Search

The tryptophanase-positive Symbiobacterium thermophilum is a free-living syntrophic bacterium that grows effectively in a coculture with Geobacillus stearothermophilus. Our studies have shown that S. thermophilum growth depends on the high CO2 and low O2 condition established by the precedent growth of G. stearothermophilus. The use of an anoxic atmosphere containing high CO2 allows S. thermophilum to grow independently of G. stearothermophilus, but the cellular yield is ten times lower than that achieved in the coculture. In this study, we characterized the coculture-dependent expression and activity of tryptophanase in S. thermophilum. S. thermophilum cells accumulated a marked amount of indole in a coculture with G. stearothermophilus, but not in the bacterium's pure culture irrespective of the addition of tryptophan. S. thermophilum cells accumulated indole in its pure culture consisting of conditioned medium (medium supplied with culture supernatant of G. stearothermophilus). Proteomic analysis identified the protein specifically produced in the S. thermophilum cells grown in conditioned medium, which was a tryptophanase encoded by tna2 (STH439). An attempt to isolate the tryptophanase-inducing component from the culture supernatant of G. stearothermophilus was unsuccessful, but we did discover that the indole accumulation occurs when 10 mM bicarbonate is added to the medium. RT-PCR analysis showed that the addition of bicarbonate stimulated transcription of tna2. The transcriptional start site, identified within the tna2 promoter, was preceded by the -24 and -12 consensus sequences specified by an alternative sigma factor, σ(54). The evidence suggests that the transcription of some genes involved in amino acid metabolism is σ(54)-dependent, and that a bacterial enhancer-binding protein containing a PAS domain controls the transcription under the presence of high levels of bicarbonate.

We report that Corynebacterium glutamicum colonies exhibit a developmental transition in culture. When cultured on a routinely used complete medium (CM2B), this bacterium first formed a flat translucent colony. Subsequently, some parts of this colony expanded to form small spherical yellow colonies that finally developed into a single large yellow colony. The small flat colony consisted of long thick cells, which were occasionally V or Y shaped, while the large yellow colony consisted of short small rods. A similar colony development pattern was observed in Corynebacterium ammoniagenes and Corynebacterium callunae. Analysis following shotgun cloning revealed that the introduction of a multi-copy-number plasmid carrying amtR, a global transcriptional regulator for nitrogen metabolism, into C. glutamicum cells induced precocious colony development. An amtR-null C. glutamicum mutant exhibited delayed development. Detailed observations of C. glutamicum cells cultured on CM2B medium containing buffers at various pH values revealed that the colony growth was rapid at a pH value of 6.4 or higher and slow but distinct at a pH of less than 6.4. This pH threshold increased to 6.8 following the addition of 0.1% glucose into the medium.

A microbial colony that contained a marked amount of cellulose was isolated from vineyard soil. The colony was formed by the associated growth of two bacterial strains: a cellulose-producing acetic acid bacterium (st-60-12) and a lactic acid bacterium (st-20). The 16S rDNA-based taxonomy indicated that st-60-12 belonged to Gluconacetobacter xylinus and st-20 was closely related to Lactobacillus mali. Cocultivation of the two organisms in corn steep liquor/sucrose liquid medium resulted in a threefold higher cellulose yield when compared to the st-60-12 monoculture. A similar enhancement was observed in a coculture with various L. mali strains but not with other Lactobacillus spp. The enhancement of cellulose production was most remarkable when sucrose was supplied as the substrate. L. mali mutants for exocellular polysaccharide (EPS) production were defective in promoting cellulose production, but the addition of EPS to the monoculture of st-60-12 did not affect cellulose productivity. Scanning electron microscopic observation of the coculture revealed frequent association between the st-60-12 and L. mali cells. These results indicate that cell-cell interaction assisted by the EPS-producing L. mali promotes cellulose production in st-60-12.

A bacterium isolated from a petal of Casa Blanca Lily (ST26 strain) produced a marked amount of extracellular trehalose (alpha- d-glucopyranosyl-[1,1]-alpha- d-glucopyranose) in culture medium containing glucose. 16S rDNA-based phylogeny showed that ST26 belongs to, or is related to, Cellulosimicrobium cellulans, a close relative of Cellulomonas spp. Various Cellulomonas strains obtained from culture collections also showed extracellular trehalose productivity, suggesting that trehalose production is a common property of this bacterial genus. ST26 accumulated trehalose in medium supplied with glucose but not with sucrose, glycerol or maltose. Effective extracellular trehalose production by ST26 was achieved by supplying 0.5-1% ammonium sulfate and 0.5-1% CaCO(3). The addition of CaCO(3) adjusted the pH of the culture to around 5.0. The optimized culture conditions yielded trehalose from glucose at a conversion rate of 61%. The addition of ammonium sulfate greatly reduced the dry cell weight of ST26 and intracellular content of trehalose, which suggests that the addition of ammonium sulfate makes ST26 cells leak trehalose into the medium. ST26 effectively propagated in minimal medium containing trehalose as a sole carbon source, which suggests that trehalose serves as a carbohydrate reserve of this organism.

A simple membrane dialysis bioreactor was developed for a large-scale axenic culture of Symbiobacterium thermophilum, a symbiotic thermophile that requires co-cultivation with an associating thermophilic Bacillus strain S for normal growth. The bioreactor consisted of an outer- and an inner-coaxial cylindrical compartment bordered across a dialyzing membrane, which enabled a 1 l-scale dialysis culture with exchange of low molecular metabolites between the two compartments to be performed. Using the bioreactor, growth characteristics of S. thermophilum and Bacillus strain S were assessed under two medium conditions. The growth of S. thermophilum was measured by quantitative PCR because the bacterium formed no visible colonies and gave abnormally low turbidity. In medium containing 2% tryptone peptone, S. thermophilum proliferated up to 4x10(7) cells/ml, and strict dependence on the co-culture with Bacillus strain S was observed. On the other hand, medium containing 0.5% yeast extract not only facilitated the growth of S. thermophilum in the co-culture (6x10(7) cells/ml), but also allowed limited pure growth independent of Bacillus strain S (1x10(7) cells/ml), implying that some component of yeast extract can partially replace the growth requirement of S. thermophilum supplied by Bacillus strain S. Both the oxidative redox potential values and the cell morphology in the independently growing culture suggested the occurrence of marked unbalanced growth possibly caused by significant metabolic changes. The bioreactor is applicable to the analyses of culturing characteristics in symbiotic systems between free-living microorganisms.

High-molecular-mass nitrile hydratase (H-NHase, 530 kDa) is a cobalt-containing enzyme produced by Rhodococcus rhodochrous J1. For efficient production of H-NHase in R. rhodochrous ATCC12674, several plasmids were constructed. The enzyme was produced in the recombinant Rhodococcus cells only in the presence of an upstream region (approximately 4 kb) of the H-NHase gene under the control of the promoter for the amidase-NHase gene cluster from Rhodococcus sp. N-774. Although H-NHase was produced as a soluble protein in the cells, the protein did not show NHase activity. However, when the recombinant R. rhodochrous ATCC12674 cells were cultured in the presence of amide compounds, such as crotonamide and methacrylamide, markedly high NHase activity was detected, Gel-filtration chromatography revealed that the NHases produced by the cells grown in the presence and absence of the amide compounds had a molecular mass of more than 500 kDa and 50-80 kDa respectively. These results suggest that the amide compounds are essential for subunit assembly to form an enzymatically active multimer. By the use of the recombinant expression system, NHase activity 1.7 times higher than that of the original strain, R. rhodochrous J1, was achieved.

To develop an efficient bioconversion process for amides, we screened our collection of Streptomyces strains, mostly obtained from soil, for effective transformers. Five strains, including the SY007 (NBRC 109343) and SY435 (NBRC 109344) of Streptomyces sp., exhibited marked conversion activities from the approximately 700 strains analyzed. These strains transformed diverse amide compounds such as N-acetyltetrahydroquinoline, N-benzoylpyrrolidine, and N-benzoylpiperidine into alcohols or N,O-acetals with high activity and regioselectivity. N,O-acetal was transformed into alcohol by serial tautomerization and reduction reactions. As such, Streptomyces spp. can potentially be used for the efficient preparation of hydroxy amides and aminoalcohols.

For development of a homologous transformation system for the zygomycete fungus, Rhizomucor pusillus, the isopropylmalate isomerase (leuA) gene was cloned from R. pusillus IFO 4578 by the DNA-probing method with the leuA sequence of Mucor circinelloides as probe. The nucleotide sequence revealed that leuA of R. pusillus encoded a 755-amino-acid protein of 82.5 kDa with no intron. The leuA gene on pUC19 (plasmid pRPLeu10) was introduced by polyethyleneglycol-assisted transformation into protoplasts of a leuA- mutant of R. pusillus that was obtained by UV mutagenesis. Transformation under optimal conditions yielded 20 Leu+ transformants (micrograms pRPLeu10 DNA)-1 (1 x 10(6) viable protoplasts)-1. Blot analysis of DNA from the transformants showed that the pRPLeu10 sequence was integrated into the genome by homologous recombination at the leuA locus.

We obtained carotenoid-producing microorganisms at a high frequency from water samples collected at Misasa (Tottori, Japan), a region known for its high natural radioactivity content. A comprehensive 16S rRNA gene-based phylogenetic analysis revealed that the 104 potential carotenoid producers isolated from Misasa could be classified into 38 different species belonging to seven bacterial classes (Flavobacteria, Sphingobacteria, alpha-Proteobacteria, gamma-Proteobacteria, Deinococci, Actinobacteria, and Bacilli). Of these 38 species, 14 showed sequence similarities less than 97% to their closest identified relatives, and 9 were related to genera that have not been described earlier in terms of carotenoid production. The red-pigmented isolates belonging to Deinococci showed marked resistance to gamma rays and UV irradiation, while those related to Sphingomonas showed weak resistance. The carotenoids produced by the isolates were zeaxanthin (6 strains), dihydroxyastaxanthin (24 strains), astaxanthin (27 strains), canthaxanthin (10 strains), and unidentified molecular species that were produced by the isolates related to Deinococcus, Exiguobacterium, and Flectobacillus. UV irradiation would be useful for the selective isolation of carotenoid-producing microorganisms, and that new microbial producers and other molecular species of carotenoids may potentially be identified from radioactive environments.

As the first step for production of rat apolipoprotein E (rApoE) in Saccharomyces cerevisiae, the rApoE cDNA was cloned and its nucleotide sequence was determined. When the intact rApoE gene including the presequence-encoding region was expressed under the control of the yeast GAL7 promoter, no protein immunoreactive with anti-rApoE antibody was detected either in the culture medium or inside the cells. For the purpose of the extracellular production of rApoE, three fusion genes were constructed in which the mature rApoE-encoding sequence was connected after the pre, prepro, and whole regions of the gene encoding a fungal aspartic proteinase, Mucor pusillus rennin (MPP), since MPP is efficiently secreted from recombinant S. cerevisiae containing the MPP gene. When these three fusion genes were expressed under the control of the GAL7 promoter, only one, encoding the mature rApoE connected to the whole MPP sequence, directed efficient secretion of the fused protein. The maximum yield of the fused protein secreted into the medium reached 11.8 mg/l and the calculated rApoE part was 5.3 mg in the fused protein. The excreted fusion protein was glycosylated at the original two sites in the MPP part. The fused protein was gradually degraded in the medium probably by proteases of the host cell, because no such degradation occurred in a yeast pep4mutant strain.

Symbiobacterium thermophilum is an obligately symbiotic thermophile that can grow only in coculture with a specific Bacillus strain. The amino acid sequences of fragments obtained by cyanogen bromide decomposition of the thermostable beta-tyrosinase (tyrosine phenol-lyase, E.C. 4.1.99.2) from this organism resembled that of the tryptophanase produced by the same organism. DNA-probing with the tryptophanase gene as the hybridization probe led to cloning in Escherichia coli of the beta-tyrosinase (tpl) gene. The nucleotide sequence revealed that the beta-tyrosinase of 458 amino acids (relative molecular mass, 52269) showed significant similarity in amino acid sequence to the tryptophanase over the entire sequence. DNA manipulation of the cloned tpl gene in E. coli led to production of 375 times as much beta-tyrosinase as that produced by the original S. thermophilum strain.

Membrane-bound alcohol dehydrogenase (ADH) was purified from the membrane fraction of an industrial-vinegar-producing strain, A. polyoxogenes sp. nov. NBI1028 by solubilization using Triton X-100 and subsequent column chromatography on DEAE-Sepharose CL-6B and hydroxyapatite. The purified enzyme was homogeneous on polyacrylamide disc gel electrophoresis (PAGE). Upon sodium dodecyl sulphate-PAGE, the enzyme showed the presence of two subunits with a molecular mass of 72 000 daltons and 44 000 daltons, respectively. The small subunit was identified as cytochrome c. In addition, absorption and fluorescence spectra showed the the presence of pyrroloquinoline quinone in the purified ADH. The ADH preferentially oxidized aliphatic alcohols with a straight carbon chain except for methanol. Formaldehyde and acetaldehyde were also oxidizable substrates. The apparent Km for ethanol was 1.2 mM. The optimum pH and temperature were 5.0–6.0 and 40°C, respectively. p-Chloromercuribenzoic acid and heavy metals such as CuSO4 were inhibitory to the enzyme activity. Ferricyanide was effective as an electron acceptor.