Search

In this study, we investigated the effect of manufacturing factors such as particle size, water content and manufacturing method on the physical stability and solubility of solid dispersion formulations of a low-glass-transition-temperature (T(g)) drug. Solid dispersions were prepared from polyvinylpyrrolidone (PVP) and hydroxypropylmethylcellulose (HPMC) by hot melt extrusion or spray drying. Water content of solid dispersions prepared by hot melt extrusion determined by dynamic moisture sorption measurement was increased drastically with relative humidity below a certain level of particle size. The blends with a lower water content (0.8%) prepared by hot melt extrusion during storage were more stable than those with a higher water content (3.5%) prepared by spray drying, which caused rapid recrystallization. Physical stability in the hot melt blends may be attributed to reduced molecular mobility due to a higher T(g). Dissolution study revealed that solid dispersions prepared by hot melt extrusion with the smallest particle size showed decreased solubility, attributed to reduced wetting properties (surface energy), which is not predictable by the Noyes-Whitney equation. Taken together, these results indicate that the control of particle size concerned in water content or wetting properties is critical to ensuring the physical stability or enhancing solubility of low-T(g) drugs. Further, hot melt extrusion, which can reduce water content, is a suitable manufacturing method for solid dispersions of low-T(g) drugs.

The purpose of this study was establishing a solid dispersion formulation containing a low glass transition temperature (T(g)) and poorly water-soluble drug. Drug/polymer blends with differing physicochemical stabilities and oral absorption were prepared from copolyvidone (PVP-VA), polyvinylpyrrolidone (PVP) or hydroxypropylmethylcellulose (HPMC) by a hot melt extrusion. HPMC drastically increased the drug oral absorption property, while PVP-VA or PVP stabilized solid dispersions during storage by increasing the T(g) in proportion to polymer concentration. Experimental T(g) values corresponded closely with theoretical T(g) values; indeed, the T(g) values of solid dispersion with HPMC did not increase significantly compared to the T(g) value for the drug alone. A solid dispersion formulation incorporating two different polymers-HPMC and either PVP-VA or PVP-maintained increased T(g), physicochemical stability, solubility, and bioavailability of the solid dispresions owing to each polymer. These findings suggested that both oral absorption and physicochemical stability of low-T(g) drug will be improved using less amount of solid dispersion of combined two polymers than polymer alone.

Histone deacetylase inhibitor (HDACI), suberoylanilide hydroxamic acid (SAHA), approved by the Food and Drug Administration (FDA) for the treatment of cutaneous T cell lymphoma, is a promising new treatment strategy for various cancers. In this study, we hypothesized that a liposomal formulation of HDACI might efficiently deliver HDACI into tumors. To incorporate HDACI efficiently into the liposomal membrane, we synthesized six HDACI-lipid conjugates, in which polyethylene glycol(2000) (PEG(2000))-lipid or cholesterol (Chol) was linked with a potent hydroxamic acid, HDACI, SAHA or K-182, by cleavable linkers, such as ester, carbamide and disulfide bonds. Liposomal HDACI-lipid conjugates were prepared with distearoylphosphatidylcholine (DSPC) and HDACI-Chol conjugate or with DSPC, Chol and HDACI-PEG-lipid conjugates, and their cytotoxicities were evaluated for human cervix tumor HeLa and mouse colon tumor Colon 26 cells. Among the liposomes, liposomal oleyl-PEG(2000)-SAHA conjugated with SAHA and oleyl-PEG(2000) via a carbamate linker showed higher cytotoxicity via hyperacetylation of histone H3 and induction of caspase 3/7 activity. These results suggested that liposomal HDACI-lipid conjugates may be a potential tool for cancer therapy.

The surface properties of cationic liposomes and lipoplexes largely determine the cellular association and gene transfection efficiency. In this study, we measured the surface properties, such as zeta potentials, surface pH and hydration levels of MHAPC- and OH-Chol-lipoplexes and their cellular association, without and with the modification of biosurfactant mannosylerythritol lipid-A (MEL-A) or Tween 80 (MHAPC=N,N-methyl hydroxyethyl aminopropane carbamoyl cholesterol; OH-Chol=cholesteryl-3beta-carboxyamindoethylene-N-hydroxyethylamine). Compared to OH-Chol-lipoplexes, the higher cellular association of MHAPC-lipoplexes correlated with the significantly higher zeta potentials, lower surface pH levels and "drier" surface, as evaluated by the generalized polarization of laurdan. Both MEL-A and Tween 80 modification of MHAPC-lipoplexes did not significantly change zeta potentials and surface pH levels, while MEL-A modification of OH-Chol-lipoplexes seriously decreased them. MEL-A hydrated the liposomal surface of MHAPC-lipoplexes but dehydrated that of OH-Chol-lipoplexes, while Tween 80 hydrated those of MHAPC- and OH-Chol-lipoplexes. In all, cationic liposomes composed of lipids with secondary and tertiary amine exhibited different surface properties and cellular associations of lipoplexes, and modification with surfactants further enlarged their difference. The strong hydration ability of Tween 80 may relate to the low cellular association of lipoplexes, while the dehydration of MEL-A-modified OH-Chol-lipoplexes seemed to compensate the negative zeta potential for the cellular association of lipoplexes.

The effects of soybean-derived sterylglucoside (SG) on the fluidity of liposomal membrane composed of dipalmitoylphosphatidylcholine (DPPC) were investigated compared with those of soybean-derived sterol (SS) and cholesterol (Ch) using an electron spin resonance spectrometer. Three kinds of liposomes were prepared in the molar ratio of DPPC/X=7/4, where X is SS, Ch or SG. The fluidity close to the polar head groups increased with an increase of temperature in the DPPC membrane containing SS, Ch and SG in the range 35 to 45 degrees C. Those near the hydrophobic end changed with an increase in temperature in liposomes containing SS, Ch and SG, which had a fluidizing effect on the DPPC membrane below the transition temperature (Tm, 41.9 degrees C) and a condensing effect over the Tm. The fluidizing effects of these compounds around 37 degrees C near the polar head group and the hydrophobic end increased in the following order: Ch < SG < or = SS and SS < Ch < SG, respectively. SG increased the fluidity of liposomal membrane dramatically above the Tm (35.4 degrees C). These results suggest that the high fluidity close to the hydrophobic end of the liposomal membranes around 37 degrees C, the decrease of Tm, and the sigmoidal nature of fluidity vs. temperature are important factors in the effectiveness of liposomes containing SG as a carrier of drugs.

Remote loading of insulin and bovine serum albumin (BSA) into neutral or positively-charged liposomes by incubation under a transmembrane pH gradient or non-pH gradient was investigated. Trapping efficiencies in several incubation conditions were compared with those of the conventional reverse-phase evaporation vesicle method (c-REV method). For neutral liposomes, insulin could not be effectively loaded into the liposomes by incubation, regardless of the incubation conditions. The trapping efficiency of insulin into positively-charged liposomes was higher than that of neutral liposomes, especially by the pH-gradient method. Insulin could be loaded into positively-charged liposomes about twofold more efficiently than by the pH-gradient method, compared with the c-REV method. Insulin distributed more on the surface of liposomes by the pH-gradient method than by the c-REV method. BSA showed significantly higher affinity to positively-charged liposomes than to neutral ones by various methods. However, the transmembrane pH-gradient method did not increase BSA loading into liposomes, compared with the c-REV and the non-pH-gradient methods. Our results suggest that the pH-gradient method, combining electrostatic interactions, may be useful for preparation of liposomal insulin and that the high hydrophobicity of BSA may not increase the remote loading of BSA into liposomes by the pH-gradient method.

The mechanism of l-menthol, oleic acid and lauricidin as enhancers on percutaneous absorption was examined using diclofenac (DH) as a hydrophobic drug and sodium diclofenac (DNa) as a hydrophilic drug in in vitro diffusion experiments with two kinds of membranes: ethanol-treated and untreated silicone membranes; these were models for the lipid and pore pathways of skin. A 20% w/w ethanol-aqueous solution decreased the flux of DH but increased the flux of DNa significantly across the treated membrane compared with those fluxes across the untreated membrane, suggesting that DH penetrated by the lipid pathway and DNa by the pore pathway. The permeability of DNa through the pore pathway decreased significantly across the treated membrane with the addition of oleic acid and lauricidin. l-Menthol increased the permeability coefficients of DH and DNa more in a treated membrane than in an untreated one, showing the same tendency as in rat skin. Thus, while oleic acid and lauricidin did not increase the permeation of DNa by the pore pathway, l-menthol appeared to enhance the permeation of the drug by both the lipid and pore pathways.

We encapsulated erythropoietin (Epo) in dipalmitoylphosphatidylcholine (DPPC) liposomes with soybean-derived sterols (SS-liposomes) and its glucoside (SG-liposomes) by reverse-phase evaporation vesicle method, and evaluated them by subcutaneous administration in rats. With 4 min of sonication, the damage to Epo activity was observed mainly in the non-encapsulated Epo in the liposomes. This study indicated that the bilayer of liposomes had the ability to protect the Epo activity, by reducing the aggregation that was caused by interaction between Epo molecules. The SG-liposomes had a higher retention of the Epo activity the SS-liposomes. 25.3% or 33.6% of activity was retained by SS-liposomes under the conditions of 4 min or 1 min of sonication, while 53.3% or 58.3% of the activity was retained by SG-liposomes under the same conditions. Shorter sonication was available to minimize the loss of the Epo activity. Epo in SG-liposomes appeared to increase the activity.

The permeability of liposome entrapping insulin through the nasal mucosa of rabbit has been studied and compared with the permeability of insulin solution with or without pretreatment by sodium glycocholate (GC). Insulin entrapped in liposome was not detected in the receiver cell using the diffusion cells with the nasal mucosa. On the other hand, permeability of insulin entrapped in liposome increased after the pretreatment of GC. The phospholipids which result from liposomes, were not observed in the receiver. Also, the GC remaining in the nasal mucosa was measured. Considering the mechanism of permeation of insulin entrapped in liposome through the nasal mucosa, the GC remaining in the nasal mucosa may cause the lysis of liposomes.

In previous studies on the nasal administration of human fibroblast interferon (HuIFN-beta), only rabbits have been used. Therefore, this route was investigated in mice, rats, rabbits and dogs. HuIFN-beta could be delivered across the nasal mucosa in mice, rats, rabbits and dogs, when it was mixed with sodium glycocholate as an absorption promoter. However, the pattern of the plasma HuIFN-beta concentration-time curve was different from that in rabbits. Rabbits gave the highest value of the maximum plasma HuIFN-beta concentration (Cmax), but plasma HuIFN-beta declined rapidly thereafter, upon nasal administration of the powder dosage form (8.45 x 10(2) IU/g). In rats and dogs, Cmax was lower than in rabbits, but plasma HuIFN-beta declined slowly after nasal administration of the powder or liquid dosage form (4-6 x 10(2) IU/g). These differences might be attributed to differences of absorption rate constant.

The utility of the absorption promoters, sodium glycocholate (GC-Na), ethylenediamine dihydrochloride (EDTA-2Na), sodium caprylate (Cap-Na) and sodium salicylate (Sal-Na), in the intranasal administration of human fibroblast interferon-beta (HuIFN-beta) in rabbits was investigated. The optimal amount of added EDTA-2Na, Cap-Na and Sal-Na with respect to HuIFN-beta was examined for nasal absorption in the powder dosage form. Formulations of HuIFN-beta with GC-Na showed greatly enhanced intranasal HuIFN-beta absorption, as compared to the other absorption promoters. The results of a stability study on HuIFN-beta in homogenates of nasal mucosa suggested that GC-Na behaved as a hydrolysis inhibitor in the nasal mucosa and maintained the activity of HuIFN-beta.