The safety of recycled fibre use is examined with respect to chemical, microbiological and organoleptic contamination. Toxicological testing possibilities on finished paper products are discussed. The harmonization work in progress at the Council of Europe level is presented in detail, and the authors give their personal view on future evolution. [ABSTRACT FROM AUTHOR]

Because of the lack of information about the possible transfer of toxic compounds from papers and boards to food, the overall cytotoxicity induced by six papers and 15 boards was investigated from water extracts prepared according to the European prestandard. Cytotoxicity measurements were based on RNA synthesis rate of human HeLa S3 cells. The tested virgin and recycled papers and boards were differentiated and classified according to their cytotoxicological quality, which ranged from absence of any cytotoxic effect to severe inhibition of RNA synthesis rate. The cytotoxicity level also varied according to the total amount of compounds detected by gas chromatography. No correlation was found between cytotoxicity and endotoxins contained in the samples. No significant difference in cytotoxicity was observed between the papers and boards produced from virgin fibres and from recycled fibres. Moreover, the products obtained from chemical pulp showed lower cytotoxicity than the products based on mechanical pulp. More generally, the cytotoxicological approach is promising for monitoring paper/board treatment-induced problems. Further work is required to assess a modified standard procedure for the preparation of water extractsspecifically adapted to paper/board. [ABSTRACT FROM AUTHOR]